DTC B1154/38 Rear Airbag Sensor RH Circuit Malfunction
|
|
|
- Shanon Cannon
- 6 years ago
- Views:
Transcription
1 202 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM T B1154/38 ircuit Malfunction ESRIPTION The rear airbag sensor RH circuit consists of the safing sensor, the diagnostic circuit and the lateral deceleration sensor, etc. If the center airbag sensor assembly receives signals from the lateral deceleration sensor, it judges whether or not the S should be activated. T B1154/38 is recorded when a malfunction in the rear airbag sensor RH circuit is detected. T No. T etecting ondition Trouble rea B1154/38 The center airbag sensor assembly receives a line short circuit signal, an open circuit signal, a short circuit to signal or a short circuit to B+ signal in the rear airbag sensor RH circuit for 2 seconds. Rear airbag sensor RH malfunction enter airbag sensor assembly malfunction Rear airbag sensor RH enter airbag sensor assembly Floor wire WIRI IGRM enter airbag Sensor assembly ESR 1 20 ESR VUR 4 19 VUR SR- SR- 2 4 SR SR+ H043054E27
2 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 203 INSPETION PROEURE 1 HEK T L3 enter irbag T B1154/38 (d) (e) lear the Ts stored in memory (See page -35). Turn the ignition switch to the L position. heck the Ts (See page -35). : T B1154/38 is not output. HINT: odes other than code B1154/38 may be output at this time, but they are not related to this check. G T E01 Go to step 2 USE SIMULTION METHO TO HEK 2 HEK ONNETION OF ONNETO Turn the ignition switch to the L position. isconnect the negative (-) terminal cable from the battery, and wait for at least 90 seconds. heck that the connectors are properly connected to the center airbag sensor assembly and the rear airbag sensor RH. : The connectors are connected. ONNET ONNETO, THEN GO TO STEP 1
3 204 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 3 HEK FLOOR WIRE (OPEN) B onnector enter irbag onnector B isconnect the connectors from the center airbag sensor assembly and the rear airbag sensor RH. Using a service wire, connect -19 (VUR) and - 20 (ESR) of connector "B". NOTIE: o not forcibly insert a service wire into the terminals of the connector when connecting. Measure the resistance according to the value(s) in the Resistance Tester connection ondition Specified condition -4 (VUR) - -1 (ESR) Below 1 Ω VUR ESR Service Wire ESR VUR E08 B onnector enter irbag onnector B (d) Using a service wire, connect -18 (SR+) and -4 (SR-) of connector "B". NOTIE: o not forcibly insert a service wire into the terminals of the connector when connecting. (e) Measure the resistance according to the value(s) in the Resistance Tester connection ondition Specified condition -3 (SR+) - -2 (SR-) Below 1 Ω SR- REPIR OR REPLE FLOOR WIRE Service Wire SR+ SR- SR E08
4 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM HEK FLOOR WIRE (SHORT TO B+) SR+ B onnector enter irbag (d) isconnect the service wire from connector "B". onnect the negative (-) terminal cable to the battery, and wait for at least 2 seconds. Turn the ignition switch to the ON position. Measure the voltage according to the value(s) in the Voltage Tester connection ondition Specified condition -4 (VUR) - Body -1 (ESR) - Body -3 (SR+) - Body -2 (SR-) - Body VUR ESR REPIR OR REPLE FLOOR WIRE E16 5 HEK FLOOR WIRE (SHORT TO GROUN) SR+ B onnector enter irbag SR- SR- Turn the ignition switch to the L position. isconnect the negative (-) terminal cable from the battery, and wait for at least 90 seconds. Measure the resistance according to the value(s) in the Resistance Tester connection ondition Specified condition -4 (VUR) - Body -1 (ESR) - Body -3 (SR+) - Body -2 (SR-) - Body VUR ESR REPIR OR REPLE FLOOR WIRE E16
5 206 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 6 HEK FLOOR WIRE (SHORT) Measure the resistance according to the value(s) in the Standard B enter irbag Tester connection ondition Specified condition -4 (VUR) - -1 (ESR) -3 (SR+) - -2 (SR-) onnector REPIR OR REPLE FLOOR WIRE SR+ SR- VUR ESR E16 7 HEK RER IRBG SENSOR RH G Sensor LH L3 T enter irbag T B1154/38 (d) (e) (f) (g) (h) onnect the connector to the center airbag sensor assembly. Interchange the rear airbag sensor LH with RH and connect the connectors to them. onnect the negative (-) terminal cable to the battery, and wait for at least 2 seconds. lear the Ts stored in memory (See page -35). Turn the ignition switch to the L position. heck the Ts (See page -35). Result T B1155/ E01 Proceed To isplay (T Output) : T B1154/38 is output. : B T B1155/39 is output. T B1154/38 and B1155/39 are not output. : REPLE ENTER IRBG SENSOR SSEMBLY
6 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 207 :B REPLE RER IRBG SENSOR RH USE SIMULTION METHO TO HEK
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
152 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM T B1140/32 ircuit Malfunction IPTION The side airbag sensor assembly RH circuit consists of the safing sensor, the diagnostic circuit and the lateral deceleration
Rear Occupant Classification Sensor LH Circuit Malfunction
SUPPLEMENTL RESTRINT SYSTEM OUPNT LSSIFITION SYSTEM 281 T 1782 ircuit Malfunction ESRIPTION The rear occupant classification sensor LH circuit consists of the occupant classification and the rear occupant
DTC B1651/33 Manual Cut off Switch Trouble
137 T 1651/33 Manual ut off Switch Trouble ESRIPTION The airbag cut-off switch circuit consists of the center airbag sensor assembly and the airbag cut off switch. T 1651/33 is set when a malfunction is
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 85 DT 1628/82 Front Passenger Side - Side irbag Sensor ssembly Initialization Incomplete DESRIPTION The side airbag sensor RH and the rear airbag sensor RH consist
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
192 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM DT B1153/25 ircuit Malfunction DESRIPTION The seat position airbag sensor circuit consists of the center airbag sensor assembly and the seat position airbag
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
122 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM DT 1647/82 Lost ommunication with Front Passenger Side Satellite Sensor us DESRIPTION The side airbag sensor RH and the rear airbag sensor RH consist of parts
DTC B1772 Seat Position Sensor Circuit Malfunction
500 SUPPLEMENTL RESTRINT SYSTEM OUPNT LSSIFITION SYSTEM (for T 1772 ircuit Malfunction ESRIPTION The seat position sensor circuit consists of the occupant classification EU and the seat position sensor.
DTC B1625/22 SIDE AIRBAG SENSOR ASSEMBLY (P SEAT SIDE) MALFUNCTION
051434 IGNOSTIS SUPPLEMENTL RESTRINT SYSTEM T 1625/22 SIE IRG SENSOR SSEMLY (P SET SIE) MLFUNTION 05IXH01 IRUIT IPTION The side airbag sensor assembly (P seat side) consists of the safing sensor, the diagnostic
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 203 DT 1825/56 DT 1826/56 DT 1827/56 DT 1828/56 Short in Front Passenger Side - Side Squib ircuit Open in Front Passenger Side - Side Squib ircuit Short to GND in
DTC B1805/52 Short in Front Passenger Side Squib Circuit. DTC B1806/52 Open in Front Passenger Side Squib Circuit
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 177 DT 1805/52 Short in Front Passenger Side Squib ircuit DT 1806/52 Open in Front Passenger Side Squib ircuit DT 1807/52 DT 1808/52 Short to GND in Front Passenger
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 191 DT 1815/54 DT 1816/54 DT 1817/54 DT 1818/54 Short in Front Passenger Side Squib 2nd Step ircuit Open in Front Passenger Side Squib 2nd Step ircuit Short to GND
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM. DTC B1800/51 Short in Driver Side Squib Circuit. DTC B1801/51 Open in Driver Side Squib Circuit
170 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM DT 1800/51 Short in Driver Side Squib ircuit DT 1801/51 Open in Driver Side Squib ircuit DT 1802/51 Short to GND in Driver Side Squib ircuit DT 1803/51 Short
DTC B1810/53 Short in Driver Side Squib 2nd Step Circuit. DTC B1811/53 Open in Driver Side Squib 2nd Step Circuit
184 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM DT 1810/53 Short in Driver Side Squib 2nd Step ircuit DT 1811/53 Open in Driver Side Squib 2nd Step ircuit DT 1812/53 DT 1813/53 Short to GND in Driver Side Squib
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 213 DT 1835/58 DT 1836/58 DT 1837/58 DT 1838/58 Short in Front Passenger Side urtain Shield Squib ircuit Open in Front Passenger Side urtain Shield Squib ircuit Short
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
262 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM DTC B1825/56 DTC B1826/56 DTC B1827/56 DTC B1828/56 Short in Circuit Open in Circuit Short to GND in Front Passenger Side - Side Squib Circuit Short to B+ in
SRS Warning Light Remains ON
232 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM S Warning Light Remains ON DESRIPTION The S warning light is located on the combination meter. When the S condition is normal, the S warning light illuminates
DTC B1141/33 Side and Curtain Shield Airbag Sensor Assembly (LH) Malfunction
DTC B1141/33 and Curtain Shield Assembly (LH) Malfunction 05719 05A1N01 CIRCUIT DESCRIPTION The side airbag sensor assy LH circuit consists of the diagnosis circuit and lateral deceleration sensor, etc.
DTC B0101/14 Open in Driver Side Squib Circuit
54 DT 0101/14 Open in ircuit DSRIPTION The driver side squib circuit consists of the center airbag sensor assembly, the spiral cable and the steering pad. The circuit instructs the S to deploy when deployment
DTC B1150/23 Occupant Classification System Malfunction
172 SUPPLMNTL RSTRINT SYSTM IRG SYSTM DT 1150/23 lassification System Malfunction DSRIPTION The occupant classification system circuit consists of the center airbag sensor assembly and the occupant classification
DTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION
05714 DTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION 05A1M01 CIRCUIT DESCRIPTION The side airbag sensor assy RH consists of the diagnosis circuit and lateral deceleration sensor, etc. It receives
DTC C1268/68 Transfer "L4" Position Switch Circuit
RKE ONTROL VEHILE STILITY ONTROL SYSTEM 135 DT 1268/68 Transfer "L4" Position Switch ircuit DESRIPTION fter confirming that the transfer is in the L4 position, -TR and downhill assist control will be activated
DTC B1140/32 Side Airbag Sensor Assy (RH) Malfunction
DI428 DIAGNOSTICS DI9HU01 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTION The side airbag sensor assy (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.
DTC B1140/32 Side Airbag Sensor Assembly (RH) Malfunction
DI342 DIAGNOSTICS DI6ZW03 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTI The side airbag sensor assembly (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.
DTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION
05644 DTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION 055Z603 CIRCUIT DESCRIPTION The side airbag sensor assy (RH) consists of the diagnosis circuit and lateral deceleration sensor, etc. It receives
DTC B1141/33 Side Airbag Sensor Assy (LH) Malfunction
DI434 DI9HV01 DTC B1141/33 Side (LH) Malfunction CIRCUIT DESCRIPTION The side airbag sensor assy (LH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc. It receives
DTC B1141/33 Side Airbag Sensor Assembly (LH) Malfunction
DI350 DI6ZX04 DTC B1141/33 Side (LH) Malfunction CIRCUIT DESCRIPTI The side airbag sensor assembly (LH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc. It receives
DTC B1156/B1157/15 Front Airbag Sensor (RH) Malfunction
DI309 DI6PW03 DTC B1156/B1157/15 Malfunction CIRCUIT DESCRIPTION The front airbag sensor (RH) circuit consists of the airbag sensor assembly and front airbag sensor (RH). For details of the function of
DTC B1801/51 OPEN IN D SQUIB CIRCUIT
051466 DIGNOSTICS DTC B1801/51 OPEN IN D SQUIB CIRCUIT 05IXN01 CIRCUIT DESCRIPTION The D squib circuit consists of the airbag assy, the spiral cable subassy and the horn button assy. The circuit instructs
DTC B1650/32 Occupant Classification System Malfunction
SUPPLMNTL RSTRINT SYSTM IRG SYSTM 125 DTC 1650/32 System Malfunction DSCRIPTION The occupant classification system circuit consists of the center airbag sensor assembly and the occupant classification
The driver side squib circuit consists of the center airbag sensor assembly, the spiral cable and the steering pad.
Page 1 of 19 DTC B1800/51 SHORT IN DRIVER SIDE SQUIB CIRCUIT; DTC B1801/51 OPEN IN DRIVER SIDE SQUIB CIRCUIT; DTC B1802/51 SHORT TO GND IN DRIVER SIDE SQUIB CIRCUIT; DTC B1803/51 SHORT TO B+ IN DRIVER
DTC B1152/28 PASSENGER AIRBAG ON/OFF INDICATOR LIGHT CIRCUIT MALFUNCTION
051352 DIGNOSTICS DTC 1152/28 PSSEER IRG ON/OFF INDICTOR LIGHT CIRCUIT MLFUNCTION 05IVQ02 CIRCUIT DESCRIPTION The passenger airbag ON/OFF indicator light circuit consists of the airbag sensor assy center
P0A38/257 GENERATOR TEMPERATURE SENSOR CIRCUIT LOW P0A39/259 GENERATOR TEMPERATURE SENSOR CIRCUIT HIGH
DT DIGNOSTIS P038/257 GENERTOR TEMPERTURE SENSOR IRUIT LOW 05537 05J601 DT P039/259 GENERTOR TEMPERTURE SENSOR IRUIT HIGH IRUIT DESRIPTION The motor temperature sensor No. 2 detects the temperature of
DTC B0103/12 Short in D and P Squib Circuit (to B+)
DI404 DIAGNOSTICS DI58L02 DTC B0103/12 Short in D and P Squib Circuit (to B+) CIRCUIT DESCRIPTI The D and P squib circuits consist of the airbag sensor assembly, spiral cable, steering wheel pad and front
DTC B0133/62 Short in LH and RH P/T Squib Circuits (to B+)
DI429 DI58O01 Sht in LH and RH P/T Squib Circuits CIRCUIT DESCRIPTI The LH and RH P/T squib circuits consist of the airbag sens assembly and LH and RH seat belt pretensioners. It causes the pretensioner
CIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI248 CIRCUIT INSPECTION DI6P303 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
PRE CHECK 1. SRS WARNING LIGHT CHECK
H08442 PRECHECK DI287 DI4L104 1. SRS WARNING LIGHT CHECK (a) Turn the ignition switch to the ACC or ON position and check that the SRS warning light lights up. (b) Check that the SRS warning light goes
DTC C2121/21 No Signal from Transmitter ID1. DTC C2122/22 No Signal from Transmitter ID2. DTC C2123/23 No Signal from Transmitter ID3
TIRE ND WHEEL TIRE PRESSURE WRNI SYSTEM 33 DTC C2121/21 No Signal from Transmitter ID1 DTC C2122/22 No Signal from Transmitter ID2 DTC C2123/23 No Signal from Transmitter ID3 DTC C2124/24 No Signal from
Seat Belt Warning Light for Passenger Seat does not Flash
5 TER TER / GUGE SYSTEM Seat elt Warning Light for Passenger Seat does not Flash WIRI DIGRM ench Seat: Instrument Panel J/ No. Hazard Warning Signal Switch P 7 PF 3 PF P 3 IG+ Driver Side J/ IL IL 8 GR-
CIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI388 CIRCUIT INSPECTION DI18Q35 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
CIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI254 CIRCUIT INSPECTION DI18Q37 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
DTC B0132/61 Short in LH and RH P/T Squib Circuit (to Ground)
DI44 DI58N0 DTC B03/6 Sht in LH and RH P/T Squib Circuit (to Ground) CIRCUIT DESCRIPTI The LH and RH P/T squib circuits consist of the airbag sens assembly and LH and RH seat belt pretensioners. It causes
ON-VEHICLE INSPECTION
32 SUSPENSION CONTROL AIR SUSPENSION SYSTEM ON-VEHICLE INSPECTION 1. CHECK FLUID LEAKAGE Check the connections of tube and parts for fluid leakage. : Supply parts only C099149E01 SUSPENSION CONTROL AIR
DTC 51 Switch Condition Signal Circuit
EG614 EINE TROUBLESHOOTI DT 51 Switch ondition Signal ircuit IRUIT DESRIPTION Park/Neutral Position Switch Signal The EM uses the signals from the Park/neutral position switch to determine whether the
DTC P0340 Camshaft Position Sensor A Circuit. DTC P0341 Camshaft Position Sensor A Circuit Range/Performance
DIAGNOSTIS EINE (2UZFE) DI637 DIDRK01 DT P0340 amshaft Position Sensor A ircuit DT P0341 amshaft Position Sensor A ircuit Range/Performance DT P0345 amshaft Position Sensor A ircuit (Bank 2) DT P0346 amshaft
DTC B1153/25 SEAT POSITION AIRBAG SENSOR MALFUNCTION
051094 DIGNOSTICS SUPPLMNTL RSTRINT SYSTM DTC 1153/25 ST POSITION IRG SNSOR MLUNCTION 05UJ01 CIRCUIT DSCRIPTION The seat position airbag sensor circuit consists of the airbag sensor assy center and the
DIAGNOSTIC TROUBLE CODE CHART
18 Cruise Control System DIAGNOSTIC TROUBLE CODE CHART If a trouble code is indicated while checking DTCs, inspect the listed for that code in the table below, and proceed to the applicable page. DTC No.
BRAKE CONTROL VEHICLE STABILITY CONTROL SYSTEM. DTC No. DTC Detecting Conditions Trouble Areas
70 RKE CONTROL VEHICLE STILITY CONTROL SYSTEM DTC C0210/33 Rear Speed Sensor RH Circuit DTC C0215/34 Rear Speed Sensor LH Circuit DTC C1238/38 DTC C1239/39 DTC C1273/73 DTC C1274/74 DTC C1277/77 DTC C1278/78
DTC B0103/12 SHORT IN D SQUIB CIRCUIT (TO B+)
051246 DIGNOSTICS DTC B0103/12 SHORT IN D SQUIB CIRCUIT (TO B+) 0525G17 CIRCUIT DSCRIPTION The D squib circuit consists of the airbag sensor assy center, the spiral cable subassy and the horn button assy.
RS 44 SUPPLEMENTAL RESTRAINT SYSTEM HINT:
RS44 DIAGNOSIS INSPECTION SRS warning light check (a) Turn the ignition switch to ACC or ON and check that the SRS warning light lights up. (b) Check that the SRS warning light goes out after approx. 6
ELECTRONIC CIRCUIT INSPECTION PROCEDURE
0 34 INTRODUTION HOW TO TROUBLESHOOT EU ONTROLLED ELETRONI IRUIT INSPETION PROEDURE. BSI INSPETION (a) RESISTNE MESURING ONDITION OF ELETRONI PRTS () Unless stated, all resistance is measured at an ambient
BRAKE CONTROL SYSTEM SECTION BRC CONTENTS BRAKES BRC-1 VDC/TCS/ABS BASIC INSPECTION... 5 COMPONENT DIAGNOSIS...57 FUNCTION DIAGNOSIS...
RKES SETION R RKE ONTROL SYSTEM ONTENTS E V/TS/S SI INSPETION... 5 IGNOSIS N REPIR WORKFLOW... 5 Work Flow...5 INSPETION N JUSTMENT... 7 PERFORM INITILIZTION OF LINER SOLE- NOI VLVE N LIRTION...7 PERFORM
Diag. Code 22 Airbag Warning Light System Malfunction CIRCUIT DESCRIPTION ABT 71
SRS AIRBAG ABT71 Diag. Code 22 Airbag Warning Light System Malfunction CIRCUIT DESCRIPTION The airbag warning light is located on the combination meter. When the airbag system is normal, the airbag warning
DI-377 SUPPLEMENTAL RESTRAINT SYSTEM DI58G-01 PRE-CHECK
W01632 PRECHECK DI377 DI58G01 1. SRS WARNING LIGHT CHECK (a) Turn the ignition switch to the ACC or ON position and check that the SRS warning light lights up. (b) Check that the SRS warning light goes
DTC B1790 AIRBAG SENSOR ASSY CENTER COMMUNICATION CIRCUIT MALFUNCTION
051493 DTC 1790 IRG SNSOR SSY CNTR COMMUNICTION CIRCUIT MLUNCTION 05IX302 CIRCUIT DSCRIPTION The airbag sensor assy center communication circuit consists of the occupant classification CU and the airbag
DTC C1735/35 Exhaust Solenoid Valve Circuit
8 DTC C7/ DTC C74/4 Rear Height Control Gate Solenoid Valve Circuit Malfunction Rear Height Control Leveling Solenoid Valve Circuit Malfunction DTC C75/5 Exhaust Solenoid Valve Circuit DTC C744/44 Tank
Trouble in Passenger Airbag ON / OFF Indicator
8 SUPPLEMENTAL RESTRAINT SYSTEM OCCUPANT CLASSIFICATION SYSTEM Trouble in Passenger Airbag ON / OFF Indicator DESCRIPTION The occupant classification system detects the front passenger seat condition and
DTC C0210/33 Rear Speed Sensor RH Circuit. DTC C0215/34 Rear Speed Sensor LH Circuit
RKE CONTROL VEHICLE STILITY CONTROL SYSTEM 65 DTC C0210/33 Rear Speed Sensor RH Circuit DTC C0215/34 Rear Speed Sensor LH Circuit DTC C1238/38 DTC C1239/39 Foreign Object is ttached on Tip of Rear Speed
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM SYSTEM DIAGRAM. Front Airbag Sensor LH Steering Pad (Driver Side Squib)
16 SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM SYSTEM DIAGRAM Front Airbag Sensor LH Steering Pad (Driver Side Squib) Front Airbag Sensor RH Front Passenger Airbag Assembly (Front Passenger Side Squib)
Pressure Control Solenoid "D" Performance (Shift Solenoid Valve SLT)
116 750E UTOMIC TRNSMISSION UTOMIC TRNSMISSION SYSTEM DTC DESCRIPTION P2714 Pressure Control Solenoid "D" Performance (Shift Solenoid Valve SLT) Line Pressure Control Pressure Current Flow to Solenoid
DTC C1341/62 MALFUNCTION IN HYDRAULIC SYSTEM (FR) DTC C1342/63 MALFUNCTION IN HYDRAULIC SYSTEM (FL) DTC C1343/64 MALFUNCTION IN HYDRAULIC SYSTEM (RR)
008 DIAGNOSTIS ELETRONIALL ONTOROLLED RAKE SSTEM DT 4/62 MALFUNTION IN HDRAULI SSTEM (FR) 0IZS0 DT 42/6 MALFUNTION IN HDRAULI SSTEM (FL) DT 4/64 MALFUNTION IN HDRAULI SSTEM (RR) DT 44/6 MALFUNTION IN HDRAULI
Diag. Code 13 Short in Squib Circuit (Between D+ Wire Harness and D Wire Harness)
SRS AIRBAG AB49 Diag. Code 13 Short in Squib Circuit (Between D+ Wire Harness and D Wire Harness) CIRCUIT DESCRIPTION The squib circuit consists of the center airbag sensor assembly, spiral cable and the
Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable
TIRE AND WHEEL TIRE PRESSURE WARNING SYSTEM. DTC C2121/21 No Signal from Transmitter ID1. DTC C2122/22 No Signal from Transmitter ID2
40 TIRE ND WHEEL TIRE PRESSURE WRNING SYSTEM DTC C2121/21 No Signal from Transmitter ID1 DTC C2122/22 No Signal from Transmitter ID2 DTC C2123/23 No Signal from Transmitter ID3 DTC C2124/24 No Signal from
No Answer-Back (Hazard Warning Light and Wireless Door Lock Buzzer)
56 No nswer-ack (Hazard Warning Light and Wireless Door Lock uzzer) DESCRIPTION If there is no answer-back of the hazard warning lights and wireless door lock buzzer while the wireless control function
SUNROOF. SUNROOF Component Parts and Harness Connector Location RF-10
omponent Parts and Harness onnector Location PFP:91210 NIS0023Q PII6291E 1. Fuse block (J/) 2. Fuse and fusible link box 3. M M1, M2, M3 (View with the glove box assembly removed) 4. Sunroof motor assembly
Taillight Relay Circuit
GHTI GHTI SYSTEM 63 Taillight Relay Circuit DESCRIPTION The headlight dimmer switch sends a signal to the main body ECU. WIRI DIAGRAM Main Body ECU TAIL To Battery TAIL TRLY Outer Rear View Mirror Illumination
OPERATION. 2. SPIRAL CABLE A spiral cable is used as an electrical joint from the vehicle body side to the steering wheel.
RS2 RS0SQ01 OPERATION 1. STEERING WHEEL PAD (with AIRBAG) The inflater and bag of the SRS are stored in the steering wheel pad and cannot be disassembled. The inflater contains a squib, igniter charge,
DTC C0210/33 RIGHT REAR SPEED SENSOR CIRCUIT DTC C0215/34 LEFT REAR SPEED SENSOR CIRCUIT
05998 IAGNOSTICS ELECTRONICALLY CONTOROLLE RAKE SYSTEM TC C010/33 RIGHT REAR SPEE SENSOR CIRCUIT 05IZC01 TC C015/34 LEFT REAR SPEE SENSOR CIRCUIT CIRCUIT ESCRIPTION Refer to TC C000/31, C005/3 on page
ON-VEHICLE INSPECTION
51 Connector Front Side: A5 ON-VEHICLE INSPECTION 1. INSPECT TOWING CONVERTER RELAY (a) Measure the voltage and check the result in accordance with the value(s) in the table below. Standard E064833E01
THEFT DETERRENT SYSTEM
THEFT DETERRENT THEFT DETERRENT SYSTEM 1 System Name Power Window Control System THEFT DETERRENT SYSTEM PRECAUTION NOTICE: For initialization: When disconnecting the cable from the negative (-) battery
CRUISE CONTROL SYSTEM
CRUISE CONTROL CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM PRECAUTION 1 1. HANDLING PRECAUTION FOR CRUISE CONTROL SYSTEM (a) Turn the cruise control main switch OFF when not using the cruise control system.
DTC P1349 VVT SYSTEM MALFUNCTION (BANK 1)
DIGNOSTICS SFI SYSTEM (2ZZGE) DTC P1349 VVT SYSTEM MLFUNCTION (NK 1) 05275 057I803 CIRCUIT DESCRIPTION VVT system controls the intake valve timing to proper timing in response to driving condition. ECM
DTC P0120 Throttle/Pedal Position Sensor/Switch A Circuit Malfunction
DI184 EINE (JZGTE) DI4SR01 DTC P010 Throttle/Pedal Position Sensor/Switch A Circuit Malfunction CIRCUIT DESCRIPTI Throttle Position Sensor VCC VTA1 IDL1 E + FI6480 The throttle position sensor is mounted
SRS AIRBAG SECTION SR CONTENTS RESTRAINTS SR-1 PRECAUTION... 2 PREPARATION... 4 ON-VEHICLE REPAIR... 5
RSTRTS ST S R TTS RUT... 2 RUTS... 2 recaution for Supplemental Restraint System (S) "R " and "ST T R-T- SR"...2 Service...2 ccupant lassification System...2 recautions ecessary for Steering Wheel Rotation
Model Year: 2008 Model: ES350 Doc ID: RM000002INN009X
1 of 12 Last Modified: 7-13-2007 Service Category: udio/visual/telematics 1.6 C Section: Park ssist/monitoring Model Year: 2008 Model: ES350 Doc ID: RM000002INN009X Title: PRK SSIST / MONITORING: INTUITIVE
CRUISE CONTROL SYSTEM
CRUISE CONTROL SYSTEM CONTROL SYSTEM PARTS LOCATION CRUISE CONTROL CRUISE CONTROL SYSTEM 1 ENGINE ROOM R/B AND J/B MAIN BODY ECU (INSTRUMENT PANEL J/B) B142328E05 2 CRUISE CONTROL CRUISE CONTROL SYSTEM
Fault Codes P1271 Fuel Regulator Circuit Malfunction DESCRIPTION:
Fault Codes P1271 Fuel Regulator Circuit Malfunction DESCRIPTION: The ECM controls the internal fuel pressure of the common rail by opening and closing the pressure discharge valve. When sudden deceleration
CRUISE CONTROL SYSTEM
Negative (-) Battery Terminal CRUISE CONTROL CRUISE CONTROL SYSTEM Cable System name METER / GAUGE SYSTEM D033496E01 CRUISE CONTROL SYSTEM PRECAUTION 1 1. DISCONNECT AND RECONNECT CABLE OF NEGATIVE BATTERY
OPERATION. 2. SPIRAL CABLE (in COMBINATION SWITCH) A spiral cable is used as an electrical joint from the vehicle body side to the steering wheel.
RS2 SUPPLEMENTAL RESTRAINT SYSTEM RS0FR03 OPERATION 1. STEERING WHEEL PAD (with AIRBAG) The inflater and bag of the SRS are stored in the steering wheel pad and cannot be disassembled. The inflater contains
DTC P0657 Actuator Supply Voltage Circuit / Open
301 DTC P0657 Actuator Supply Voltage Circuit / Open DCRIPTION The ECM monitors the output voltage to the throttle actuator. This self-check ensures that the ECM is functioning properly. The output voltage
SRS (SUPPLEMENTAL RESTRAINT SYSTEM)
SRS (SUPPEMENT RESTRINT SYSTEM) NOTICE: When inspecting or repairing the SRS (supplemental restraint system), perform the operation in accordance with the following precautionary instructions and the procedure
DTC P2120 Throttle/Pedal Position Sensor/Switch D Circuit
EINE DI207 DIAFO02 DTC P2120 Throttle/Pedal Position Sensor/Switch D Circuit *: Only for sequential manual transmission vehicle. CIRCUIT DESCRIPTI The accelerator pedal position sensor is mounted on the
DTC P0120/41 Throttle Position Sensor Circuit Malfunction
DI42 DIAGNOSTICS EINE (2JZGE) DI2S505 DTC P0120/41 Throttle Position Sensor Circuit Malfunction CIRCUIT DESCRIPTI Throttle position sensor is mounted on the throttle body and it have the 2 sensors to detect
OPERATION. 2. SPIRAL CABLE (in COMBINATION SWITCH) A spiral cable is used as an electrical joint from the vehicle body side to the steering wheel.
RS2 RS0UB01 OPERATION 1. STEERING WHEEL PAD (with AIRBAG) The inflater and bag of the SRS are stored in the steering wheel pad and cannot be disassembled. The inflater contains a squib, igniter charge,
DTC P1120/19 Accelerator Pedal Position Sensor Circuit Malfunction
DIAGNOSTICS EINE (2JZGE) DI103 DI2SE04 DTC P1120/19 Accelerator Pedal Position Sensor Circuit Malfunction CIRCUIT DESCRIPTION Accelerator pedal position sensor is mounted on the throttle body and it have
SUPPLEMENTAL RESTRAINT SYSTEM
PRECAUTION CAUTION: HIGHLANDER is equipped with SRS, which consists of a driver airbag, front passenger airbag, side airbag and curtain shield airbag. Failure to carry out service operations in the correct
DTC P0617 STARTER RELAY CIRCUIT HIGH
0534 DTC P067 STARTER RELAY CIRCUIT HIGH 05DJY0 MONITOR DESCRIPTION While the engine is being cranked, the battery positive voltage is applied to terminal STA of the ECM. If the ECM detects the starter
ELECTRONIC POWER STEERING SYSTEM
POWER STEERING ELECTRONIC POWER STEERING SYSTEM 1 ELECTRONIC POWER STEERING SYSTEM PRECAUTION 1. HANDLING PRECAUTION (a) When handling the electronic parts: Avoid any impact to electronic parts such as
DTC P2440 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN BANK1 DTC P2441 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK CLOSE BANK1
DIAGNOSTICS SFI SYSTEM (2ZZ GE) (May, 2003) DTC P2440 SECONDARY AIR INJECTION SYSTEM SWITCHI VALVE STUCK OPEN BANK1 05 575 05DWI 01 DTC P2441 SECONDARY AIR INJECTION SYSTEM SWITCHI VALVE STUCK CLOSE BANK1
Diag. Code 71 EGR System Malfunction CIRCUIT DESCRIPTION. TR-92 ENGINE TROUBLESHOOTING - Circuit Inspection
TR-92 EINE TROUBLESHOOTI - Circuit Inspection Diag. Code 71 EGR System Malfunction CIRCUIT DESCRIPTION The EGR system is designed to recirculate the exhaust gas properly controlled according to the driving
SECURITY CONTROL SYSTEM
Y XTRR, RS, R & V URTY T URTY TR SYST TTS WT TT KY SYST S T... 5 SS RR WRKW... 5 Work low...5 T USTT... 8 T SRV W R TR UT...8 T SRV W R TR UT : Special Repair Requirement...8 R-UT UT...8 R-UT UT : escription...8
Fault Code 16: Eaton Proprietary Link (EPL)
ault ode 16: aton Proprietary Link (PL) ault Isolation Procedure ault ode 16: aton Proprietary Link (PL) 1587:MI 130 SI 248 MI 2 Overview ault ode 16 indicates the Shift ontroller and the Transmission
DTC C2121/21 No Signal from Transmitter ID1 in Main Mode. DTC C2122/22 No Signal from Transmitter ID2 in Main Mode
38 TIRE ND WHEEL TIRE PRESSURE WRNING SYSTEM DTC C2121/21 No Signal from Transmitter ID1 in Main Mode DTC C2122/22 No Signal from Transmitter ID2 in Main Mode DTC C2123/23 No Signal from Transmitter ID3
DTC P0120/41 Throttle Position Sensor Circuit Malfunction
DI42 EINE DI63S01 DTC P0120/41 Throttle Position Sensor Circuit Malfunction CIRCUIT DESCRIPTI Throttle position sensor is mounted on the throttle body and it have the 2 sensors to detect the throttle opening
Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.
NOTICE: hen inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model
SRS AIRBAG CONTROL SYSTEM
RSTRTS ST SRS R TR SYST TTS S ST... 3 SS RR WR W... 3 Work low...3 TRTTT T... 5 nspection rocedure...5 Trouble iagnosis with SUT...5 SYST SRT... 6 SRS R SYST... 6 SRS onfiguration...6 SRS omponent arts
SUPPLEMENTAL RESTRAINT SYSTEM(SRS)
52B-1 GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM(SRS) CONTENTS GENERAL INFORMATION........ 52B-3 SERVICE PRECAUTIONS......... 52B-15 SRS AIR BAG DIAGNOSIS........ 52B-17 INTRODUCTION.....................
LAN SYSTEM SECTION LAN CONTENTS ELECTRICAL & POWER CONTROL LAN-1 CAN FUNDAMENTAL PRECAUTION...21 PRECAUTION... 5 FUNCTION DIAGNOSIS...
TR & WR TR ST SYSTM TTS UMT RUT...21 RUT... 5 RUTS... 5 recautions for Trouble iagnosis...5 recautions for arness Repair...5 UT SS... 6 MMUT SYSTM... 6 System escription...6 System iagram...6 ommunication
CHARGING SYSTEM SECTION CHG CONTENTS ELECTRICAL & POWER CONTROL CHG-1 BASIC INSPECTION... 2 WIRING DIAGRAM...11 SYSTEM DESCRIPTION...
TR & WR TR ST R SYSTM TTS S ST... 2 SS RR WRW... 2 Work low...2 SYSTM SRT... 3 R SYSTM... 3 System iagram...3 System escription...3 omponent escription...3 WR RT VT VR- TR SYSTM... 4 System iagram...4
DTC P0657 Actuator Supply Voltage Circuit / Open
1GR-FE EINE CONTROL SYSTEM SFI SYSTEM 277 DTC P0657 Actuator Supply Voltage Circuit / Open MONITOR DCRIPTION The ECM monitors the output voltage to the throttle actuator. This self-check ensures that the