JANDY HEATERS A QUICK REFERENCE OF MOST COMMONLY REPLACED PARTS

Transcription

1 JANDY HEATERS Heaters H-58 A QUICK REFERENCE OF MOST COMMONLY REPLACED PARTS E-Z FIND CHART MARK V XE XE SERIES I SERIES I MILLIVOLT MILLIVOLT ELECTRONIC MILLIVOLT ELECTRONIC DM, DR EG ES, EC EPG EPS, EPC, EPGII ITEM NO. ITEM NO. ITEM NO. ITEM NO. ITEM NO. (MFG NO.) (MFG NO.) (MFG NO.) (MFG NO.) (MFG NO.) PILOT GEN B CARTRIDGE (W ) (W ) (W ) PILOT ASSY. NAT (R ) (R ) (R ) PILOT ASSY. LP A A A (R ) (R ) (R ) GAS VALVE, NAT J J J (R ) (R ) (R ) GAS VALVE, NAT D D 125 & 175 (R ) (R ) GAS VALVE, NAT E E 250, 325, 400 (R ) (R ) GAS VALVE, LP K K K I (EPC) (R ) (R ) (R ) (R ) HI-LIMIT SWITCH A A A A A 135 (E ) (E ) (E ) (E ) (E ) HI-LIMIT SWITCH (E ) (E ) (E ) (E ) (E ) PRESS. SWITCH C C C C 1-10 PSI (R ) (R ) (R ) (R ) PRESS SWITCH A A A PSI (R ) (R ) ( ) (R ) ( ) ON/OFF SWITCH * (EC) (EPC) ASSY. (R ) (R ) (R ) (R ) (R ) FUSIBLE LINK (R ) (R ) (R ) (R ) FRONT HEADER OBSOLETE(DM) (R ) (R ) (R ) (R ) (R ) OBSOLETE(DR) (R ) REAR HEADER (R ) (R ) (R ) (R ) (R ) HEADER GASKET SET (R ) (ROO50800) (R ) (R ) (R ) FLANGE & GASKET KIT 1½" (R ) (R ) (R ) (R ) (R ) FLANGE & GASKET A A KIT 2" (R ) (R ) GASKET 1½" (S ) (S (S ) (S ) (S ) SLEEVE 1½" OBSOLETE OBSOLETE OBSOLETE OBSOLETE OBSOLETE (S ) (S ) (S ) (S ) (S ) GASKET 2" B B (S ) (S ) SLEEVE 2" A A (S ) (S ) THERMOSTAT* B(ES) B(EPS) (ELECTRONIC) (R ) (R ) (R ) (R ) (EC) B(EPC) (R ) (R ) THERMOSTAT* ELECTRONIC ELECTRONIC (MECHANICAL) (R ) (R ) ONLY (ES) (R ) ONLY (EPS) (EC) (EPC) (R ) (R ) * LAARS R IS NOW AN ELECTRONIC THERMOSTAT. R IS THE STANDARD MECHANICAL THERMOSTAT.

2 JANDY HEATERS Heaters H-59 A QUICK REFERENCE OF MOST COMMONLY REPLACED PARTS E-Z FIND CHART SERIES II SERIES II LITE LLG LITE LLD MILLIVOLT ELECTRONIC MILLIVOLT ELECTRONIC ESG ESC ITEM NO. ITEM NO. ITEM NO. ITEM NO. (MFG NO.) (MFG NO.) (MFG NO.) (MFG NO.) PILOT GEN B B CARTRIDGE (W ) (W ) PILOT ASSY. NAT B (R ) (R009600) (R ) PILOT ASSY. LP A C A (R ) (R ) (R ) GAS VALVE, NAT B B A (R ) (R ) (V ) GAS VALVE, NAT D 125 & 175 (R ) GAS VALVE, NAT G 250, 325, 400 (R ) GAS VALVE, LP C H C B (R ) (R ) (R ) (V ) HI-LIMIT SWITCH A A A A 135 (R ) (R ) (R ) (R ) HI-LIMIT SWITCH R ) (R ) (R ) (R ) PRESS. SWITCH C C 1-10 PSI (R ) (R ) PRESS SWITCH A A A A 2 PSI (R ) (R ) (R ) (R ) ON/OFF SWITCH ASSY. (R ) (R ) (R ) FUSIBLE LINK (R ) (R ) (R ) (R ) FRONT HEADER C C (R ) (R ) FRONT HEADER C C C C 2" (R ) (R ) (R ) (R ) REAR HEADER (R ) (R ) (R ) (R ) HEADER GASKET SET (R ) (R ) (R ) (R ) FLANGE & GASKET KIT 1½" FLANGE & GASKET A A A A KIT 2" (R ) (R ) (R ) (R ) GASKET 1½" SLEEVE 1½" GASKET 2" B B B B (S ) (S ) ( ) ( ) SLEEVE 2" A A A A (S ) (S ) ( ) ( ) THERMOSTAT* * B * B (ELECTRONIC) (R ) (R ) (R ) (R ) THERMOSTAT* * * * (MECHANICAL) (R ) (R ) (R ) * LAARS R IS NOW AN ELECTRONIC THERMOSTAT. R IS THE STANDARD MECHANICAL THERMOSTAT.

3 JANDY LITE/LITE 2 Heaters H CIRCUIT BOARD CIRCUIT BOARD B 39 38A,B 69A,B ,9 93A-E 70 68A,B 74 51,52,53,54, A-E A-E 75 77A,B , A,B 12A-E A,B A-D A,B 17A-E 6 15

4 JANDY LITE/LITE 2 Heaters H-61 Edited KEY ITEM # DESCRIPTION MFG. # PILOT GAS SYSTEM 1A A PILOT, MAIN BURNER ASSY., LP R B PILOT, MAIN BURNER ASSY., NG R A PILOT BURNER, NG R B D PILOT BURNER, LP R B PILOT GENERATOR W A CERAMIC INSULATOR ASSY R MAIN BURNER W/PILOT BRACKET HIGH VOLTAGE LEAD ASSY R A PILOT TUBING R OBSOLETE OBSOLETE PIEZO LIGHTER ASSY R OBSOLETE OBSOLETE PIEZO LIGHTER KNOB R IGNITOR, LLD R MAIN GAS SYSTEM 11A GAS ORIFICE, NG ( FT) L B GAS ORIFICE, LP ( FT) L A E BURNER SHELF ONLY, 125 R B A BURNER SHELF ONLY, 175 R C B BURNER SHELF ONLY, 250 R D C BURNER SHELF ONLY, 325 R E D BURNER SHELF ONLY, 400 R A B GAS VALVE, NG, LLG (MV) R B C GAS VALVE, LP, LLG (MV) R C A GAS VALVE, NG, LLD (ELECT) R D B GAS VALVE, LP, LLD (ELECT) R MOUNTING BRACKET ASSY MAIN BURNER L A BURNER MANIFOLD, 125 L B A BURNER MANIFOLD, 175 L C B BURNER MANIFOLD, 250 L D C BURNER MANIFOLD, 325 L E D BURNER MANIFOLD, 400 L ELECTRICAL SYSTEM TEMP CONTROL ASSY., LLG (MV) R (INCLUDES WIRE HARNESS) ON/OFF SWITCH R OBSOLETE OBSOLETE PLATE ASSY B TEMP CONTROL ASSY, LLD (ELECT) R REPLACE NLA WIRE HARNESS REP W/ WIRE HARNESS R KNOB R TEMPERATURE SENSOR (LLD,LLG) R BULB PROTECTOR SLEEVE TEMP CONTROL O-RING E THERMOSTAT KNOB R OBSOLETE OBSOLETE TEMP-LOK STOP PLATE FUSIBLE LINK R * FLAME SENSOR (LITE 2 ONLY) R WATER SYSTEM 38A A PRESSURE SWITCH, 2 P.S.I. R B C PRESSURE SWITCH, 1-10 P.S.I. R SYPHON LOOP ASSY. R REDUDANT HI-LIMIT ASSY R A HI-LIMIT, 135 DEG R HI-LIMIT, 150 DEG R (RED-DOT ON THIS SWITCH) COMPLETE HI-LIMIT ASSY (BOTH HI-LIMITS, RUBBER BOOTS, WIRE HARNESS) KEY ITEM # DESCRIPTION MFG. # HI-LIMIT SET (1 135 DEG & DEG) R IGNITION CONTROL ASSY. R INCLUDES IGNITION CONTROL, WIRE HARNESS, TRANSFORMER, CONTROL PANEL, IN-LINE FUSE 52 REPLACE NLA IGNITION CONTROL REP W/ R INGNITION CONTROL REPLACEMENT R WIRE HARNESS R TRANSFORMER R IN-LINE FUSE ASSY A C INLET/OUTLET HEADER,CAST IRON R B A INLET/OUTLET HEADER, BRONZE R A* RETURN HEADER, CAST IRON R B* RETURN HEADER, BRONZE R OBSOLETE OBSOLETE HEADER BOLT ASSY R HEADER GASKET (SET OF 18) R A FLANGE ASSY (SET OF 2) R FLANGE ONLY, A B FLANGE GASKET ONLY, 2 S B A FLANGE GASKET ONLY, 2 TO 1-1/2 S A FLANGE SLEEVE, 2 S FLANGE BOLT ONLY F DRAIN PLUG, ¼ NPT P A BUSHING, ½ NPT X ¼ NPT P BRASS PLUG, ¾ NPT P BY-PASS ASSY R BY-PASS VALVE ROD S BY-PASS VALVE DISC R REPLACE NLA CAP REP W/ A VALVE SPRING, PURPLE, 125 S B VALVE SPRING, WHITE, 175 S C VALVE SPRING, RED, 250 S D VALVE SPRING, BLUE, 325 S E VALVE SPRING, BLACK, 400 S BY-PASS VALVE GASKET R A TUBE BUNDLE, 125, 10" LONG R B TUBE BUNDLE, 175, 12 7/8" LONG R C TUBE BUNDLE, 250, 17 5/8" LONG R D TUBE BUNDLE, 325, 22" LONG R E TUBE BUNDLE, 400, 26 3/4" LONG R COMBUSTION CHAMBER 94A CHAMBER, 125 R B CHAMBER, 175 R C CHAMBER, 250 R D CHAMBER, 325 R E CHAMBER, 400 R VENT SYSTEM VENT CAP, VENT CAP, VENT CAP, VENT CAP, VENT CAP, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD,

5 JANDY SERIES 2 Heaters H-62 ESG MILLIVOLT MANUFACTURED SHOWN KEY 86

6 JANDY SERIES 2 Heaters H-63 ESG MILLIVOLT MANUFACTURED Edited KEY ITEM # DESCRIPTION MFG. # KEY ITEM # DESCRIPTION MFG. # GAS SYSTEM PILOT, MAIN BURNER NG R A PILOT, MAIN BURNER LP R PILOT BURNER, NG R D PILOT BURNER, LP R B PILOT GENERATOR W CERAMIC INSULATOR R MAIN BURNER W/PILOT BRACKET A PILOT TUBING R OBSOLETE OBSOLETE PIEZO LIGHTER R E BURNER TRAY SHELF ONLY, 125 R A BURNER TRAY SHELF ONLY, 175 R B BURNER TRAY SHELF ONLY, 250 R C BURNER TRAY SHELF ONLY, 325 R D BURNER TRAY SHELF ONLY, 400 R B GAS VALVE, NG R C GAS VALVE, LP R GAS ORIFICE, NG L GAS ORIFICE, LP L MAIN BURNER L ELECTRICAL SYSTEM TEMPERATURE CONTROL R A WIRE HARNESS R TEMP LOCK PLATE ON OFF SWITCH R TEMP CONTROL LABEL H TEMP SENSOR R TEMP CONTROL BULB O-RING E BULB SLEEVE THERMOSTAT KNOB R BEZEL S BRACKET BRACKET SCREW F A PRESSURE SWITCH, 2 PSI R C PRESSURE SWITCH, 1-10 PSI R SYPHON LOOP R OBSOLETE OBSOLETE REDUNDANT HI LIMIT R COMPLETE HI LIMIT ASSY R (BOTH HI-LIMITS, RUBBER BOOTS, WIRE HARNESS) A HIGH LIMIT, 135 DEGREE R HIGH LIMIT, 150 DEGREE R RETAINER CLIP OBSOLETE OBSOLETE RETAINER BOOT S OBSOLETE OBSOLETE SWITCH COVER FUSIBLE LINK R FUSIBLE LINK BRACKET TERMINAL BLOCK R WATER SYSTEM C INLET/OUTLET, 2, CAST IRON R A INLET/OUTLET, 2, BRONZE R RETURN HEADER R RETURN HEADER, BRONZE R OBSOLETE OBSOLETE HEADER BOLT SET R B HEADER BOLT, 2-1/2 F WASHER F NUT F HEADER GASKET (SET OF 18) R A FLANGE & GASKET ASSY R FLANGE, B FLANGE GASKET, 2 S A FLANGE SLEEVE, 2 S FLANGE BOLT F A FLANGE GASKET 2 X 1-1/2 S DRAIN PLUG P BRASS PLUG, 3/4 P BY PASS ASSY R BY PASS ROD S BY PASS DISC R REPLACE NLA BY PASS CAP REP W/ S SPRING PURPLE, 125 S SPRING WHITE, 175 S SPRING RED, 250 S SPRING BLUE, 325 S SPRING BLACK, 400 S BY PASS GASKET R TUBE BUNDLE, 125, 10" LONG R TUBE BUNDLE, 175, 12 7/8" LONG R TUBE BUNDLE, 250, 17 5/8" LONG R TUBE BUNDLE, 325, 22" LONG R TUBE BUNDLE, 400, 26 3/4" LONG R OBSOLETE OBSOLETE EXCHANGER BAFFLE A EXCHANGER BAFFLE, SINGLE, B EXCHANGER BAFFLE, SINGLE, C EXCHANGER BAFFLE, SINGLE, D EXCHANGER BAFFLE, SINGLE, BAFFLE RETAINER S VENT CAP, VENT CAP, VENT CAP, VENT CAP, VENT CAP, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, * HI-LIMIT SET R (INCLUDES KEYS 41 & DEG & DEG) * NOT SHOWN KEY 21

7 JANDY SERIES 2 Heaters H-64 ESC ELECTRONIC IGNITION MANUFACTURED SHOWN KEY 78

8 JANDY SERIES 2 Heaters H-65 ESC ELECTRONIC IGNITION MANUFACTURED Edited KEY ITEM # DESCRIPTION MFG. # KEY ITEM # DESCRIPTION MFG. # GAS SYSTEM B PILOT, MAIN BURNER NG R C PILOT, MAIN BURNER LP R B PILOT BURNER, NG R E PILOT BURNER, LP R PILOT BRACKET SHIELD W A CERAMIC INSULATOR R BURNER W/PILOT BRACKET HIGH VOLTAGE LEAD R A PILOT TUBING R E BURNER TRAY SHELF ONLY, 125 R A BURNER TRAY SHELF ONLY, 175 R B BURNER TRAY SHELF ONLY, 250 R C BURNER TRAY SHELF ONLY, 325 R D BURNER TRAY SHELF ONLY, 400 R D GAS VALVE, NG, R G GAS VALVE, NG, R H GAS VALVE, LP R A GAS ORIFICE, NG L A GAS ORIFICE, LP L MAIN BURNER L ELECTRICAL SYSTEM B TEMPERATURE CONTROL R TEMP SENSOR R SINGLE BAR KNOB R THERMOSTAT KNOB R OBSOLETE OBSOLETE TEMP LOCK STOP PLATE BEZEL S REPLACE NLA WIRE HARNESS REP W/ WIRE HARNESS (EPC) R RETAINER BRACKET BRACKET SCREW F TEMP CONTROL BULB O-RING E A PRESSURE SWITCH, 2 PSI R C PRESSURE SWITCH, 1-10 PSI R SYPHON LOOP R COMPLETE HI LIMIT ASSY R (BOTH HI-LIMITS, RUBBER BOOTS, WIRE HARNESS) A HIGH LIMIT, 135 DEGREE R HIGH LIMIT, 150 DEGREE R RETAINER CLIP OBSOLETE OBSOLETE RETAINER BOOT S OBSOLETE OBSOLETE SWITCH COVER COMPLETE HI LIMIT ASSY FUSIBLE LINK R FUSIBLE LINK BRACKET TERMINAL BLOCK R IGNITION CONTROL ASSY, NG A IGNITION CONTROL ASSY, LP R B KEY A IGNITION CONTROL, NG R IGNITION CONTROL, LP R HARNESS R TRANSFORMER R IGNITION CONTROL PANEL IN LINE FUSE WATER SYSTEM C INLET/OUTLET, 2, CAST IRON R A INLET/OUTLET, 2, BRONZE R RETURN HEADER R RETURN HEADER, BRONZE R OBSOLETE OBSOLETE HEADER BOLT SET R B HEADER BOLT, 2-1/2 F WASHER F NUT F HEADER GASKET (SET OF 18) R A FLANGE & GASKET ASSY R FLANGE, B FLANGE GASKET, 2 S A FLANGE SLEEVE, 2 S FLANGE BOLT F A FLANGE GASKET 2 X 1-1/2 S DRAIN PLUG P BRASS PLUG, 3/4 P BY PASS ASSY R BY PASS ROD S BY PASS DISC R REPLACE NLA BY PASS CAP REP W/ S SPRING PURPLE, 125 S SPRING WHITE, 175 S SPRING RED, 250 S SPRING BLUE, 325 S SPRING BLACK, 400 S BY PASS GASKET R TUBE BUNDLE, 125, 10" LONG R TUBE BUNDLE, 175, 12 7/8" LONG R TUBE BUNDLE, 250, 17 5/8" LONG R TUBE BUNDLE, 325, 22" LONG R TUBE BUNDLE, 400, 26 3/4" LONG R OBSOLETE OBSOLETE EXCHANGER BAFFLE A EXCHANGER BAFFLE, SINGLE, B EXCHANGER BAFFLE, SINGLE, C EXCHANGER BAFFLE, SINGLE, D EXCHANGER BAFFLE, SINGLE, BAFFLE RETAINER S VENT CAP, VENT CAP, VENT CAP, VENT CAP, VENT CAP, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, * HI-LIMIT SET R (INCLUDES KEYS 29 & DEG & DEG) * NOT SHOWN A KEY 26

9 JANDY LX/LT Heaters H-66 STANDARD MODELS MFG JAN 2004 LO NOX MFG 2003-PRESENT VERSION A A VERSION JAN 2004-PRESENT 44A LO-NOX VERSION 64 STANDARD VERSION

10 JANDY LX/LT Heaters H-67 STANDARD MODELS MFG 1999 LO NOX MF PRESENT KEY ITEM # DESCRIPTION MFG. # KEY ITEM # DESCRIPTION MFG. # COMPLETE HEAT EXCHANGER (COPPER) 250 R COMPLETE HEAT EXCHANGER (COPPER) 400 R TUBE ASSY, (CU) W/HARDWARE & GASKETS 250 R TUBE ASSY. (CU) W/HARDWARE & GASKETS 400 R BAFFLES, HEAT EXCHANGER (SET OF 10) 250 R BAFFLES, HEAT EXCHANGER (SET OF 10) 400 R FRONT HEADER, W/HARDWARE & GASKETS R REAR HEADER, W/HARDWARE & GASKETS R BY-PASS ASSY, W/HARDWARE & GASKETS R GASKET, BYPASS ASSEMBLY R SPRING, BYPASS R COMPLETE COUPLING KIT, SET OF 2 R COUPLING O-RING SET R HEADER DRAIN PLUG W/GASKET (SET OF 3) R HEADER GASKET, SINGLE R * HARDWARE KIT & GASKETS, HEAT EXCHANGER R BURNER, TRAY WELDMENT 250, STANDARD R BURNER, TRAY WELDMENT 400, STANDARD R BURNER, MAIN, STANDARD L MANIFOLD, GAS (250) R MANIFOLD, GAS (400) R NAT. ORIFICE (0-3K FT) (SET OF 20) R OBSOLETE OBSOLETE NAT. ORIFICE (3K-6K FT) (SET OF 20) R NAT. ORIFICE (6K-9K FT) (SET OF 20) R LP ORIFICE (0-5K FT) (SET OF 20) R LP ORIFICE (5K-10K FT) (SET OF 20) R ANTI-ROTATION BRACKET R GAS VALVE, NATURAL W/STREET ELL R GAS VALVE, LP W/STREET ELL R FLUE COLLECTOR (250), STANDARD R FLUE COLLECTOR (400), STANDARD R OBSOLETE OBSOLETE FLUE COLLECTOR (250), LO NOX R OBSOLETE OBSOLETE FLUE COLLECTOR (400), LO NOX R BLOWER ASSEMBLY R GASKET W/BLOWER MOUNTING HARDWARE R TRANSFORMER, V/24V-ALL ELECTRIC R WIRE HARNESS, POWER TRANSFORMER R BLOWER PRESSURE SWITCH R THERMISTER, TEMPERATURE SENSOR R TEMP SENSOR GASKET E SLEEVE, PROTECTOR FOR BULB RETAINER, TEMPERATURE SENSOR SCREW, RETAINER BRACKET F REPLACE NLA IGNITION CONTROL REP W/ R IGNITION CONTROL REPLACEMENT - STANDARD R A IGNITION CONTROL - LO NOX R A PRESSURE SWITCH, ESG (2 PSI) (OEM) R SIPHON LOOP R A HI-LIMIT SWITCH 135 F R HI-LIMIT SWITCH 150 F R HI LIMIT WIRE HARNESS R RETAINER PLATES, HIGH LIMIT (SET OF 2) R HOT SURFACE IGNITOR - STANDARD R A HOT SURFACE IGNITOR - LO NOX R EXHAUST TEMP. LIMIT SWITCH R WIRE HARNESS, 120V POWER PLUG R WIRE HARNESS, 240V POWER PLUG R WIRE HARNESS, 15 PIN CONNECTOR R TERMINAL BLOCK R TEMPERATURE CONTROL W/BEZEL R DIGITAL TYPE CONTROL TEMPERATURE CONTROL W/BEZEL, DUAL R THERMOSTAT KNOBS ON CONTROL FLAME SENSE ROD, STANDARD R A FLAME SENSE ROD, LO NOX R FUSIBLE LINK R TEMPERATURE CONTROL COVER R OBSOLETE OBSOLETE FUSIBLE LINK BRACKET R PRESSURE RELIEF VALVE R POWER DISTRIBUTION CIRCUIT BOARD R BURNER TRAY, LO NOX, LOW ALT, 250, NG R BURNER TRAY, LO NOX, LOW ALT, 400, NG R BURNER TRAY, LO NOX, MID ALT, 250, NG R BURNER TRAY, LO NOX, MID ALT, 400, NG R BURNER TRAY, LO NOX, HIGH ALT, 250, NG R BURNER TRAY, LO NOX, HIGH ALT, 400, NG R BURNER TRAY, LO NOX, LOW ALT, 250, LP R BURNER TRAY, LO NOX, LOW ALT, 400, LP R BURNER TRAY, LO NOX, HIGH ALT, 250, LP R BURNER TRAY, LO NOX, HIGH ALT, 400, LP R BURNER WITHOUT ORIFICE R MANIFOLD, LO NOX, LOW ALT, 250, NG R MANIFOLD, LO NOX, LOW ALT, 400, NG R MANIFOLD, LO NOX, MID ALT, 250, NG R MANIFOLD, LO NOX, MID ALT, 400, NG R MANIFOLD, LO NOX, HIGH ALT, 250, NG R MANIFOLD, LO NOX, HIGH ALT, 400, NG R MANIFOLD, LO NOX, LOW ALT, 250, LP R MANIFOLD, LO NOX, LOW ALT, 400, LP R MANIFOLD, LO NOX, HIGH ALT, 250, LP R MANIFOLD, LO NOX, HIGH ALT, 400, LP R GAS VALVE, NG W/STREET ELL, LO NOX R GAS VALVE, LP W/STREET ELL, LO NOX R * WIRE HARNESS COMPLETE R PRIOR TO JAN, * WIRE HARNESS COMPLETE R JAN 2004 TO CURRENT * WIRE HARNESS POWER TRANSFORMER R * WIRE HARNESS, IGNITION CONTROL R * WIRE HARNESS, GAS VALVE R * WIRE HARNESS, SAFETY LOOP R * NOT SHOWN SHOWN KEY KEY KEY 54

11 JANDY LITE 2 LJ MODEL Heaters H-68 MFG PRESENT KEY SHOWN KEY SHOWN

12 JANDY LITE 2 LJ MODEL Heaters H-69 MFG PRESENT Edited KEY ITEM # DESCRIPTION MFG. # KEY ITEM # DESCRIPTION MFG. # E BURNER TRAY WELDMENT, 125 R A BURNER TRAY WELDMENT, 175 R B BURNER TRAY WELDMENT, 250 R C BURNER TRAY WELDMONT, 325 R D BURNER TRAY WELDMENT, 400 R A GAS VALVE LLJ, NG ELECTRONIC R B GAS VALVE LLJ, LP ELECTRONIC R GAS ORIFICE, NATURAL GAS L GAS ORIFICE, PROPANE L BURNER, MAIN L MANIFOLD, GAS (125) L A MANIFOLD, GAS (175) L B MANIFOLD, GAS (250) L C MANIFOLD, GAS (325) L D MANIFOLD, GAS (400) L HEATER CONTROL ASSEMBLY R HIGH VOLTAGE ASSEMBLY R TRANSFORMER W/ WIRING HARNESS R POWER CENTER BOARD R CONVERSION PLUG 115/230 VAC R CASTING, TEMP. CONTROL BEZEL S TEMPERATURE SENSOR R WITH GASKET & SCREW TEMP SENSOR RETAINER BRACKET SCREW, RETAINER BRACKET F A PRESSURE SWITCH, ESG (2 PSI) (OEM) R C PRESSURE SWITCH, SPECIAL(1-10 PSI) R TUBE, SYPHON LOOP ASSY R COMPLETE HI-LIMIT ASSY R (BOTH HI-LIMITS, RUBBER BOOTS, WIRE HARNESS) A DISC, HI-LIMIT SWITCH 135 F R DISC, HI-LIMIT 150 F R OBSOLETE OBSOLETE S-989 RUBBER RETAINER S OBSOLETE OBSOLETE WIRE HARNESS HI LIMIT RETAINER CLIP OBSOLETE OBSOLETE HI LIMIT SWITCH COVER FUSIBLE LINK R REPLACE NLA IGNITOR BOX ASSY REP W/ R REPLACE NLA IGNITER REP W/ R IGNITION RETROFIT KIT R OBSOLETE OBSOLETE IGNITOR FUSE, SET OF 2 R REPLACE NLA FLAME SENSE ROD REP W/ R FLAME SENSE ROD R WIRE HARNESS, TEMP R IGINITION CONTROL C HEADER, FRONT 2 IN R A HEADER,INLET/OUTLET 2 BRONZE R HEADER, REAR R HEADER, RETURN - ALL (BRONZE) R OBSOLETE OBSOLETE BOLT KIT R B HEADER BOLT 2.5 INCH F WASHER, HEADER F NUT, HEADER F GASKET, HEADER - SET OF 18 R A FLANGE KIT 2" & 1 1/2" (2 PER KIT) R FLANGE, SINGLE B GASKET, FLANGE 2 (SINGLE) S A GASKET, FLANGE 2 X 1 1/2IN S A SLEEVE FOR 2 FLANGE S BOLT, FLANGE (3/8-16 X 2) F PLUG, FOR REDUNDANT HI-LIMIT P PLUG, 3/4IN P ROD ASSY. W/DISK (NO SPRING) R E BY PASS ASSY WITH SPRING F BY PASS ASSY WITH SPRING G BY PASS ASSY WITH SPRING H BY PASS ASSY WITH SPRING I BY PASS ASSY WITH SPRING ROD, FLOW CONTROL S NUT, FOR FLOW CONTROL ASSY. F DISC, BY-PASS R REPLACE NLA CAP, CAST IRON REP W/ BYPASS ASSY R REPLACE NLA CAP, BRONZE REP W/ BYPASS CAP, BRONZE S CAPSCREW F SPRING, BY-PASS (PURPLE) S SPRING, BY-PASS (WHITE) S SPRING, BY-PASS (RED) S SPRING, BY-PASS (BLUE) S SPRING, BY-PASS (BLACK) S GASKET, FLOW CONTROL R TUBE BUNDLE, 125, 10" LONG R TUBE BUNDLE, 175, 12 7/8" LONG R TUBE BUNDLE, 250, 17 5/8" LONG R TUBE BUNDLE, 325, 22" LONG R TUBE BUNDLE, 400, 26 3/4" LONG R OBSOLETE OBSOLETE BAFFLE, SINGLE, A BAFFLE, SINGLE, B BAFFLE, SINGLE, C BAFFLE, SINGLE, D BAFFLE, SINGLE, CLIP, BAFFLE RETAINER S RESTRICTORS, (125 ONLY) S VENT CAP, VENT CAP, VENT CAP, VENT CAP, VENT CAP, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, DRAFT HOOD, HEAT EXCHANGER COMPLETE, A HEAT EXCHANGER COMPLETE, B HEAT EXCHANGER COMPLETE, C HEAT EXCHANGER COMPLETE, D HEAT EXCHANGER COMPLETE, * BY PASS ASSY LITE R * HI-LIMIT SET ( DEG & DEG) R (INCLUDES BOTH KEYS 22 & 23) * NOT SHOWN KEY KEY 31 NLA REP W/ KEY 31

13 JANDY LXI Heaters H-70 NATURAL GAS & LP MODELS 250, 300, &

14 JANDY LXI Heaters H-71 NATURAL GAS & LP MODELS 250, 300, & 400 KEY ITEM # DESCRIPTION MFG. # HEAT EXCHANGER COMPONENTS LXI 250, COMPLETE HEAT EXCHANGER R LXI 300, COMPLETE HEAT EXCHANGER R LXI 400, COMPLETE HEAT EXCHANGER R LXI 250, TUBE BUNDLE W/HDWR, GASKETS R LXI 300, TUBE BUNDLE W/HDWR, GASKETS R LXI 400, TUBE BUNDLE W/HDWR, GASKETS R CONTROL, USER INTERFACE AND GASKET R LXI 250, HEAT EXCHANGER END BAFFLES R LXI 300, HEAT EXCHANGER END BAFFLES R LXI 400, HEAT EXCHANGER END BAFFLES R FRONT HEADER W/HDWR & GASKETS R BY PASS WITH HDWR & GASKETS R BY PASS WITH O-RING R BY PASS SPRING R COUPLING NUT KIT W/O-RING (SET OF 2) R COUPLING O-RING (SET OF 2) R REAR HEADER W/HDWR & GASKETS R HEADER GASKET, (SET OF 16) R DRAIN PLUG W/O-RING (SET OF 3) R HEAT EXCHANGER HDWR W/GASKETS R SENSOR CAP WITH O-RING R RETURN HEADER CAP WITH O-RING R GAS COMPONENTS BURNER WITH GASKET R BURNER WITH TAP & GASKET R LXI 250 GAS MANIFOLD W/ORIFICES, NG R LXI 300 GAS MANIFOLD W/ORIFICES, NG R LXI 400 GAS MANIFOLD W/ORIFICES, NG R LXI 250 GAS MANIFOLD W/ORIFICES, LP R LXI 300 GAS MANIFOLD W/ORIFICES, LP R LXI 400 GAS MANIFOLD W/ORIFICES, LP R GAS VALVE WITH STREET ELBOW, NG R GAS VALVE WITH STREET ELBOW, LP R EXHAUST SYSTEM LXI 250 FLUE COLLECTOR WITH GASKETS R LXI 300 FLUE COLLECTOR WITH GASKETS R LXI 400 FLUE COLLECTOR WITH GASKETS R BLOWER ASSY WITH GASKETS R AIR ORIFICE ADJUSTMENT BRACKET R LXI 250 FLUE VENT ASSY W/GASKETS R LXI 300 & 400 FLUE VENT W/GASKETS R LXI 250 OUTDOOR GRILL R OBSOLETE OBSOLETE LXI 300, LXI400 OUTDOOR GRILL R VENT HARDWARE KIT R FLUE BOX ASSY WITH GASKET R LXI 250 & 300, SIDE WALL VENT KIT R LXI 400, SIDE WALL VENT KIT R KEY ITEM # DESCRIPTION MFG. # ELECTRICAL TRANSFORMER R AIR PRESSURE SWITCH R TEMP SENSOR W/SLEEVE & GASKET R TEMP SENSOR GASKET R TEMP SENSOR PLASTIC SLEEVE R TEMP SENSOR RETAINING NUT R IGNITION CONTROL R WATER PRESSURE SWITCH ASSY R A WATER PRESSURE SWITCH, 2 PSI R WATER PRESSURE SWITCH TUBING R HIGH LIMIT SET R HIGH LIMIT 130 DEGREE R HIGH LIMIT 150 DEGREE R HI LIMITS WITH WIRING HARNESS R HOT SURFACE IGNITOR R WIRE HARNESS SET COMPLETE R CONTROLLER WIRE HARNESS R WATER PRESSURE SWITCH HARNESS R SAFETY CIRCUIT WIRE HARNESS R AIR FLOW SWITCH WIRE HARNESS R POWER DISTRIBUTION PC BOARD R CONTROLLER PWER INTERFACE PCB R UNIVERSAL CONTROL INTERFACE R SMOKED DISPLAY COVER R CONTROL GASKET R FLAME SENSOR R FUSIBLE LINK R FUSIBLE LINK BRACKET R JACKET ASSEMBLY LXI 250 DOOR WITH LATCH R LXI 300 DOOR WITH LATCH R LXI 400 DOOR WITH LATCH R DOOR LATCH & HANDLE ASSEMBLY R LXI 250 TOP ASSEMBLY R LXI 300 TOP ASSEMBLY R LXI 400 TOP ASSEMBLY R OBSOLETE OBSOLETE COMBUSTION CHAMBER PANELS R OBSOLETE OBSOLETE COMBUSTION CHAMBER PANELS R OBSOLETE OBSOLETE COMBUSTION CHAMBER PANELS R LXI 250 AIR CHAMBER HOUSING R LXI 300 AIR CHAMBER HOUSING R LXI 400 AIR CHAMBER HOUSING R LXI 250 AIR CHAMBER COVER R LXI 300 AIR CHAMBER COVER R LXI 400 AIR CHAMBER COVER R AIR DUCT R OBSOLETE OBSOLETE BURNER PANEL R OPTIONAL OPTIONAL UNIVERSAL REMOTE R * PRESSURE RELIEF VALVE R * NOT SHOWN

15 JANDY Hi-E2 Heaters H-72 MODEL 220 & 350

16 JANDY Hi-E2 Heaters H-73 MODEL 220 & 350 Edited KEY ITEM # DESCRIPTION MFG. # MAINTENANCE AND SERVICE LIMESTONE GRAVEL R (CONDENSATE NEUTRALIZER) COMBUSTION AIR FILTER R WATER SYSTEM HEAT EXCHANGER ASSY, R COMPLETE, HEAT EXCHANGER ASSY, R COMPLETE, TUBE BUNDLE, 220 R TUBE BUNDLE, 350 R INLET/OUTLET HEADER R RETURN HEADER R GASKET, HEADER R BY-PASS VALVE ASSEMBLY R BYPASS VALVE CAP, BRONZE BY-PASS VALVE GASKET S BY-PASS VALVE SPRING R BY-PASS VALVE ROD R BY-PASS VALVE DISK R A FLANGE & GASKET ASSY,(SET OF 2) R FLANGE, 2" B FLANGE GASKET, 2" S A FLANGE SLEEVE, 2" S FLANGE BOLT F A FLANGE GASKET 1 ½ - 2" S * PRESSURE RELIEF VALVE R * HEAT EXCHANGER HARDWARE KIT R * INLET/OUTLET HEADER HARDWARE KIT R * RETURN HEADER HARDWARE KIT R COMBUSTION SYSTEM GAS VALVE R * ANTI-ROTATION BRACKET R ORIFICE HOLDER R OBSOLETE OBSOLETE GAS ORIFICE, NG, 220 R GAS ORIFICE, NG, 350 R OBSOLETE OBSOLETE GAS ORIFICE, LP, 220 R GAS ORIFICE, LP, 350 R OBSOLETE OBSOLETE COMBUSTION AIR FILTER ASSY R COMBUSTION AIR FILTER R OBSOLETE OBSOLETE VENTURI INLET, 220 R VENTURI INLET, 350 R VENTURI O-RING R VENTURI PLENUM R OBSOLETE OBSOLETE VENTURI/TAILPIPE GASKET R MIXING CHAMBER/TAILPIPE ASSEMBLY R MIXING CHAMBER/BURNER GASKET R BURNER ASSEMBLY, 220 R BURNER ASSEMBLY, 350 R BURNER GASKET, 220 R BURNER GASKET, 350 R OBSOLETE OBSOLETE COMBUSTION CHAMBER ASSY R COMBUSTION CHAMBER ASSY, 350 R REFRACTORY TILE SET, 220 R OBSOLETE OBSOLETE REFRACTORY TILE SET, 350 R SIGHT GLASS ASSY R COMBUSTION CHAMBER STRIP SET, 220 R COMBUSTION CHAMBER STRIP SET, 350 R COMBUSTION CHAMBER GASKET, 220 R KEY ITEM # DESCRIPTION MFG. # COMBUSTION CHAMBER GASKET, 350 R * VENTURI HARDWARE KIT R * MIXING CHAMBER HARDWARE KIT R * BURNER HARDWARE KIT, 220 R * BURNER HARDWARE KIT, 350 R EXHAUST ASSEMBLY 50 OBSOLETE OBSOLETE COLLECTOR, 220 R OBSOLETE OBSOLETE COLLECTOR, 350 R BLOWER/COLLECTOR GASKET R COMBUSTION BLOWER R BLOWER/VENT DUCT SLEEVE R BLOWER/ VENT DUCT CLAMP R VENT DUCT ASSEMBLY R VENT DUCT/HEATER TOP GASKET R HEATER TOP/OUTDOOR R EXHAUST GRILL GASKET OUTDOOR EXHAUST GRILLE R INDOOR VENT COLLAR R CONDENSATE TRAP ASSEMBLY R LIMESTONE GRAVEL R OBSOLETE OBSOLETE CONDENSATE TRAP COVER R * VENTURI HARDWARE KIT R * MIXING CHAMBER HARDWARE KIT R ELECTRICAL TRANSFORMER R IN-LINE FUSE HOLDER ASSEMBLY R IGNITION CONTROL R WIRE HARNESS, IGNITION CONTROL R IGNITER ASSEMBLY R IGNITER GASKET R OBSOLETE OBSOLETE TERMINAL BLOCK R HIGH-LIMIT SWITCH SET R HIGH-LIMIT SWITCH, 135 F R HIGH-LIMIT SWITCH, 150 F R OBSOLETE OBSOLETE HIGH-LIMIT WIRE HARNESS R PRESSURE SWITCH & R SYPHON LOOP ASSY A PRESSURE SWITCH, 2 PSI R OBSOLETE OBSOLETE PRESSURE SWITCH R B TEMPERATURE CONTROL ASSY, R ELECTRONIC * TEMPERATURE SENSOR R TEMPERATURE SENSOR GASKET E TEMPERATURE SENSOR PLASTIC SLEEVE TEMPERATURE CONTROL KNOB R POOL/SPA SELECTOR KNOB R OBSOLETE OBSOLETE TEMP-LOK" DISC " TEMPERATURE SENSOR RETAINER CLIP DIFFERENTIAL PRESSURE SWITCH R DIFFERENTIAL PRESSURE R SWITCH BRACKET EXHAUST VENT LIMIT SWITCH R BURNER HIGH LIMIT SWITCH R COMBUSTION BLOWER WIRE HARNESS R

17 JANDY HOT SHOT Heaters H-74 ABOVE GROUND HEATER MODEL LHS100N & LHS100P Edited KEY 5 KEY ITEM # DESCRIPTION MFG. # BURNER TRAY, NG R BURNER TRAY, LP R GAS VALVE, NG R GAS VALVE, LP R PILOT ASSY, NG R PILOT ASSY, LP R PILOT GENERATOR W THERMOSTAT ASSY R ON/OFF SWITCH R THERMOSTAT KNOB R OBSOLETE OBSOLETE KNOB STOP PLATE HI LIMIT, 135 DEGREE R HI LIMIT, 150 DEGREE R A PRESSURE SWITCH, 2PSI R FUSIBLE LINK R INLET/OUTLET HEADER ASSY R UNION KIT 1 1/2" SET OF 2 R * OBSOLETE OBSOLETE TEMP SENSOR E * UNION O-RING KIT R * NOT SHOWN

18 JANDY HEATERS Heaters H-75 Edited COMPLETE HEAT EXCHANGERS - 2" HEADERS ITEM # HEATER SIZE MFG. NO A B C D Includes - Tube Bundle with baffles and gaskets. Front Header with bypass, plug, & pressure switch fitting Rear Header with plugs D HEAT SINKS SR SMITH - STAINLESS STEEL KEY ITEM # DESCRIPTION MFG. # 1 OBSOLETE OBSOLETE SET OF 2 H /2" X 17" WITH 1 1/2" SLIP UNION (TUBING OUTSIDE DIAMETER IS 1 5/8") SET OF 2 H " X 23" WITH 2" SLIP UNION (TUBING OUTSIDE DIAMETER IS 2 1/4") 1 2 UNION PARTS KEY ITEM # DESCRIPTION MFG. # 1 1/2" HEAT SINKS A UNION NUT HS UNION O-RING HS B TAILPIECE WITH O-RING HS200 2" HEAT SINKS C UNION NUT HS UNION O-RING HS B TAILPIECE ONLY HS

19 JANDY SERIES 1 Heaters H-122 EPC & EPS ELECTRONIC MANUFACTURED ATTENTION THIS PAGE IS ONLY AVAILABLE IN THE INTERNET VERSION OF THE POOL & SPA CATALOG.

20 JANDY SERIES 1 Heaters H-123 EPC & EPS ELECTRONIC MANUFACTURED ATTENTION THIS PAGE IS ONLY AVAILABLE IN THE INTERNET VERSION OF THE POOL & SPA CATALOG. KEY ITEM # DESCRIPTION MFG. # KEY ITEM # DESCRIPTION MFG. # GAS SYSTEM B PILOT BURNER, NG R C PILOT BURNER, LP W A PILOT TUBING R FLAME SENSOR, LP W A CERAMIC INSULATOR R E BURNER TRAY SHELF ONLY, 125 R A BURNER TRAY SHELF ONLY, 175 R B BURNER TRAY SHELF ONLY, 250 R C BURNER TRAY SHELF ONLY, 325 R D BURNER TRAY SHELF ONLY, 400 R D GAS VALVE, NG, R E GAS VALVE, NG, R OBSOLETE OBSOLETE GAS VALVE, LP R GAS ORIFICE, NG L GAS ORIFICE, LP L MAIN BURNER W/PILOT BRACKET MAIN BURNER L ELECTRICAL SYSTEM B TEMP CONTROL (EPS, EPCII) R REPLACE NLA WIRE HARNESS (EPS, EPCII) R REP W/ WIRE HARNESS R TEMP SENSOR (EPS, EPCII) R KNOB, SINGLE BAR (EPS, EPCII) R TEMP CONTROL (EPC) R ON OFF SWITCH (EPC) R OBSOLETE OBSOLETE TEMP PLATE (EPC) THERMOSTAT KNOB R BEZEL S TEMP LOCK STOP PLATE A PRESSURE SWITCH, 2 PSI R C PRESSURE SWITCH, 1-10 PSI R SYPHON LOOP R HI-LIMIT SET ( DEG & DEG) R A HIGH LIMIT, 135 DEGREE R HIGH LIMIT, 150 DEGREE R RETAINER CLIP RETAINER BOOT S OBSOLETE OBSOLETE SWITCH COVER FUSIBLE LINK R FUSIBLE LINK BRACKET TRANSFORMER R IN LINE FUSE ASSEMBLY A IGNITION CONTROL, NG R IGNITION CONTROL HARNESS R REPLACE NLA HIGH VOLTAGE LEAD REP W/ C HIGH VOLTAGE LEAD, LP (RED WIRE) R (EPC-LP) HIGH VOLTAGE LEAD (ESC) R WATER SYSTEM INLET/OUTLET, 1-1/2, CAST IRON R C INLET/OUTLET, 2, CAST IRON R A INLET/OUTLET, 2, BRONZE R RETURN HEADER R RETURN HEADER, BRONZE R A HEADER BOLT SET R B HEADER BOLT, 2-1/2 F WASHER F NUT F HEADER GASKET (SET OF 18) R FLANGE & GASKET ASSY 1-1/2 R REPLACE NLA FLANGE, 1-1/2 REP W/ S /2" FLANGE WITH BOLTS R FLANGE GASKET, 1-1/2 S OBSOLETE OBSOLETE FLANGE SLEEVE, 1-1/2 S FLANGE BOLT F A FLANGE & GASKET ASSY 2 R FLANGE, B FLANGE GASKET, 2 S A FLANGE SLEEVE, 2 S FLANGE BOLT F A FLANGE GASKET 2 X 1-1/2 S DRAIN PLUG P BRASS PLUG, 3/4 P BY PASS ASSY R BY PASS ROD S BY PASS DISC R REPLACE NLA BY PASS CAP REP W/ S SPRING WHITE, 125, 1-1/2 S SPRING RED, 175, 1-1/2 S SPRING BLUE, 250, 1-1/2 S SPRING BROWN, 325, 1-1/2 S SPRING ORANGE, 400, 1-1/2 S SPRING PURPLE, 125, 2 S SPRING WHITE, 175, 2 S SPRING RED, 250, 2 S SPRING BLUE, 325, 2 S SPRING BLACK, 400, 2 S BY PASS GASKET R EXCHANGER TUBE ASSY, 125 R EXCHANGER TUBE ASSY, 175 R EXCHANGER TUBE ASSY, 250 R EXCHANGER TUBE ASSY, 325 R EXCHANGER TUBE ASSY, 400 R OBSOLETE OBSOLETE EXCHANGER BAFFLE A EXCHANGER BAFFLE, SINGLE, B EXCHANGER BAFFLE, SINGLE, C EXCHANGER BAFFLE, SINGLE, D EXCHANGER BAFFLE, SINGLE, BAFFLE RETAINER S * WIRE HARNESS (EPC, EPS, EPCII) R * COMPLETE BYPASS ASSY R LAARS LITE * COMPLETE HI-LIMIT ASSY R (BOTH HI-LIMITS, RUBBER BOOTS, WIRE HARNESS) * NOT SHOWN

21 JANDY SERIES 1 Heaters H-124 EPG & EPM MILLIVOLT MANUFACTURED ATTENTION THIS PAGE IS ONLY AVAILABLE IN THE INTERNET VERSION OF THE POOL & SPA CATALOG.

22 JANDY SERIES 1 Heaters H-125 EPG & EPM MILLIVOLT MANUFACTURED ATTENTION THIS PAGE IS ONLY AVAILABLE IN THE INTERNET VERSION OF THE POOL & SPA CATALOG. KEY ITEM # DESCRIPTION MFG. # KEY ITEM # DESCRIPTION MFG. # GAS SYSTEM PILOT BURNER, NG R A PILOT BURNER, LP R B PILOT GENERATOR W PILOT GENERATOR (OLD STYLE GC) R A PILOT TUBING R E BURNER TRAY SHELF ONLY, 125 R A BURNER TRAY SHELF ONLY, 175 R B BURNER TRAY SHELF ONLY, 250 R C BURNER TRAY SHELF ONLY, 325 R D BURNER TRAY SHELF ONLY, 400 R J GAS VALVE, NG R K GAS VALVE, LP R GAS ORIFICE, NG L GAS ORIFICE, LP L MAIN BURNER W/PILOT BRACKET MAIN BURNER L ELECTRICAL SYSTEM 14** TEMPERATURE CONTROL (EPG) R MECHANICAL THERMOSTAT R A WIRE HARNESS (EPG) R TEMP LOCK STOP PLATE (EPG) ON OFF SWITCH (EPG) R TEMP CONTROL LABEL (EPG) H D TEMP CONTROL (EPM) R STOP PLATE (EPM) KNOB, SINGLE BAR (EPM) R TEMP SENSOR R TEMP CONTROL BULB O-RING E PROTECTOR SLEEVE THERMOSTAT KNOB R BEZEL S A PRESSURE SWITCH, 2 PSI R C PRESSURE SWITCH, 1-10 PSI R SYPHON LOOP R OBSOLETE OBSOLETE REDUNDANT HI LIMIT R HI-LIMIT SET ( DEG & DEG) R A HIGH LIMIT, 135 DEGREE R HIGH LIMIT, 150 DEGREE R RETAINER CLIP RETAINER BOOT S OBSOLETE OBSOLETE SWITCH COVER FUSIBLE LINK R FUSIBLE LINK BRACKET WATER SYSTEM INLET/OUTLET, 1-1/2, CAST IRON R C INLET/OUTLET, 2, CAST IRON R A INLET/OUTLET, 2, BRONZE R RETURN HEADER R RETURN HEADER, BRONZE R A HEADER BOLT SET R NUT F B HEADER BOLT, 2-1/2 F WASHER F HEADER GASKET (SET OF 18) R FLANGE & GASKET ASSY 1-1/2 R REPLACE NLA FLANGE, 1-1/2 REP W/ S /2" FLANGE WITH BOLTS R FLANGE GASKET, 1-1/2 S OBSOLETE OBSOLETE FLANGE SLEEVE, 1-1/2 S FLANGE BOLT F A FLANGE & GASKET ASSY 2 R FLANGE, B FLANGE GASKET, 2 S A FLANGE SLEEVE, 2 S FLANGE BOLT F A FLANGE GASKET 2 X 1-1/2 S DRAIN PLUG P BRASS PLUG, 3/4 P BY PASS ASSY R BY PASS ROD S BY PASS DISC R REPLACE NLA BY PASS CAP REP W/ S SPRING WHITE, 125, 1-1/2 S SPRING RED, 175, 1-1/2 S SPRING BLUE, 250, 1-1/2 S SPRING BROWN, 325, 1-1/2 S SPRING ORANGE, 400, 1-1/2 S SPRING PURPLE, 125, 2 S SPRING WHITE, 175, 2 S SPRING RED, 250, 2 S SPRING BLUE, 325, 2 S SPRING BLACK, 400, 2 S BY PASS GASKET R EXCHANGER TUBE ASSY, 125 R EXCHANGER TUBE ASSY, 175 R EXCHANGER TUBE ASSY, 250 R EXCHANGER TUBE ASSY, 325 R EXCHANGER TUBE ASSY, 400 R OBSOLETE OBSOLETE EXCHANGER BAFFLE A EXCHANGER BAFFLE, SINGLE, B EXCHANGER BAFFLE, SINGLE, C EXCHANGER BAFFLE, SINGLE, D EXCHANGER BAFFLE, SINGLE, BAFFLE RETAINER S * COMPLETE BYPASS ASSY R LAARS LITE * COMPLETE HI-LIMIT ASSY R (BOTH HI-LIMITS, RUBBER BOOTS, WIRE HARNESS) * NOT SHOWN ** SOLID STATE REPLACEMENT