AMERICAN-LINCOLN TECHNOLOGY

Transcription

1 AMERICAN-LINCOLN TECHNOLOGY Service Manual RS SWEEPER Beginning with Serial No. 066 READ THIS BOOK! This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your machine could result in injury to you or to other personnel; damage to the machine or to other property could occur as well. you must have training in the operation of this machine before using it. If you or your operator (s) cannot read English, have this manual explained fully before attempting to operate this machine. Si Ud. o sis operadores no pueden leer el Inglés, se hagen explicar este manual completamente antes de tratar el manejo o servicio de esta máquina. ISO 00 U L # FILE A87 All directions given in this book are as seen from the operator's position at the rear of the machine. For new books, write to: Alto U.S., Inc., 00 Haskins Road, Bowling Green, Ohio 0 Part No American-Lincoln Technology 80 Printed in the USA

2 TABLE OF CONTENTS - CHAPTER Main Broom... - Side Brooms... - Doors, Flaps, & Seals Side Cover & Battery Pan Hopper... - Forward/Reverse Pedal Console Assembly... - Filter System... - Drive Compartment & Seat Steering & Drive Wheel Lock Power Panel... - Instrument Panel... - Decals American-Lincoln Technology -

3 MAIN BROOM - PARTS LIST Knob L.H. Arm Support Idler Hub Spring Lever Knob Drive Hub Shaft Collar Bushing Cover Spacer Pulley, Broom Pulley, Idler Pulley, Motor Motor 077- Brush Assembly for R.H. Arm Collar Bracket Belt, Broom Drive HARDWARE USED: H Screw, /-0 x.70 HHC H Lock Washer, /6 HS Med. H Lock Washer, Helical Spring /8 Med. H Nut, /8-6 Hex H Screw, /- x.000 HHC, H Flat Washer H Lock Washer, ½ HS Med. H Nut, /- Fiber Lock H Screw, /6-8 x.87 HHC H Lock Washer, Helical Spring / Med. H Flat Washer,.87 x.7 x.060 H Spring Washer,.87 x.00 x.0 H Screw, /8-6 x.00 HHC, H Lock Washer, /8 Bolt H Carriage Bolt, / - x.00 H Set Screw, /-0 x.00 H Washer,.00 x. x..06 H Nut, /- Hex. Jamb H Washer, Engine Mount H Carriage Bolt, /8-6 x.000 H Snap Ring H Bearing, Double Seal H Square Key, x.0 H Lockwasher, /8 Int. H Spacer, ½ ID ¾ OD.6 Lg H Spacer, / ID, / OD, /8 LG. H Bearing H Flat Washer,. x.76 x..06 H Tye-Wrap H Terminal H Terminal, ¼ x.0-0 C-0/8 - American-Lincoln Technology

4 MAIN BROOM - EXPLODED VIEW 7 H6 H6 H H H H H6 0 8 H H 6 MAIN BROOM H0 H6 H7 H H H H H0 H H6 H7 0 H6 H6 H7 H6 H0 H H H H H H7 H H8 C0/8 H8 H6 8 7 H7 H H6 H 6 H7 H8 American-Lincoln Technology -

5 SIDE BROOMS - PARTS LIST Brush Drive Motor 087- Brushes for Motor Mounting Bracket Motor Mounting Bracket Flange, Side Broom Side Broom Motor Mounting Bracket Hanger, Side Broom Lift Cable Deflector Deflector Latch Wire Terminal (Male) Wire Terminal (Female) Set Screw, /-0 x Tye-Wrap Strap Wire, Drive Motor Stand Off Boot Wire Harness Ref Tye- Wrap Edging HARDWARE USED: H Screw #0- x.70 RHM H Lock Washer #0 Med. HS H Nut Hex MS #0- x.7 x. H Nut,Hex Fiber Insert #0- H Screw, /-0 x.70 HHC H Screw, /-0 x.7 HHC H Screw, /-0 x.000 HHC 6 H Nut Hex /-0 8 H Nut, /-0 Insert Fiber 8 H Flat Washer,.6 x..8 x.06 H Screw, /6-8 x.0 HHC H Lock Washer, /6 HS Med. H Nut, Hex. /6-8 x.00 x.6 H Screw, /8-6 x.000 HHC H Washer H Lock Washer, Helical Spring /8 Med. H Screw, /- x.0 HHC H Nut, /- Fiber Lock H Lock Washer, Helical spring / Med. H Screw, #0- x.70 THM H Lock Washer, /8 H Screw, #0- x.00 MMTF H Clamp C-07/8 - American-Lincoln Technology

6 SIDE BROOMS - EXPLODED VIEW H6 H7 H7 H7 H H7 H H7 H6 H H8 H 0 H6 H H7 H H H6 H BLACK WIRE RED WIRE H H7 H7 H7 H7 H7 H7 H H0 H0 H H0 H7 H BLACK WIRE RED WIRE 8 H8 H H7 H7 H H6 0 H C07/8 H H0 0 H VIEW SHOWING LOCATION OF TY-WRAP American-Lincoln Technology -

7 DOORS, FLAPS & SEALS - PARTS LIST Door, R.H Clamp, R.H. Front Clamp, R.H. Rear Flap, Right Side Seal, Side Hopper Flap, Rear Outer Clamp Seal, Center Hopper Flap, Rear Inner Hanger, Rear Flap Seal, Door Upper Seal, Door Lower Door, L.H Flap, L.H. Door Latch Clamp, L.H. Door Hinge Flap, Front Outer Hanger, Front Flap Flap Frame, RS Door Side Broom Screw, /-0 x Carriage Bolt, /-0 x.6 HARDWARE USED: H Screw, /-0 x.70 HHC 7 H Nut, Hex /-0 x.7 x.8 6 H Lock Washer, Helical Spring / Med. H Screw, #0- x.00 MMTF C-06/8-6 American-Lincoln Technology

8 DOORS, FLAPS & SEALS - EXPLODED VIEW H6 H H7 0 H H7 6 H H7 7 H6 H6 7 H6 0 H-H7 C06/8 H-H7 American-Lincoln Technology -7

9 SIDE COVER & BATTERY PAN 6 Ca/ Battery ( volt) Battery (6 volt) Battery Pan Wire - Battery ( volt) Wire - Battery (6 volt) Side Cover Side Cover C-0a/8-8 American-Lincoln Technology

10 HOPPER H H H6 H6 C00B-8 H Hopper Handle Axle Wheel Latch HARDWARE USED: H Nut, Hex. /6-8 x.00 x.6 H Lock Washer, /6 HS Med. H Nut, /- Fiber Lock H Screw, /6-8 x.70 HHC C-00/8 American-Lincoln Technology -

11 FORWARD/REVERSE PEDAL - PARTS LIST Bracket, Pedal Mounting Pedal, Forward/Reverse Bracket, Pedal Mounting (Black) Centering Device 087- Potentiometer Potentiometer Lever Arm Clevis Interconnecting Rod --0 Nut, / Interconnecting Rod HARDWARE USED: H Screw, /-0 x.70 HHC H Nut, Hex /-0 x.7 x.8 H Washer,.6 x.8 x.06 H Screw, /6-8 x.70 HHC H Bolt, Hex Head, /6-8 x.70 H Lock Washer, /6 Med. HS H Nut Hex, /6-8 x.00 x.6 H Washer,.70 x.0 x.0 H Lock Washer, Helical Spring / Med. H Flat Washer,.06 x.6 x.06 H Yoke Pin Assembly H Cotter Pin,.06 x.00 C-0/8-0 American-Lincoln Technology

12 FORWARD/REVERSE PEDAL - EXPLODED VIEW H00 H0 8 H H 7 0 H H H H H H7 H H00 C0/8 H 7 H H7 H7 H H7 6 H7 American-Lincoln Technology -

13 CONSOLE ASSEMBLY - PARTS LIST 8--0 Console Instrument Panel (R.H.) Instrument Panel (L.H.) Lift Arm Cover Flat Washer Cable Pulley Spacer Wire Harness, Instrument Panel Bracket - Cable Clamp HARDWARE USED: H Nut, /-0 Insert Fiber H Screw, /6 - x.00 HHC H Flat Washer,.687 x. x.06 H Lock Washer, /6 HS Med. 7 H Nut, /8-6 Stop H Screw, /8-6 x.000 HHC H Washer,.70 x.0 x.0 H Nut, Hex / - x.70 x.7 H Screw, /-0 x.0 HHM H Spring Washer,.87 x.00 x.0 H Screw, # 0-6 x.00 TF/RH H Washer Flat,.06 x.8 x H Screw, /6-8 x.70 HHC H Screw, /6-8 x.6 HHC 6 H Nut, Insert Fiber.8-6 Heavy Nut C-060/8 - American-Lincoln Technology

14 CONSOLE ASSEMBLY - EXPLODED VIEW H H6 H H6 H6 7 6 H H H H0 H H6 H6 0 H H8 8 H 6 H FRAME C060/8 H H H American-Lincoln Technology -

15 FILTER SYSTEM - PARTS LIST Filter Pivot Rod Plate, Shaker Motor Arm, Shaker Impellor Manifold Impellor Bracket, Impellor Motor and Guard Impellor Motor Shaker Motor Cover Filter Shaker Motor (6V) Filter Shaker Weight Rod, Threaded / Terminals / FISO (Male) Collar Gasket Gasket Wire Nut - Tee HARDWARE USED: H Screw, /-0 x.70 HHC H Nut, /-0 Insert Fiber 8 H Washer,.6 x.8 x.06 H Flat Washer, /6 H Nut, /6-8 Insert Fiber H Lock Washer, Helical Spring ¼ Med. H Carriage Blt, /-0 x.70 8 H Set Screw, /-0 x.0 HSKCP H Screw, /6-8 x.6 HHC H Set Screw, /-0 x. HSKCP H Wing Nut, /6-8 C-0/8 - American-Lincoln Technology

16 FILTER SYSTEM - EXPLODED VIEW 8 0 H 7 H7 H H6 0 H87 H87 H H6 6 6 H88 H H86 H7 H6 FRAME LOCTITE ALL SET SCREWS C0/8 SHAKER PLATE PIVOT MOTOR FACE.7. SHAKER MOTOR AND WEIGHT INSTALLATION.. American-Lincoln Technology -

17 DRIVE COMPARTMENT & SEAT - PARTS LIST Drive Compartment Hinge Seat Base Seat (7-00) Seat (7-0) Slide Adjuster Kit Seal Edging, Seat Panel Seal Switch, Broom Bracket, Broom Switch Serial Plate Bar, Seat Lock Rivet HARDWARE USED: H Screw, #0- x.0 RHM H Screw, /6-8 x.70 HHC H Screw, ¼ HHC H Screw, ¼ - 0 x.0 HHM H Flat Washer,.687 x. x.06 H Flat Washer,.00 x.8 x.06 H Lock Washer, Helical Spring / Med. 0 H Lock Washer, #0 Med. H Lock Washer, /6 HS Med. H Nut, Hex /-0 x.7 x.8 0 H Nut, Hex #0- MS H Nut, /-0 Insert Fiber H Nut Fiber Insert, /6-8 H Nut Fiber Insert #0- H Washer,.6 x.8 x.06 0 C-0/8-6 American-Lincoln Technology

18 DRIVE COMPARTMENT & SEAT - EXPLODED VIEW 0 H7 8 H6 H H6 H H H7 H H7 H7 H H6 H H H-H H0-H H H7 H C0/8 H H7 American-Lincoln Technology -7

19 STEERING & DRIVE - PARTS LIST Wheel and Drive Motor Plate, Drive Wheel Mounting Bracket, Drive Wheel Mounting Sprocket Pivot Caster Flange, Steering Mount Steering Shaft Universal Joint Shaft, Steering Wheel Steering Wheel Steering Chain Bearing, Support, Wheel Guard Wheel Guard Flap Horn Hanger Wire assy. Ref Boots, Terminal Roll Pin,. x.0 HARDWARE USED: H Screw, /-0 x.00 H Screw, /-0 x.70 HHC H Nut, Hex / - 0 x.7 x.8 H Nut, /-0 Insert Fiber H Screw, /6-8 x.0 HHC H Flat Washer,.687 x. x.06 H Lock Washer, /6 HS Med. 7 H Washer,.70 x.0 x.0 H Lock Washer, Helical Spring /8 Med. H Nut, /8-6 Hex H Lock Washer, Helical Spring H Flat Washer,.70 x.6 x.06 H Screw, /6-8 x.0 HHC H Screw, #0 x. 0 mm HHC H Lock Washer, 7/6 Split, Cadmium Plated H Screw, #0- x.00 MMTF H Screw, /6-8 x.6 HHC H Screw, /6-8 x.00 H Flat Washer,.000 x.0 x.06 H Clamp H Flat Washer, # 0 SS H Carriage Bolt, /8-6 x.00 H Nut, /8-6 Stop H Nut, / Hex. Nylock Jam H Screw C-08/8-8 American-Lincoln Technology

20 STEERING & DRIVE - EXPLODED VIEW FRAME 0 6 H-H8 0 H78 H H H7 H-H-H H8 H0 7 H H7 H7 H-H-H8 H7-H H H6 8 6 H0 H H78-H H H-H 8 FRAME C08/8 7 H0-H6 H0-H6 American-Lincoln Technology -

21 WHEEL LOCK - PARTS LIST Wheel Lock Rod Bracket Cable Spring Axle Spacer Hub Assembly Flat Washer Wheel Assembly (Ultraseal) Bushing Lever Wheel Lock Knob Clamp Bearing Washer Flange Rim HARDWARE USED: H Screw, /-0 x.70 HHC H Screw, /-0 x.00 H Screw, /6-8 x. HHC 0 H Screw, /6-8 x.0 HHC H Screw, /8-6 x.000 HHC H Washer.687 x. x.06 H Lock Washer / Med. Helical Spring H Lock Washer, /6 HS Med. 8 H Nut Hex, /-0 x.7 x.8 H Nut, /-0 Insert Fiber H Nut Hex /6-8 Fiber Insert H Lock Washer, /8 HS Med. H Fitting H Spring Washer,.87 x.00 x..0 H Washer,.6 x.8 x.06 H Roll Pin, / x.000 LG. H Screw, /8-6 x.00 FHSC H Screw, /-0 x.0 HHC H Washer C-07/8-0 American-Lincoln Technology

22 WHEEL LOCK - EXPLODED VIEW FRAME PART DRIVER COMPARTMENT H7 H7 H7 H7 H6 0 H H H8 H6 H 8 H8 H86 H7 H H8 H8 H0 H8 FRAME PARTS H8 H H 6 H86 C07/8 6 INSIDE 7 H H6 American-Lincoln Technology -

23 POWER PANEL - PARTS LIST Panel Cover Power Cable standoff Circuit Breaker ( amp) Circuit Breaker (0 amp) Controller Solenoids 077- Diode Assembly Diode Assembly Spacers Circuit Breaker ( amp) Boot, CB Boot, CB Boot, Red Wire - Harness Bracket - Handle Handle HARDWARE USED: H Screw, 0- x.000 RHM H Screw, # 0- x.00 RHM H Screw, /6-8 x.70 HHC H Screw, /-0 x.70 HHC 0 H Washer,.687 x. x.06 7 H Flat Washer,.00 x. x.06 H Lock Washer, Helical Spring 8 H Lock Washer, # 0 Med HS 6 H Lock Washer, /6 HS Med. 7 H Nut, Hex. /6-8 x.00 x.6 H Nut, Hex Jam /-0 x.7 x.6 H Nut, Hex /-0 x.7 x.8 8 H Nut, Hex MS # 0- x.7 x. H Nut, /-0 Insert Fiber H Nut, Hex Fiber Insert #0- H Screw, /-0 x.000 HHC H Washer,.6 x.8 x.06 8 C0/8 - American-Lincoln Technology

24 POWER PANEL - EXPLODED VIEW H6 H7 6 8 H H8 H H H7H7 H6 H H H6 6 ON (+) TERMINAL ONLY H H H H0 0 8 H H0 H 7 H HH H 7 FRAME H6 H6 C0-8 American-Lincoln Technology -

25 INSTRUMENT PANEL - PARTS LIST Hour Meter Momentary Switch Plug, Hole Switch Decal, Instrument Panel Battery Condition Meter Switch Circuit Breaker, 0 amp Decal, Instrument Panel Switch Boot Plug, Hole C-06/8 - American-Lincoln Technology

26 INSTRUMENT PANEL - EXPLODED VIEW C06/8 American-Lincoln Technology -

27 DECALS - PARTS LIST Decal, C/B Power Panel Decal, Electrical Hazard Decal, Left Side Dash Ref Decal, Battery Charging Decal, General Hazard Decal, Patent Name, Plate - Amercan-Lincoln Decal, Main Broom Decal, Wheel Lock Decal, Key/Wheel Lock Decal, Pinch Point Pad, Non-Skid Pad, Non-Skid Decal, Right Side Dash Ref Decal, C/B Dash Panel Decal, Caution (Wire ) C076/8-6 American-Lincoln Technology

28 WHEEL LOCK UNLOCK LOCK WARNING. CAUTION MAIN BROOM FLOAT SWEEP OFF MODEL NO. SERIAL NO. This Product is manufactured under one or more of the following Patents, or other Patents which may be pending. U.S.-,006,06,,7,0,,7,6,,7,,,7,,,8,0,,6,,,6,,,,7,,6,0,,,,,6,80,,,077 To avoid possible injury or property damage, read the operator's manual before using the machine. Fire hazard. Fine dust, fuels, solvents and thinners can explode and cause severe burns. Do not use with/or near flammable materials or vapors. Use only with good ventilation. Heavy machinery. Improper use can cause personal injury. Operate only when lids, doors and access panels are securely closed. Do not leave machine on a ramp or dock. After stopping the machine, turn all switches off. Maintenance and repairs must be done by authorized personnel only. Use care when reversing machine in confined area. CAUTION LEAVE BATTERY CONNECTED DISCONNECT WIRE FROM TERMINAL M ON CURTIS MOTOR CONTROLLER BEFORE TOWING (PUSHING OR PULLING) MACHINE OPTION WARNING THIS IS A DECAL FOR YOUR THIS IS A DECAL FOR YOUR THIS IS A DECAL FOR YOUR DECALS - EXPLODED VIEW VIEW A-A 7 6. WARNING WARNING DECAL FLUSH WITH TOP OF NAME PLATE. TYP () PLACES B A B A PATENT DECAL FLUSH WITH SIDE OF NAME PLATE.. TYP () PLACES... 8 VIEW C-C..... D.00 C C American-Lincoln D WARNING DECAL CENTERED ON BATTERY COVER VIEW B-B 0 LOGO CENTERED ON REAR COVER 7 CB- CB- CB- CB-7 CB VIEW D-D CB- CB-6 CB- PAD FLUSH WITH BEND ON HOPPER PAD CENTERED ON HOPPER C076/8 American-Lincoln Technology -7

29 TABLE OF CONTENTS - CHAPTER Back-up Alarm... - Battery Option... - Broom Option... - Head & Taillight Option Overhead Guard Option Amber Strobe Light Option Strobe Light Option For Overhead Guard... - Low Battery Shutdown Option Emergency Stop Option... - Vac Wand Option... - Drive motor Service Parts... - Spare Parts List... - Index Warranty American-Lincoln Technology -

30 BACK-UP ALARM - PARTS LIST C Spacer Switch Back-Up Alarm Circuit Breaker, 0 amp Boot Terminal Connector, -Way Wire, 6 ga. Red 6' Terminal, Female Bullet Terminal, Male Bullet Wire, 6 ga. Black 8' Terminal Ring Tye Raps Terminal Ring Screw, /-0 x.70 HHC Nut, Hex /-0 x.7 x Screw, /-0 x.87 HHC Washer,.6 x.8 x Nut, #6- Hex Flat Washer,.7 x.6 x Screw, #6- x.000 Lg. RHM Lock Washer, Helical Spring - American-Lincoln Technology

31 BACK-UP ALARM - EXPLODED VIEW RED WIRE *NOTE: USED ONLY WITH STROBE OPTION C CB-8 6 7* 8 TB- NEG. C08/80 SWITCH American-Lincoln Technology -

32 BATTERY OPTION 6 Ca/ Battery ( Volt) Battery ( Volt Dry) Connector Assembly Battery Connectors Battery Spacer Ca/ Battery (6 Volt Wet) Battery (6Volt Dry) Connector Assembly Battery Connectors Cc/8 - American-Lincoln Technology

33 BROOM OPTION C086 C Side Broom, Poly Side Broom, Nylon Main Broom, Proex Main Broom, Nylon Main Broom, Hi Density Nylon Main Broom, Proex and Wire American-Lincoln Technology -

34 HEAD & TAILLIGHT OPTION LT. INST. PANEL FRONT BUMPER LT. HEAD LIGHT RT. HEAD LIGHT C08 6 RT. INST. PANEL BAT.. IGN.. EXISTING KEY SW. ( BACK VIEW) NOTE: ROUTE WIRE & TIE TO EXISTING HARNESS USING TYE RAPS ITEM # ST. 7 EXISTING TB- (-) DISCONNECT IN THIS AREA TO REMOVE POWER PANEL COVER LT.TAIL LIGHT POWER PANEL COVER RT.TAIL LIGHT DRILL CP MARKS TO.8 (8) PLACES C Light Switch Head Light Tail Light Bracket Bracket Bracket Terminal, Ring Terminal, # Connector, -Way Wire, 6 ga. Red ' Wire, 6ga. Black ' Terminal,.6 Female Bullet Terminal,.6 Male Bullet Tye Raps Screw, /-0 x.00 HHC 8-6 American-Lincoln Technology

35 AMBER STROBE LIGHT OPTION 0 6 TB- NEG. - 0 C CB * * NOTE: USED ONLY WITH BACK-UP ALARM C Circuit Breaker, 0 Amp Boot Support, Warning Light Grommet Strobe Light, Amber Strobe Light, Red Ref Black Loom ' Connector Wire, 6 ga. Red ' Terminal, Female Bullet Terminal, Male Bullet Wire, 6 ga. Black ' Terminal Tye Raps Connector, -Way Lock Washer, # 0 INT Nut, Hex MS # 0- x.7 x Lock Washer, Helical Spring /8 Med Nut, /8-6 Hex Screw, #0- x.00 THM Screw, /-0 x.0 HHC C08/0 American-Lincoln Technology -7

36 OVERHEAD GUARD OPTION Leg, L.H Lg, R.H Overhead Guard Top Weld Plug Button Fiber Nut Screw, /8-6 x.000 HHC Flat Washer,.70 x.0 x Lock Washer, / HS Med Screw, /- x.0 HHC C-060 C-060/80-8 American-Lincoln Technology

37 6 STROBE LIGHT OPTION FOR OVERHEAD GUARD C-06/ Terminal Wire, #6 AWG. (Black) ' Terminal, Male Bullet Terminal, Female Bullet Wire, #6 AWG. (Red) " Strobe Light, Amber * Strobe Light, Red Panel Light Support Duct, Wire Strip Grommet Threaded Insert Connector Nut, Hex Fiber Insert # Screw, #0- x.70 THM Screw, /-0 x.000 HHC Lock Washer, Helical Spring Use for Amber Strobe Light Option * Use for Red Strobe Light Option C-06 American-Lincoln Technology -

38 LOW BATTERY SHUTDOWN OPTION 8 RED (NC) (C) (NO) RED RED BLK L Solid State Module Bracket Light, volt Decal Butt Splice Wire, 6 ga. Red ' Wire, 6 ga. Black ' FISO 0- ga FISO -6 ga Connector, -Way ga Tye Raps Screw, #0- x.7 THM Screw, 0- x.000 RHM Lock Washer, # 0 Med HS Nut, Hex MS # 0- x.7 x Lock Washer, # 0 INT. C-08/0 8 HM 6C 6D LT. INST. PANEL -0 American-Lincoln Technology BLK RED ROUTE ALL WIRING & TIE TO EXISTING HARNESS USING TYE RAPS ITEM C08 RT. INST. PANEL 6A 6B CM REMOVE WIRE 6A FROM (+) ON METER, THEN ADD BUTT SPLICE

39 EMERGENCY STOP OPTION EXISTING SOL. A ROUTE ALL WIRING & TIE TO EXISTING HARNESS USING TYE RAPS ITEM RT. INST. PANEL REMOVE WIRES B & FROM KEY SWITCH, CUT OFF TERMINALS STRIP AND ADD ITEM #6 0 SOL. A 6 7 WIRE D WIRE 8 SOL. 0A POWER PANEL (+) TB- WIRE B WIRE WIRE 0 DECAL EXISTING KEY SW. ( BACK VIEW) IGN.. ST. WIRE 6 7 B EXISTING HARNESS 6 EMERG. STOP SW. (BACK VIEW WIRE WIRE 7 C Solenoid 077- Diode Assembly Terminal, #0 Spring Spade Decal Emergency Stop Switch Butt Splice, -6 ga Terminal, #0 Spring Spade Terminal,.0 Ring Terminal,.0 Ring Terminal,.0 Ring Wire, ga. Red ' Wire, 6 ga. Red 0' Wire, 6 ga. Black ' Tye Raps Nut, Hex /-0 x.7 x Washer,.6 x.8 x Lock Washer, Helical Spring Screw, /-0 x.6 RHM C-08/0 American-Lincoln Technology -

40 VAC WAND OPTION - PARTS LIST Panel, Vac Adapter, Hose Retainer Gasket Swivel Bag Handle Circuit Breaker Toggle Switch Boot-Toggle Tab 06-0 Carpet Tool (") 06-0 Wand 06-0 Hose Baffle Vac Motor Plate Spacers Motor Mounting Ring Cover Seal Seal Fastener Retainer Receptacle Terminal. Ring Terminal. Female FISO Terminal. Male FISO Terminal #6 Spring Spade Wire # AWG (Black) Tye-Wrap Decal - Warning Decal Warning Decal - American-Lincoln Decal, Caution (Wire ) Lock Washer, # 0 Med HS Nut, Hex MS #0 - x.7 x Nut, Hex Fiber Insert # Nut, Hex Jam, Screw, /-0 x.70 HHC Screw, #0- x.0 RD. HD Screw, #0- x.6 T/C Hex HD Screw, #8 - x Screw, #0 - x.0 THM 8 C-0/80 - American-Lincoln Technology

41 VAC WAND OPTION - EXPLODED VIEW NOTE: DECAL LOGOS ARE CENTERED ON PANEL (-) POST TB- (+) POST TB- VAC. MTR VAC WAND SWITCH CB- 7 THESE WIRES ( LONG) SHOULD BE TIES TO BATTERY CABELS WITH ITEM # TO ALLOW REMOVAL OF BACK PANEL C-0/80 0 American-Lincoln Technology -

42 DRIVE MOTOR SERVICE PARTS C088/ Rubber Wheel Oil Seal Bearing DC Motor, Diameter mm Rotor Brush Holder Brush Spring Protection Shield C American-Lincoln Technology

43 SPARE PARTS LIST SPARE PARTS PACKAGE Diode Assembly 087- Potentiometer Shaker Motor Bearing (Broom Drive) Bearing (Broom Drive) Solenoid Bearing (Rear Wheel) V-Belt (Broom Drive) Circuit Breaker ( amp) Circuit Breaker (0 amp) Circuit Breaker ( amp) Spring (Wheel Lock) Switch Side Broom Broom (Proex) Panel Filter Flap (Rear Inner) Flap (LH Door) Flap, (Front Outer) Flap, (Front Inner) Flap, (Rear Outer) Flap, (Right Side) Flap, (Wheel Drive) Seal, (Door Upper) Seal, (Door Lower) Seal, (Hopper Center) Seal, (Hopper Side) Switch, (Dust Control/Side Brooms) Switch, (Filter Shaker) American-Lincoln Technology -

44 INDEX AMBER STROBE LIGHT OPTION BACK-UP ALARM OPTION... - BATTERIES, TO REMOVE THE...- BATTERIES, TO CHARGE THE... - BATTERY CONDITION METER... - BATTERY OPTION... - BATTERY SERVICE INSTRUCTIONS... - BROOM OPTION... - CONNECTION DIAGRAM... - CONSOLE ASSEMBLY... - DECALS DECIMAL-METRIC CONVERSION TABLE DOORS, FLAPS & SEALS DRIVE COMPARTMENT & SEAT DRIVE MOTOR SERVICE PARTS... - DRIVE WHEEL & SIDE FLAPS, TO ADJUST THE... - DUST CONTROL INSTRUCTIONS... - DUST CONTROL SWITCH... - EMERGENCY STOP BUTTON OPTION... -, - FILTER BAFFLE, TO CLEAN THE... - FILTER SHAKER SWITCH... - FILTER SYSTEM... - FLAP INSTRUCTIONS... - FOOT PEDAL... - FORWARD/REVERSE PEDAL HARDWARE ABBREVIATIONS HEAD AND TAILLIGHT OPTION HELPFUL HINTS FOR SWEEPING OPERATION HOPPER... - HOPPER RELEASE LATCH... - HORN BUTTON... - HOUR METER... - INDEX INSTRUMENT PANEL... - KEY SWITCH... - LIGHT SWITCH... - LOW BATTERY LIGHT OPTION... - LOW BATTERY SHUTDOWN OPTION MACHINE CONTROLS... - MACHINE DIMENSION... - MACHINE PREPARATION... - MACHINE SPECIFICATION... - MAIN BROOM... - MAIN BROOM INSTRUCTIONS... - MAIN BROOM LIFT LEVER... - MAIN BROOM SWEEP PATTERN, TO CHECK THE... - MAIN BROOM, TO CHANGE THE American-Lincoln Technology

45 INDEX MAIN BROOM, TO ADJUST THE SWEEP HEIGHT... - OPERATING INSTRUCTIONS... - ORDERING PARTS OVERHEAD GUARD OPTION PANEL FILTER, TO CHANGE THE... - PANEL FILTER, TO CLEAN THE... - POST OPERATION CHECK LIST POST START CHECK LIST... - POWER PANEL... - PRE-START CHECK LIST... - RECYCLING FLAP, TO ADJUST THE... - SAFETY PRECAUTIONS... - SCHEMATIC DIAGRAM... - SEAT ADJUSTMENT LEVER... - SERVICE CHART SERVICE INSTRUCTIONS... - SIDE BROOM HEIGHT ADJUSTMENT, TO CHANGE THE SIDE BROOM INSTRUCTIONS SIDE BROOM LIFT LEVER... - SIDE BROOM SWEEP PATTERN, TO CHECK THE SIDE BROOM SWITCH... - SIDE BROOM, TO CHANGE THE SIDE BROOMS... - SIDE COVER & BATTERY PAN SPARE PARTS... - STANDARD HARDWARE & TORQUE VALUES STARTING... - STEERING & DRIVE...-8 STROBE LIGHT OPTION FOR OVERHEAD GUARD... - TABLE OF CONTENTS - CHAPTER... - TABLE OF CONTENTS - CHAPTER... - TO BEGIN THE CLEANING OPERATION... - TO EMPTY HOPPER TO STOP THE CLEANING OPERATION TO TRANSPORT MACHINE... - VAC WAND OPTION... - WARRANTY WHEEL LOCK... -, -0 American-Lincoln Technology -7