McQuay Climate Control Singer. Water Source Heat Pump. LE, LG, LL, LM, WA, WE, WG, WH, WM, WR, WW Vintage B. Last Manufactured: 1990

Transcription

1 Replacement Parts List No. Revision A /99 McQuay Climate Control Singer Water Source Heat Pump LE, LG, LL, LM, WA, WE, WG, WH, WM, WR, WW 7 intage B Last Manufactured: 99 To find your Daikin Applied parts distributor, call 7777 or visit

2 CONTENTS PARTS LIST REISION HISTORY... MODEL NUMBER NOMENCLATURE... 4 CATALOG NUMBER NOMENCLATURE... SERIAL NUMBER NOMENCLATURE... UNITS 7 ASSEMBLY DIAGRAM... 7 UNITS 7 ASSEMBLY PART NUMBERS... FIELD INSTALLED ACCESSORY PART NUMBERS... 4 WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

3 Parts List Revision History Revision Date Description A /9 Updated to OnLine format. Added Revision History page. Changes made to: Page Corrected footnote. Page 9 Removed Old/New Condensing Coil footnote for WMC and WME. Daikin Applied, Industrial Park Blvd., P.O. Box, Minneapolis, MN 44 (7) WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

4 MODEL NUMBER NOMENCLATURE WMC7BDE W M 7 B 7 NAMEPLATE OLTAGE CODE: SYSTEM UTILIZATION OLTAGE OLTAGE = = 4 = 7 = 77 DESIGN SERIES: (B = nd Generation) NOMINAL CAPACITY: Hundreds of BTU's UNIT TYPE: M () = Water Source Heat Pump E () = Boilerless System G () = Cooling Only Unit B (P) = Water Source Heat Pump (EQU) C (S) = Boilerless System (EQU) D (T) = Cooling Only Unit (EQU) * Unit types in parenthesis indicate a unit with Fuse Disconnect Assembly FAMILY GROUP: L = Low Sill Unit W = Standard Height Unit CATALOG NUMBER: An eight digit Specific Bill Of Material Number, which is used to identify and order the desired model. Refer to page. WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page 4

5 CATALOG NUMBER NOMENCLATURE W M C 7 B D E. FAMILY GROUP W = Standard Height Unit L = Low Sill Unit. UNIT TYPE * M () = Water Source Heat Pump E () = Boilerless System G () = Cooling Only Unit B (P) = Water Source Heat Pump (EQU) C (S) = Boilerless System (EQU) D (T) = Cooling Only Unit (EQU) * Unit types in parenthesis indicate a unit with Fuse Disconnect Assembly. CAPACITY AND PIPING SIDE* A (B) = 7 C (D) = 9 E (F) = G (H) = J (K) = 7 * Letters in parenthesis indicate a LEFT hand unit. 4. OLTAGE, PHASE & FREQUENCY =, Ph., =, Ph., 7 =, Ph.,. CONTROL OPTIONS. CABINET OPTIONS 7. HEATER OPTIONS = Less Heater A =.4 KW B =. KW C = 4. KW D =. KW E =.4 KW F =. KW. FRESH AIR DAMPER WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

6 SERIAL NUMBER NOMENCLATURE COMPLETE EQUIPMENT SERIAL NUMBER MUST BE FURNISHED ON ALL INWARRANTY ORDERS BEFORE // UNIT TYPE: YEAR MANUFACTURED (979) SEQUENCE NUMBER WEEK MANUFACTURED ( ) KF HEAT SJB HEAT C HEAT KF COOL 4 JB COOL CEC COOL EB HEAT & COOL 7 KF CONTROL SJB CONTROL 9 C CONTROL WK CHASSIS COOL B HEAT & COOL EK HEAT EC HEAT 4 WK HEAT EK HEAT RWK HEAT 7 EWK CONTROL EC CONTROL 9 EJB HEAT EJB CONTROL C CIRCUIT BREAKER D HUMIDIFIER C AUTO TEMP CONTROL 4 BTODC DISPLAY CONTROL U WINDOW P.H. SINGER WINDOW UNIT & REM. 7 R WINDOW UNIT N WINDOW UNIT 9 T WINDOW UNIT F WINDOW UNIT (Tropical) E & K WINDOW UNIT (Sheldon) B & A WINDOW UNIT (anguard) EC CIRCUIT BREAKER & TFR BOX 4 EC TERMINAL BOX AC CIRCUIT BREAKER BOX CW HEAT 7 JW HEAT JB HEAT 9 EKF CONTROL 4 EA UNIT 4 A CONTROL 4 EHC UNIT 4 CC 44 KG/EKG CHASSIS 4 EKG ELECTRIC HEAT SECTION 4 KG CONTROL 47 KG HEAT SECTION (STEAM/H.W.) 4 WM 49 CC HEAT PUMP (CARTERET) F HEAT PUMP (CARTERET) KS P I 4 TYPE 4 (AUBURN) RS UNIT 7 WW, WH, WR CHASSIS S, ES 9 LHP DX FAN COIL (INT'L) GROUND WATER HEAT PUMP (REDBUD RESID. PROD.) DX (HIGH SIDE) RXL COOLING CHASSIS 4 RKL HREAT SECTION 7 WODC & WOTC 7 SCAP 7 INN COMMAND 7 ZONE COMMAND 74 EMCS 7 EMCS 7 EMCS 77 EMCS 7 EMCS 79 EMCS SERIES NE & NH CHASSIS SERIES & NR HIRISE CHASSIS HI RISE 4 REMOTEAIRE AFTER 4//9 PLANT IDENTIFICATION NUMBER: = MINNEAPOLIS = FARIBAULT = GRENADA = STAUTON 7 = AUBURN 9 = SCOTTSBORO 7 R M 4 ENGINEERING REISION SEQUENCE NUMBER YEAR MANUFACTURED: MONTH MANUFAC TURED: A = 97 J = 979 S = 97 A = JANUARY G = JULY B = 97 K = 9 T = 9 B = FEBRUARY H = AUGUST C = 97 L = 9 U = 99 C = MARCH J = SEPTEMBER D = 974 M = 9 = 99 D = APRIL K= OCTOBER E = 97 N = 9 W = 99 E = MAY L = NOEMBER F = 97 P = 94 X = 99 F = JUNE M = DECEMBER G = 977 Q = 9 Y = 99 H = 97 R = 9 Z = 994 WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

7 UNITS 7 ASSEMBLY DIAGRAM WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page 7

8 UNITS 7 ASSEMBLY PART NUMBERS KEY PART No. DESCRIPTION FIELD REFERENCE No. COMPRESSOR AKAT4A4 COMPRESSOR (WM9 Units Only) olt 9 COMPRESSOR AKET4A4 7 COMPRESSOR AKJB4A4 7 COMPRESSOR AKJT4A4 7 B 9 B 74 COMPRESSOR AKET4A4 7 COMPRESSOR AKJB4A4 COMPRESSOR AKJT4A4 7 COMPRESSOR AKET4A4 7 COMPRESSOR AKJB4A4 B 9 COMPRESSOR AJJTA4 OERLOAD, COMPRESSOR MRA79 99 OERLOAD, COMPRESSOR MRA97 77 OERLOAD, COMPRESSOR MRA9 7 OERLOAD, COMPRESSOR MRA9 79 OERLOAD, COMPRESSOR MRA94 OERLOAD, COMPRESSOR MRA79 OERLOAD, COMPRESSOR MRA99 OERLOAD, COMPRESSOR MRA94 9 OERLOAD, COMPRESSOR MRA999 OERLOAD, COMPRESSOR MRA9 4 OERLOAD, COMPRESSOR MRA944 4 OERLOAD, COMPRESSOR CSTAKN 79 GROMMET, COMPRESSOR MOUNTING CONNECTOR 4 7 CLIP, COMPRESSOR MOUNTING 74 CAPACITOR, COMPRESSOR MFD/7 74 CAPACITOR, COMPRESSOR MFD/7 74 CAPACITOR, COMPRESSOR MFD/44 7 CAPACITOR, COMPRESSOR MFD/7 74 CAPACITOR, COMPRESSOR 7.MFD/7 74 REERSING ALE 9 REERSING ALE 7 4 SOLENOID COIL, RE. ALE L7 (also for WM9) 7 SOLENOID COIL, RE. ALE L7 7 SOLENOID COIL, RE. ALE L7 7 4 SOLENOID COIL, RE. ALE L7 ONLY! Compressor 9 uses Capacitor 74 WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

9 UNITS 7 ASSEMBLY PART NUMBERS KEY PART No. DESCRIPTION FIELD REFERENCE No. 7 B 9 B B 4 FUSIBLE PLUG FITTING, FUSIBLE PLUG 9 STRAINER, CAPILLARY (Formed, 497) 9 9 STRAINER, CAPILLARY (Formed, ) 9 99 STRAINER, CAPILLARY (Formed, 4) 4 SWITCH, HIGH PRESSURE CUT OUT G 4 T'STAT, LOW TEMP. CUTOUT (Clamp On) 4F THERMOSTAT, LOW TEMP. CUTOUT (Screw On) A9 CLAMP, LOW TEMP. THERMOSTAT 47 COIL, CONDENSER 47 COIL, CONDENSER 49 COIL, CONDENSER 4 ALE, CHECK COIL, EAPORATOR 4 47 COIL, EAPORATOR 4 47 COIL, EAPORATOR RELAY, COMPRESSOR LOCKOUT 9774Z 4 RELAY, COMPRESSOR LOCKOUT 9774Z 47 RELAY, COMPRESSOR LOCKOUT 97744Z 79 TERMINAL BOARD MOLEX (4 Circuit) 77 MOLEX (4 Circuit) 7 MOLEX TERMINAL (4 Circuit) Use Clamp with 4 Thermostat Replace old Condensing Coil with new Condensing Coil, Discharge Tube and Water Tube: Old New Discharge Water Condensing Coil Condensing Coil Tube Tube WMB WA/WGB WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page 9

10 UNITS 7 ASSEMBLY PART NUMBERS KEY PART No. DESCRIPTION FIELD REFERENCE No. 9 4 MOTOR PJM MOTOR PJM MOTOR PJM 9 44 MOTOR PJM 9 44 MOTOR PJ4H 7 B 9 B 9 4 MOTOR KCP9BK7S 9 49 MOTOR KCP9BKS 9 49 MOTOR KCP9BK9S 9 44 MOTOR PJ4H 9 49 MOTOR (Except EQU units) KCP9BKS 9 44 MOTOR (EQU Only) 9 49 MOTOR KCP9BK4S 9 49 MOTOR KCP9BKS B 9 44 MOTOR PJ4K 74 CAPACITOR, MOTOR, MFD/7 97F7 7 CAPACITOR, MOTOR, MFD/7 97F 74 CAPACITOR, MOTOR, MFD/44 97F47 74 CAPACITOR, MOTOR, 4MFD/7 97F CAPACITOR, MOTOR, MFD/44 7 CAPACITOR, MOTOR, MFD/7 WHEEL, BLOWER THERMOSTAT ACO 4 C79 4 THERMOSTAT MCO 4 C9 THERMOSTAT NCO 4 SWITCH PB 4 ASP SWITCH PB 4 ASP4 SWITCH PB 4 ASP47 SWITCH PB 4 ASP447 4 KNOB, THERMOSTAT 9 ESCUTCHEON PLATE (Button) 9 ESCUTCHEON PLATE (Button) 7 ESCUTCHEON PLATE (Blank) 7 MOLEX ( Circuit) 7 7 MOLEX ( Circuit) 79 MOLEX TERMINAL ( Circuit) 4 Check endor Number for correct part. WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

11 UNITS 7 ASSEMBLY PART NUMBERS KEY PART No. DESCRIPTION FIELD REFERENCE No. 7 B 9 B B 9 PANEL, R.H. 9 9 PANEL, L.H. 9 PANEL, CENTER 9 PANEL, BACK 9 BASE PAN 97 COIL SUPPORT, L.H CONDENSATE TRAY 9 WIREWAY 9 COER, CONDENSER 7 49 COER, COMPRESSOR FAN BOARD 7 FAN BOARD 9 SCROLL 4 END PLATE, L.H. 4 END PLATE, R.H MOTOR MOUNT 4 7 GUARD 4 GUARD 44 7 CLIP, MOTOR MOUNT 4 FILTER, DISPOSABLE (WM Only) 7. x 9. x. 4 7 FILTER, PERMANENT (WM Only) 4 4 FILTER, DISPOSABLE (LM Only) 4 FILTER, PERMANENT (LM Only) 4 FILTER RAIL SAMPLING CHAMBER 4 77 BOTTOM, CONTROL BOX SEAL WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

12 UNITS 7 ASSEMBLY PART NUMBERS KEY PART No. DESCRIPTION FIELD REFERENCE No. 9 COIL SUPPORT, R.H. 7 B 9 B 99 COIL SUPPORT, R.H. B 9 COIL SUPPORT, R.H. BAFFLE 779 GRILLE 7 GRILLE CHANNEL 4 TRANSFORMER 4/4A AT4A 4 TRANSFORMER 4/4A AT4A TRANSFORMER 4/4A 4E7 4 BRACKET, TRANSFORMER 4 COIL, WET HEAT x 4 COIL, WET HEAT x 4 COIL, WET HEAT x4 4 ALE, STEAM (N.C.) 4C47GB 4 4 ALE, STEAM (N.C.) 4C47GU 4 ALE, STEAM (N.C.) 4C47GD 4 ALE, STEAM (N.C.) 4CO47GT 4 9 ALE, HOT WATER (N.O.) (WM 9 Only)4C7GB 4 9 ALE, HOT WATER (N.O.) 4C7GU 4 ALE, HOT WATER (N.O.) 4CO7GD 4 9 ALE, HOT WATER (N.O.) 4CO7GT ALE, WATER REGULATING (WH, WR & WW) 4 HEATER ASS Y /W 4 HEATER ASS Y 4/W/W 4 HEATER ASS Y 77/W4/W 4 HEATER ASS Y 77/W 77 HEATER ASS'Y (WE 7 Only) HEATER ASS Y /W 74 HEATER ASS Y 4/W/W 74 HEATER ASS Y 4/W77/W 74 HEATER ASS Y 77/W ELEMENT, HEATER, KW / 9 SWITCH, SAFETY (Electric Heat Only)TX (Thermodisc) 47 SWITCH, SAFETY L SWITCH, SAFETY Use 4 Bracket with Transformer. WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

13 UNITS 7 ASSEMBLY PART NUMBERS KEY PART No. DESCRIPTION FIELD REFERENCE No. 74 THERMOSTAT, LOOP TEMPERATURE 4T B 9 B B 49 SWITCH, STANDBY (TOGGLE) EX77 WIRE HARNESS, OLD MOLEX TO AMP ONNECTOR 4 CONTROL BOX, K 77 4 CONTROL BOX, M (STD/MCO) 949 KICK PLATE, R.H. END, REAR 9 KICK PLATE, L.H. END, REAR 9 KICK PLATE, R.H. END, FRONT 9 KICK PLATE, L.H. END, FRONT CIRCUIT BREAKER ASSEMBLY 9 CIRCUIT BREAKER A/77 49 FUSE FOR BREAKER A/ 7 FUSE HOLDER A Circuit Breaker Assembly includes 9 (circuit breaker), 49 (breaker fuse) and 7 (fuse holder) WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page

14 FIELD INSTALLED ACCESSORIES SUPPLY AND RETURN HOSES (Chamberlin) /" Long... 9 /4" Long... 9 /4" Long /4" Long... 9 /4" Long... 9 /4" Long /4" Long... 9 CONDENSATE HOSE (Chamberlin) Preformed, clear with nylon /" MPT fittings and clamps:... NOTE: A typical hose kit might consist of two 94 and one. COMBINATION SHUTOFF/BALANCING BALL ALE /" FPT (Two required per unit) SILL GRILLE & DUCT ADAPTER A: With 4way steel grilles and control door: UNITS... PART NO B: With extruded grille and control door: UNITS... PART NO CORD KITS & RECEPTACLES Amp, / olt Cord Kit (NEMA P)... Receptacle (NEMA R) Amp, / olt Cord Kit (NEMA P)... (d) Receptacle (NEMA R)...9 (e) Amp, olt Cord Kit (NEMA 7P)... Receptacle (NEMA 7R) FUSED DISCONNECT SWITCH Pole, Amp, olt Pole, Amp, / olt Pole, Amp, olt Pole, Amp, / olt Pole, Amp, / olt OUTSIDE WALL BOX (for use with fresh air damper) brick high x bricks long: Natural anodized Bronze anodized... ENGR AB Bronze enamaled... ENGR AC FINISHED BACK PANEL KITS For instances where chassis cannot be bolted to the wall in the normal manner. Kits include insulated back panel with mounting hardware and floor mounting brackets. UNITS... PART NO. 7 LM WM CONTROL DOOR KITS (Retrofit ) LM/WM Standard LM/WM with Keylock SPARE CABINETS (Shipped seperataly for replacements) For WM/WE/WG sizes 7 "L" closure/duct collar... 7 Standard cabinet, R.H... 9 Standard cabinet, L.H Cabinet with door, R.H... Cabinet with door, L.H... Cabinet with lock, R.H... Cabinet with lock, L.H... 4 Extruded grille & door, R.H... 7 Extruded grille & door, L.H... Extruded grille & lock, R.H... 9 Extruded grille & lock, L.H... 7 For LM/LE/LG sizes 7 "L" closure/duct collar... 9 Standard cabinet, R.H Standard cabinet, L.H Cabinet with door, R.H... Cabinet with door, L.H... 4 Cabinet with lock, R.H Cabinet with lock, L.H Extruded grille & door, R.H... ENGR AD Extruded grille & door, L.H... ENGR AE Extruded grille & lock, R.H...ENGR AM Extruded grille & lock, L.H... ENGR AN WSHP; LE,LG,LL,LM,WA,WE,WG, WH,WM,WR,WW 7, int. B Rev. A /99 RPL / Page 4