Illustrated Parts List

Transcription

1 More time on the road Illustrated s List RTLO-88B November 0

2 Contents How To Use The Illustrated s List... AFTERMARKET TRANSMISSIONS... AUXILIARY DRIVE GEAR... 6 CASE (AUX)... CASE (FRONT)... 9 COUNTERSHAFT & BRGS(AUX)... COUNTERSHAFT ASSY... FILTER REGULATOR... H & C W/A-5000 VALVE... 5 INPUT SHAFT & DRIVE GEAR... INTEGRAL OIL PUMP... 8 ISOLATORS... KITS & ASSEMBLIES... LEVERS/HOUSINGS... 5 MAINSHAFT & SYNCHRO(AUX)... 8 MAINSHAFT ASSY... 0 MISCELLANEOUS... NON-SELECTIVE M/S ASSY... OIL COOLER... 5 OIL FILTER... RANGE CYLINDER... 9 REVERSE IDLER... 0 ROADRANGER VALVES... SHIFT BAR HOUSING... SLAVE VALVE - A SPLITTER CYLINDER... 8

3 How To Use The Illustrated s List The information contained in this document is subject to frequent updates. Therefore, for the latest information available, please visit the interactive Electronic s Catalog at Model Designation or Nomenclature For information regarding Model Designation and Nomenclature, visit Kits and Assemblies (K/A's) Kits and Assemblies contain groups of individual or assembled parts developed for optimal replacement or repair of a service problem. Kits and Assemblies are shown with applicable parts groupings in the parts listings. Identifying Kits and Assemblies A- numbers beginning with the letter 'A' are pre-assembled Production Assemblies K- numbers beginning with the letter 'K' are kits that are not assembled S- numbers beginning with the letter 'S' are pre-assembled Service Assemblies Note: Some Production Assemblies do not begin with a letter prefix (Midrange only). Illustrations Illustrations show parts in assembly groups. Item numbers on illustrations correspond with parts listings on pages adjacent to the illustration. Notes are included on illustrations where additional information is needed. s Listing s listings are defined by parts groupings and are broken down by service assemblies. s listings identify a part for servicing with the following categories Item Number - corresponding with numbers on illlustrations for part identification. - indentifies part as it is available for service. Description - specifies part name or description. Replaced - quantity quantity required for assembly. Quantity - defines unique characteristics or requirements. Notes - indicates Kits or Assemblies that contain a particular part. Kits/Assy's Where Used

4 Group: AFTERMARKET TRANSMISSIONS Reman Transmission AFTMKT 09- Generic Illustration - Not specific to part numbers listed below AFTERMARKET TRANSMISSIONS Item Description Replaced Qty. Notes Kits/Assys Where TA-B- R TA-B- RDS TA-B- RM TA-B- RMDS TA-B- RV TA-B- RVDS TA-B- X RTLO-88B REMAN TRANS RTLO-88B REMAN TRANS RTLO-88B REMAN TRANS RTLO-88B REMAN TRANS RTLO-88B REMAN TRANS RTLO-88B REMAN TRANS RTLO-88B NEW SVC EXCH TRANS WITH INTERNAL PUMP DEALER STOCK - DAY LEAD- TIME - WITH INTERNAL PUMP NODAL MOUNT BELOW CENTER - WITH INTERNAL PUMP DEALER STOCK - DAY LEAD- TIME - NODAL MOUNT BELOW CENTER - WITH INTERNAL PUMP NODAL MOUNT ABOVE CENTER - WITH INTERNAL PUMP DEALER STOCK - DAY LEAD- TIME - NODAL MOUNT ABOVE CENTER - WITH INTERNAL PUMP WITH INTERNAL PUMP - NO CLUTCH HOUSING

5 5

6 Group: AUXILIARY DRIVE GEAR A-5-0 AUXILIARY DRIVE GEAR Item Description Replaced Qty. Notes Kits/Assys Where 06 SPACER BOX BEARING , K-865,K-866,K RETAINER X-8-65 CAPSCREW X /8"-6X" SPACER K K-808 REPL KIT-DRIVE GEAR 009, WASHER 0090 K SNAP RING K-808,K-86,K- 865,K-866,K- 6

7 Group: CASE (AUX) 5 OEM supplied adjustable speedometer sensor OEM supplied non-adjustable speedometer sensor * Latest Design 9 0 * See Service Manual for Proper Shimming Procedure * CASE (AUX) Item Description Replaced Qty. Notes Kits/Assys Where X-8L-6 CAPSCREW 6 /8"-6X-/" S-0 REAR BRG COVER ASSY GASKET K-60,K-99,K- 6,S-0 0 PLUG-MAGNETIC S-0,S SENSOR SEAL S PLUG-MECHANICAL S-0,S-56 -O- RING S-0,S BUSHING S-0

8 Item Description Replaced Qty. Notes Kits/Assys Where 9 X-8L-60 CAPSCREW 8 /8"-6X-/" K LIFTING EYE S REAR BEARING COVER PRIOR TO SERIAL NUMBER 505 & PRIOR TO SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER 0086 GASKET PRIOR TO SERIAL NUMBER 505 & PRIOR TO SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER K-60,K-99 K-805 SHIM KIT 5 K - 06 K-69,K-865,K- 866,K-,S-56 X-8L-60 CAPSCREW /8"-6X-/" X-8L-6 CAPSCREW /8"-6X" REAR HOUSING PRIOR TO SERIAL NUMBER 505 & PRIOR TO SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER REAR HOUSING BEGINNING W/SERIAL NUMBER 505 & ALL SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER 6 5 GASKET K-60,K-99,S COVER 6 BEGINNING W/SERIAL NUMBER 505 & ALL SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER GASKET 06 BEGINNING W/SERIAL NUMBER 505 & ALL SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER S-56 K-60,K-99,K- 5,S-56 0 K-6 OIL SEAL W/SLINGER "FOR MECHANICAL COVER" K-69,K-865,K- 866,K- K-65 OIL SEAL TOOL KIT 8

9 Group: CASE (FRONT) Latest Design * * A-/9 Iron Hsg * Bushing quantity requirements: # Housing Upper bore use #85 / Lower bore use #86. # Housing Upper bore use #85 and #86 / Lower bore use #86. Note: Some part requirements are specific to # or # Clutch Housings and Push or Pull type Clutch. CASE (FRONT) Item Description Replaced Qty. Notes Kits/Assys Where S-6 CASE ASSY 06 X--00 PIPE PLUG X 006 X--0 PIPE PLUG X 0,X 06 /" MAGNETIC 050 GASKET 080 K PTO COVER 6596,005 6 X-8-5 CAPSCREW X 8 8 /6"-X/8" 0658 CLUTCH HOUSING GASKET 085,05668 K-99 8 A- CLUTCH HOUSING ASSY A - 00 # PULL IRON 8 A- CLUTCH HOUSING ASSY A -,A - # PULL IRON 9 96 SCREW X-8L-509 5/6-8X.8 QUANTITY DEPENDENT ON DESIGN 0 50 HAND HOLE COVER # PULL 9

10 Item Description Replaced Qty. Notes Kits/Assys Where HAND HOLE COVER 5 # PULL 0658 STUD X WASHER X 000,X0 000,X X 6.60 X--0 HEX NUT X FRONT BEARING COVER K-68,K-,K- 5 5 X-8L-60 CAPSCREW 6 /8"-6X-/" K-5 GASKET K BUSHING FOR # HOUSING UPPER A-,A-,K- 68,K BUSHING FOR # HOUSING UPPER A-,A-,K- 68,K BUSHING FOR # HOUSING UPPER A-,A BUSHING FOR # AND # HOUSING LOWER A-,A- 0 X-8C-80 HEX HEAD SCREW/WASHER ASSY 0 X-8C-8 HEX HEAD SCREW/WASHER ASSY X-8C X.90, FOR IRON HOUSING X-8C X.60, FOR IRON HOUSING 00 PLUG 0 -/6" MAGNETIC, O-RING INCLUDED S-6 X CAPSCREW 6 /8"-6X/" 55 PTO COVER GASKET 68 K-99 MAGNET K-,S PIN 9 X--0 HEX NUT X WASHER X 000,X0 000,X0 00. X STUD 6,659 5/8" X -/6" 6 0 PLUG X CAPSCREW 5/8"-X-/" 8 08 SPACER 9 X--80 PIPE PLUG X 800 /" BUSHING 0

11 Group: COUNTERSHAFT & BRGS(AUX) 0-5/9 CS Helical COUNTERSHAFT & BRGS(AUX) Item Description Replaced Qty. Notes Kits/Assys Where 085- BOX BEARING 085 K-69,K-865,K- 866,K- K-0 COUNTERSHAFT REPLT KIT 0 SPACER 09,09,A - 68,A - 660,A K-0

12 Group: COUNTERSHAFT ASSY /9 CS/RT COUNTERSHAFT ASSY Item Description Replaced Qty. Notes Kits/Assys Where 0 S-09 COUNTERSHAFT ASSEMBLY, RIGHT 0 S-00 COUNTERSHAFT ASSEMBLY, LEFT COMPLETE COUNTERSHAFT ASSEMBLY, RIGHT COMPLETE COUNTERSHAFT ASSEMBLY, LEFT 008 SNAP RING K-86,K-865,K- 866,K-,S- 09,S-00 0 BEARING K-865,K-866,K- K-9 CNTRSHFT-W/REV & LO 065 X-6-E KEY S-09,S ROLL PIN K-86,S-09,S KEY 96 S-09,S ST GEAR-CNTRSHFT S-09,S ND GEAR-CNTRSHFT S-09,S OD GEAR - CNTRSHFT 0508,05 K-,S-09,S-

13 Item Description Replaced Qty. Notes Kits/Assys Where PTO GEAR - LOWER S PTO GEAR - UPPER 595 S DRIVE GEAR-CNTRSHFT K-,S-09,S SNAP RING K-,S-09,S BEARING K-865,K-866,K RETAINER 958 ROLL PIN NO LONGER REQUIRED 5 X--005 CAPSCREW 5/8"-8X-/"

14 Group: FILTER REGULATOR NSS -O- Ring/Element Kit AFR NSS - Not Sold Separately FILTER REGULATOR Item Description Replaced Qty. Notes Kits/Assys Where A-0 FILTER/REGULATOR 9600 K- K-698 -O- RING/ELEMENT KIT FOR FILTER REGULATOR X-8C- CAPSCREW X 8S /"-0X-/"

15 Group: H & C W/A-5000 VALVE 9 H 6 5 From RRV H L P 8 9 Range Cylinder 8 From RRV S L S Splitter Cylinder 0 SP 00I-/9 A-5000 HC spl cyl H & C W/A-5000 VALVE Item Description Replaced Qty. Notes Kits/Assys Where A-5000 SLAVE VALVE ASSY 0850 K- 98 GASKET K O- RING 0 K-969 K-969 SLEEVE KIT 6,960,6 FOR SLAVE VALVES K SPRING PIN ELBOW /8" K- 8 X-8C- CAPSCREW /"-0X-/" HOSE ASSY 6" K HOSE ASSY " K- A-0 FILTER/REGULATOR 9600 K- X--08 PIPE PLUG /8" NPT X-8L-60 CAPSCREW /8"-6X-/" K-5 HOSE CLAMP K- 5 5 STRAP K- 5

16 Item Description Replaced Qty. Notes Kits/Assys Where 6 6 BRACKET K- 8 HOSE CLAMP K- 8 X-8L-60 CAPSCREW /8"-6X-/" K HOSE ASSY 5" K- 5 -O- RING A-5000,K-95,K- 6

17 Group: INPUT SHAFT & DRIVE GEAR * * 00-/9 IS * For Shipping Only -- Do Not Replace INPUT SHAFT & DRIVE GEAR Item Description Replaced Qty. Notes Kits/Assys Where 559 SEAL NOT SOLD FOR SERVICE 6980 SNAP RING K-68,K-865,K- 866,K-,K BEARING K-68,K-865,K- 866,K-,K-5 66 SPACER 5 50 SNAP RING K-68,K-86,K- 865,K-866,K-,K MAIN DRIVE GEAR K- 8 S-659 INPUT SHAFT " PULL - USE W/FBC 0550 K-68,K-866,K-,K-5 8 S-660 INPUT SHAFT 056,56 " PUSH - USE W/FBC BUSHING K-865,S-659,S- 660

18 Group: INTEGRAL OIL PUMP 0 Indicates part of item or Latest Design INTEGRAL OIL PUMP Item Description Replaced Qty. Notes Kits/Assys Where X-8C-09 CAPSCREW 5 /"-0X5/8" K-0 COVER & SCREW KIT GASKET K-0 8

19 Item Description Replaced Qty. Notes Kits/Assys Where 08 PLUG O- RING K-80,K-80,K K-6 FASTENER KIT 08, X-8-8 KIT CONTAINS FASTENERS AND WASHERS K DOWEL PIN 9 00 RETAINER 050 S ELEMENT 058 CRESCENT RING 65 ROLL PIN K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A - K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A - 5 K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A O- RING K SUCTION TUBE 068 O-RING INCLUDED ON SUCTION TUBE K DRIVE SHAFT KEY 85 SNAP RING 05 DRIVE GEAR 6 X--60 PIPE PLUG X 60 /8" NPT X--00 STEEL BALL /6" TUBE 9 K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A SPLITTER LUBE TUBE A - 9 K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A - 9

20 Item Description Replaced Qty. Notes Kits/Assys Where X CAPSCREW /8"-6X/" 999 K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A - 0

21 Group: ISOLATORS New Design 6 9 New Design Isolator Indicates Of Item 0 ISOLATORS Item Description Replaced Qty. Notes Kits/Assys Where 9 -E- RING K-6 PIN REPLACEMENT KIT 5 6 BUSHING K-00,K-8,K- 9,K-98,K- 99,S-9,S- 0,S-59 S-9 ISOLATOR ASSY 6 LEVER STRAIGHT 8.6" 5 STUB LEVER LOW TOWER K-8,S-6 6 STUB LEVER HIGH TOWER K-9,S-59,S STUB LEVER MID TOWER K DEG LEVER STRAIGHT " 0 K-99 ISOLATOR BUSHING KIT, X SCREW K-00 X-9-50 NUT K-00

22 KITS & ASSEMBLIES Item Description Replaced Qty. Notes Kits/Assys Where K-6 SHIFT LEVER HSG 50,6,898,0905,A - LOW TOWER K-60 GASKET KIT FOR AUXILIARY SECTION K-69 K-698 -O- RING/ELEMENT KIT FOR FILTER REGULATOR K-95 REPAIR KIT-SLAVE VALVE FOR A-5000 VALVE K-956 COOLER INSTLN KIT K-969 SLEEVE KIT 6 960,6 FOR SLAVE VALVES K- K-00 PIN & BUSHING KIT K-0 MASTER VALVE REPAIR KIT FOR A-50 VALVE K-99 GASKET KIT K-865,K-866,K- K-6 OIL SEAL W/SLINGER "FOR MECHANICAL COVER" K-69,K-865,K- 866,K- K-9 AIR SYSTEMS TOOL KIT K-0 COVER & SCREW KIT 005 K-8 LEVER REPLACEMENT KIT K-9 LEVER REPLACEMENT KIT K-68 CLUTCH INSTALLATION KIT LOW TOWER HIGH TOWER FOR USE WITH S-659 INPUT SHAFT ASSY AND 850 INPUT SHAFT BEARING K-69 AUXILIARY REBUILD KIT FOR AUXILIARY SECTION K-80 -O- RING KIT-RANGE K-80 O-RING KIT - SPLITTER K-80 -O- RING KIT-COMPLETE K-69,K-865,K- 866,K- K-805 SHIM KIT 5 K - 06 K-69,K-865,K- 866,K-,S-56 K-808 REPL KIT-DRIVE GEAR 009,0098 K-809 RANGE CYLINDER KIT K-86 SMALL PARTS KIT K-86 KEY & WASHER KIT

23 Item Description Replaced Qty. Notes Kits/Assys Where K-865 BASIC REBUILD KIT K-866 BASIC OVERHAUL KIT K-9 COUNTERSHAFT REPL KIT 065 K-9 SHIFT LEVER HSG KIT 66,6,0050,090,K - 60 K - 9 K-9 SHIFT LEVER HSG KIT 06,090,A K-98 LEVER REPLACEMENT KIT HIGH TOWER MID TOWER MID TOWER K-0 ACTUATOR PIN KIT 08 K- K- SPLITTER GEAR UPDATE KIT K-9 MASTER VALVE REPAIR KIT K-9 MASTER VALVE REPAIR KIT K-95 MASTER VALVE REPAIR KIT 0659 FOR A-698 VALVE FOR A-69 VALVE FOR A- VALVE K-09 IDLER SHAFT REPL KIT 605,098,055 K-0 COUNTERSHAFT REPLT KIT 09,09,A - 68,A - 660,A K- SPLITTER VLV REPL KIT 009,00,00,A K-6 OIL PUMP KIT 089,098,06,059,05 A - 696,A - K-6 O-RING & WASHER KIT 0 K-99 ISOLATOR BUSHING KIT, K- OIL FILTER/ADAPTER KIT K-6 PIN REPLACEMENT KIT 5 K-9 SYNCHRONIZER KIT K - 6 K-9 SYNCHRONIZER REPLACEMENT KIT K - 00 SLIDING CLUTCH INCLUDED IN KIT K-65 OIL SEAL TOOL KIT K- MASTER REBUILDER KIT USE TO REBUILD RTLO-88B W/NON-SELECTIVE WASHERS

24 Item Description Replaced Qty. Notes Kits/Assys Where AND FORCED LUBE ONLY K-5 CLUTCH INSTALLATION KIT (RT), HYDRAULIC RELEASE STANDARD RT INPUT SHAFT AND YOKE FOR HYDRAULIC CLUTCH RELEASE S-9 YOKE ASSY LOW-REV S-0 OIL FILTER 8 S-56 CAP ASSY 085,085 S-659 INPUT SHAFT " PULL - USE W/FBC 0550 K-68,K-866,K-,K-5 S-9 ISOLATOR ASSY S-0 REAR BRG COVER ASSY 0089 S-9 SHIFT LEVER HSG ASSY LOW TOWER S-0 SHIFT LEVER HSG ASSY S - 05 HIGH TOWER S-6 CASE ASSY 06 S-69 SHIFT BAR HSG 069 HOUSING ONLY (XF) S-0 SHIFT BAR HSG 065 HOUSING ONLY (X) S- SHIFT BAR HSG ASSY 069 COMPLETE (XF) S- SHIFT BAR HSG ASSY 065 COMPLETE (X) S-59 SHIFT LEVER HSG ASSY S - 99 MID TOWER S-555 ROADRANGER VALVE ASSY S-68 ROADRANGER VALVE ASSY RTLO - W/SHIFT DIAGRAM MEDALLION A RT - W/SHIFT DIAGRAM MEDALLION S-56 RANGE SECTION ASSY S-08 MAINSHAFT ASSY 0658,00,S - 68,S-560

25 Group: LEVERS/HOUSINGS K-8 - Low K-98 - Mid K-9 - High S-6 - Low S-96 - Mid S-59 - High S-9 - Low S-59 - Mid S-0 - High LEVERS/HOUSINGS Item Description Replaced Qty. Notes Kits/Assys Where K-6 O-RING & WASHER KIT PIN K-6,K-9,S- 6 5

26 Item Description Replaced Qty. Notes Kits/Assys Where X-8C-60 CAPSCREW /8"-6X-/" S-69,S-0,S-,S- X--600 NUT /8"--N.F.PLAIN 5 X--600 LOCKWASHER /8" 6 9 STUD 6 K-6 SHIFT LEVER HSG 50,6,898,0905,A - LOW TOWER GASKET 0 K-6,K-99,K- 8,K-9,K- 9,K-9,K- 98,S-59,S- 6,S-96,S- 9,S-0,S-,S-,S-59 9 K-9 SHIFT LEVER HSG KIT 06,090,A MID TOWER 000 PIN K-9,S-59,S PIN /8" - USED W/6 ONLY K-9 SHIFT LEVER HSG KIT 66,6,0050,090,K - 60 K - 9 HIGH TOWER 5 0 BOOT K-6,K-9,K- 9,S-59,S- 6,S-0 6 X--600 NUT /8"--N.F.PLAIN X--600 LOCKWASHER /8" GEAR SHIFT LEVER STRAIGHT - LOW -/" 0 88 GEAR SHIFT LEVER STRAIGHT - HIGH 5" 58 RETAINER K-6,K-9,K- 9,S-59,S- 6,S-0 56 SPRING K-6,K-9,K- 9,S-59,S- 6,S-0 K-8 LEVER REPLACEMENT KIT K-9 LEVER REPLACEMENT KIT K-98 LEVER REPLACEMENT KIT LOW TOWER HIGH TOWER MID TOWER S-59 SHIFT TOWER ASSY HIGH TOWER 6

27 Item Description Replaced Qty. Notes Kits/Assys Where S-6 SHIFT TOWER ASSY LOW TOWER S-96 SHIFT TOWER ASSY MID TOWER S-9 SHIFT LEVER HSG ASSY LOW TOWER S-0 SHIFT LEVER HSG ASSY S - 05 HIGH TOWER S-59 SHIFT LEVER HSG ASSY S - 99 MID TOWER

28 Group: MAINSHAFT & SYNCHRO(AUX) Latest Design Universal Joint Yoke /9 Aux MS MAINSHAFT & SYNCHRO(AUX) Item Description Replaced Qty. Notes Kits/Assys Where 0090 SLIDING CLUTCH X--00 SCREW 5/8"-8X-/" 08 RETAINER K- SPLITTER GEAR UPDATE KIT BOX TAPERED ROLLER BRG 0090 K-865,K-866,K BEARING SLEEVE K- 086 NO LONGER AVAILABLE NO LONGER AVAILABLE 9 89 SPRING K-69,K-86,K- 865,K-866,K- 8

29 Item Description Replaced Qty. Notes Kits/Assys Where 9,K-9,K- 0 A- SYNCHRONIZER ASSY A - 59 HI RANGE K-9,K-9,K- 080 SLIDING CLUTCH 086 K-9,K- A-5 SYNCHRONIZER ASSEMBLY A - 9 A LO RANGE K-9,K-9,K AUXILIARY MAINSHAFT 08 WASHER K-86,K REDUCTION GEAR SPACER K-86,K- 56- BOX BEARING 56 K-69,K-865,K- 866,K ROTOR 9 5 NUT K-,S SPLITTER GEAR 0 0 K- 0 SNAP RING K-865,K-866,K-,K- 9

30 Group: MAINSHAFT ASSY MS w/ OD -Sided Key Design MAINSHAFT ASSY Item Description Replaced Qty. Notes Kits/Assys Where 065 -SIDED KEY 000 K-86,K-86,K- K-86 KEY & WASHER KIT S-08 MAINSHAFT ASSY 0658,00,S - 68,S ROLL PIN S SNAP RING K-68,K-86,K- 865,K-866,K-,K REVERSE GEAR- MAINSHAFT SPACER K WASHER.9-WHITE OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY 008 WASHER.5-GREEN OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY K-86,K-86,K- K-86,K-86 0

31 Item Description Replaced Qty. Notes Kits/Assys Where 008 WASHER.59-ORANGE OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY K-86,K WASHER.6-PURPLE OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY 0086 WASHER.69-YELLOW OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY 008 WASHER.-BLACK OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY 0080 WASHER.-BLUE OPTIONAL OR 0080 USE ANY WASHERS. USE WITH -SIDED KEY K-86,K SLIDING CLUTCH 9 50 LO GEAR-MAINSHAFT 0 0 ST GEAR-MAINSHAFT 968, ND GEAR-MAINSHAFT 05 OD GEAR-MAINSHAFT ,06 K- 098 WASHER K-86,K-86,K- 0 SLIDING CLUTCH 06 K SPACER K WASHER 09 K-86,K-86,K-

32 MISCELLANEOUS Item Description Replaced Qty. Notes Kits/Assys Where 68 SHIFT DIAGRAM LABEL SILICONE LUBE 8 OZ (6.59 CC)-FLEET SIZE 0 ADHESIVE SEALANT 0.5 CC (SINGLE APPLICATION SIZE) 05 SEALANT CC (SINGLE APPLICATION SIZE) K-866,K- 06 SILICONE LUBE CC (SINGLE APPLICATION SIZE) K-8,K-9,K- 80,K-80,K- 80,K-809,K- 98,K-,K-

33 Group: NON-SELECTIVE M/S ASSY B-0-96 NON-SELECTIVE M/S ASSY Item Description Replaced Qty. Notes Kits/Assys Where S-08 MAINSHAFT ASSY 0658,00,S - 68,S ROLL PIN S SIDED KEY 000 K-86,K-86,K- 50 SNAP RING K-68,K-86,K- 865,K-866,K-,K REVERSE GEAR- MAINSHAFT SPACER K- 68 SLIDING CLUTCH LO GEAR-MAINSHAFT WASHER 09 K-86,K-86,K ST GEAR-MAINSHAFT

34 Item Description Replaced Qty. Notes Kits/Assys Where 060 ND GEAR-MAINSHAFT 05 OD GEAR-MAINSHAFT ,06 K- 008 WASHER.9-WHITE K-86,K-86,K- 098 WASHER K-86,K-86,K- 5 0 SLIDING CLUTCH 06 K-866

35 Group: OIL COOLER 6 Flow Oil Return 6 0 Oil Pump Outlet * *6 Outlet * Fuller *6 Inlet *5 Return Outlet 055-/9 Cooler *Adding Oil Filter and parts as shown is optional. Return / Outlet Location OIL COOLER Item Description Replaced Qty. Notes Kits/Assys Where 805 OIL COOLER K HOSE 5 FEET K-956 X-8-55 CAPSCREW 5/6"-6X-/" X--506 LOCKWASHER 5/6" 5 8 BRACKET K CONNECTOR 6 K-956,K-,K- 5,S-0 95 SWIVEL K X-0-50 WASHER 5/6" PLUG-RUBBER MOUNT K STRAP 8 K CLAMP 5 K NUT K-956 5

36 Item Description Replaced Qty. Notes Kits/Assys Where 9 ELBOW K-956 S-0 OIL FILTER 8 5 FILTER ELEMENT S-0 6

37 Group: OIL FILTER Oil Filter Cover Kit (not pictured) 9 - Contained in Item # OIL FILTER Item Description Replaced Qty. Notes Kits/Assys Where 99 CONNECTOR K-956,K-,K- 5,S-0 X-8-5 SCREW K- X-8-5 SCREW K- 080 GASKET K- 5 0 ELBOW K- 6 K- OIL FILTER/ADAPTER KIT A - 08 OIL FILTER ELEMENT K-,K ELBOW K- 9 K- OIL FILTER/ADAPTER KIT 0 A-00 AUX COUNTERSHAFT COVER ASSY K-5 K-5 OIL FILTER COVER KIT CONTAINS A-00

38 8

39 Group: RANGE CYLINDER A-6/9 Rng Cyl RANGE CYLINDER Item Description Replaced Qty. Notes Kits/Assys Where A-6 WELDED YOKE ASSY GASKET K-60,K-99,K- 80,K-80,K CYLINDER K O- RING K-80,K-80,K PISTON 5 K O- RING K-80,K-80,K O- RING K-80,K-80,K X--00 NUT 5/8" GASKET K-60,K-99,K- 80,K-80,K CYLINDER COVER X-8L-60 CAPSCREW 8 /8"-6X-/" K-5 9

40 Group: REVERSE IDLER Latest Design Old Design RI Old Design REVERSE IDLER Item Description Replaced Qty. Notes Kits/Assys Where X--008 NUT 5/8"-8 8 WASHER 0

41 Item Description Replaced Qty. Notes Kits/Assys Where 098 WASHER 8 K-09,S-6 8 BEARING 0500 K-865,K-866,K REVERSE IDLER GEAR RETAINING RING K-09,K- K-09 IDLER SHAFT REPL KIT 605,098, PLUG 9 8 NO LONGER AVAILABLE 0 X--008 CAPSCREW 5/8"-8X-/ 06 RETAINING RING K-09,K- 055 IDLER SHAFT K-09

42 Group: ROADRANGER VALVES 999 Old Design P S SP * * * See: Appendix / Airline Tubing P * 0 S * 0 SP * 0 Splitter Cylinder 00B-5-98 RRV - *For Connector and Elbow Assy component information see Appendix.

43 ROADRANGER VALVES Item Description Replaced Qty. Notes Kits/Assys Where 00 MEDALLION, LOGO (OLD DESIGN) FULLER LOGO ONLY MEDALLION, LOGO (LATEST DESIGN) FULLER LOGO ONLY A-698 K-0 MASTER VALVE REPAIR KIT K-9 MASTER VALVE REPAIR KIT FOR A-50 VALVE FOR A-698 VALVE 095 LEVER A COVER A X-8- SCREW X X/8" 6 X-9-80 NUT /"- 800 CONNECTOR ASSY 850 /8"TUBE-/6"NPTF 800 CONNECTOR ASSY 850 5/"TUBE-/6"NPTF 8005 CONNECTOR ASSY "PUSH-TO-CONNECT" 5/"TUBE- /6"NPTF K-866,K ELBOW ASSY 850 5/"TUBE-/8"NPTF ELBOW ASSY 850 /8"TUBE-/8"NPTF ELBOW ASSY "PUSH-TO-CONNECT" 5/"TUBE- /8"NPTF K-69,K-866,K-,K- 80 UNION ASSY /8" TUBING 80 UNION ASSY 5/" TUBING 80 UNION ASSY "PUSH-TO-CONNECT" 5/" TUBING 5 -O- RING CLAMP 999 A-698 ROADRANGER VALVE ASSY A - 50 STANDARD-W/LOGO

44 Group: SHIFT BAR HOUSING X-Bar SHIFT BAR HOUSING Item Description Replaced Qty. Notes Kits/Assys Where

45 Item Description Replaced Qty. Notes Kits/Assys Where S-0 SHIFT BAR HSG 065 HOUSING ONLY (X) 066 GASKET 98 K-99,S-69,S- 0,S-,S- 060 BREATHER 605 /" NPT K- X--0 PIPE PLUG /" NPT 000 OIL TROUGH S-,S- 5 0 AIR VALVE SHAFT S-,S- 6 X-8- CAPSCREW /"-0X/" X--60 PIPE PLUG X 60 /8" NPT 8 X-8L-609 CAPSCREW /8"-6X-/" 9 GASKET S-69,S-0,S-,S PLUG 8 S-69,S-0,S-,S- 9 NEUTRAL LIGHT SWITCH 69 SWITCH NORMALLY CLOSED LIFTING EYE 05 S-56 6 X-8L-60 CAPSCREW /8"-6X-/" 6 X-8L-60 CAPSCREW 5 /8"-6X-/" OR USE PCS OF X-8L-60 WITH PCS OF X-8L-60 K PIN S-69,S-0,S-,S GASKET S-69,S-0,S-,S REVERSE LIGHT SWITCH 680 SWITCH NORMALLY OPEN PLUG 59 S-69,S-0,S-,S- 598 SPRING K-86,K-866,K-,S-,S- X--800 STEEL BALL /" K-0 ACTUATOR PIN KIT 08 K- 6 6 SHIFT YOKE REVERSE/LO S-9,S- X--00 STEEL BALL /" SHIFT BLOCK ST/ND S- 9 0 LOCKSCREW 5 S-,S- 0 6 INTERLOCK PIN K-86,S-,S- 5

46 Item Description Replaced Qty. Notes Kits/Assys Where 906 SHIFT BLOCK RD/OD S- 00 SHIFT BLOCK 89 RD/OD S-,S- 898 YOKE BAR 060 RD/OD S- 89 SHIFT YOKE ST/ND S-,S YOKE BAR ST/ND S SNAP RING K-0,S-,S- 05 ACTUATOR S-,S SHIFT YOKE 050 RD/OD K-,S-,S YOKE BAR REVERSE/LO S PLUNGER S-9,S-,S- 69 SPRING S-9,S-,S PLUG S-9,S-,S- 999 S- SHIFT BAR HSG ASSY 065 COMPLETE (X) 6

47 Group: SLAVE VALVE - A A-5000 SV Repair Kit SLAVE VALVE - A-5000 Item Description Replaced Qty. Notes Kits/Assys Where A-5000 SLAVE VALVE ASSY 0850 K- K-95 REPAIR KIT-SLAVE VALVE FOR A-5000 VALVE 0855 PLUG A PISTON A CAP 5 A-5000 S-56 CAP ASSY 085,085 8 X-8C- CAPSCREW /"-0X-/"

48 Group: SPLITTER CYLINDER 0 Indicates part of item Latest Design SPLITTER CYLINDER Item Description Replaced Qty. Notes Kits/Assys Where A-0 SPLITTER YOKE ASSY A - 60,A GASKET PRIOR TO SERIAL NUMBER 505 & PRIOR TO SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER 058 GASKET BEGINNING W/SERIAL NUMBER 505 & ALL SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER K-60,K-99,K- 80,K-80 K-60,K-99,K- 80,K SPLITTER CYLINDER PRIOR TO SERIAL NUMBER 505 & PRIOR TO SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER 058 SPLITTER CYLINDER BEGINNING W/SERIAL NUMBER 505 & ALL SERIAL NUMBERS STARTING WITH AN ALPHA CHARACTER 08 -O- RING K-80,K-80 8

49 Item Description Replaced Qty. Notes Kits/Assys Where PISTON O- RING K-80,K-80,K-,K- 0 GASKET K-60,K-99,K- 80,K O- RING K-80,K-80 9 X--805 NUT 0 K- SPLITTER VLV REPL KIT 009,00,00,A INSERT VALVE K-69,K-865,K PLUG X-8L-50 CAPSCREW 5/6"-8X-/8" O- RING K-80,K-,K- 65 -O- RING K-80,K-80,K-,K- 8 X00 BREATHER 95 9 K- SPLITTER VLV REPL KIT 009,00,00,A X-8L-50 CAPSCREW 5/6"-8X-/8" 999 K- SPLITTER VLV REPL KIT 009,00,00,A

50 50

51 5