92 Series MAConnect with Sub D

Size: px
Start display at page:

Download "92 Series MAConnect with Sub D"

Transcription

1

2 9 Series MAConnect with Sub D MAXIMUM OF 0 SOLENOIDS CAN BE POWERED BY A SINGLE MULTI-PIN CONNECTOR. UP TO 40 SOLENOIDS CAN BE POWERED BY MEANS OF A SECOND MULTI-PIN CONNECTOR STATION. LEFT OR RIGHT END CONNECTOR ADAPTERS AVAILABLE. MAXIMUM ALLOWABLE COIL AMPERAGE IS 50 MILLIAMPS. STANDARD AC AND DC VOLTAGE OPTIONS AVAILABLE UP TO 40 VOLTS. CURRENT CONNECTION TYPES AVAILABLE ARE: 9, 5, AND 5 PIN SUB-D CONNECTORS. 0, 6, 0, AND 6 PIN RIBBON TYPE CONNECTORS. 4 PIN AMP CPC CONNECTOR. WASH-DOWN SUB-D CONNECTORS AVAILABLE (9, 5 AND 5 PIN) - DESIGNED TO MEET NEMA4 AND IP65 RATINGS. GROUNDING OF THE STATIONS AND ADAPTER IS STANDARD FOR 30 VOLT COILS AND ABOVE, OPTIONAL FOR 30 VOLTS AND LOWER. DIELECTRIC STRENGTH TO GROUND IN EXCESS OF 000 VOLTS.

3 9 Series MAConnect with SM3 Maximum of 6 solenoids possible (4VDC with a maximum of 6.0 watts per solenoid ). Maximum of 4 inputs available with PNP or NPN capability. 6 inputs available with a tethered input module. All outputs are protected by self resetting fuses. This protects the electronics in the event of a short and enables the node to remain active. Left or right end SM3 adapters available. Flexability to support remotely located stacks. Designed to meet NEMA 4 and IP65 ratings - washdown (except Allen Bradley Remote I/O). Multiple protocols available (DeviceNet, Allen Bradley Remote I/O, Profibus) 3

4 9 Series MAConnect with SM6 Maximum of 6 solenoids possible ( 4VDC with a maximum of 6.0 watts per solenoid ). Left or right end SM6 adapters available. Flexability to support remotely located stacks. Designed to meet NEMA 4 and IP65 ratings - washdown. Available with common through ports (i.e. inlet, exhaust and ext. pilot ports ). DeviceNet compatible. 4

5 9 Series MAConnect with Tethered Inputs 6 inputs. Field convertable for either positive or negative logic. Inputs are divided into four groups of four. Each group is field convertible for either PNP or NPN. Washdown model available - designed to meet NEMA 4 and IP65 ratings. 5

6 9 Series MAConnect Remote Manifolds Easy hookup. Remote stacks are compatible with Sub D and ribbon style connectors, SM3 and SM6 serial modules. Primary and remote stacks can operate 0 solenoids in any configuration with Sub D connectors. Primary and remote stacks can operate 6 solenoids in any configuration with SM3 or SM6 serial modules. 6

7 Specifications 9 Series Valve Fluids: Compressed Air or Inert Gases Lubrication: Not required. If used, select a medium aniline point lubricant (between 80ºF and 0ºF) Safe Operating Temperature Range: 0ºF to 0ºF (-8ºC to 50º C) Pressure Range: 0 to 0 PSI (Internal Pilot) Vacuum to 0 PSI (External Pilot) 35 to 0 PSI (3 Position, Internal/External Pilot) Electrical: AC 0/60 Inrush current 7.6 Volt-amps (.063 amps) Holding Current 4.8 Volt-amps (.04 amps) Maximum Coil Amperage - 50mA Maximum Voltage - 40VAC Dielectric Strength in Excess of 000 Volts. Recommended Mating Sub D Cable Specifications 3 Amp Current Rating per Conductor 300 Volt RMS, 05ºC Insulation Amp CPC Connector Specifications Receptacle: (Mounted in MAConnect adapter block) Series Amp CPC Connector Shell size 3 4 Male pins (.57mm diameter) Five key configuration Recommended Plug Amp part number key configuration Recommended receptacle contacts are size 6 type III+ (Accepts pin dia..57mm) Additional information can be obtained from Amp Catalog 80 7

8 Specifications SM6 Manifold Outputs: Number: Voltage Current: 6 Channels / Solenoids on manifold 4 VDC at.5 per channel (6.0 Watts max.) Inputs: Not available at this time Protocols: DeviceNet Current Consumption: Outputs - 4 A Max. Electronics - 00mA Voltage Ranges: Operating with single supply: 4VDC Operating separate supply for valves : 4VDC Safe Operating Temperature Range: 0-50º C (3-0ºF) 0-90% RH (Non-condensing) Operating Atmosphere: No corrosive gases Enclosure: Designed to meet NEMA 4 and IP65 8

9 Specifications SM3 Manifold Outputs: Number: Voltage Current: 6 Channels / Solenoids on manifold 4 VDC at.5 per channel (6.0 Watts max.) Inputs: Number: 4 Type: 4 VDC NPN or PNP Logic Protocols: DeviceNet Allen Bradley Remote I/O* Current Consumption: Outputs - 4 A Max. Electronics and Inputs - 75mA Voltage Ranges: Operating with single supply: 4VDC Operating separate supply for valves : 4VDC Safe Operating Temperature Range: 0-50º C (3-0ºF) 0-90% RH (Non-condensing) Enclosure: Designed to meet NEMA 4 and IP65 *This product incorporates technology which is licensed by Allen-Bradley Company, Inc. Allen- Bradley has not technically approved, nor does it warrant or support this product. All warranty and support for this product and its application is provided solely by MAC Valves, Inc. 9

10 How to Order 9 Series MAConnect 9 B - X X X - X X X - XX - D XX P - X XX 0 Pilot Valve Options (see below) MAConnect Plug-In Manifold 0 Valve Only Internal Pilot Models Sgl. Sol. Plug-In to Left Dbl. Sol. Plug-In to Left 3 Sgl. Sol. Plug-In to Right 4 Dbl. Sol. Plug-In to Right External Pilot Models 5 Sgl. Sol. Plug-In to Left 6 Dbl. Sol. Plug-In to Left 7 Sgl. Sol. Plug-In to Right 8 Dbl. Sol. Plug-In to Right Manifold Base Configurations 0 Valve Only J Side Cyl. Ports (Middle) K Bottom Cyl. Ports (Mid.) L Side Cyl Ports Left End M Bottom Cyl. Ports Left End N Side Cyl. Ports Right End P Bottom Cyl. Ports Right End Note: Left and Right Determined by facing the A Solenoid Port Size and Thread Type In. and Cyl. 0 Valve Only B /4 NPTF C 3/8 NPTF E /4 BSPPL F 3/8 BSPPL H /4 BSPTR J 3/8 BSPTR Body Electrical Options 0 Base Only A No Light in Top B w/ Light F w/ Supp., Blocking Diode, and Light H w/ M.O.V. and Light Body Type and Exhaust Options 0 Base Only A Plug-In Std. Exhaust C Plug-In w/exh. to Main Exhaust * * Must use DU Pilot Body Valve Function 0 Base Only A Sgl. Oper. Sgl. Press. B Dbl. Oper. Sgl. Press. C Sgl. Oper. Dual Press. D Dbl. Oper. Dual Press. E 3 Pos. Closed Center F 3 Pos. Open Center G 3 Pos. Sgl. Press. Press. Center Pilot Valve Options Spools w/ Memory Spring L Sgl. Oper. Sgl. Press. N Sgl. Oper. Dual Press. XX - D XX P - X XX Electrical Connection DM Plug-In DN Plug-In w/ Diode DP Plug-In w/ M.O.V. DG Plug-In w/ Ground DH Plug-In w/ Diode and Ground DJ Plug-In w/ M.O.V. and Ground Manual Operator 0 No operator Recessed Non-Locking Oper. Recessed Locking Oper. 3 Extended Non-Locking Oper. 4 Extended Locking Oper. Voltage JA 0/60,0/50 (.9w) JB 40/60,0/50 (.9w) JD 00/50/60,0/60 (3.9w) JE 0/60 (3.4w) JF 40/50 (.8w) JG 00/60, 00/50 (3.9w) DA 4 VDC (5.4w) FA VDC (.8w) FB 4 VDC (.8w) FE VDC (.4w) FF 4 VDC (.4w) Pilot Style DM Muffled Exhaust DP Piped Exhaust DU Universal Pilot Pilot Exhaust out Main Exhaust Note:For Solenoids 30 volts or above, a ground wire is required Note: For Negative Commons (PNP) Use Mod 705 After Model Number

11 How to Order Adapters / Input Module MAConnect Adapter Assembly (Positive Commons - NPN) M XX - X X 09 9 Pin Sub D 0 0 Pin 5 5 Pin Sub D 6 6 Pin 0 0 Pin 4 4 Pin Amp CPC 5 5 Pin Sub D 6 6 Pin Internal Pilot Left End External Pilot Left End 3 Internal Pilot Right End 4 External Pilot Right End MAConnect Adapter Assembly (Required For Connecting To A Remote Stack) M-90 - XX - X X Leave Blank for NPTF Threads P BSPPL Threads T BSPTR Threads Note: For Negative Commons (PNP) Use MOD 705 after model number Note: For washdown Sub-D connector use MOD 53M after model number Pin Sub D 0 0 Pin 5 5 Pin Sub D 6 6 Pin 0 0 Pin 4 4 Pin Amp CPC 5 5 Pin Sub D 6 6 Pin Internal Pilot Left End External Pilot Left End 3 Internal Pilot Right End 4 External Pilot Right End Leave Blank for NPTF Threads P BSPPL Threads T BSPTR Threads Note: For washdown Sub-D connector use MOD 53M after model number. Remote Tethered Input Module (For use with SM3 only) N-SM005 - X X X X - XX Inputs -4 B NPN C PNP Inputs No Inputs B NPN C PNP Inputs 9-0 No Inputs B NPN C PNP Inputs No Inputs B NPN C PNP 0 Positive Logic 0 Negative Logic

12 How to Order SM6 for MAConnect Serial Manifold MAConnect SM6 - XX A - X X X - XX M - X X XX Output Indicator Lights 0 St d (No Lights) Power Connector DeviceNet A 3 Pin Micro Bus Connector DeviceNet A 5 Pin Micro Inputs 00 No Inputs Location of MAConnect Adapter 0 No Adapter Left End Right End Adapter has common inlet and exhaust ports How to Order SM3 for MAConnect Serial Manifold MAConnect SM3 - XX A - X X X - X X M - X X XX Output Indicator Lights Monitoring Valve Signal A St d (6) Monitoring Bus Logic Signal B St d (6) Power Connector DeviceNet A 3 Pin Mini B 4 Pin Mini C 3 Pin Micro AB Remote IO G 5 Pole Term. Bus Connector DeviceNet A 5 Pin Mini B 5 Pin Micro AB Remote IO F 3 Pole Term. * Inputs A No Inputs B Input C Inputs D 3 Inputs E 4 Inputs F Tethered Input Connector *Input Module Ordered Separately (See how to order) Input Types A No Inputs B NPN C PNP Location of MAConnect Adapter 0 No Adapter Left End Right End Left or right is determined by facing the A Solenoid Pilot and Thread Type0 0 No adapter A Int. NPTF B Ext. NPTF C Int. BSPPL D Ext. BSPPL E Int. BSPTR F Ext. BSTPR Protocol DN DeviceNet Pilot and Thread Type0 0 No adapter A Int. NPTF B Ext. NPTF C Int. BSPPL D Ext. BSPPL E Int. BSPTR F Ext. BSTPR Valve Series Adapter 00 No Adapter 9 9 Series Valve Series Adapter 00 No Adapter 9 9 Series Protocol DN DeviceNet AB Allen Bradley Remote IO

13 Input Module Examples for Ordering MAConnect Assemblies Valve Descriptions are Configured Left to Right Qty Description 9B-BAB-BL4-DM-DDAP-DM 9B-BAB-BJ4-DM-DDAP-DM 9B-AAB-BJ3-DM-DDAP-DM M Qty Description 9B-BAB-BL4-DM-DDAP-DM 9B-BAB-BJ4-DM-DDAP-DM 9B-AAB-BJ3-DM-DDAP-DM SM6-DNA-0AA-00M-A9 Qty Description 9B-BAB-BL4-DM-DDAP-DM 9B-BAB-BJ4-DM-DDAP-DM 9B-AAB-BJ3-DM-DDAP-DM SM3-DNA-BAB-AAM-A9 Qty Description 9B-BAB-BL4-DM-DDAP-DM 9B-BAB-BJ4-DM-DDAP-DM 9B-AAB-BJ3-DM-DDAP-DM SM3-DNA-BAB-FAM-A9 Input Module N-SM005-BBCC-0 Inputs -8 (NPN) Inputs 9-6 (PNP) Positive Logic Remote Stack Primary Stack Primary Stack Qty Description M B-BAB-BJ4-DM-DDAP-DM 9B-AAB-BJ3-DM-DDAP-DM SM3-DNA-BAB-AAM-A9 Remote Stack Qty Description 9B-BAB-BL4-DM-DDAP-DM 9B-BAB-BJ4-DM-DDAP-DM 9B-AAB-BJ3-DM-DDAP-DM M

14 9 Series MAConnect With Multi-Pin Connector On Right End Cylinder Ports This End 6. Dia. 3 Places Note: All Dimensions Shown Are In Millimeters 4

15 SM3 Tethered Input Module SM8 TETHERED INPUT MODULE *ALL DIMENSIONS SHOWN ARE IN MILLIMETERS 3. DIA. TYP.() SPECIFICATIONS NUMBER OF INPUTS: 4,8,,6 CONFIGURATION: EACH BANK OF FOUR INPUTS CONFIGURABLE FOR NPN OR PNP INPUT TYPES COMPLETE UNIT CONFIGURABLE FOR POSITIVE OR NEGATIVE LOGIC ELECTRICAL: 4 VDC TYPE INPUTS ACCEPTED PROTECTION: DESIGNED TO MEET NEMA 4 AND IP 65 WEIGHT: APPROXIMATELY 500 GRAMS ENVIRONMENT: CONNECTOR: 0-50 C 0-90% RH (NON-CONDENSING) 5 PIN SUB-D TETHER BETWEEN SM3 ADAPTER BLOCK AND INPUT MODULE 4 PIN SINGLE KEY MICRO STYLE FOR INPUTS, ONE CHANNEL PER CONNECTOR 5

16 9 Series MAConnect TM With SM6 SM6 On On Right Right End End Cylinder Ports This End POWER STATUS ADDRESS NOTE: ALL DIMENSIONS SHOWN ARE IN MILLIMETERS 6

17 P E 9 Series MAConnect TM With SM3 SM8 On Right End Cylinder Ports This End 3 O W R ADDRESS STATUS POWER INPUT INPUT INPUT 47.0 INPUT B U S NOTE: ALL DIMENSIONS SHOWN ARE IN MILLIMETERS 7

18 P O E R 9 Series MAConnect Tethered To A 9 Series MAConnect Stack TETHERED STACK 5 PIN D-SUB ADAPTER SM8 3 MOUNTED ON ON MACONNECT ADAPTER Cylinder Ports This End Cylinder Ports This End 3 W INPUT INPUT INPUT INPUT B U S

19 PIN # Solenoid # PIN # Solenoid # PIN # Solenoid # ~ 0 5 PIN SUB-D ~ ~ ~ ~ 5 PIN SUB-D 9 PIN SUB-D ~ PIN # Solenoid # ~ ~ PIN AMP CPC PIN ORIENTATION TRIANGLE PIN ORIENTATION TRIANGLE PIN ORIENTATION TRIANGLE PIN # PIN # PIN #5 PIN #9 PIN # PIN #5 PIN # PIN #6 PIN # PIN #0 PIN # PIN #6 PIN # Solenoid # ~ ~ PIN # Solenoid # PIN # Solenoid # PIN # Solenoid # ~ ~ ~ ~ ~ ~ PIN #9 PIN # PIN # PIN # PIN ORIENTATION TRIANGLE 9

20 MAC Valves, Inc. Wixom, Michigan, U.S.A. MAC Valves Europe Liege, Belgium MAC Valves Pacific Auckland, New Zealand MAC Valves, Inc. Dundee, Michigan, U.S.A. Installation and Service Precautions: A. Do not install or service MAC valves without first making sure both air and electrical power to the machine are off and that all air has been completely bled from the system. B. MAC valves should only be installed and/or serviced by qualified knowledgable personnel who understand how the specific valve is to be pneumatically piped and electrically connected (where applicable). Flow paths through the valve are shown in the catalog and on the valve by use of ANSI or ISO type standard and graphic symbols. Do not install unless these symbols and the valve functions and operations are thoroughly understood. C. Before service, maintenance, repair or cleaning, consult local distributor or factory for Parts and Operation Sheet and information on proper cleaning and lubrication agents. Do not subject MAC valves parts to any foreign substance including lubricants and cleaning agents not specifically recommended by MAC Valves, Inc. D. MAC valves are never to be stepped on while working on a machine. Damage to the valve, or lines to the valve (either air or electrical lines) or accidental activating of a manual operator on the valve could result in a dangerous condition. Warning: Under no circumstances are MAC valves to be used in any application where failure of the valve to operate as intended could jeopardize the safety of the operator or any other person. -Do not operate outside of the pressure range listed on valve label or outside of designated temperature range. -Air supply must be clean. Contamination of valve can affect proper operation. -Before attempting to repair, adjust or clean valve, consult catalog, parts and operation sheet, or factory for proper maintenance procedures, lubrication, and cleaning agents. Never attempt to repair or perform other maintenance with air pressure to valve. -If airline lubrication is used, consult catalog, parts and operation sheet, or factory for recommended lubricants.

82 Series MAConnect with Sub-D

82 Series MAConnect with Sub-D 82 Series MAConnect with Sub-D Maximum of 20 solenoids can be powered by a single multi-pin connector. Up to 40 solenoids can be powered by means of a second multi-pin connector station. Left or right

More information

External Pilot Models 5 Sgl. Sol. Plug-In to Left. Internal Pilot Models 1 Sgl. Sol. Plug-In to Left. 4 Dbl. Sol. Plug-In to Right

External Pilot Models 5 Sgl. Sol. Plug-In to Left. Internal Pilot Models 1 Sgl. Sol. Plug-In to Left. 4 Dbl. Sol. Plug-In to Right How to Order 93 Series MAConnect 93 A - X X X - X X X - XX - D XX P - X XX Pilot Valve Options (see below) Valve Function 0 Base Only A Sgl. Oper. Sgl. Press. B Dbl. Oper. Sgl. Press. C Sgl. Oper. Dual

More information

42 Series MAConnect TM. 42 Series Plug-In Manifold

42 Series MAConnect TM. 42 Series Plug-In Manifold 42 Series MAConnect TM 42 Series Plug-In Manifold Specifications 42 Series Valve Operating Data Fluids: Lubrication: Safe Operating Temperature Range: Pressure Range: Electrical: Air or Inert Gas Not Required.

More information

EtherNet/IP EtherCAT POWERLINK PROFINET Modbus/TCP

EtherNet/IP EtherCAT POWERLINK PROFINET Modbus/TCP We are pleased to announce the release and availability of the MI/O-67 Fieldbus Platform. Our initial release includes several different protocol options in addition to several modules to ensure a complete

More information

Specifications 54 Series Valve

Specifications 54 Series Valve Specifications 54 Series Valve Fluids: Compressed Air or Inert Gases Lubrication: Not required. If used, select a medium aniline point lubricant (between 180ºF and 210ºF) Safe Operating Temperature Range:

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series Inline Manual operator Solenoid 4-way pilot with balanced poppet Inlet (1) Exhaust (3) Cylinder () 33 34 36 3 37 38 5 67 69

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series Inline Sub-base non plug-in 4 6 Air return Manual operator Solenoid 4-way pilot with balanced poppet Bonded spool 2 7 8 2 67

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Series ISO Individual mounting Valve only No base non plug-in Conform to ISO 99/ Valve only No base plug-in Conform to ISO 99/ Manifold mounting Valve

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series inline inline hazardous location Manifold mounting 35 sub-base non plug-in sub-base with pressure regulators sub-base hazardous

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series inline Manifold mounting 5 stacking sub-base non plug-in sub-base with pressure regulators 100 200 1 55 56 57 58 59 Manual

More information

MAC VALVES, INC. Rev. T

MAC VALVES, INC. Rev. T REVISION LEVEL DATE RELEASED CHANGE DESCRIPTION ECN NUMBER P.E. APPROVAL P.D APPROVAL A 5-11-95 ENGINEERING RELEASE 12727 EPJ B 1-15-96 ADDED 35 SERIES 13228 EPJ ADDED MOD 2938 TO 6500 SERIES, MODS 2910

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series Inline Manual operator Solenoid 4-way pilot with balanced poppet Air return 33 34 36 3 37 38 5 67 69 44 46 4 47 48P SERIES

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series Inline Sub-base non plug-in Sub-base plug-in Manifold mounting Sub-base non plug-in Sub-base plug-in 33 34 36 32 onded spool

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves 8mm valve Series 33 Function Port size Flow (Max) Individual mounting Series 3/ NC M3 0.08 C v Inline OPERATIONAL BENEFITS 1. 8mm valve direct solenoid

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series Inline Oval shaped armature Encapsulated coil Push pin Manifold mounting Stacking Manifold base plug-in Manifold base plug-in

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves SIZE 26 mm Individual mounting Valve only No base non plug-in Conform to ISO 15407/1 Manifold mounting Valve only No base non plug-in Conform to ISO 15407/1

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Manual operator Solenoid Individual mounting Sub-base non Sub-base Manifold mounting Manifold base Sub-base/ manifold base non with latching solenoid

More information

Bullet Valve (BV) Series

Bullet Valve (BV) Series BULLET Valve Bullet Valve (BV) Series The Bullet Valve represents yet another evolution in air valve technology from MAC. VERY FEW PARTS LONG LIFE LIFTING SOLENOID ONE PIECE POPPET / ARMATURE (Patents

More information

Section 2 Proportional Quick Exhaust

Section 2 Proportional Quick Exhaust V A L V E S Section 2 Proportional Quick Exhaust OPERATION OF THE PQE 1. The pilot operated regulator and the PPC5C are both fed from a common inlet. 2. The out port of the PPC5C sends pressure to the

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series non plug-in plug-in Manifold mounting 35 non plug-in plug-in 100 Pilot air accumulator ir/spring return Integral ground wire

More information

GM - G XXX-XXX. Direct solenoid and solenoid pilot operated valves. Function Port size Flow [Max] Individual mounting. Series 77

GM - G XXX-XXX. Direct solenoid and solenoid pilot operated valves. Function Port size Flow [Max] Individual mounting. Series 77 Direct solenoid and solenoid pilot operated valves Series 77 Function Flow [Max] Individual mounting 3/2 NC, 2/2 NC 1/8-1/4 1.0 Cv Inline OPERATIONAL BENEFITS 1. The 4-way pilot develops maximum shifting

More information

2005 / 2012 / 2035 Series

2005 / 2012 / 2035 Series 005 / 0 / 035 Series Accessories Sandwich Pressure Regulators Accessory Description 0. to bar - 005 Regulator repair kit 0.3 to bar - 0.7 to 9 bar -3 0. to bar 39-909 0 Regulator repair kit 0.3 to bar

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series inline sub-base non plug-in Manifold mounting 35 stacking sub-base non plug-in sub-base with pressure regulators sub-base with

More information

MAC Pulse Valve PV03 Series

MAC Pulse Valve PV03 Series The MAC Pulse Valve series is designed to be a direct drop-in replacement for existing pulse technology. The MAC solution utilizes a long life, bonded-spool design, instead of the traditional diaphragm

More information

BULLET VALVE THINK GLOBAL ACT LOCAL. Our global distribution network is keeping your machines running around the clock around the world

BULLET VALVE THINK GLOBAL ACT LOCAL. Our global distribution network is keeping your machines running around the clock around the world THINK GLOBAL ACT LOCAL P A T E N T T E C H N O L O G Y TEL: 1-800-MAC VLVS TEL: 1 (48) 64-7700 FAX: 1 (48) 64-0549 www.macvalves.com mac@macvalves.com MAC VALVES, INC. 5555 ANN ABO OAD DUNDEE, MI 48131

More information

Direct solenoid and solenoid pilot operated valves

Direct solenoid and solenoid pilot operated valves Direct solenoid and solenoid pilot operated valves Individual mounting Series Inline Oval shaped armature Encapsulated coil Push pin onded balanced poppet Return spring Manifold mounting Stacking plug-in

More information

MAC Pulse Valve PV06 Series

MAC Pulse Valve PV06 Series The MAC Pulse Valve series is designed to be a direct drop-in replacement for existing pulse technology. The MAC solution utilizes a long life, bonded-spool design, instead of the traditional diaphragm

More information

Series 581 ISO Pneumatic Directional Control Valves

Series 581 ISO Pneumatic Directional Control Valves Series 581 ISO 5599-1 Pneumatic Directional Control Valves Series 581 Pneumatic Valves 01_1 st Headline_36 pt/14.4 mm 4-Way ISO Directional Control second line Series 581 - A complete series of standardized

More information

CONTROLS. Bray Pneumatic Actuators & Accessories. Technical Manual. A Division of BRAY INTERNATIONAL, Inc.

CONTROLS. Bray Pneumatic Actuators & Accessories. Technical Manual. A Division of BRAY INTERNATIONAL, Inc. CONTROLS A Division of BRAY INTERNATIONAL, Inc. Bray Pneumatic Actuators & Accessories Technical Manual TM-056 Pneumatic Actuator - 08//00 Bray Pneumatic Actuators & Accessories Technical Manual - Table

More information

3/8 & 1/2 NPT. with 3/8 and 1/2 NPT ports for 4 Way - 2 & 3 Position see Pg locate counterbores in body to control static squeeze on seals.

3/8 & 1/2 NPT. with 3/8 and 1/2 NPT ports for 4 Way - 2 & 3 Position see Pg locate counterbores in body to control static squeeze on seals. 8 SERIES /8 Ported Air Valves 1/ Ported Air Valves /8 & 1/ 1, 1A, 1B & 8 Series Note! Spring return & spring centered models NOT suitable for dry air service. Features & Way - Position. Way - &. operator

More information

ISO 5599/ Series Technical and Operating Data

ISO 5599/ Series Technical and Operating Data ISO 5599/ Series...................................................................3-9 Technical and Operating Data......................................................................3- How to Order...................................................................................5-6

More information

32, CONTENTS SMALL LARGE

32, CONTENTS SMALL LARGE SMALL 11,2 LARGE 3-WAY VALVES - 2 to 32 Introduction 02-03 33 Series 04 34 Series 05-06 35 Series 07-08 36 Series 09-12 37 Series 13-14 100 Series 15 200 Series 16 1100 Series 17 Introduction 18-19 52

More information

Introduction Section 1 Section 2 Section 3 Section 4 Section 5 Section 6 Section 7

Introduction Section 1 Section 2 Section 3 Section 4 Section 5 Section 6 Section 7 NEW Technology Page Introduction Section 1 Section Section Section 4 Section 5 Section 6 Section 7 Direct solenoid and solenoid pilot operated valves 9 Remote air valves 197 Bases according to ISO 5599

More information

A K 3 E D G

A K 3 E D G 005 Series. How to Order - G3 or Multipol Assembly Kit A K 3 E D 0 0 0 0 3 G A36 Electronic / Electrical Systems Type & Location 3 = T = Terminal Strip - 3 J = 5 pin SUB-D connector M = 37 pin SUB-D connector

More information

33 SERIES 34 SERIES 34B/C - X X X - G XX X - X XX A - X X X - R XX X - X XX

33 SERIES 34 SERIES 34B/C - X X X - G XX X - X XX A - X X X - R XX X - X XX Patents and Patents Pending SMALL 3 WAY SOLENOID, AIR AND MECHANICALLY OPERATED VALVES MANUAL OPERATOR COIL SOLENOID STROKE (GAP) PUSH PIN POLE PIECE POLE PIECE SPRING The 34 series is a direct operated

More information

Electrical Interface Dimensional Drawings Connector Kits

Electrical Interface Dimensional Drawings Connector Kits Table of Contents ISO 99/ Series...3-9 Technical and Operating Data....3- How to Order....-6 Valve and Regulator Dimensions... 7 Base Assembly... 8 Manifold Block Assembly... 9 Manifold Assembly Kits...

More information

Bullet Valve (BV) Series

Bullet Valve (BV) Series ullet Valve (V) Series VERY FEW PARTS LONG LIFE LIFTING SOLENOID ONE PIECE POPPET / ARMATURE ALANCED DESIGN SOLENOID ISOLATED FROM CONTAMINATED AIR UNIQUE MOUNTING D-SEAL TECHNOLOGY LONG LIFE LIFTING SOLENOID

More information

Solenoid valves "ENOVA" Series 2300

Solenoid valves ENOVA Series 2300 Solenoid valves "ENOVA" Series 300.04 Series 300 Solenoid valves "ENOVA".05 Solenoid valves "ENOVA" Series 300 Solenoid - Differential (Monostable) 5/ 3eC.5.00.36.v ELECTRICAL CONTACTS 0=STANDARD-only

More information

Remote Process Actuation Control System AirLINE - Rockwell 1734 Point I/O System

Remote Process Actuation Control System AirLINE - Rockwell 1734 Point I/O System Remote Process Actuation Control System AirLINE - Rockwell 1734 Type 8644 can be combined with... Fully compatible with Rockwell 1734 Point I/O System Combination of Fieldbus, pilot valves and I/O modules

More information

Series ITV1000/2000/3000

Series ITV1000/2000/3000 Electro-Pneumatic Regulator Series ITV// How to Order [Option] RoHS ITV S Model type type type Pressure range 5 MPa MPa.9 MPa CE compliant Nil Q CE compliant Note) Refer to pages, 5, and 6 for information

More information

Electro-Pneumatic Regulator Electronic Vacuum Regulator

Electro-Pneumatic Regulator Electronic Vacuum Regulator Electro-Pneumatic Regulator Electronic Vacuum Regulator New Stepless control of air pressure proportional to an electrical signal Added Fieldbus compliant specifications to Series ITV//! Reduced wiring

More information

Series ITV0000. Compact Electro-Pneumatic Regulator ITV N Q. IITV00 02 n. How to Order. For single unit and single unit for manifold

Series ITV0000. Compact Electro-Pneumatic Regulator ITV N Q. IITV00 02 n. How to Order. For single unit and single unit for manifold Compact Electro-Pneumatic Regulator Series ITV How to Order For single unit and single unit for manifold ITV N Q Pressure range. MPa MPa.9 MPa Power supply voltage 4 VDC ±% to VDC Cable connector N S L

More information

Electro-Pneumatic Regulators. Electronic Vacuum Regulators

Electro-Pneumatic Regulators. Electronic Vacuum Regulators Electro-Pneumatic Regulator Electronic Vacuum Regulator New Reduced wiring Applicable Fieldbus protocols Compact & light Weight: g Note ) (ITV) Power consumption: 4 W Note ) or less Electro-Pneumatic Regulators

More information

Valve Manifolds Series

Valve Manifolds Series Valve Manifolds 00 Series General Information Valve 00 series belongs to the new Numatics Valve Generation 000. It fulfills all requirements of automation. Characteristics: - Modular reality, true plug

More information

2012 Series Solenoid Pilot Actuated Valves

2012 Series Solenoid Pilot Actuated Valves Series Solenoid Pilot Actuated Valves www.numatics.com Table of Contents 202 Series Terminal Strip, Sub-D, and Round Connector Options-Exploded View 3 Technical and Operating Data 4 How to Order 5 Individual

More information

ROSS CONTROLS. Base Mounted Valves. and Serial Bus Communication

ROSS CONTROLS. Base Mounted Valves. and Serial Bus Communication ROSS CONTROLS Base Mounted Valves and Serial Bus Communication ISO 15407-1 & 2 ISO 5599/I & /II Serial Communications VLVE TYPE NSI SE Miniature 14 Series Solenoid Pilot Valves Pack VLVE SERIES DESCRIPTION

More information

Introduction Section 1 Section 2 Section 3

Introduction Section 1 Section 2 Section 3 V A L V E S Page Introduction Section 1 Section 2 Section Proportional Pressure Controller 9 Proportional Quick Exhaust 65 Pressure Control Systems 77 1 Consult Precautions page 94 before use, installation

More information

Today Numatics is proud to be a part of the Industrial Automation Division of Emerson Electric Co.

Today Numatics is proud to be a part of the Industrial Automation Division of Emerson Electric Co. Numatics, Inc. is a leading manufacturer of pneumatic products and motion control products. Our broad spectrum of standard, custom developed products and application components, have made a significant

More information

Remote Process Actuation Control System AirLINE WAGO Remote I/Os and Fieldbusses

Remote Process Actuation Control System AirLINE WAGO Remote I/Os and Fieldbusses Remote Process Actuation Control System AirLINE WAGO Remote I/Os and Fieldbusses Type 8644 can be combined with... Fully compatible with WAGO I/O Combination of Fieldbus, pilot valves and I/O modules High

More information

Electro-Pneumatic Regulators. Electronic Vacuum Regulators

Electro-Pneumatic Regulators. Electronic Vacuum Regulators Electro-Pneumatic Regulator Electronic Vacuum Regulator New Reduced wiring Applicable Fieldbus protocols Compact & light Weight: g Note ) (ITV) Power consumption: 4 W Note ) or less Electro-Pneumatic Regulators

More information

Valve Manifolds. Series Fielbus Electronics - 51

Valve Manifolds. Series Fielbus Electronics - 51 Valve Manifolds 07GB-07/R0 Series 0 Fielbus Electronics - 0 Series General Information 0 Valve Series belong to the Numatics Valve Generation 000. With up to outputs and 96 inputs., depending on the protocols

More information

2035 Series Solenoid Pilot Actuated Valves

2035 Series Solenoid Pilot Actuated Valves Solenoid Pilot Actuated Valves www.numatics.com Table of Contents...- Terminal Strip, Sub-D, and Round Connector Options... Technical and Operating Data.... How to Order-Valves and Regulators... How to

More information

Gateway Type Serial Transmission System

Gateway Type Serial Transmission System P99-EX-B Gateway Type Serial Transmission System P Maximum 8 point control (64 inputs/64 outputs) P Flexibility of manifold valve installation improved with 4 branch wiring Flexible installation and removal

More information

Electro-Pneumatic Regulators. Electronic Vacuum Regulators

Electro-Pneumatic Regulators. Electronic Vacuum Regulators Electro-Pneumatic Regulator Electronic Vacuum Regulator Stepless control of air pressure proportional to an electrical signal Added Fieldbus compliant specifications to New Series Reduced wiring Series

More information

F5 Valve F6 Valve F7 Valve

F5 Valve F6 Valve F7 Valve Basic Valve Features 2 & -Position Valve Functions Valve Valve Valve Valve 5 2 2 Specifications : : : :.55 Cv.60 Cv Operating Vacuum to 5 PSIG Ports NPT Standard BSPP G Option /8 Inch to / Inch Cylinder

More information

Remote Process Actuation Control System AirLINE - Siemens ET 200S

Remote Process Actuation Control System AirLINE - Siemens ET 200S Remote Process Actuation Control System AirLINE - Siemens ET 200S Type 8644 can be combined with... Fully compatible with Siemens ET 200S Combination of Fieldbus, pilot valves and I/O modules High flexibility

More information

3/8 & 1/2 NPT. 4-Way - 5 Ported - 2 Position - Type 2 Use on all 4 Way - 2 Position applications

3/8 & 1/2 NPT. 4-Way - 5 Ported - 2 Position - Type 2 Use on all 4 Way - 2 Position applications 8 SERIES: /8 Ported Air Valves, A & B SERIES: / Ported Air Valves /8 & /, A, B & 8 Series, & Way; & Position Operation to 50 psi Note! Spring return & spring centered models NOT suitable for dry air service.

More information

LIMIT SWITCH Prism - PI

LIMIT SWITCH Prism - PI LIMIT SWITCH Prism - PI with SST Switching Sensors Installation, Maintenance and Operating Instructions (PI ) Publication# 07revA Table of Contents Publication# 07revA Table Of Contents... Page Prism PI

More information

AirLINE and AirLINE Quick electrical/pneumatic Automation System

AirLINE and AirLINE Quick electrical/pneumatic Automation System AirLINE and AirLINE Quick electrical/pneumatic Automation System Type 8644 can be combined with Fully compatible with Rockwell Combination of Fieldbus, pilot valves and I/O modules higher fl exibility

More information

Technical Bulletin. MAC Valves, Inc., is pleased to announce. Introduction - Plunger up / Plunger Cooling / Counterblow Solutions

Technical Bulletin. MAC Valves, Inc., is pleased to announce. Introduction - Plunger up / Plunger Cooling / Counterblow Solutions Introduction - Plunger up / Plunger Cooling / Counterblow Solutions MAC Valves, Inc., is pleased to announce the release of new proportional valves designed for the plunger control and plunger cooling

More information

Isonic Mod 3 Series 3000/ /2, 3/2 Direct - 4/2 Single & Double Solenoid Valves

Isonic Mod 3 Series 3000/ /2, 3/2 Direct - 4/2 Single & Double Solenoid Valves Isonic Mod 3 Series 3000/5000 2/2, 3/2 Direct - 4/2 Single & Double Solenoid Valves Isonic Mod 3 Valve Series With an innovative concept and a pioneering approach to valve design, Mead s new technology

More information

Simultaneous Electrical / Pneumatic Connection to Manifold 1/4 or 6mm Integral Push-In Fittings. AC or DC Circuit Board

Simultaneous Electrical / Pneumatic Connection to Manifold 1/4 or 6mm Integral Push-In Fittings. AC or DC Circuit Board With an innovative concept and a pioneering approach to valve design, Mead s new technology has directly challenged the conventions of traditional valve manufacturers. In doing so, Mead has overcome many

More information

Individual, Multipole and Fieldbus

Individual, Multipole and Fieldbus Valve Islands > 016 > Series Y valve islands Series Y valve islands, Individual, Multipole and Fieldbus Valve Island with integrated Pneumatics and Electronics. Available versions: Individual, Multipole,

More information

VSD10M DIRECTIONAL CONTROL VALVES SOLENOID ACTUATED, PILOT OPERATED

VSD10M DIRECTIONAL CONTROL VALVES SOLENOID ACTUATED, PILOT OPERATED NFPA SIZE D10 TYPICAL PERFORMANCE SPECIFICATIONS Performance is measured on a four-way circuit (full circuit). Performance may be reduced from that shown if a three-way circuit (half circuit) is used,

More information

1329I Integrated Drive/Motor CE Filter Option Kit

1329I Integrated Drive/Motor CE Filter Option Kit Instruction Sheet 1329I Integrated Drive/Motor CE Filter Option Kit CE filter options are designed to be used with the 1329I Integrated Drive/Motor. The main function of the CE filter is to reduce the

More information

Easytork Solenoid Valve IOM

Easytork Solenoid Valve IOM Easytork Solenoid Valve IOM General This installation document is to be read in conjunction with the Easytork Vane Actuator IOM. Description The Easytork Solenoid Valve ( ESV ) series is intended for the

More information

Solenoid Valve Output Module IC693MDL760 Product Description

Solenoid Valve Output Module IC693MDL760 Product Description GFK-A November 000 Solenoid Valve Output Module ICMDL0 Product Description Description This ICMDL0 output module provides eleven pneumatic outputs and five VDC sourcing outputs. For each pneumatic output,

More information

Electro-Pneumatic Regulator/Electronic Vacuum Regulator

Electro-Pneumatic Regulator/Electronic Vacuum Regulator Electro-Pneumatic Regulator/Electronic Vacuum Regulator Series Stepless control of air pressure proportional to an electrical signal // series are compatible with various input specifications, including

More information

ANTI-SHOCK DIRECTIONAL CONTROL VALVES

ANTI-SHOCK DIRECTIONAL CONTROL VALVES ACTUATED, DIRECT OPERATED TYPICAL PERFORMANCE SPECIFICATIONS Performance is measured on a four-way circuit (full circuit). Performance may e reduced from that shown if a three-way circuit (half circuit)

More information

ARO EasyWire System Installation Guide

ARO EasyWire System Installation Guide TM ARO EasyWire System Installation Guide Flexible Communications for ARO Genesis Manifold Valves Using Any Discrete Output PLC. INDEX PAGE System Features.......................................................................

More information

503 series. GENERAL Operating pressure

503 series. GENERAL Operating pressure FEATURES rate up to 00 l/min Spool & Sleeve or rubber packed technology in the same dimension body Wide electrical connection selection : G3 or 580 Fieldbus Electronics, 25 or 37 Pin Sub-D connector, 19

More information

Valvair Sprint TM Pneumatic Valves Solenoid & Pilot-Operated Directional Spool Valves. Catalog VAL-VS-E/USA April 2004

Valvair Sprint TM Pneumatic Valves Solenoid & Pilot-Operated Directional Spool Valves. Catalog VAL-VS-E/USA April 2004 Valvair Sprint TM Pneumatic Valves Solenoid & Pilot-Operated Directional Spool Valves Catalog VAL-VS-E/USA April 2004 ! WARNING FAILURE OR IMPROPER SELECTION OR IMPROPER USE OF THE PRODUCTS AND/OR SYSTEMS

More information

Maintenance Instructions & Parts List

Maintenance Instructions & Parts List PM-PTR/LTR-C Automation Actuator Division Wadsworth, Ohio 448 October 7, 993 Rev. October 999 PTR/LTR Series Actuators Maintenance Instructions & Parts List Provide Model Number and Serial Number When

More information

Technical Data... 3 How to Order... 4 Dimensions... 5 Inline Mount Valve... 6 Manifold Dimensions and Part Numbers... 6

Technical Data... 3 How to Order... 4 Dimensions... 5 Inline Mount Valve... 6 Manifold Dimensions and Part Numbers... 6 Table of Contents Minature Valve Series...3-14 RB Series...3-6 Technical Data.... 3 How to Order.... 4 Dimensions... 5 Inline Mount Valve.... 6 Manifold Dimensions and Part Numbers... 6 S Series...7-9

More information

Action Automation & Controls, Inc.

Action Automation & Controls, Inc. IN-Stock Directional Control Valves Table of Contents MAC Small 3 Way Valves..................... - 34 Series, Cv up to.1.................... - 35 Series, Cv up to.17....................-5 36 Series, Cv

More information

Technical Information Features Fast Response - Bubble Tight Sealing Small Size - 4 Inches High Single Solenoid - Only 3 Moving Parts Pilot Interchange

Technical Information Features Fast Response - Bubble Tight Sealing Small Size - 4 Inches High Single Solenoid - Only 3 Moving Parts Pilot Interchange Model Number Index Function / Mounting Style N195 4-Way Line Mounting N205 4-Way Non Plug-In Manifold Mounted N215 4-Way Plug-In Manifold Mounted Line Mounting, Non Plug-In, Manifold Mounting Function

More information

Valve Islands Series H

Valve Islands Series H CATALOGUE > Release 8. Valve Islands Series H Valve Island with Pneumatics and Electronics integrated. Available versions: Multipole (PNP and NPN) and Fieldbus (Profibus-DP, DeviceNet, CANopen). Valve

More information

DISTRIBUTORS. n o p q. hdm + multi-pole connection TECHNICAL DATA COMPONENTS

DISTRIBUTORS. n o p q. hdm + multi-pole connection TECHNICAL DATA COMPONENTS + multi-pole connection HDMs are the ideal solution for those requiring the unbeatable performance, flexibility and modularity of Multimach valves combined with sturdy mechanics and a high degree of protection

More information

The New Filter Valve Technology

The New Filter Valve Technology The New Filter Valve Technology HIGH FLOW, QUICK RESPONSE.. Connections Ports available in NPT, and BSPP G thread to international standards Response Minimized space above the diaphragm guarantees fast

More information

Base Mounted Metal Seal/Rubber Seal VQ0000 (VV5Q05) VQ1000 (VV5Q11) Individual SUP spacer. Individual EXH spacer

Base Mounted Metal Seal/Rubber Seal VQ0000 (VV5Q05) VQ1000 (VV5Q11) Individual SUP spacer. Individual EXH spacer Base Mounted Metal Seal/Rubber Seal VQ Built-in silencer, direct exhaust Space-saving profile All pilot valves are compactly mounted on one side. The space-saving design of mounting all fittings on one

More information

FIELDBUS ELECTRONICS 580 Electronics (Series : M7 to 1/2 (G or NPT) or with push-in fittings Ø4 to 10 mm)

FIELDBUS ELECTRONICS 580 Electronics (Series : M7 to 1/2 (G or NPT) or with push-in fittings Ø4 to 10 mm) FIELDBUS ELECTRONICS 580 Electronics (Series - : M7 to 1/2 (G or NPT) or with push-in fittings Ø4 to 10 mm) 580 Fieldbus - Electronics Made Easy! Innovative Graphic Display is used for easy commissioning,

More information

Installation Instructions. Y-Series Brushless Servo Motor

Installation Instructions. Y-Series Brushless Servo Motor Installation Instructions Y-Series Brushless Servo Motor Catalog Number Y-1002-1, Y-1002-2, Y-1003-1, Y-1003-2, Y-2006-1, Y-2006-2, Y-2012-1, Y-2012-2, and Y-3023-2 These installation instructions describe

More information

Port Flow Rate/ Function Series Actuators Page Number Size Factor

Port Flow Rate/ Function Series Actuators Page Number Size Factor Section dex Port Flow Rate/ Function Series Actuators Page Number Size Factor 0- Cv = 0.05 Way Modular Solenoid. -. & to Way Manifold /8 NPT Cv = 0. Way, Position Modular /8 NPT Cv = 0.05 Way Hex Solenoid.5.6

More information

PNEUMATIC VALVE MANIFOLDS 11 mm - Series 501 M7 or with push-in fittings Ø6 mm

PNEUMATIC VALVE MANIFOLDS 11 mm - Series 501 M7 or with push-in fittings Ø6 mm PNEUMATIC VALVE MANIFOLDS mm - Series 50 M7 or with push-in fittings Ø6 mm Series G3 50 Types MULTIPOL-BUS new 50 D/3D CAD models - In 3D 0056GB-0/R0 6 Manifold assemblies kit (Electronic + End plate)

More information

CERAM ISO 5599/1 VALVES PNEUMATIC DIRECTIONAL CONTROL

CERAM ISO 5599/1 VALVES PNEUMATIC DIRECTIONAL CONTROL CERAM ISO 5599/1 VALVES PNEUMATIC DIRECTIONAL CONTROL 4 Pneumatic Directional Control Valves AVENTICS Corporation Index TABLE OF CONTENTS PAGE Specifications and features... 5-6 Model number identification...

More information

Valve Manifolds Type 44 VTSA, Type 45 VTSA-F Metric Series Overview

Valve Manifolds Type 44 VTSA, Type 45 VTSA-F Metric Series Overview Overview Modular multi-functional valve manifold for up to 3 valves: Type 44 VTSA, ISO 15407-/ISO 5599- Type 45 VTSA-F with optimized flow Different valve sizes on one valve manifold: 18 mm (ISO 0) 6 mm

More information

Sub-Base Mounted Valves to ISO 5599/2 Fielbus Electronics - 239

Sub-Base Mounted Valves to ISO 5599/2 Fielbus Electronics - 239 Valves Sub-Base Mounted Valves to ISO 5599/2 Fielbus Electronics - 239 General Information ISO 1, ISO 2 and ISO 3 valve series incorporate the famous Numatics lapped spool and sleeve for ultimate service

More information

Double Acting & Spring Return. SERIES 92/93 Rack & Pinion PNEUMATIC ACTUATOR. The High Performance Company

Double Acting & Spring Return. SERIES 92/93 Rack & Pinion PNEUMATIC ACTUATOR. The High Performance Company PNEUMATIC ACTUATOR SERIES 92/93 Rack & Pinion Double Acting & Spring Return The High Performance Company SERIES 92/93 Styling, strength, compactness, and simplicity of design have been combined to produce

More information

Valve Manifolds Type 44 VTSA, Type 45 VTSA-F Inch Series Overview

Valve Manifolds Type 44 VTSA, Type 45 VTSA-F Inch Series Overview Overview Modular multi-functional valve manifold for up to 3 valves: Type 44 VTSA, ISO 15407-/ISO 5599- Type 45 VTSA-F with optimized flow Different valve sizes on one valve manifold: 0.71 in (ISO 0) 1.0

More information

APS & APIS ATEX AIRPOWER SWITCH BOXES FEATURES DESCRIPTION

APS & APIS ATEX AIRPOWER SWITCH BOXES FEATURES DESCRIPTION page 1 DESCRIPTION The switch boxes are suitable for rotary actuators and are the industry leader in versatility, quality and approvals gained. Models include APS standard range with a variety of outputs

More information

S Series Technical Data...7 How to Order...8 Dimensions...8 Manifold Dimensions and Part Numbers...9

S Series Technical Data...7 How to Order...8 Dimensions...8 Manifold Dimensions and Part Numbers...9 Miniature Valve Series............................................................3-14 RB Series..................................................................................3-6 Technical Data...................................................................................3

More information

Thread type to 0.8 MPa to 0.8 MPa. Note) Air operated type is model IR2120 only. Note) Air operated type is model IR3120 only.

Thread type to 0.8 MPa to 0.8 MPa. Note) Air operated type is model IR2120 only. Note) Air operated type is model IR3120 only. Precision Regulator Series IR//3 5 Precision Regulator Series IR//3 Features Precise air pressure regulator for instrument applications. Three body sizes available. Pressure unaffected by supply pressure

More information

Section 6. Four Station Nugget 30 High Flow Micro Valve with 25-pin D connector and Pneufit Fittings

Section 6. Four Station Nugget 30 High Flow Micro Valve with 25-pin D connector and Pneufit Fittings Section 6 Nugget 30 Series Valves 5/2 and 5/3-position, high flow, compressed air micro valve with compact, lightweight 10mm body, and interchangeable fittings for 1/8", 5/32", 1/4", 4 or 6 mm tubing.

More information

QPV1 Electronic Pressure Regulator INSTALLATION AND MAINTENANCE INSTRUCTIONS

QPV1 Electronic Pressure Regulator INSTALLATION AND MAINTENANCE INSTRUCTIONS INSTALLATION AND MAINTENANCE INSTRUCTIONS DESCRIPTION / IDENTIFICATION The QPV1 is a high resolution electronic pressure regulator. The QPV1 provides a regulated output pressure that is proportional to

More information

High performance Vector Control. Ratings. System configuration

High performance Vector Control. Ratings. System configuration System configuration High performance Vector Control Low harmonic or regenerative drive IP54 full range Compact design and robustness Built-in filter (according to C3 class) Built-in fuses (from 200 kw)

More information

D05 Directional Control Valves

D05 Directional Control Valves Engineering D05 Directional Control Valves WFDG4S*4-01, 60 Design Wet Armature Solenoid Operated Max Pressure up to 248 Bar (3600 psi) Same Day Shipments www.fluidynefp.com Table of Contents Basic Characteristicts...2

More information

Directional Controls

Directional Controls Vickers Directional Controls Wet Armature Solenoid Operated Directional Control Valves Model DGV-, Series Typical Construction of a Spring-Centered DC Valve with Variable Speed Pilot Control passage Speed

More information

TECHNICAL BULLETIN. The main focus of MAC Valves is to offer an innovative product developed according to users experience and that provides:

TECHNICAL BULLETIN. The main focus of MAC Valves is to offer an innovative product developed according to users experience and that provides: 100% DROP-IN SOLUTIONS FOR SOLENOID VALVES ON PET PREFORM INJECTION PRESSES MAC Valves, Inc. is pleased to bring to your attention the 100% drop-in replacement solutions for OEM supplied solenoid valves

More information

BALDOR MN413 Brakes Manual

BALDOR MN413 Brakes Manual BALDOR MN413 Brakes Manual http://www.manuallib.com/baldor/mn413-brakes-manual.html The DODGE D-Series motor brakes are manufactured to NEMA standards for mounting to C-face and double shafted motors.

More information

Contact Air Incorporated for further assistance. Ph:

Contact Air Incorporated for further assistance. Ph: Form DVA-10 Rev. 7/10 DASH 1... 1-11 Cutaway Drawing... 2 Color Coding... 1,2,6 Mounting Styles... 3 Electrical Connector Options... 4 Temperature Range... 5 Electrical Specifications... 5 Part Number

More information