ELECTRICAL DIAGNOSTICS & OPERATION
|
|
- Roy Barnett
- 6 years ago
- Views:
Transcription
1 Operation Function: Provides power to the headlights, tail lights, hazard lights, work light and dash lights in different combinations depending upon the position the light switch is placed in. Operating Conditions: A properly connected and operating unswitched power circuit. and The light switch in either the HAZARD, WORK or ROAD position. Road Position: In the Road position, current is provided to the headlights, tail lights and dash lights through the same circuits as the light switch in the Work position, however the work lights are not powered. The turn/hazard lights receive current through the same circuits as they do with the light switch in the Hazard position. Theory of Operation: The light switch has 4 positions. OFF, HAZARD, WORK and ROAD. The light switch receives unswitched power from the battery through the 211, 212, 214, 95 and 96 / wires and is protected by the F1 40 amp fuse. Dash s The dash lights are used to illuminate the control panel. When the S5 light switch is in the WORK or ROAD position, voltage is provided through the light switch and F5 20 amp fuse to the H6 dash lights (15, 13, and 563 wires). Hazard Position: In the Hazard position current flows from the light switch through the (light switch) connector, 11 and 12 wires, F3 10 Amp fuse, and the 29, 103, and 104 wires, V7 diode, and 24 wire to the K6 flasher (terminals A and ). Intermittent current flows from the flasher (terminal I) through the 31, 30, and 32 Yel wires to the H4 left turn indicator light and the E3 left turn/hazard light. Intermittent current also flows from the flasher (terminal H) through the 34, 33, and 35 wires to the H5 right turn indicator light and the E1 right turn/hazard light. Work Position: In the Work position current flows from the S5 light switch through the 9 wire, F5 20 amp fuse, and the 15, 17, 18, 19, 106, and 14 wires to the E6 right headlight, E5 left headlight, E2 right tail light and the E4 left tail light. The 13 and 563 wires also provides current to the H6 dash lights. The Work position of the light switch also provides current to the E7 work light. The E7 work light receives current through the 68 Yel wire, F4 10 Amp fuse, and 69 Yel wire. Electrical Diagnostics & Operation - 160
2 Schematic ELECTRICAL DIAGNOSTICS & OPERATION / S1 Key X M1 Starting Motor F1 Fuse 211 X2 R1 G1 attery R2 / M / C1 / Start On Off C2 214 X8 Y1 Starting Motor Solenoid W1 Frame Ground 95 X3 96 / Yel/ Yel/ Yel/ S5 S5 Power (Unswitched) S5 D J Power (ed) 24 A K6 Flasher 68 Yel V7 Diode 103 H4 Turn I H K 31 Yel F4 Fuse 69 Yel F5 Fuse 12 / F3 Fuse Yel Grn /Yel Ground (Unswitched) H6 Dash 594 H5 Turn X13 E1 Turn/ Hazard 32 Yel X16 E5 Head Control Panel Wiring Harness E3 Turn/ Hazard E6 Head X20 E7 Work (Option) X20 X14 E2 Tail X15 87 X17 E4 Tail X Electrical Diagnostics & Operation - 161
3 Diagnosis ELECTRICAL DIAGNOSTICS & OPERATION switch in HAZARD position s - Hazard s A 1. Is battery voltage present at the S5 light switch (A)? No: Test F1 fuse. Check 211, 212, 214, 95, and 69 / wire and E F 5. Is intermittent battery voltage present at the H4 left turn light socket (E)? No: Check 31 and 30 Yel wires and If OK, replace K6 flasher. 6. Is continuity to ground present at the H4 left turn light socket (F)? No: Check 145, 142, 71, and 73 wires and 2. Is battery voltage present at the K6 flasher ()? No: Test F3 fuse. Test V7 Diode. Check 11, 12, 29, 103, and 24 wires and If OK, replace light switch. 3. Is battery voltage present at the K6 flasher (C)? No: Test F3 fuse. Check 11, 12, 29, 103, and 104 wires and If OK, replace light switch. 4. Is continuity to ground present at the K6 flasher (D)? No: Check 88 and 82 wires and D C H 7. Is intermittent battery voltage present at the H5 right turn light socket (G)? No: Check 34 and 33 wires and If OK, replace K6 flasher. 8. Is continuity to ground present at the H5 right turn light socket (H)? No: Check 144, 142, 71, and 73 wires and 9. Is intermittent battery voltage present at the E1 right turn/hazard light (I)? G I J Electrical Diagnostics & Operation - 162
4 No: Check 34 and 35 wires and If OK, replace K6 flasher. 10. Is continuity to ground present at the E1 right turn/ hazard light (J)? No: Check 87 and 82 wires and L K N O 2. Is battery voltage present at the E7 work light (N)? No: Check F4 fuse. Check 68 and 69 Yel wires and If OK replace light switch. 3. Is continuity to ground present at the E7 work light (O)? No: Check 90 and 82 wires and 11. Is intermittent battery voltage present at the E3 left turn/hazard light (K)? No: Check 31 and 32 Yel wires and If OK, replace K6 flasher. 12. Is continuity to ground present at the E3 left turn/ hazard light (L)? Yes: Go to next test condition. No: Check 84 and 82 wires and switch in WORK position s - Work s Q P 4. Is battery voltage present at the E2 right tail light (P)? No: Test F5 fuse. Check 9, 15, and 106 wires 5. Is continuity to ground present at the E5 right tail light (Q)? No: Check 87 and 82 wires and M 1. Is battery voltage present at the S5 light switch (M)? No: Test F1 fuse. Check 211, 212, 214, 95, and 69 / wire and Electrical Diagnostics & Operation - 163
5 6. Is battery voltage present at the E4 left tail light (R)? No: Test F5 fuse. Check 9, 15, and 14 wires 7. Is continuity to ground present at the E4 left tail light (S)? No: Check 84 and 82 wires and T U 8. Is battery voltage present at the H6 dash lights sockets (T)? No: Test F5 fuse. Check 9, 15, 13, and 563 wires 9. Is continuity to ground present at the H6 dash lights sockets (U)? Yes: Test bulb(s). Go to next step. No: Check 147, 146, 142, 71, and 73 wires and U R S T V 10. Is battery voltage present at the E6 right headlight (V)? No: Test F5 fuse. Check 9, 17, and 19 wires 11. Is continuity to ground present at the E6 right headlight (W)? No: Check 80 and 73 wires and X W Y 12. Is battery voltage present at the E5 left headlight (X)? No: Test F5 fuse. Check 9, 17, and 18 wires 13. Is continuity to ground present at the E5 left headlight (Y)? Yes: Test bulb. Go to next test. No: Check 80 and 73 wires and switch in ROAD position s - Road s 1. Are the hazard lights flashing? No: See s - Hazard s on page Are the headlights and taillight illuminated? Yes: Test complete. No: See s - Work s on page 163. Electrical Diagnostics & Operation - 164
DIAGNOSIS. https://mitsubishitechinfo.com/data/st41/2003/m /html/m of 6 1/17/2016 5:45 PM
1 of 6 1/17/2016 5:45 PM DIAGNOSIS Required Special Tools: MB991223: Harness Set MB991502: Scan Tool (MUT-II) MB991862: SWS monitor kit STEP 1. Use scan tool MB991502 to select "ECU COMM CHK" on the SWS
More informationDIAGNOSTIC INFORMATION AND PROCEDURES > WIPERS INOPERATIVE - ONE OR MORE MODES
1 of 6 2/1/2015 8:12 PM 2005 Chevrolet Colorado 3.5L Eng Vehicle Reference: WIPER SYSTEMS & WASHER SYSTEMS DIAGNOSTIC INFORMATION AND PROCEDURES > WIPERS INOPERATIVE - ONE OR MORE MODES Wipers Inoperative
More informationELECTRICAL TABLE OF CONTENTS
ELECTRICAL TABLE OF CONTENTS Electrical Table of Contents General Information...205 Reading Electrical Schematics...205 Theory Of Operation Information...206 Diagnostic Information...206 Wire Color Abbreviation
More informationELECTRICAL / GENERAL INFORMATION
ELECTRICAL / GENERAL INFORMATION General Information Reading Electrical Schematics The schematic is made up of individual circuits laid out in a sequence of related functions. It is formatted with all
More informationDTC P Shift Solenoid Circuit Electrical
1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve Assembly (1-2 SS Valve Assy.) controls the transmission fluid pressure on the 1-2
More informationFuel Pump Electrical Circuit Diagnosis
Page 1 of 6 Document ID# 599891 2000 Chevrolet Camaro Feedback Print Fuel Pump Electrical Circuit Diagnosis Circuit Description When the ignition switch is ON, the powertrain control
More informationPRESSURE SWITCH SENSE CIRCUIT
Symptom: P0876-UD PRESSURE SWITCH SENSE CIRCUIT When Monitored and Set Condition: P0876-UD PRESSURE SWITCH SENSE CIRCUIT When Monitored: Whenever the engine is running. Set Condition: This DTC is set if
More informationDTC P1655 Evaporative Emission (EVAP) Purge Solenoid Control Circuit
Page 1 of 5 1997 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 58460 DTC P55 Evaporative Emission (EVAP) Purge Solenoid Control Circuit Circuit Description Output Driver
More informationTURN SIGNAL AND HAZARD WARNING SYSTEM
BE68 BODY ELECTRICAL SYSTEM TURN SIGNAL AND HAZARD WARNING SYSTEM DESCRIPTION The component parts of this system and their function are as shown in the following table. Parts Name Function Turn Signal
More informationTaillight Relay Circuit
GHTI GHTI SYSTEM 63 Taillight Relay Circuit DESCRIPTION The headlight dimmer switch sends a signal to the main body ECU. WIRI DIAGRAM Main Body ECU TAIL To Battery TAIL TRLY Outer Rear View Mirror Illumination
More informationDiesel Technology: Electrical and Electronic Systems
Diesel Technology: Electrical and Electronic Systems NATEF Crosswalk The following NATEF Electrical/Electronic Systems tasks (rev. 2001) are covered in this publication. The chart shows where each task
More informationExterior Lights. How the Headlights Circuit Works USA. Flash-to-Pass WARNING
Exterior Lights How the s Circuit Works USA WARNING A transient high tension (25,000 V) occurs at the bulb sockets of the high intensity discharge (HID) lamps when the combination light switch is turned
More informationTEST SPECIFICATIONS AND TASK LIST ELECTRICAL/ELECTRONIC SYSTEMS (TEST A6)
TEST SPECIFICATIONS AND TASK LIST ELECTRICAL/ELECTRONIC SYSTEMS (TEST A6) Content Questions Percentage Area in Test of Test A. General Electrical/Electronic System 13 26% Diagnosis B. Battery Diagnosis
More informationCHASSIS TECH TIPS. Subject: DPR TEMPERATURE SENSOR CIRCUIT LOAD TEST
Subject: DPR TEMPERATURE SENSOR CIRCUIT LOAD TEST 1. RELEVANT MODELS: 2008 thru 2010 J05 and J08 Engines. 2. CONDITIONS: a. The driver may report a recent increase in the request for Manual Regeneration
More informationINSTRUCTION SHEET. Part Number Application: Standard Beetle Hardtop Sedans. Tools Needed
Part Number 344-509 Application: 1972-1973 Standard Beetle Hardtop Sedans Part Includes 1 - Main Harness Replacement Wiring Harness Tools Needed SOAP 1- Front Harness 1- Brake Master Cylinder Harness 1-
More information2009 Model year NPR, NPR HD Gas Electrical Symbols. Symbol Meaning Symbol Meaning Symbol Meaning
2009 Model year NPR, NPR HD Gas Electrical Symbols 14.1 Symbol Meaning Symbol Meaning Symbol Meaning Fuse Electronic Parts Coil (Inductor), Solenoid Magnetic Valve Fusible Link Resistor Relay Fusible Link
More informationGUARDIAN 401 A - Symptom Flow Chart - Lift Interlock Condition Possible Causes Action No prove out of LED's
GUARDIAN 401 A - Symptom Flow Chart - Lift Interlock Condition Possible Causes Action prove out of LED's Connections Power Ground Wake up LED panel Harness(es) Module Go to Pinpoint Test A LED's not illuminated
More informationDTC P Shift Solenoid Circuit Electrical
1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve (1-2 SS Valve) controls the fluid flow acting on the 1-2 and 3-4 shift valve. The
More informationP0030, P0036, -- P0135, P0141, P0155, P0161 P0030, P0036, P0050, P0056, P0135, P0141,
Page 1 of 6 2008 Pontiac G8 DTC P0030, P0036, P0053, P0054, P0135, or P0141 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure. Review Strategy
More informationSymptom Suspected Area See page Ignition switch is not set to each position. 11.Ignition switch BE 14
BE2 BODY ELECTRICAL PROBLEM SYMPTOMS TABLE IGNITION SWITCH AND KEY UNLOCK WARNING SWITCH BE0ON18 Ignition switch is not set to each position. 11.Ignition switch BE14 Key unlock warning system does not
More informationPower Supply Circuit For Transfer Control Unit
Page 1 of 7 2005 Nissan Xterra 4.0L Eng S Power Supply Circuit For Transfer Control Unit CONSULT-II REFERENCE VALUE IN DATA MONITOR MODE Data are reference value. DATA MONITOR MODE REFERENCE Monitored
More informationModifying the exterior lighting of the Ram truck
Modifying the exterior lighting of the Ram truck The Ram truck has been designed and developed using standard incandescent lights. These lights are controlled by a computerized module called the Central
More informationHEADLIGHT AND TAILLIGHT
BE14 HEADLIGHT AND TAILLIGHT SYSTEM PARTS LOCATION BE15 TROUBLESHOOTING The table below will be useful for you in troubleshooting these electrical problems. The most likely causes of the malfunction are
More informationPantera Electronics LED Taillight Installation Manual
Pantera Electronics LED Taillight Installation Manual (2nd Gen) This LED signal lamp conversion was designed to replace the incandescent lamp 1157 with a Light Emitting Diode Array designed specifically
More informationLight Kit Groundsmaster 7200 Series Mowers
Form No. 3405-333 Rev A Light Kit Groundsmaster 7200 Series Mowers Model No. 31508 Serial No. 400000000 and Up Register at www.toro.com. Original Instructions (EN) *3405-333* A Ordering Replacement Parts
More informationPantera Electronics LED Taillight Conversion Installation Manual
Pantera Electronics LED Taillight Conversion Installation Manual This LED signal lamp conversion was designed to replace the incandescent lamp 1157 with a Light Emitting Diode Array designed specifically
More informationEU DLX LED Tail-Light Kit Installation:
WWW.MUSTANGPROJECT.COM Page 1 1964.5-1966 EU DLX LED Tail-Light Kit Installation: First we will remove the old original flasher module. The original flasher module will be located on the driver side of
More informationAudi A4 Current Flow Diagram No. 50 / 1 Edition
Page 1 of 8 Audi A4 Current Flow Diagram No. 50 / 1 Edition 12.2003 5-speed automatic gearbox with Tiptronic From model year 2002 Main fuse On battery Fuse box Dash panel, driver's side Fuse colours 30
More informationPorsche 928 Electrics. Table of Contents
PAGE 1 Table of Contents ALL PAGE NUMBERS ARE HYPERLINKED [SECTIONS BEYOND SECTION 8 ARE IN THE MAIN 928-ELECTRICS DOCUMENT ONLY] WIRING DIAGRAM PRIMER 1 2 WIRING OVERVIEW... 1 2.1 Standardized Wire Jacket
More informationSymptom Suspect Area See page. 11.Ignition Switch 12.Power Source Circuit. Symptom Suspect Area See page
BE2 PROBLEM SYMPTOMS TABLE IGNITION SWITCH: BE18204 Ignition switch is not set to each position. KEY UNLOCK WARNING SWITCH: 11.Ignition Switch 12.Power Source Circuit BE15 Key unlock warning system does
More informationBMW K1100LT 1993 & Earlier Wiring Diagrams
BMW K1100LT 1993 & Earlier Wiring Diagrams 1)ABS 2) Motronic with Inputs 3) Motronic with Outputs 4) Instrument Cluster 5) Plus, s, Fuses 6) Reading Light 7) Radio 8) Windscreen 9) Lights with Brake Lights
More informationEmission Control System
Emission Control System Exhaust Gas Recirculation (EGR) System [B18A1 engine: A/T] Troubleshooting Flowchart The Malfunction Indicator Lamp (MIL) indicates Diagnostic Trouble Code (DTC) 12: A problem in
More informationSTEERING COLUMN SWITCHES
STEERING COLUMN SWITCHES 1994 Toyota Celica 1994 ACCESSORIES & EQUIPMENT Toyota Motor Sales, U.S.A., Inc. - Steering Column Switches Celica * PLEASE READ THIS FIRST * WARNING: Are equipped with a driver-side
More informationPage 1 of 6 2007 Chevrolet Tahoe 5.3L Eng 1Search Print Date: P0036 DTC P0030, P0036, P0053, P0054, P0135, Or P0141 DTC Descriptors DTC P0030 HO2S Heater Control Circuit Bank 1 Sensor 1 DTC P0036 HO2S
More informationActive Grille Air Shutter 1 Malfunction
Page 1 of 5 Active Grille Air Shutter 1 Malfunction 2015 Cadillac ATS 2.0L Eng Premium Print Date: Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.
More informationheadlights [H only] dip switch hi beam flasher pillar interior lights rear interior panel switch C/D cubby A B boot map light LED strip
to Alpine unit exterior lights [S or H or F] FUSE BOX LIGHTS ENGINE ACC reverse light, brake Note: diode (6a 50v) prevents triggering of Alpine backup camera when brake light is closed brake L tail plate
More informationBody Electrical System
Body Electrical System GENERAL....BE -2 MULTI FUNCTION SWITCH...BE -8 HORN...BE -11 FUSES AND RELAYS...BE -12 INDICATORS AND GAUGES...BE -19 LIGHTING SYSTEM...BE -24 DAYTIME RUNNING LIGHTS...BE -30 BE-2
More informationPage 1 of 5 1Search Print Date: P0179 DTC P0179: Fuel Composition Sensor Circuit High Frequency Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.
More informationDistributor Ignition DI System Diagnosis
Page 1 of 8 2004 Chevrolet K Silverado - 4WD Sierra, Silverado VIN C/K Service Manual Engine Engine Controls - 4.3L Diagnostic Information and Procedures Document ID: 848577 Distributor Ignition DI System
More informationDTC P3401, P3425, P3441, or P3449
Page 1 of 5 2008 Chevrolet Avalanche - 4WD Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C/K Service Manual Document ID: 1914310 DTC,,, or Diagnostic Instructions Perform the Diagnostic System Check
More informationTRANSMISSION - NGC. Symptom: P0706-CHECK SHIFTER SIGNAL. When Monitored and Set Condition:
Symptom: P0706-CHECK SHIFTER SIGNAL When Monitored and Set Condition: P0706-CHECK SHIFTER SIGNAL When Monitored: Continuously with the ignition on. Set Condition: After 3 occurrences in one ignition cycle
More informationP3449-MDS SOLENOID 7 CIRCUIT
8 - HG - CHRYSLER ASPEN - 5.7L HEMI V8 - P449- ENOID 7 CIRCUIT CONTROL CONTROL NO. CONTROL NO. 4 CONTROL NO. 6 CONTROL NO. 7 6 C 8 C 6 C 5 C K45 K454 K45 K45 BR/OR P C8 BR/LB M C8 K45 K454 BR/OR 4 C K45
More informationComponents included in your kit:
Page 1 Components included in your kit: All of the equipment illustrated in this manual was proudly manufactured in the USA by Mustang Project a SafeCode Inc. enterprise. For accessories and spare parts
More informationTHROTTLE BODIES 7-6. c. Connect the pressure gauge 2 and adapter 3 to the fuel hose (fuel tank to primary
THROTTLE BODIES EAS26980 CHECKING THE INJECTORS 1. Check: Injectors Damage Replace. EAS26990 CHECKING THE THROTTLE BODIES 1. Check: Throttle bodies Cracks/damage Replace the throttle bodies as a set. 2.
More informationSequential Tail Light System
Sequential Tail Light System Installation Instructions Notice: Our conversion systems are intended for 1965-70 Ford Mustangs only. This is not a replacement system for Shelby Mustangs or Mercury Cougars
More informationSCHEMATIC AND ROUTING DIAGRAMS
2004 ACCESSORIES & EQUIPMENT Theft Deterrent - Corvette SCHEMATIC AND ROUTING DIAGRAMS THEFT DETERRENT SYSTEM SCHEMATICS Fig. 1: Theft Deterrent Relay, Security Indicator, Lighting and Horn References
More informationPage 1 of 6 1Search Print Date: B3140 Power Door Lock Switch Malfunction - DTC B3140, B3145, B3150, Or B3155 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic
More informationCOMPONENT LOCATION INDEX
COMPONENT LOCATION INDEX 2003-04 ACCESSORIES & EQUIPMENT Gauges - Element Fig. 1: Identifying Gauges Component Locations Page 1 Fig. 2: Locating Gauges & Gauge Connectors & Identifying Gauge Connector
More informationHEADLIGHT AND TAILLIGHT SYSTEM
BE13 PARTS LOCATION BE14 BODY ELECTRICAL SYSTEM TROUBLESHOOTING The table below will be useful for you in troubleshooting these electrical problems. The most likely causes of the malfunction are shown
More informationP0882-TRANS 12 VOLT SUPPLY RELAY CONTROL CIRCUIT LOW (DIESEL)
6 - DH - RAM / PICKUP -.9L HO CUMMINS TURBO DIESEL P-TRANS VOLT SUPPLY RELAY CIRCUIT LOW (DIESEL) RUN-START F FUSE A OUTPUT ELECTRONICS POWER C C 9 C F T YL/DB T6 YL/OR S6 F C C T YL/DB 6 T T9 T DG DG/TN
More informationINSTRUCTIONS. 20 Circuit Wiring Kit Instructions October 2009, Speedway Motors, Inc.
1 MAIN FUSE PANEL The main fuse panel harness s designed to be mounted under the dash a the firewall in an area close to the steering column. The enclosed representation of the main dash harness shows
More information2002 Buick Rendezvous - AWD
2002 Buick Rendezvous - AWD DTC P0410 Description The control module activates the secondary air injection (AIR) system by grounding both the pump relay and the vacuum control solenoid control circuits.
More information2004 Ranger Workshop Manual
Page 1 of 6 SECTION 413-00: Instrument Cluster and Panel Illumination 2004 Ranger Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 10/30/2003 Instrument Cluster and Panel Illumination Printable
More informationP TURBOCHARGER BOOST CONTROL CIRCUIT/OPEN
Page 1 of 8 P0045 - TURBOCHARGER BOOST CONTROL CIRCUIT/OPEN Page 2 of 8 Page 3 of 8 For a complete wiring diagram Refer to Section 8W When Monitored: With the ignition on and the Boost Pressure Servo Motor
More informationSunbeam Alpine Series V Four-Way Flasher by Michael Hartman Version 1.0 October 9, 2018
Sunbeam Alpine Series V Four-Way Flasher by Michael Hartman Version 1.0 October 9, 2018 Background My Sunbeam Alpine Series V has the original wiring harness, which does not have a four-way flasher circuit.
More informationLIGHTING. GROUP 54Ac. Continued on next page. 54Ac-1 CONTENTS. GENERAL INFORMATION...54Ac-5. SERVICE SPECIFICATIONS...54Ac-7. SPECIAL TOOLS...
54Ac-1 GROUP 54Ac LIGHTING CONTENTS GENERAL INFORMATION...54Ac-5 SERVICE SPECIFICATIONS...54Ac-7 SPECIAL TOOLS...54Ac-8...54Ac-11 STANDARD FLOW OF DIAGNOSTIC TROUBLESHOOTING...54Ac-11 DIAGNOSTIC FUNCTION...54Ac-11
More informationSPN 51 or Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description
SPN 51 or 3673 Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN FMI Description Possible Causes 51 3 TPS1 Sensor Signal Voltage High Open/high resistance in low Short to
More informationTL - Keyless Entry/Security Alarm System Control Unit Input Test
1999 3.2TL - Keyless Entry/Security Alarm System Control Unit Input Test '99-01 Models 1. Before testing the keyless entry/security control functions, troubleshoot the multiplex control system. Multiplex
More informationCHAPTER 4. ELECTRICAL Table of Contents
4. ELECTRICAL Table of Contents Table of Contents 1 General Information 1-1 Electrical Diagram Information 1-2 Circuit Diagnosis Information...4-3...4-4 1-3 Common Circuit Tests.4-4 2 Electrical System
More informationDIAGNOSTIC TROUBLESHOOTING INDEX
DIAGNOSTIC TROUBLESHOOTING INDEX Curtis Industries, LLC. 111 Higgins Street Worcester, MA 01606 Telephone: (508) 853-2200 Fax: (800) 876-9104 www.snoproplows.com TROUBLESHOOTING INDEX - BY PROBLEM Section
More information2004 HVAC. HVAC Systems - Automatic - Corvette. Fastener Tightening Specifications Specification Application
2004 HVAC HVAC Systems Automatic Corvette SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English Blower Motor Control Module Retaining
More informationFUSES & CIRCUIT BREAKERS Ford Taurus LX
Page 1 of 7 ARTICLE BEGINNING FUSES & CIRCUIT BREAKERS Interior Fuse Panel Identification Fuse panel is located to left of steering column under instrument panel. To expose fuse panel, pull release bar
More informationMUSTANG PROJECT INSTALLING THE MUSTANG PROJECT SHELBY SEQUENTIAL CONVERSION KIT ON YOUR MUSTANG
VOLUME 6 Price:$9.95 MUSTANG PROJECT A SafeCode Inc. Publication INSTALLING THE MUSTANG PROJECT SHELBY SEQUENTIAL CONVERSION KIT ON YOUR 64.5-66 MUSTANG Convert from original 1964.5-66 Mustang style taillights
More informationP0760-OD SOLENOID CIRCUIT
- JC - DGE JOURNEY -.5L V6 V MPI - HIGH OUTPUT P6- CIRCUIT BATT A RELAY-PCM MULE- TOTALLY INTEGRATED POWER A FUSE J A 6 C T6 6 C T6 D C5 T6 S T6 6 L/R / /TRS EMCC VFS C LR UD 6 5 T6 T6 T6 T5 T T T T YL/TN
More informationASE 6 - Electrical Electronic Systems. Module 16 Lighting Systems
Electronic Systems Module 16 Acknowledgements General Motors, the IAGMASEP Association Board of Directors, and Raytheon Professional Services, GM's training partner for GM's Service Technical College wish
More informationDH - RAM 1500/2500 PICKUP - 6.7L CUMMINS TURBO DIESEL
007 - DH - RAM 500/500 PICKUP - 6.7L CUMMINS TURBO DIESEL U004-CAN B BUS (-) CIRCUIT OPEN For a complete wiring diagram, refer to the Wiring Information. When Monitored: With the ignition on and battery
More informationAudi A6 Current Flow Diagram No. 14 / 1 Edition
Стр. 1 из 7 Audi A6 Current Flow Diagram No. 14 / 1 Edition 01.1998 Anti-lock brake system (ABS) with electronic differential lock (EDL), traction control system (ASR/TCS) and electronic stability program
More informationDTC B0228, B0413, B0423, Or B3779
2007 Chevrolet Silverado 1500 : Heating, Ventilation, & Air Conditioning > HVAC Systems - Manual > Diagnostic Information And Procedures > DTC B0228, B0413, B0423, Or B3779 DTC B0228, B0413, B0423, Or
More information1 of 6 3/7/2013 9:56 AM 2002 Chevrolet TrailBlazer - 4WD Bravada, Envoy, TrailBlazer VIN S/T Service Manual DTC P1481 Circuit Description The powertrain control module (PCM) uses the cooling fan speed
More informationCVT RE0F09B TCM P1701 TCM. Description
2012 Nissan-Datsun Altima L4-2.5L (QR25DE) Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts > P1701 CVT RE0F09B TCM P1701 TCM Description When the power supply to
More informationCHAPTER 10 ELECTRIC SYSTEM
CHAPTER 10 ELECTRIC SYSTEM 1. ELECTRIC SYSTEM ELECTRIC SYSTEM 1.1 WIRING DIAGRAM CK20-USA 196WA00A S196-WOO Jul. 2003 10-3 CK20(M) CHAPTER 10 CK20-EU 196WA51A 10-4 S196-WOO Jul. 2003 ELECTRIC SYSTEM 1.2
More information1995 Honda Accord LX. ANTI-LOCK BRAKE SYSTEM' ' BRAKES Honda - Anti-Lock
TROUBLE SHOOTING ANTI-LOCK (ABS) WARNING LIGHT NOTE: ABS system is okay if ABS warning light goes out after engine is started. Diagnostic Trouble Code (DTC) Recognition 1. ABS control unit recognizes system
More informationCruise Control Inoperative/Malfunctioning (WO/ETC)
Cruise Control Inoperative/Malfunctioning (WO/ETC) Diagnostic Aids Important: Perform the following in order to avoid misdiagnosis. Inspect for proper operation of brake lamps and clutch switch, if equipped.
More informationAudi A4 Current Flow Diagram No. 63 / 1 Edition
Sivu 1/6 Audi A4 Current Flow Diagram No. 63 / 1 Edition 04.2006 Headlight for gaseous discharge light (Xenon plus) and automatic headlight range control from August 2004 Notes: For information concerning
More informationIdle Air Control (IAC) System Diagnosis
2001 Oldsmobile Alero Idle Air Control (IAC) System Diagnosis Circuit Description The idle air control (IAC) valve is located in the throttle body. It consists of a movable pintle, driven by a gear attached
More informationFuse/Relay Information
BD 10/24/91 kd 11/12 smk 11/14/91 MC 4/8/92 bd 4/14/92 92 PRELUDE /Relay Information Under-hood /Relay Box 47 46 45 44 43 42 41 40 39 31 49 48 51 50 37 36 35 34 33 32 C941 (To ABS motor relay) 38 C942
More information2008 Hummer H2 - Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L,
Page 1 of 7 2008 Hummer H2 : Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L, 6.0L, 6.2L, Or 7.0L > Diagnostic Information And Procedures > DTC P0011 DTC P0011 DTC P0011 Diagnostic
More information1999 Toyota RAV ACCESSORIES & EQUIPMENT Steering Column Switches - Trucks
1999 ACCESSORIES & EQUIPMENT Steering Column Switches - Trucks DESCRIPTION WARNING: Deactivate air bag system before performing any service operation. See AIR BAG RESTRAINT SYSTEMS article. DO NOT apply
More informationIntelligent Lift Interlock System (ILIS) Installation Instructions
Intelligent Lift Interlock System (ILIS) Installation Instructions Part No: ILIS602-G 2000 2005 Chevrolet Venture Mini-Van To aid in installation, first gain access to the connection points. Remove the
More informationEmission Control System
Emission Control System Exhaust Gas Recirculation System Troubleshooting Flowchart Self diagnosis indicates code 12: Most likely a problem in the Exhaust Gas Recirculation (EGR) system. The EGR System
More informationDTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S)
Page 1 of 5 2001 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S) Circuit Description This
More informationComponents included in your kit:
Page 1 Components included in your kit: The LED flasher module will replace your existing flasher module. The left and right taillight modules will replace your existing All of the equipment illustrated
More informationPN DODGE CORONET Two panel Sequential LED Taillight kit installation guide. Kit Contents:
1969 DODGE CORONET Two panel Sequential LED Taillight kit installation guide Kit Contents: 2 LED panels 4 rubber grommets 1 power wire with t-tap 1 driver side LED harness, 24 1 passenger side LED harness,
More informationFuel System Diagnosis
Page 1 of 6 2001 Chevrolet Malibu Malibu (VIN N) Service Manual Engine Engine Controls - 3.1L (LG8) Diagnostic Information and Procedures Document ID: 704675 Fuel System Diagnosis System Description When
More informationINSTRUMENT PANEL Toyota Celica DESCRIPTION & OPERATION GAUGES SWITCHES TESTING - GAUGES FUEL GAUGE & WARNING LIGHT
INSTRUMENT PANEL 1994 Toyota Celica 1994 ACCESSORIES & EQUIPMENT Toyota Motor Sales, U.S.A., Inc. - Instrument Panel Celica * PLEASE READ THIS FIRST * WARNING: Vehicles are equipped with a driver-side
More informationSystem Description. Diagnostic Aids. Enhanced Ignition System Diagnosis
Enhanced Ignition System Diagnosis System Description This system includes the distributor, the CAM position sensor ignition coil with the ignition coil driver, the secondary wires, spark plugs, the knock
More informationP0030, P0036, P0050, P0053, P0054, P0056, P0059, P0060, P0135, P0141, P0155, or P0161
DTC Descriptors DTC P0030 HEGO Heater Control Circuit Bank 1 Sensor 1 DTC P0036 HEGO Heater Control Circuit Bank 1 Sensor 2 DTC P0050 HEGO Heater Control Circuit Bank 2 Sensor 1 DTC P0053 HEGO Heater Resistance
More informationSTARTER CIRCUIT TROUBLESHOOTING
2000 Honda Accord EX Sedan V6-3.0L Vehicle > Starting and Charging > Starting System > Starter Motor > Testing and Inspection > Component Tests and General Diagnostics STARTER CIRCUIT TROUBLESHOOTING Starter
More informationDTC P0341 Camshaft Position (CMP) Sensor Performance
Page 1 of 5 1999 Buick Century Century, Regal VIN W Service Manual Document ID: 345654 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description During cranking, the Ignition Control Module
More informationP0750-LR SOLENOID CIRCUIT
9 - JS - DGE AVENGER -.L CYL DOHC V DUAL V.V.T. P-LR CIRCUIT BATT A B(+) CONTROL OUTPUT ELECTRONICS TOTALLY INTEGRATED POWER C T S T C T C T S T - - UD / T T YL/TN YL/DG T9 DG/TN T9 T T9 T YL/DB DG/WT
More informationCAUTION. Even Brakes with a black cable need second vehicle kit Even Brakes with a blue cable need second vehicle kit 98450
cable not included cable not included Even Brakes with a blue cable need second vehicle kit 98450 Even Brakes with a black cable need second vehicle kit 98400 Check the Even Brake serial number before
More informationTransfer Control Device
Page 1 of 9 2005 Nissan Xterra 4.0L Eng S Transfer Control Device CONSULT-II REFERENCE VALUE IN DATA MONITOR MODE Data are reference value. DATA MONITOR MODE REFERENCE Monitored item [Unit] Content Condition
More informationFORD MUSTANG. Two Panel Sequential LED Tail Light Kit Installation Guide
1967-68 FORD MUSTANG Two Panel Sequential LED Tail Light Kit Installation Guide Kit Contents: 2 LED panels 2 rubber grommets 1 power wire with t-tap 1 driver side LED harness, 24 1 passenger side LED harness,
More informationG.M. Electronic 4x4 System
154 Diagnosis The NV233 systems up to 2004, found on Blazer, S-10 trucks and Tahoe applications, will not allow data or code retrieval with a scanner, however manual code retrieval is available. To retrieve
More informationGuardian Personal Mobility Lift Interlock GRD701-AR ( Dodge Sprinter) Installation Instructions
An ISO 9001:2000 Registered Company Guardian Personal Mobility Lift Interlock GRD701-AR (2007-2008 Dodge Sprinter) Installation Instructions GUARDIAN MODULE Remove drivers seat and step-well trim for access.
More information1970 DODGE CHALLENGER Four panel Sequential LED Taillight kit installation guide
1970 DODGE CHALLENGER Four panel Sequential LED Taillight kit installation guide Kit Contents: 4 LED panels 4 rubber grommets 1 power wire with t-tap 2 driver side LED harnesses, 24 2 passenger side LED
More informationUNIVERSAL WIRING HARNESS Installation Manual
UNIVERSAL WIRING HARNESS Installation Manual Terminals are provided for most connections on your wiring kit. Following the gauge manufacturer s instructions, use the terminals supplied with your gauge
More information3/25 Switch, power sunroof 3/26 Control module, driver's seat 3/27 Control module, passenger's seat 3/28 Switch for heated driver's seat 3/29 Switch
List of Components 1/1 Battery 2/1 Headlight relay with bulb failure sensor 2/2 Foglight relay 2/3 Regulator DIM-DIP 2/4 Intermittent wiper relay, windshield wipers 2/5 Relay, seat belt reminder/ignition
More informationIntelligent Lift Interlock System Installation Instructions
Intelligent Lift Interlock System Installation Instructions MB 45/55 & International 3200 w/allison 2200/2400 Transmission & Shift Lock Solenoid Allison Generation 3 Controls Part # ILIS801-D 2002-2006
More informationDiesel Technology: Electrical and Electronic Systems
Diesel Technology: Electrical and Electronic Systems Instructional/Task Analysis 2. Composition of atoms Unit 1: Introduction to Diesel Electrical and Electronic Systems 3. Electrical charges in atoms
More information