SERVICE PARTS MANUAL CIM SERIES CIM0330, CIM0430, CIM0436, CIM0530 and CIM0636 CIM0335, CIM0435, CIM0535 and CIM0635

Transcription

1 SERVICE PARTS MANUAL CIM SERIES CIM0330, CIM0430, CIM0436, CIM0530 and CIM0636 CIM0335, CIM0435, CIM0535 and CIM Date 10/19/ E. 45th Avenue Denver, CO

2

3 CIM Service Parts Table of Contents This parts list contains the service parts available for the following CIM Series. CIM /60/1 CIM /50/1 CIM /60/1 CIM /60/1 CIM /50/1 CIM /60/1 CIM /50/1 CIM /60/1 CIM /50/1 Model Number Example CIM0330HA CIM = Cuber Ice Machine 03 = 300 lb, in 24 hours capacity 3 = 30 inch wide cabinet 0 = 115 Volt, 5 = /50/1 6 = /60/1 Volt H = Half Cube Size, F = Full Cube Size A = Air Cooled Condenser, W = Water Cooled Condenser R=Remote Condenser Check the model number on the data plate and refer to the correct listing for the specific component. Check carefully that the correct part is identified and ordered. Table of Contents Page 1 Cabinet Page 2-3 Water System Page 4-5 Air Cooled Condenser Page 6-7 Water Cooled Condenser Page 8-9 Remote Condenser Page Electrical Page Ice-O-Matic East 45th Ave. Denver Co Page 1

4 CIM Series Service Parts Cabinet Page 2

5 CIM Service Parts Cabinet Model Number No. CIM0330 CIM0430 CIM0436 CIM0530 CIM0636 Description S S S S S Front Panel Front Panel Screws Left Side Side Panel S S S S S Top Panel-Air Cooled Top Panel-Remote and Water Cooled Rear Cover Screws Rear Cover Right Side Panel-Remote and Water Cooled S S S S S Right Side Panel-Air Cooled Junction Box Cover Junction Box Screw Left Front Corner Post Right Front Corner post Brace 30 Inch Rear Brace Base Front Left Brace Front Right Brace Right Side Framework 30"Assembly Left Side Framework 30"Assembly Elevation Skid 30 Inch Carton Liner 30 Inch Shipping Bracket 2 Req. (Field Installed) Carton, Elevation 30 Inch Corner Post (Each), Elevation, (4 Required) P P P P P Pop Rivets Not Shown ( Package of 10) CIM0335 CIM0435 CIM0535 CIM0635 Description S S S S Front Panel Front Panel Screws Left Side Side Panel S S S S Top Panel-Air Cooled 5 Not Used Not Used Top Panel-Remote and Water Cooled Rear Cover Screws Rear Cover 8 Not Used Not Used Right Side Panel-Remote and Water Cooled S S S S Right Side Panel-Air Cooled Junction Box Cover Junction Box Screw Left Front Corner Post Right Front Corner post Brace 30 Inch Rear Brace Base Front Left Brace Front Right Brace Right Side Framework 30"Assembly Left Side Framework 30"Assembly Elevation Skid 30 Inch Carton Liner 30 Inch Shipping Bracket 2 Req. (Field Installed) Carton, Elevation 30 Inch Corner Post (Each), Elevation, (4 Required) P P P P Pop Rivets Not Shown ( Package of 10) Page 3

6 CIM Series Service Parts Water System The Model Number of the machine has a designator for the Cube Size Example: CIM0430FA F = Full Cube CIM0430HA H = Half Cube Page 4

7 CIM Service Parts Water System Model Number No. CIM0330 CIM0430 CIM0436 CIM0530 CIM0636 Description Lower Curtain Assembly Evaporator Cover Hose Clamp, Plastic Water Distribution Tube Assembly Water Tube, Upper Coupler, Straight, 5/8 I.D. Tubing Water Tube, Sump Sump/Water Trough Water Pump Purge Valve Top Cover Water Inlet Valve Drain Fitting Hose Clamp, Plastic Float Switch Assembly (Includes Instructions) S S S S S Purge Valve Tubing to Drain Purge Valve Tube to Inlet Outlet Bracket Inlet Outlet Bracket Evaporator-FULL Cube = 7/8 x 7/8 x 7/ Evaporator-HALF Cube = 3/8 x 7/8 x 7/ Water Inlet Valve to Inlet Outlet Bracket Tube Evaporator-FULL Cube = 7/8 x 7/8 x 7/ Evaporator-HALF Cube = 3/8 x 7/8 x 7/8 115/60/1 115/60/ /60/1 115/60/ /60/1 Machine Voltage The Model Number of the machine has a designator for the Cube Size Example: CIM0430FA F = Full Cube Cube Size = 7/8 x 7/8 x 7/8 CIM0430HA H = Half Cube Cube Size = 3/8 x 7/8 x 7/8 Model Number /50/1 Machine Voltage No. CIM0335 CIM0435 CIM0535 CIM0635 Description Lower Curtain Assembly Evaporator Cover Hose Clamp, Plastic Water Distribution Tube Assembly Water Tube, Upper Coupler, Straight, 5/8 I.D. Tubing Water Tube, Sump Sump/Water Trough Water Pump Purge Valve Top Cover Water Inlet Valve Drain Fitting Hose Clamp, Plastic Float Switch Assembly (Includes Instructions) S S S S Purge Valve Tubing to Drain Purge Valve Tube to Inlet Outlet Bracket Inlet Outlet Bracket Evaporator-FULL Cube = 7/8 x 7/8 x 7/ Evaporator-HALF Cube = 3/8 x 7/8 x 7/ Water Inlet Valve to Inlet Outlet Bracket Tube Evaporator-FULL Cube = 7/8 x 7/8 x 7/ Evaporator-HALF Cube = 3/8 x 7/8 x 7/8 Page 5

8 CIM Series Service Parts Air Cooled Page 6

9 CIM Service Parts Air Cooled No. CIM0330A CIM0430A Model Number CIM0436A CIM0530A CIM0636A Description B A Compressor Kit Hot Gas Valve Body Hot Gas Valve Coil Switch, Fan Cycle TXV High Temp Switch Switch, High Pressure Drier (Included in Compressor Kit) Not Used Restrictor Insulation, TXV Insulation, Bulb Cable Tie-For TXV and Bulb Insulation Fan Motor Assembly Fan Shroud Condenser Service Valve Cap Service Valve Core Service Valve Stem 115/60/1 115/60/ /60/1 115/60/ /60/1 Machine Voltage CIM0330A CIM0430A CIM0436A CIM0530A CIM0636A Starting Components (Included in Comp Kit) B A Compressor Kit Start Capacitor Run Capact\itor Compressor Relay Internal Overload Model Number /50/1 Machine Voltage No. CIM0335A CIM0435A CIM0535A CIM0635A Description A Compressor Kit Hot Gas Valve Body Hot Gas Valve Coil Switch, Fan Cycle TXV High Temp Switch Switch, High Pressure Drier (Included in Compressor Kit) Not Used Restrictor Insulation, TXV Insulation, Bulb Cable Tie-For TXV and Bulb Insulation Fan Motor Assembly Fan Shroud Condenser Service Valve Cap Service Valve Core Service Valve Stem CIM0335A CIM0435A CIM0535A CIM0635A Starting Components (Included in Comp Kit) A Compressor Kit Start Capacitor Run Capact\itor Compressor Relay Internal Overload Page 7

10 CIM Series Service Parts Water Cooled Page 8

11 CIM Service Parts Water Cooled No. CIM0330W CIM0430W Model Number CIM0436W CIM0530W CIM0636W Description B A Compressor Kit Hot Gas Valve Body Hot Gas Valve Coil TXV High Temp Switch Switch, High Pressure Drier (Included in Compressor Kit) Insulation, TXV Insulation, Bulb Cable Tie-For TXV and Bulb Insulation Water Regulator Condenser Service Valve Cap Service Valve Core Service Valve Stem 115/60/1 115/60/ /60/1 115/60/ /60/1 Machine Voltage CIM0330A CIM0430A CIM0436A CIM0530A CIM0636A Starting Components (Included in Comp Kit) B A Compressor Kit Start Capacitor Run Capact\itor Compressor Relay Internal Overload Model Number /50/1 Machine Voltage No. CIM0535W CIM0635W Description Compressor Kit Hot Gas Valve Body Hot Gas Valve Coil TXV High Temp Switch Switch, High Pressure Drier (Included in Compressor Kit) Insulation, TXV Insulation, Bulb Cable Tie-For TXV and Bulb Insulation Water Regulator Condenser Service Valve Cap Service Valve Core Service Valve Stem CIM0535A CIM0635A Starting Components (Included in Comp Kit) Compressor Kit Start Capacitor Run Capact\itor Compressor Relay Internal Overload Page 9

12 CIM Series Service Parts Remote Page 10

13 CIM Service Parts Remote No. CIM0530R Model Number CIM0535R CIM0636R Description B A Compressor Kit Hot Gas Valve Body Hot Gas Valve Coil Pump Down Control TXV Insulation, TXV Cable Tie-For TXV and Bulb Insulation Insulation,TXV Bulb Not Used Pressure Control Valve Not Used Accumulator High Temp Switch Switch, High Pressure Service Valve Cap Service Valve Core Service Valve Stem Receiver Check Valve Liquid Line Solenoid Liquid Line Coil Drier (Included in Compressor Kit) /2 Inch Coupling Flange (Large) /2 Inch Coupling (Large) /8 Inch Coupling Flange (Small) /8 Inch Coupling (Small) CIM0530R CIM0535A CIM0636R Starting Components (Included in Comp Kit) B A Compressor Kit Start Capacitor Run Capactitor Potential Relay Internal Overload 115/60/ /50/ /60/1 Machine Voltage Page 11

14 CIM Series Service Parts Electrical Page 12

15 CIM Service Parts Electrical No. CIM0330A CIM0430A Model Number CIM0436A CIM0530A CIM0636A Description B A Compressor Start Capacitor Run Capact\itor Potential Relay Internal Overload Switch, High Temp Contactor Cable Tie, Metal Valve, Water Inlet Water Pump Purge Valve Purge Drain Float Switch Assembly (Includes Instructions) Board Dual Voltage P P P P P Plastic Standoff, Control Board (Pkg of 10) Harvest Assist Membrane Switch (Includes Cable) 115/60/1 115/60/ /60/1 115/60/ /60/1 Machine Voltage Model Number /50/1 Machine Voltage No. CIM0335A CIM0435A CIM0535A CIM0635A A Compressor Kit Start Capacitor Run Capact\itor Compressor Relay Internal Overload Switch, High Temp Contactor Cable Tie, Metal Valve, Water Inlet Water Pump Purge Valve Purge Drain Float Switch Assembly (Includes Instructions) Board Dual Voltage P P P P Plastic Standoff, Control Board (Pkg of 10) Harvest Assist Membrane Switch (Includes Cable) Page 13