MOR/ryde Drive Axle Suspension System

Size: px
Start display at page:

Download "MOR/ryde Drive Axle Suspension System"

Transcription

1 MOR/ryde Drive Axle Suspension System (Double Eye Leaf Spring) RL Installation Instructions MOR/ryde International 1966 Moyer Avenue Elkhart, IN RL Rev.1

2 MOR/ryde RL Installation Instructions Instructions will assume procedures apply to both sides of vehicle. TYPICAL RL DRIVE AXLE SUSPENSION KIT U.S.A. Patent Number 6,176,478 Required Tools for Installation of MOR/ryde RL Suspension Kit *Floor Jack *Safety Stands Socket Set 9/16 Swivel Socket Wrench Set Cutting Torch Hand Drill 1/2 Drill Bit **Reciprocating Saw **Wire Welder Pneumatic Air Chisel Screwdriver Drift Pin MOR/ryde Installation Tool or Large C-Clamp (6 min.), Porta-Power, Small Pipe Clamp * Check for Adequate Capacity. It must support the weight of the rear of the vehicle. ** May be Required for Tailpipe Modifications Torque Chart Foot-LBS +/- 10% Bolt Size Grade 5 Grade 8 1/4-20 5/ /8-16 7/ /2-13 5/8-11 5/ /

3 Place floor jack under differential and raise drive axle tires to approximately 6 off the ground. Step 1 Place jack stands underneath OEM frame and release floor jack. Drive axle tires should be approximately 1 off ground. Be sure jack stands and floor jacks have sufficient capacity to safely support vehicle. Step 2 The exhaust pipe can not be closer than 1 from metal parts and no closer than 2 from the rubber parts of the MOR/ryde system. If alteration of the exhaust is expected, cut exhaust just behind the drive axle leaving 1-1/2 of straight flat pipe. The exhaust will be rejoined at a later time. If no exhaust alteration is expected go to Step 4. Step 3 To facilitate installation one may want to remove the spare tire or fuel tank. Remove rear spring eye shackle nut and bolt. If possible, raise drive axle and remove shackle nut and bolt over top of frame. If spring hanger is above leaf spring eye, lower leaf spring to remove spring eye bolt. Note: Save spring eye nut and bolt for use later. Step 4 3

4 If the OEM spring hanger is riveted onto the frame, remove the rivets with an air chisel or a cutting torch (usually 4-8 rivets). If the hanger is bolted on, remove it with the appropriate tools. DANGER: Gasoline is very flammable. Be sure that the fuel cell, fuel lines and wire harnesses are adequatley protected from sparks. Step 5 If the shackle was not removed in step 4, lower the spring eye below the frame and remove the shakel bolt and nut. Step 6 With the approriate drill bit (see parts list), ream the existing spring hanger hole to be sure that the hole is clear of any debris. These holes will be used to bolt the MOR/ryde frame hanger to the OEM chassis. Step 7 Frame and leaf spring are now ready for installation of MOR/ryde components. Step 8 4

5 Step 9 MOR/ryde spring carrier Carefully inspect the MOR/ryde spring carrier assemblies for an offset spring plate. If an offset is observed, position the largest offset away from the OEM frame rail. Refer to the diagram below. This will achieve the greatest clearance between the spring plate and the OEM frame rail. Re-use the spring eye nut and bolt to install the MOR/ryde spring carrier, except on the Ford E350 & E450 chassis.* The bolt head must be installed towards the OEM frame rail. OEM frame rail. Offset side Bolt the MOR/ryde frame hanger to the chassis frame through the existing holes that were reamed in step 7. Use the mounting hardware provided by MOR/ryde. The fuel cell may need to be lowered to install the frame hanger nuts. A long handled socket wrench and mechanical fingers may be helpful. The nuts must be installed on the inside of the chassis frame. Do Not tighten the nuts at this time. Step 10 If your kit is equipped with a cross member, install the MOR/ryde cross member between the frame hangers with the bolts provided. Tighten the frame hanger and cross member bolts at this time. Note the torque requirements on page two. Step 11 5

6 Bolt the MOR/ryde Rubber Spring Assembly to the Frame Hanger using hardware as provided. Note three ride height options on the Frame Hanger, a lower hole setting will raise the vehicle. A top hole setting will lower the vehicle. Step 12 Using a bottle jack, position jack head under MOR/ ryde Rubber Spring Assembly. Step 13 Raise Rubber Spring to align holes through Spring Carrier. Drift pins can be used to aid in aligning the holes. Step 14 Bolt Rubber Spring Assembly to Spring Carrier using hardware as provided. Step 15 6

7 a ppl yt hes ugge s t e dt or quea ss hownont he

8 Remove Installation Tool. Be sure Spacer Sleeve/ Pad is flat against leaf spring at normal vehicle weight. Check this after unit is sitting on ground. If required, rotate Spacer Sleeve/Pad to bear flat against leaf spring. Be sure bolt head faces towards frame. Go to step 22. Step 19 C-Clanp Method Position C-clamp between lower portion of Spring Carrier and Frame Hanger as shown. Tighten C- clamp until nose of Spring Carrier is positioned under leaf spring. Install 1/2 bolt and Spacer Sleeve/Pad between legs os Spring Carrier. Be sure bolt head faces towards frame. Step 20 Porta-Power Method Position Porta-Power between lower portion of MOR/ryde Spring Carrier and rear of axle. Pump Porta-Power until nose of Spring Carrier drops below the leaf spring. Install 1/2 bolt and Spacer Sleeve/Pad between legs of Spring Carrier. Be sure bolt head faces towards frame. Step 21 Tighten spring eye bolt. Repeat procedure on opposite side. FINAL HARDWARE CHECK: Be sure all bolts are torqued to spec. If fuel cell was lowered, check hoses and electrical connections. Step 22 8

9 Step 23 The closest edge of the exhaust pipe to the MOR/ryde Rubber Spring should be a 2 minimum clearance and 1 minimum clearance to steel components. Other options for exhaust and tailpipe termination may be: 1 In front of drive axle, 2 behind Frame Hanger or 3 out the back of the vehicle. Be sure when altering exhaust that the joints are gas tight. Accepable methods may be to weld seams and/or exhaust pipe joint clamps. WARNING: The exhaust pipe must not touch or blow on the MOR/ryde rubber spring. Doing so could cause premature failure of the rubber spring. Perform final check. Be sure all nuts and bolts are properly torqued. Refer to the chart on page 2. Verify spring eye bolt is positioned with bolt head toward the frame. Step 24 9

Super Duty Front Air Bag Installation Instructions

Super Duty Front Air Bag Installation Instructions 2005-2010 Super Duty Front Air Bag Installation Instructions Congratulations! You have just purchased the best engineered, highest quality front air suspension kit available on the market for your 2005-2010

More information

Toyota Tundra Tow Kit Installation Instructions

Toyota Tundra Tow Kit Installation Instructions 2007-2013 Toyota Tundra Tow Kit Installation Instructions Congratulations! You have just purchased the best engineered, highest quality air suspension kit available on the market for your 07-14 Toyota

More information

Dodge Ram 2500/3500 Tow Kit Installation Instructions

Dodge Ram 2500/3500 Tow Kit Installation Instructions 2003-2010 Dodge Ram 2500/3500 Tow Kit Installation Instructions Congratulations! You have just purchased the best engineered, highest quality air suspension kit available on the market for your 2003-2010

More information

720BAG GM 2 FRONT & 4 REAR LOWERING KIT

720BAG GM 2 FRONT & 4 REAR LOWERING KIT *720BAG2* 720BAG2 92720200 07-13 GM 2 FRONT & 4 REAR LOWERING KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6592 REAR HANGER & SHACKLE KIT DODGE RAM 2500 / 3500 Congratulations! You were

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6420 SHACKLE & HANGER KIT FORD F-350 Congratulations! You were selective enough

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6419 HANGER & SHACKLE KIT FORD F-150 Congratulations! You were selective enough

More information

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203)

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203) INSTALLATION INSTRUCTIONS P/N: C2094 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly clamps

More information

CHECK ALL PARTS INCLUDED IN THIS KIT TO THE PARTS LIST BEFORE INSTALLATION. IF ANY PIECES ARE MISSING, PLEASE CONTACT: TOTAL COST INVOLVED

CHECK ALL PARTS INCLUDED IN THIS KIT TO THE PARTS LIST BEFORE INSTALLATION. IF ANY PIECES ARE MISSING, PLEASE CONTACT: TOTAL COST INVOLVED 1949-1954 TCI Engineering Chevy Rear 4-Link Coil-Over & Air Bag Kit Installation Instructions 1-866-925-1101 www.totalcostinvolved.com Read and understand these instructions before starting any work! CHECK

More information

GM HD Heavy Duty 4 Link Tow Kit Installation Instructions

GM HD Heavy Duty 4 Link Tow Kit Installation Instructions 2001-2010 GM HD Heavy Duty 4 Link Tow Kit Installation Instructions Congratulations! You have just purchased the best engineered, highest quality air suspension kit available on the market for your 2001-2010

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6907 REAR LOWERING KIT 97-00 CHEVY 1-TON C-3500 Congratulations! You were selective

More information

99-04 Ford F250 Super Duty 4-6 Suspension Kit

99-04 Ford F250 Super Duty 4-6 Suspension Kit 92758200 99-04 Ford F250 Super Duty 4-6 Suspension Kit Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS 6525 REAR AXLE FLIP & HANGER KIT 5 OR 6 INCH LOWERING 14&UP CHEVROLET SILVERADO / GMC SIERRA 1500 Thank you for being selective enough to choose our high quality BELLTECH PRODUCT.

More information

A. Tools Needed:

A. Tools Needed: 92723200A 2014 GM 2 FRONT & 4 REAR LOWERING KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition to these

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6570 SPRING HANGER KIT DODGE DAKOTA Congratulations! You were selective enough

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS --300 W PONTIAC WAY CLOVIS, CA 93612 local: 559-875-0222 fax: 559-876-2249 toll free: 800-445-3767-- 6446 5.5 REAR AXLE FLIP-KIT 2015+ FORD F-150 2WD SHORT BED Thank you for being

More information

& 6 XJ CHEROKEE LONG ARM KIT

& 6 XJ CHEROKEE LONG ARM KIT 92PERF1689 84-01 4.5 & 6 XJ CHEROKEE LONG ARM KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these

More information

8" 4-LINK SUSPENSION SYSTEM. Ford Super Duty 4WD Part#:

8 4-LINK SUSPENSION SYSTEM. Ford Super Duty 4WD Part#: Part#: 013813 8" 4-LINK SUSPENSION SYSTEM Ford Super Duty 4WD 2011-2016 Rev. 051817 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand

More information

4 & 6 4-Link Suspension Systems. Ford Super Duty 4WD Part#: ,

4 & 6 4-Link Suspension Systems. Ford Super Duty 4WD Part#: , Part#: 013013, 013014 4 & 6 4-Link Suspension Systems Ford Super Duty 4WD 2011-2016 Rev. 051817 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read

More information

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203)

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203) INSTALLATION INSTRUCTIONS P/N S: C2090 & C2092 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly

More information

INSTALLATION INSTRUCTIONS P/N: C2094 SLIDE-A-LINK

INSTALLATION INSTRUCTIONS P/N: C2094 SLIDE-A-LINK INSTALLATION INSTRUCTIONS P/N: C2094 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly clamps

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----3300 W. Pontiac Way Clovis, CA 93612 toll free: 1-800-445-3767 web: www.belltech.com---- 6605-6607 FLIP KIT CHEVROLET C/K 1500 / 2500 PICK UP Thank you for being selective

More information

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W B&W Trailer Hitches 1216 Hawaii Rd / PO Box 186 Humboldt, KS 66748 P:620.473.3664 F:620.869.9031 Turnoverball Gooseneck Hitch Installation Instructions

More information

For Technical Assistance, call Competition Engineering's Tech Line at (203) , 8:30am-5:00pm Eastern Time COMPETITION ENGINEERING

For Technical Assistance, call Competition Engineering's Tech Line at (203) , 8:30am-5:00pm Eastern Time COMPETITION ENGINEERING INSTALLATION INSTRUCTIONS C2099 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly clamps around

More information

Before beginning this installation read the instruction sheet thoroughly. Check that all parts on parts list are present.

Before beginning this installation read the instruction sheet thoroughly. Check that all parts on parts list are present. INSTALLATION INSTRUCTIONS C2085 SLIDE-A-LINK, FORD F-150/LIGHTNING The Slide-A-Link by Competition Engineering is designed for use in 2 Wheel Drive Ford Lightning Pickups. The rigid front mount assembly

More information

Nissan Frontier 2wd/4wd 2.5 Suspension Kit

Nissan Frontier 2wd/4wd 2.5 Suspension Kit 92186500 Nissan Frontier 2wd/4wd 2.5 Suspension Kit Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition

More information

Installation Instructions

Installation Instructions Equipment Required: Installation Instructions Fastener Kit: F Wrenches: 8mm, 13mm, 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill, Reciprocating Saw, File WARNING: Under no circumstances do we recommend

More information

ReadyLift (Part# ) Ford F-350 4WD Leveling Kit Installation Instructions

ReadyLift (Part# ) Ford F-350 4WD Leveling Kit Installation Instructions 999-004 Ford F-350 4WD Leveling Kit SAFETY WARNING:ReadyLift Suspension Inc. recommends this system be installed by a professional technician. In addition to these instructions, professional knowledge

More information

WD DODGE SUSPENSION LIFT KIT P/N

WD DODGE SUSPENSION LIFT KIT P/N 4/03/03 94-01 4WD DODGE 1500 3 SUSPENSION LIFT KIT P/N 10-46094 NOTE: Each lift kit, and options to lift kits, are packaged separately. Therefore installation procedures are covered in separate instructions.

More information

INSTALLATION INSTRUCTIONS FOR M.O.R.E. SHACKLE REVERSAL SYSTEM (S.R.S. ) PART # THIS SYSTEM FITS Jeep CJ-5, CJ-7, CJ-8 VEHICLES.

INSTALLATION INSTRUCTIONS FOR M.O.R.E. SHACKLE REVERSAL SYSTEM (S.R.S. ) PART # THIS SYSTEM FITS Jeep CJ-5, CJ-7, CJ-8 VEHICLES. INSTALLATION INSTRUCTIONS FOR M.O.R.E. SHACKLE REVERSAL SYSTEM (S.R.S. ) PART # 7686-6 THIS SYSTEM FITS 1976-1986 Jeep CJ-5, CJ-7, CJ-8 VEHICLES. Please read all instructions carefully (including terms-policies)

More information

4, 6 Suspension System. Ford F250/350 4WD Part#: ,

4, 6 Suspension System. Ford F250/350 4WD Part#: , Part#: 013411, 013611 4, 6 Suspension System Ford F250/350 4WD 2005-2007 Rev. 071917 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand

More information

INSTALLATION INSTRUCTIONS QA1 P/N R , R , R R , R , R F100 Rear Coil-over Conversion System

INSTALLATION INSTRUCTIONS QA1 P/N R , R , R R , R , R F100 Rear Coil-over Conversion System INSTALLATION INSTRUCTIONS QA1 P/N R120-170, R120-200, R120-250 R220-170, R220-200, R220-250 65-72 F100 Rear Coil-over Conversion System TOOLS AND SUPPLIES REQUIRED Floor Jack Two (2) Jack Stands Drill

More information

READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS PRIOR TO INSTALLATION OF SYSTEM AND OPERATION OF VEHICLE.

READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS PRIOR TO INSTALLATION OF SYSTEM AND OPERATION OF VEHICLE. Add-A-Leaf Installation Instructions READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS PRIOR TO INSTALLATION OF SYSTEM AND OPERATION OF VEHICLE. PRODUCT SAFETY WARNING: Certain BDS Suspension products

More information

05-07 F250 6 SUSPENSION KIT

05-07 F250 6 SUSPENSION KIT 92159300 Stabilizer Drop Brackets Track Bar Bracket Control Arm Bracket Brake Line Drop Bracket Sway Bar Link Ext. Hardware Bags Pitman Arm 6111 Add-a-leaf 6578 3 Block and U-Bolt Kit 05-07 F250 6 SUSPENSION

More information

Read and understand all instructions and warnings prior to installation of system and operation of vehicle.

Read and understand all instructions and warnings prior to installation of system and operation of vehicle. 491 W. Garfield Ave., Coldwater, MI 49036 Phone: 517-279-2135 Web/live chat: www.bds-suspension.com E-mail: tech@bds-suspension.com Product: GM Leaf Spring Read and understand all instructions and warnings

More information

»Product» Safety Warning

»Product» Safety Warning #F1404, F1405 Installation Instructions 1999-2004 Ford Super Duty F-250/350 4wd 4" Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6636 HANGER and SHACKLE KIT 95 99 CHEVY TAHOE / GMC YUKON Congratulations! You

More information

99-04 Ford F250 Super Duty 4-6 Suspension Kit

99-04 Ford F250 Super Duty 4-6 Suspension Kit 92758200 99-04 Ford F250 Super Duty 4-6 Suspension Kit Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition

More information

LRE SUSPENSION SYSTEM OWNER S MANUAL

LRE SUSPENSION SYSTEM OWNER S MANUAL LRE SUSPENSION SYSTEM OWNER S MANUAL LRE SUSPENSION SYSTEM CONTENTS INTRODUCTION...3 PARTS LISTING...4 MEASURING SHEAR SPRING DEFLECTION...5 MINIMUM CLEARANCE REQUIREMENTS...5 RUBBER SHEAR SPRING INSPECTION...5

More information

37-39 TCI Chevy Rear 4-Link Kit Installation Instructions

37-39 TCI Chevy Rear 4-Link Kit Installation Instructions 37-39 TCI Chevy Rear 4-Link Kit Installation Instructions 1-800-984-6259 www.totalcostinvolved.com Read and understand these instructions before starting any work! SUPPORT VEHICLE WITH JACK STANDS BEFORE

More information

NOTICE TO DEALER AND VECHICLE OWNER

NOTICE TO DEALER AND VECHICLE OWNER 84-01 4.5 & 6 XJ CHEROKEE LONG ARM KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

WARNING DO NOT EXCEED THE MANUFACTURER S RECOMMENDED GROSS VEHICLE WEIGHT RATING (GVWR).

WARNING DO NOT EXCEED THE MANUFACTURER S RECOMMENDED GROSS VEHICLE WEIGHT RATING (GVWR). WARNING DO NOT EXCEED THE MANUFACTURER S RECOMMENDED GROSS VEHICLE WEIGHT RATING (GVWR). As in any suspension installation, it is the installer s responsibility to assure a correct installation. The installer

More information

INSTALLATION INSTRUCTIONS P/N S: C2091 & C2093 SLIDE-A-LINK

INSTALLATION INSTRUCTIONS P/N S: C2091 & C2093 SLIDE-A-LINK INSTALLATION INSTRUCTIONS P/N S: C2091 & C2093 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly

More information

»Product» Safety Warning

»Product» Safety Warning J1457, J1458 Installation Instructions 1984-2001 Jeep Cherokee XJ 4.5 Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information

PRE-INSTALLATION. INSTALLATION INSTRUCTIONS Front Dodge Ram WD 6" Suspension Lift Kit

PRE-INSTALLATION. INSTALLATION INSTRUCTIONS Front Dodge Ram WD 6 Suspension Lift Kit 2012-2015 Dodge Ram 1500 4WD 6" Suspension Lift Kit PRE-INSTALLATION 35015 2 - Knuckle (Driv/Pass) 2 - Crossmember (Front/Rear) 2 - Differential Bracket (Driv/Pass) 1 - Diff. Brace Bracket (Pass) 2 - Front

More information

This suspension system was developed using a Maximum tire size of 33 X 12.5 with a 17 x 9 aftermarket wheel with 4 1/2-5 backspacing..

This suspension system was developed using a Maximum tire size of 33 X 12.5 with a 17 x 9 aftermarket wheel with 4 1/2-5 backspacing.. 92174700 Thank you for choosing Rough Country for your suspension needs. 2005-15 TACOMA 6 Kit Rough Country recommends a certified technician install this system. In addition to these instructions, professional

More information

02-10 GM 2500HD / HD & HD CLASSIC 6 2WD SUSPENSION KIT

02-10 GM 2500HD / HD & HD CLASSIC 6 2WD SUSPENSION KIT 92122000 92127400 02-10 GM 2500HD / 01-06 1500HD & 07 1500HD CLASSIC 6 2WD SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician

More information

HP10033 KIT. * See application guide for proper fitment.

HP10033 KIT. * See application guide for proper fitment. HP10033 KIT * See application guide for proper fitment. Use the most advanced air springs on the market to eliminate your vehicle s sag, sway and bottoming out. Pacbrake air suspension levels your truck

More information

K20 4x4 Radius Arm Conversion Installation Instructions

K20 4x4 Radius Arm Conversion Installation Instructions 1973-1991 K20 4x4 Radius Arm Conversion Installation Instructions 1- Radius arm Hangers 2- Bracket, Driver Lower 3- Bracket, Passenger Upper 4- Radius Arm 5- Bracket, Driver Upper 6- Bracket, Passenger

More information

05-07 F250 6 SUSPENSION KIT

05-07 F250 6 SUSPENSION KIT 92158000 05-07 F250 6 SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W B&W Trailer Hitches 1216 Hawaii Rd / PO Box 186 Humboldt, KS 66748 Turnoverball Gooseneck Hitch Installation Instructions MODEL 1314 2013 2014 RAM 3500

More information

INSTALLATION INSTRUCTION 88578

INSTALLATION INSTRUCTION 88578 INSTALLATION INSTRUCTION 88578 For Rancho Suspension System RS6579B: 4WD Dodge 1500 & 2500 READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev E IMPORTANT NOTES! WARNING:

More information

INSTALLATION INSTRUCTIONS CHEVY C-10 4-Link Rear End

INSTALLATION INSTRUCTIONS CHEVY C-10 4-Link Rear End INSTALLATION INSTRUCTIONS 73-87 CHEVY C-10 4-Link Rear End Please read these instructions completely before starting your installation. Assemble suspension on vehicle before powder-coating to ensure proper

More information

2015+ Ford F-150 Off-Road Exhaust Kit

2015+ Ford F-150 Off-Road Exhaust Kit 2015+ Ford F-150 Off-Road Exhaust Kit Installation Instructions P/N: 421985 (1115-5E292ORR) Application: 2015+ Ford F-150 OFF-ROAD USE ONLY Important Note: Before installing the ROUSH Performance Product,

More information

Installation Instructions

Installation Instructions Equipment Required: Installation Instructions Fastener Kit: F Wrenches: 8mm, 13mm, 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill, Reciprocating Saw, File WARNING: Under no circumstances do we recommend

More information

Comfort Ride Shock absorber system part numbers 2450, 2460 and 2470 Installation Instructions

Comfort Ride Shock absorber system part numbers 2450, 2460 and 2470 Installation Instructions Comfort Ride Shock absorber system part numbers 2450, 2460 and 2470 Installation Instructions All specifications are subject to change without notice. MOUNTING FLANGE CENTER HOLE FRONT OF Item Qty Part

More information

»Product» Safety Warning

»Product» Safety Warning J1455, J1456 Installation Instructions 1984-2001 Jeep Cherokee XJ 4.5 Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information

INSTALLATION INSTRUCTIONS FOR FORD 4WD SUPER DUTY F COIL SPRING SUSPENSION SYSTEM

INSTALLATION INSTRUCTIONS FOR FORD 4WD SUPER DUTY F COIL SPRING SUSPENSION SYSTEM INSTALLATION INSTRUCTIONS FOR 2008-10 FORD 4WD SUPER DUTY F250-350 6 COIL SPRING SUSPENSION SYSTEM Requires the following parts (sold separately) for a complete installation: KIT PART NUMBER (6860) REQUIRES

More information

Technical Support Line: (952) Hanover Ave. Lakeville, MN

Technical Support Line: (952) Hanover Ave. Lakeville, MN Technical Support Line: (952) 985-5675 Email: Sales@QA1.net 21730 Hanover Ave. Lakeville, MN 55044 www.qa1.net INSTALLATION INSTRUCTIONS QA1 1967-1979 Mopar A-Body Rear 6 link Conversion System QA1 p/n

More information

Joy Rider Shock System Installation

Joy Rider Shock System Installation Joy Rider Shock System Installation Manufacturer s Part Numbers: 3 Inch Single Axle 200103 UPC 784672350945 2⅜ Inch Single Axle 200102 UPC 784672350921 Each single axle kit contains the following: 2 Shock

More information

08-10 F SUSPENSION KIT

08-10 F SUSPENSION KIT 92147800 Thank you for choosing Rough Country for your suspension needs. 08-10 F250 4.5 SUSPENSION KIT Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

09-12 Dodge 4WD Leveling Kit

09-12 Dodge 4WD Leveling Kit 9235900 09-12 Dodge 4WD 1500 2.5 Leveling Kit Thank you for choosing Rough Country for all your suspension needs. DOES NOT FIT TRX PACKAGE VEHICLES!! Rough Country recommends a certified technician install

More information

LIFT Drop Spindle Lift Kit E-Z-Go RXV Gas or Electric Installation Instructions

LIFT Drop Spindle Lift Kit E-Z-Go RXV Gas or Electric Installation Instructions LIFT-107 6 Drop Spindle Lift Kit E-Z-Go RXV Gas or Electric Installation Instructions Contents of LIFT-107 E-Z-Go RXV Drop Spindle Lift Kit: a (1 ea.) Driver Side Spindle b (1 ea.) Passenger Side Spindle

More information

INSTALLATION INSTRUCTIONS FOR PLEASE READ AND UNDERSTAND TERMS/POLICIES BEFORE YOU INSTALL THIS SYSTEM

INSTALLATION INSTRUCTIONS FOR PLEASE READ AND UNDERSTAND TERMS/POLICIES BEFORE YOU INSTALL THIS SYSTEM MOUNTAIN OFF ROAD ENTERPRISES. LLC. P.O. BOX 690 DELTA, COLORADO 81416 970-625-0500 E-mail: info@mountainoffroad.com www.mountainoffroad.com INSTALLATION INSTRUCTIONS FOR 8795-2 PLEASE READ AND UNDERSTAND

More information

»Product» Safety Warning

»Product» Safety Warning RBP-LK305-60 Installation Instructions 1999-2004 Ford Super Duty F-250/350 4wd 6" Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle.

More information

XJ CHEROKEE LIFT KIT

XJ CHEROKEE LIFT KIT 92162300 84-01 4.5 XJ CHEROKEE LIFT KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

Installation Instructions

Installation Instructions Installation Instructions For easy installation, you will need to: READ ALL the instructions completely before beginning. Have the necessary tools available Tools required: 1 1 1/16 wrench / socket 1 1

More information

C-10 Rear 4Link

C-10 Rear 4Link Part # 11367199-1973-1987 C10 Rear 4Link Recommended Tools 1973-1987 C-10 Rear 4Link Installation Table of contents Page 2... Included Components Page 3... Hardware List & Getting Started Page 4... Disassembly

More information

GM Street Scraper Instructions

GM Street Scraper Instructions GM 92-00 3500 Street Scraper Instructions 1. Remove bed from truck. 2. Using floor jack, jack up rear of truck at axle till the tires are off the ground. 3. Support truck at the frame in front of axle

More information

07-UP AVALANCHE 7.5 KIT

07-UP AVALANCHE 7.5 KIT 92120900R1 07-UP AVALANCHE 7.5 KIT Thank you for choosing Rough Country for your suspension needs. We appreciate your business!! This kit will not fit vehicles equipped with electric steering or trucks

More information

INSTALLATION INSTRUCTIONS FOR FORD 4WD SUPER DUTY F /2 COIL SPRING SUSPENSION SYSTEM

INSTALLATION INSTRUCTIONS FOR FORD 4WD SUPER DUTY F /2 COIL SPRING SUSPENSION SYSTEM INSTALLATION INSTRUCTIONS FOR 2005-07 FORD 4WD SUPER DUTY F250-350 4 1/2 COIL SPRING SUSPENSION SYSTEM Requires the following parts (sold separately) for a complete installation: KIT PART NUMBER (6345

More information

A i r R i d e C o n v e r s i o n S y s t e m I n s t a l l a t i o n I n s t r u c t i o n s. kelderman air ride

A i r R i d e C o n v e r s i o n S y s t e m I n s t a l l a t i o n I n s t r u c t i o n s. kelderman air ride A i r R i d e C o n v e r s i o n S y s t e m I n s t a l l a t i o n I n s t r u c t i o n s 800 334-6150 www.keldermanairride.com kelderman air ride The difference in the ride is like night and day Inside

More information

08-10 F OR 6 SUSPENSION KIT

08-10 F OR 6 SUSPENSION KIT 92159400 Thank you for choosing Rough Country for your suspension needs. 08-10 F250 4.5 OR 6 SUSPENSION KIT Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

NOTICE TO DEALER AND VEHICLE OWNER

NOTICE TO DEALER AND VEHICLE OWNER 921751200 *1751BAG1* 1751BAG1 Thank you for choosing Rough Country for all your suspension needs. This kit will fit both 4WD and 2WD models, all brackets will be used for 4WD models. On 2WD models the

More information

»Product» Safety Warning

»Product» Safety Warning #F1422 Installation Instructions 2008-2010 Ford Super Duty F250/350 4wd 4" Radius Arm Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of

More information

Installation Instructions

Installation Instructions Equipment Required: Installation Instructions Fastener Kit: F Wrenches: 8mm, 13mm, 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill, Reciprocating Saw, File WARNING: Under no circumstances do we recommend

More information

Installation Instructions

Installation Instructions Equipment Required: Fastener Kit: F Wrenches: 3/4, 15/16 Drill Bits: 1/4 Other Tools: Drill Short & Long Bed All Megacabs 9464/9474 HIDE-A-GOOSE HITCH INSTALLATION WARNING: Under no circumstances do we

More information

08-09 F250 8 SUSPENSION KIT

08-09 F250 8 SUSPENSION KIT 92159200 08-09 F250 8 SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

Ford Super Duty Recoil Traction Bar System. Part#: ,123409

Ford Super Duty Recoil Traction Bar System. Part#: ,123409 Part#: 123418,123409 Ford Super Duty Recoil Traction Bar System Rev. 011017 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 Web/live chat: www.bds-suspension.com. E-mail: tech-bds@sporttruckusainc.com

More information

05-07 F250 8 SUSPENSION KIT

05-07 F250 8 SUSPENSION KIT 92159000 05-07 F250 8 SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

09-12 Dodge 4WD /4 Body Lift

09-12 Dodge 4WD /4 Body Lift 92RC80000 09-12 Dodge 4WD 1500 1 1/4 Body Lift Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this kit. Attempts to install

More information

PRE-INSTALLATION Ford F150 4WD 4" Suspension Lift Kit

PRE-INSTALLATION Ford F150 4WD 4 Suspension Lift Kit 2009-2013 Ford F150 4WD 4" Suspension Lift Kit PRE-INSTALLATION 25007 2 - Knuckle (Driv/Pass) 2 - Crossmember (Front/Rear) 2 - Differential Bracket (Driv/Pass) 1 - Diff. Brace Bracket (Pass) 2 - Front

More information

INSTALLATION INSTRUCTION 88148

INSTALLATION INSTRUCTION 88148 INSTALLATION INSTRUCTION 88148 Rev C For Rancho Suspension Systems RS6548, RS6549 & RS6550: GM 2500HD, 2500, and 1500HD Trucks READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION

More information

*1234BAG1 1234BAG WD CHEVY/GM LIFT N200

*1234BAG1 1234BAG WD CHEVY/GM LIFT N200 *1234BAG1 1234BAG1 921234N200 99-06 2WD CHEVY/GM 1500 6 LIFT Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician installs this system.

More information

»Product» Safety Warning

»Product» Safety Warning #F1424 Installation Instructions 2011 Ford Super Duty F250/350 4wd 4" Radius Arm Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle.

More information

ReadyLift (Part# ) Lift Kit, Installation Instructions Toyota Tundra New Body Style 2WD & 4WD

ReadyLift (Part# ) Lift Kit, Installation Instructions Toyota Tundra New Body Style 2WD & 4WD SAFETY WARNING: recommends this system be installed by a professional technician. In addition to these instructions, professional knowledge of disassembly/ reassembly procedures and post installation checks

More information

INSTALLATION INSTRUCTIONS 89551

INSTALLATION INSTRUCTIONS 89551 INSTALLATION INSTRUCTIONS 89551 For Rancho Suspension System RS66551B: Ford F250, F350 Super Duty 4x4 DIESEL ONLY (Single Rear Wheels Only With or Without Auxiliary Spring). (WILL NOT WORK ON GAS ENGINES

More information

FRONT & 4 REAR GM WD LOWERING KIT

FRONT & 4 REAR GM WD LOWERING KIT 92725200 88-98 2 FRONT & 4 REAR GM 1500 2WD LOWERING KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition

More information

XJ CHEROKEE LIFT KIT

XJ CHEROKEE LIFT KIT 921633XN200 Thank you for choosing Rough Country for your suspension needs. 84-01 4.5 XJ CHEROKEE LIFT KIT Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

CLAYTON OFF ROAD COR JEEP GRAND CHEROKEE LONG ARM UPGRADE KIT ( WJ)

CLAYTON OFF ROAD COR JEEP GRAND CHEROKEE LONG ARM UPGRADE KIT ( WJ) CLAYTON OFF ROAD COR-4806011 JEEP GRAND CHEROKEE LONG ARM UPGRADE KIT (1999-2004 WJ) NOTES: This product requires general welding, fabrication and automotive mechanic skills. ing should only be done by

More information

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W Trailer Hitches 1216 Hawaii Rd / PO Box 186 Humboldt, KS P: F:

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W Trailer Hitches 1216 Hawaii Rd / PO Box 186 Humboldt, KS P: F: B&W Trailer Hitches 6 Hawaii Rd / PO Box 86 Humboldt, KS 6678 P:60.7366 F:60.73766 Turnoverball Gooseneck Hitch Installation Instructions MODEL 38 0 06

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 5052 AIR JACK 94-99 DODGE ½ TON RAM C-1500 Congratulations! You were selective

More information

2013-UP 3500 Dodge 5 Lift Kit SRW

2013-UP 3500 Dodge 5 Lift Kit SRW 92369200 2013-UP 3500 Dodge 5 Lift Kit SRW Thank you for choosing Rough Country Suspension for your Off Road needs. Rough Country recommends a certified technician installs this system. In addition to

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS --1075 North Ave. Sanger, CA 93657-3539 local: 559-875-0222 fax: 559-876-2259 toll free: 800-445-3767-- 6522 REAR AXLE FLIP & SHACKLE KIT 07-UP CHEVROLET 1500 REGULAR CAB ONLY

More information

07 & UP 4WD GM FRT 1.5 REAR LIFT KIT

07 & UP 4WD GM FRT 1.5 REAR LIFT KIT 92126900 Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician install this system. In addition to these instructions, professional knowledge of

More information

2011-UP CHEVY/GM 2500HD 2WD/4WD 5 NTD LIFT KIT

2011-UP CHEVY/GM 2500HD 2WD/4WD 5 NTD LIFT KIT 921260X00F *1260BAG6* 1260BAG6 2011-UP CHEVY/GM 2500HD 2WD/4WD 5 NTD LIFT KIT Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician installs

More information

»Product» Safety Warning

»Product» Safety Warning #F1420 Installation Instructions 2011 Ford Super Duty F250/350 4wd 4" Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information

4WD RANGER/BRONCO II WD EXPLORER CLASS II INSTALLATION INSTRUCTIONS

4WD RANGER/BRONCO II WD EXPLORER CLASS II INSTALLATION INSTRUCTIONS 4WD RANGER/BRONCO II 8-97 4WD EXPLORER 90-94 CLASS II INSTALLATION INSTRUCTIONS Before beginning the installation, read these instructions and the enclosed driver s WARNING NOTICE thoroughly and completely.

More information

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W

<THESE INSTRUCTIONS MUST BE GIVEN TO THE END USER> B&W B&W Trailer Hitches 6 Hawaii Rd / PO Box 86 Humboldt, KS 6678 P:60.7366 F:60.86.03 Turnoverball Gooseneck Hitch Installation Instructions MODEL 38 0 08

More information

»Product» Safety Warning

»Product» Safety Warning #F1410 Installation Instructions 2017 Ford Super Duty F250/350 4WD 4" Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information