Charging Li*gate Ba.eries Part 2 Seven Way Aux Pin Circuit Li*gate Ba.ery Charging Problems. May 21, :00 P.M. CDT Proprietary Informa/on
|
|
- Kristina Watson
- 6 years ago
- Views:
Transcription
1 Charging Li*gate Ba.eries Part 2 Seven Way Aux Pin Circuit Li*gate Ba.ery Charging Problems May 21, :00 P.M. CDT Proprietary Informa/on
2 About the Presenter Bruce Purkey Founder & Chief Crea4ve Engineer Bruce has over 40 years of experience servicing fleets electrical needs. Widely recognized as the authority on electrical issues in the heavy- duty trucking industry, Bruce has worked closely with some of the largest fleets in North America. Several of his invenyons have been awarded US patents and earned the Technology & Maintenance Council s Silver Spark Plug award, one of the highest honors awarded to members.
3 TC- 6 (P3000- K) Overview Li1gate Charging Webinar Part 2 TC- 6 (or P3000- K) A DC/DC charger that is only powered from the aux circuit of the seven way
4 ExisYng Charging Challenges Majority of truck load carriers have several trailers at every terminal that have li*gates These trailers cause operayon issues as they always require a tractor equipped with a synger cord to keep li*gate ba.eries charged If there are no tractors with synger cords available before routes, the trailer does not receive charge and li*gate failures could result
5 TC- 6 (P3000- K) SoluYon The TC-6 (or P3000-K) is the solution No synger cord is required Every tractor matches every trailer
6 P3000- K Diagram From Tractor Seven Way The power to the Trail Charger is provided via the aux (blue wire or middle pin) of the seven way cable
7 P3000- K Diagram This can be accomplished because the current load of the DC/DC converter is limited to 20+ amp Tractor s aux circuit is normally circuit protected to 30 amps
8 How It Works Trailer Seven Way Cable Tractor Output Ground TRAIL CHARGER Brake Aux Ground ABS MODULE Tractor ba.eries When the igniyon is in the run posiyon, the aux is powered it powers the trail charger
9 How It Works Trailer Seven Way Cable Tractor Output Ground TRAIL CHARGER Brake Aux Ground ABS MODULE Tractor ba.eries Shared Circuit The tractor and seven way cord is shared as it powers both the trailer ABS and trail charger
10 How It Works Trailer Seven Way Cable Tractor Output Ground TRAIL CHARGER Brake Aux Ground ABS MODULE Tractor ba.eries Not Shared Circuit Shared Circuit The trailer has two completely separate circuits that start at the aux pin
11 How It Works Trailer Seven Way Cable Tractor Output Ground TRAIL CHARGER Brake Aux Ground ABS MODULE Tractor ba.eries Not Shared Circuit Shared Circuit When the brakes are applied, the trail charger turns off and allows all power to go to trailer ABS module
12 TesYng Verifying the OperaYon
13 How to Test Step 1 (tractor off) with a voltmeter, test the li*gate ba.ery voltage
14 How to Test Step 2 Make sure the seven way is plugged into the trailer Now start the tractor
15 How to Test Step 3 Green LED light of DC/DC converter should turn on
16 How to Test Step 4 With a voltmeter, test the li*gate ba.ery voltage You should see an increase in voltage
17 How to Test Step 5 With an ammeter, test the amp flow from the #2 pin of the DC/DC converter that connects to the circuit protecyon lead to the li*gate ba.eries
18 How to Test Step 6 If you see an increase in voltage and amp flow, the system is working In this example, voltage increased from 12.5 to amp flow increased from 0 to 23.61
19 Possible Issues TroubleshooYng
20 Possible Issues with Tractor DC/DC Indicator Light: No Light Condi4on: No Voltage from Tractor Test and Repair/Fix: With Voltmeter, test the seven way receptacle (at trailer end). Replace tractor fuse or circuit breaker, repair or replace seven way cord, or repair wiring in tractor.
21 Possible Issues with Trailer DC/DC Indicator Light: No Light Condi4on: No Voltage from Trailer Test and Repair/Fix: Check input in li*gate ba.ery box. Replace the fuse in the nose box or repair the trailer wiring as needed.
22 Possible Issues with Load DC/DC Indicator Light: Green light then two red lights, (then it repeats) Condi4on: Excessive voltage drop within the system Test and Repair/Fix: Check voltage while under load at seven way nose box. Repair or replace as needed. Test trailer wiring and repair as necessary.
23 Possible Issues with DC/DC Converter DC/DC Indicator Light: Green light on, but no voltage increase at li*gate ba.eries or any current flow Condi4on: Blown fuse or tripped circuit Breaker on output lead from DC/DC Converter Test and Repair/Fix: Make sure the output lead is not grounded, then replace fuse or reset the circuit breaker
24 Possible Issues with Li*gate Ba.eries DC/DC Indicator Light: Green light on with low voltage and high current Condi4on: Deeply discharged or defecyve li*gate ba.eries Test and Repair/Fix: Charge, then test each of the li*gate ba.eries and replace as needed
25 Possible Issues with Brake Circuit DC/DC Indicator Light: Solid green LED light Condi4on: No signal from brake circuit Test and Repair/Fix: Blown fuse in seven way nose box or damaged brake wire Test and Repair/Fix:
26 Possible Issues with Brake Signal DC/DC Indicator Light: Green LED light slowly blinking Condi4on: ConYnue signal to brake lockout pin Test and Repair/Fix: Brake signal connected wrong. Check to see where the wire is connected.
27 Conclusion Don t Miss Our Next Webinar Charging Li*gate Ba.eries Part 3 Dual Pole Powered with Extender (TC- 5) Wednesday, June 18 12:00 P.M. CDT Signup for Our Weekly E- Newsle.er Case Studies About Charging Li*gate Ba.eries Tips and Tricks About Charging Li*gate Ba.eries More Valuable InformaYon for Trucking Fleets
28
Charging Liftgate Batteries Part 4 Automatic Single Pole, Dual Pole, or Seven Way Aux Pin Powered Circuit (TC-8) July 16, :00 P.M.
Charging Liftgate Batteries Part 4 Automatic Single Pole, Dual Pole, or Seven Way Aux Pin Powered Circuit (TC-8) July 16, 2014 12:00 P.M. CDT Proprietary Information About the Presenter Bruce Purkey Founder
More informationTRAIL CHARGER BASED CHARGING SOLUTIONS
TRAIL CHARGER BASED CHARGING SOLUTIONS The Challenge Keeping Auxiliary Liftgate Charged The performance and proper function of a liftgate depends on an adequately charged auxiliary battery pack. The issue:
More information3 in 1 TRAIL CHARGER with LOCKOUT
Owner s Manual P/N: 283821 500 3 in 1 TRAIL CHARGER with LOCKOUT 283821 01 Version 2.04 07/05/2011 Owners Manual Operation Installation Wiring Diagram Troubleshooting Parts Breakdown 1 GENERAL OPERATION
More informationSELECT DIAGNOSTIC GUIDE. INST028 Doc 3.02
SELECT DIAGNOSTIC GUIDE INST028 Doc 3.02 CONTENTS General Information...2 Select Call-Outs...3 Wire Diagram and Legend...4 Diagnostics...6 Excessive Voltage Drop Diagnostics...6 Static Diagnostics...7
More informationINSTRUCTION PLASTIC BATTERY BOX & CHARGER KIT
LIFT CORPORATION Sht. 1 of 9 DSG# M-11-09 Rev. B Date: 08/12/13 INSTRUCTION PLASTIC BATTERY BOX & CHARGER KIT KIT P/N 285131-01 NOTE: Parts shown on sheets 1 and 2 are shipped as loose parts. Electrical
More informationTRAIL CHARGER with EXTENDER and COMBO NOSE BOX
TRAIL CHARGER with EXTENDER and COMBO NOSE BOX 284424 01 Version 1.02 03/14/2011 Owners Manual Operation Installation Wiring Diagram Troubleshooting Parts Breakdown 1 GENERAL OPERATION PROBLEM On applications
More informationFundamentals of Multimeter Training
Fundamentals of Multimeter Training House Cleaning REMINDER: This Webinar is being Recorded Please Turn Off Cell Phones net About the Presenter Larry Rambeaux Senior Account Representative Larry has over
More informationSELECT-32 V1.10 OWNERS MANUAL MAXON#
MAXON# 296170-500 1 SELECT DUAL POLE COMBINATION, REEFER AND 7 WAY OPTION CONTENTS General Information...2 Select-32 Diagram...3 Select Controller Mounting Instructions...4 Dual/Single Nose Box Installation...5
More informationProduct Catalog. To place an order or, for more information,
Product Catalog To place an order or, for more information, email Fleets today face lots of challenges. Driver retention. A shrinking pool of technicians. Increased competition. Increased regulation. The
More informationService Manual for Battery Control Center
Service Manual for Battery Control Center P/N 82 E0071 00 (Ref. 81 1317) June, 1999 Battery Control Box Operation Charging Circuit This function charges the coach battery from the engine alternator while
More informationSELECT -24 INSTALLATION GUIDE. INST036 Doc 2.02
SELECT -24 INSTALLATION GUIDE INST036 Doc 2.02 CONTENTS General Information...2 Select-24 Diagram...3 Mounting the Select Controller...4 Dual Pole Nosebox Installation...5 Aux Harness Installation...6
More informationSELECT/DIRECT DEMO BOX USER GUIDE. INST164 Doc 1.00
SELECT/DIRECT DEMO BOX USER GUIDE INST164 Doc 1.00 CONTENTS Using the Demo Box...2 Direct Dual Pole (Stinger) Demonstration...5 Select Dual Pole, Reefer, or Aux Demonstration...6 Switch Board Callouts...7
More informationEAVERLINE. Operator s Manual. Series 5 Feed Cart Models 521, 525, 531 & 537. Weaverline, LLC - Churchtown, PA 17555
EAVERLINE Operator s Manual Series 5 Feed Cart Models 521, 525, 531 & 537 CAUTION: Drive at a speed slow enough to ensure safety and complete control at all times. CAUTION: Know the controls and how to
More informationIMPORTANT SAFETY INSTRUCTIONS
1163714 1.5 AMP 12VOLT TRICKLE 1.5 AUTOMATIC AMP AUTOMATIC TRICKLE 1.5 AMP AUTOMATIC 12V12VOLT BATTERY CHARGER IMPORTANT SAFETY INSTRUCTIONS 1. SAVE THESE INSTRUCTIONS This product offers a wide range
More informationST Charger. Industrial Battery Charger
ST Charger Industrial Battery Charger Installation and Operation Manual ST_13 Table of Contents Pg# 1.0 INSTALLATION 1 1.1 Receiving 1 1.2 Location 1 1.3 Line Voltage 1 1.4 A.C. Service Requirements 2
More informationTRAILER AUXILIARY POWER SYSTEM (TAPS) INSTALLATION GUIDE V1.10
TRAILER AUXILIARY POWER SYSTEM (TAPS) INSTALLATION GUIDE V1.10 TAPS INSTALLATION GUIDE V1.10 1 TRAILER AUXILIARY POWER SYSTEM CONTENTS General Information and System Logic... 2 Diagrams... 3 System Diagram
More informationINSTRUCTION, TRAIL CHARGER KIT P/N
LIFT CORPORATION Sht. 1 of 8 DSG# M-05-03 Rev. A Date: 01/20/06 INSTRUCTION, KIT P/N 267370-01 ASSEMBLY P/N 267369-01 FUSE & FUSE HOLDER ASSEMBLY P/N 267376-01 COVER () P/N 267522-01 DC-DC P/N 906484-01
More informationDC TO AC 1500 WATT POWER INVERTER
Product Catalog Fleets today face lots of challenges. Driver retention. A shrinking pool of technicians. Increased competition. Increased regulation. The list goes on and on. Fleets are doing everything
More informationOPERATOR S MANUAL. Mobile Universal Trailer Tester #9102 HEAVY RANGER MUTT. Limited One Year Warranty Satisfaction Guaranteed
Limited One Year Warranty Satisfaction Guaranteed #9102 HEAVY RANGER MUTT Mobile Universal Trailer Tester Innovative Products of America Incorporated has established a Limited One Year Warranty Policy
More informationThunder Power Tarp Kit Operation Guide
Thunder Power Tarp Kit Operation Guide Dual Arm Curb Side Stowing Single Arm Curb Side Stowing Flex Arm Curb Side Stowing REV - B 1/13/17 2 P a g e USE THE PROCEDURES BELOW TO OPERATE THE TARP SYSTEM Powering
More informationLESTRONIC II BATTERY CHARGER TAYLOR-DUNN MODEL TYPE 24LC25-8ET
LESTRONIC II BATTERY CHARGER TAYLOR-DUNN 79-301-10 MODEL 13110-32 TYPE 24LC25-8ET AC Supply: DC Output: Battery Capacity: Specifications 120 volts, 60 Hertz, single-phase 24 volts, 32 amps Use only on
More informationONE TOUCH CONTROL BOX
ONE TOUCH CONTROL BOX CONVERSION KIT INSTRUCTIONS REMOVAL, INSTALLATION, OPERATION, AND REMOTE CONTROL PROGRAMMING THUNDERSTONE PART #101322 REVISION A JULY 14 TH 2016 2 P a g e INSTALLING THE THUNDER
More informationIMPORTANT! Remote Control Instructions
Remote Control Instructions FOR New Tarp Remote Control Installation Use these in place of the rocker switch and solenoid section of instructions in your roll tarp owner s manual. FOR Existing Electric
More informationA DANGER. jshivvers/ location, it will need to be relocated, possibly into another enclosure. CELL CONDUIT LOCK NUT REMOVE KNOCK-OUT PLUG CORD GRIP
jshivvers/ SHIVVERS LINK 641AE-001A (2G/3G) OR 641AU-001A (4G) FIELD INSTALLATION INSTRUCTIONS FOR COMMAND CENTER (SEE NEXT SECTION FOR CONVERT INSTALLATION) A DANGER DISCONNECT AND LOCK OUT POWER TO THE
More informationMODEL H INSTALLATION INSTRUCTIONS
WWW.BURCAM.COM 2190 Boul. Dagenais West TEL: 514.337.4415 LAVAL (QUEBEC) FAX: 514.337.4029 CANADA H7L 5X9 info@burcam.com Your unit has been carefully packaged at the factory to prevent damage during shipping.
More information0500 Low Voltage on the Battery or Dead Cell in the Battery
0500 Low Voltage on the Battery or Dead Cell in the Battery Whenever you press the remote transmitter and you get one short beep from the control box, you press the remote and hear a warning buzzer but
More informationA Seven-Step Inspection Method Method of Inspection.
A Seven-Step Inspection Method Method of Inspection. You should do a pre-trip inspection the same way each time so you will learn all the steps and be less likely to forget something. The following seven-step
More informationReproduction. Not for ADVANCE PRODUCT SERVICE INFORMATION INFORMATION BULLETIN NO: 36 DATE: 11/27/02 SUBJECT: POWERLINK SYSTEM
ADVANCE PRODUCT SERVICE INFORMATION INFORMATION BULLETIN NO: 36 DATE: 11/27/02 SUBJECT: POWERLINK SYSTEM FILE IN: INTEK & VANGUARD REPAIR MANUAL GFCI Inverter Stator POWERLINK Harness Reset ON OFF Switch
More informationEquipment Register. Purchased from: Date of purchase: Serial Number:
RVCHECK User s Guide Equipment Register Purchased from: Date of purchase: Serial Number: Thank You For buying an RVcheck Using your RVcheck is so easy it s almost intuitive. Still, we encourage you to
More informationOPERATOR'S MANUAL IMPORTANT SAFETY INSTRUCTIONS
ASSOCIATED OPERATOR'S MANUAL IMPORTANT SAFETY INSTRUCTIONS MODEL 6366 12 VOLT, 0-20 AMP 4 X 20 BATTERY CHARGER 1. SAVE THESE INSTRUCTIONS. This manual contains important safety and operating instructions
More informationPORTABLE POWER SUPPLY MODEL NUMBER VMS-1 VERSION 1.0
PORTABLE POWER SUPPLY MODEL NUMBER VMS-1 VERSION 1.0 MM September 21, 2012 TABLE OF CONTENTS Section Number DANGER INTRODUCTION AND TECHNICAL SPECIFICATIONS 1 CONTROL AND METERING DESCRIPTION 2 OPERATION
More informationQPET, QPETXU Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S QPET, QPETXU Battery Chargers INTRODUCTION: The QPET line of chargers are designed for general purpose deep cycle batteries. They are an electronically
More informationSURE TRIP SLT-201 SECONDARY TEST SET
1 SURE TRIP SLT-201 SECONDARY TEST SET SURE TRIP, INC 703-A CONCORD ROAD ALBEMARLE, NORTH CAROLINA 28001 TOLL FREE: (877) 382-5864 (800) 382-5864 FAX: (905) 315-8892 (704) 983-6128 E MAIL: SURETRIP@suretrip.com
More informationDigitrip Retrofit System for ITE K-3000, K-3000 S, K-4000 and K-4000 S Breakers
Supersedes IL 33-858-4 Dated 05/02 Digitrip Retrofit System for ITE K-3000, K-3000 S, K-4000 and K-4000 S Breakers Digitrip Retrofit System for ITE K-3000, Digitrip Retrofit System for ITE K-3000, K-3000
More informationInstallation Instructions
30RAP010-150, 38APS05-065, 38APD05-130 Ground-Fault Interrupter Convenience Outlet Accessory Installation Instructions Part No. 30RA-900---058, 30RA-900---059 SAFETY CONSIDERATIONS Installation of this
More informationSOLAR BOLT CHARGING SYSTEM INSTALLATION GUIDE
CHARGING SYSTEM Doc 1.00 INST052 1 SOLAR BOLT CHARGING SYSTEM CONTENTS General Information... 2 Solar Panel Installation... 3 Solar Bolt Main Harness and Indicate Installation... 4 Cable Routing... 9 Solar
More informationSTEP-BY-STEP INSTALLATION GUIDE
Battery Backup System STEP-BY-STEP INSTALLATION GUIDE Operating Instructions & Parts Manual ESP25 Please read and save these instructions. Read carefully before attempting to assemble, install, operate
More informationOPERATOR S MANUAL. Mobile Universal Trailer Tester #9101 LIGHT RANGER MUTT LIMITED ONE YEAR WARRANTY SATISFACTION GUARANTEED
LIMITED ONE YEAR WARRANTY SATISFACTION GUARANTEED #9101 LIGHT RANGER MUTT Mobile Universal Trailer Tester Innovative Products of America Incorporated has established a Limited One Year Warranty Policy
More informationSwitching DC Power Supply
99 Washington Street Melrose, MA 02176 Phone 781-665-1400 Toll Free 1-800-517-8431 Visit us at www.testequipmentdepot.com Model 1693, 1694 Switching DC Power Supply INSTRUCTION MANUAL 1 Safety Summary
More informationT-Dolly Troubleshooting Guide
T-Dolly Troubleshooting Guide Complete following items before beginning troubleshooting 1. Place wheel chocks and jack stands in place per the BLOCKING DIAGRAM decal. Located on the underside of the pump
More informationBattery Control Center - Diesel
Service Manual CAUTION: All servicing of the Battery Control Center should be done only by a qualified Service Technician. Inadvertent shorts inside the Battery Control Center could result in severe damage
More informationOBAE, OBAEXU, ON BOARD Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S OBAE, OBAEXU, ON BOARD Battery Chargers INTRODUCTION: The OBAE line of chargers are designed for the permanent installation on battery powered
More informationElectrical Circuits Discussion Questions:
Electrical Circuits Discussion Questions: 1) What is electricity? 2) How does an electrical circuit work? 3) What types of materials conduct electrical energy? 4) How is electrical energy measured? 5)
More informationTethered Trailer Tracks (TT100) Quick Installation Guide
Tethered Trailer Tracks (TT100) Quick Installation Guide Table of Contents 1) Introduction... 1 Supported Hardware... 1 Firmware Requirements... 1 2) Fuse Kit Installation... 2 3) Installing the TT100
More informationBattery. Charger Model: Save Important Safety Instructions
Owner's Manual Battery Charger Model: SS-51A-PE, 10 Amp Fully Automatic Battery Charger For 12 Volt Marine Deep Cycle & Automotive Batteries Save Important Safety Instructions Read Rules for Safe Operation
More informationTC1000 Service Manual SALES: CUSTOMER SERVICE:
TC1000 Service Manual SALES: 800-278-3933 CUSTOMER SERVICE: 800-745-1373 Table of Contents Section Page I. Overview 2 II. Troubleshooting Tables 3 III. Maintenance Procedures Procedure 1 Removal and Reinstallation
More informationELECTRICAL. CDTA Technical Training Center
ELECTRICAL ATOMIC STRUCTURE Protons positive charge Electron negative charge Neutron - neutral Electricity is the movement of electrons from atom to atom ELECTRON FLOW CONDUCTOR - Materials which have
More informationGround Control 3.0 Landing Gear
Ground Control 3.0 Landing Gear OEM INSTALLATION MANUAL Rev: 12.28.2017 Page 1 TABLE OF CONTENTS Safety and System Information 2 Installation 3 Landing Gear 3 Wiring Landing Gear 4 Wiring Diagram 5 Operation
More informationDIRECT PLUS/FLEX/MAX INSTALLATION GUIDE. INST165 Doc 1.04
DIRECT PLUS/FLEX/MAX INSTALLATION GUIDE INST165 Doc 1.04 CONTENTS General Information...2 Diagrams...3 Mounting the Direct Nosebox...5 Main Harness Installation...6 Interior Light Harness Installation...10
More informationStudent Exploration: Advanced Circuits
Name: Date: Student Exploration: Advanced Circuits [Note to teachers and students: This Gizmo was designed as a follow-up to the Circuits Gizmo. We recommend doing that activity before trying this one.]
More information1. INTRODUCTION AND SYSTEM DESCRIPTION SPECIFICATIONS... 5
TABLE OF CONTENTS 1. INTRODUCTION AND SYSTEM DESCRIPTION... 4 2. SPECIFICATIONS... 5 2.1 CURRENT CAPACITY:... 5 2.2 VOLTAGE MEASUREMENT CAPACITY:... 5 2.3 VOLTAGE SOURCE:... 5 2.4 SHUNT:... 5 2.5 METERS:...
More informationR800-16PCPS DUAL REDUNDANT POWER SUPPLY FOR THE R RACK USER MANUAL
R800-16PCPS Manual 1 R800-16PCPS DUAL REDUNDANT POWER SUPPLY FOR THE R800-16 RACK USER MANUAL R800-16PCPS Manual 2 R800-16PCPS DUAL REDUNDANT POWER SUPPLY USER S MANUAL DRAWING # A00728 Rev. A GDI Communications,
More informationGround Control 3.0 Landing Gear OEM INSTALLATION MANUAL
Ground Control 3.0 Landing Gear OEM INSTALLATION MANUAL TABLE OF CONTENTS Safety and System Information 2 Installation 3 Landing Gear 3 Wiring Landing Gear 4 Wiring Diagram 5 Operation 6 Prior to Operation
More informationInstallation recommendations
Installation recommendations Solution A Solution B iluxx Lighting Inc, Qc Canada, www.iluxxinc.com Page 1 of 5 Additional Info iluxx Lighting Inc, Qc Canada, www.iluxxinc.com Page 2 of 5 Use the following
More informationAIRSTREAM - BATTERY CONTROL CENTER - Diesel
P/N 00-00755-000 CAUTION: The Battery Control Center is a centralized power switching, fusing, and distribution center. Power from both the chassis and coach batteries is fed into the box. The full power
More informationMODEL AP/W HIGH VOLTAGE HOLIDAY DETECTOR (NEW PRODUCT RELEASE 2015)
MODEL AP/W HIGH VOLTAGE HOLIDAY DETECTOR (NEW PRODUCT RELEASE 2015) ALWAYS CONNECT CABLES PRIOR TO POWERING ON THE INSTRUMENT 1. HOLIDAY DETECTOR FUNCTION The Tinker & Rasor Model AP/W Holiday Detector
More informationHouston Office Corpus Christi Branch Dallas Branch 248 McCarty Dr Westway 4770 Gretna P.O. Box P.O. Box 5036 Dallas, TX 75207
-Instructions for AP/W & AP (to serial# 8043) Holiday Detectors- WARNING!!!! THISTYPE HOLIDAY DETECTOR GENERATES HIGH VOLTAGES.THE OUTPUT VOLTAGES GENERATED, ARE WITHIN THE SAFE LIMITS OF FATAL "SHOCKHAZARD"
More informationUser s Manual. Automatic Switch-Mode Battery Charger
User s Manual Automatic Switch-Mode Battery Charger IMPORTANT Read, understand, and follow these safety rules and operating instructions before using this battery charger. Only authorized and trained service
More informationCABINET REEL OPERATING INSTRUCTIONS
CABINET REEL OPERATING INSTRUCTIONS MODELS 15, 25, 40 & 60 SERIES RAPID-AIR CORPORATION 4601 KISHWAUKEE ST. ROCKFORD, IL 61109-2925 Phone: (815) 397-2578 Fax: (815) 398-3887 Web Site: www.rapidair.com
More informationJazzy 1122 Wheelchair Trainer: Owner s Manual
Jazzy 1122 Wheelchair Trainer: Owner s Manual KEYED IGNITION The keyed Ignition allows for more control and safety over your wheelchair trainer. With the trainer being inoperable without the key engaged
More informationNorthwest RV Supply Manual Compliments of Printed From TROUBLESHOOTING
TROUBLESHOOTING for the 5 BUTTON 3109228.001 COMFORT CONTROL CENTER SYSTEM INTRODUCTION The Comfort Control Center control system can be used to operate the following Duo-Therm Units: Roof Top Air Conditioners
More informationElectricity Merit Badge
Electricity Merit Badge Class 4 Safety at Home June 13, 2017 Electricity Merit Badge Class 4 2017 National Scout Jamboree 1 Classes Class 1 Basics Electricity Class 2 Magnetism Class 3 Electric Power,
More informationOn-Board Battery Charger Kit
Page1of6 On-Board Battery Charger Kit Models: 5680 / 5700 The following On- board Battery Charger information is not included in your Operator or Parts List manuals. Please keep this information with your
More informationQSSE, QSSEX INDUSTRIAL Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S QSSE, QSSEX INDUSTRIAL Battery Chargers INTRODUCTION The QSE line are electronically controlled float chargers. The batteries are brought
More informationEnerdrive Lithium-Ion Battery System
Enerdrive Lithium-Ion Battery System After 2 years of research, testing and proving, and a further 2 years of infield sales, Enerdrive has designed and created a COMPLETE Lithium Battery & Installation
More informationBMF TROUBLESHOOTING GUIDE
BMF TROUBLESHOOTING GUIDE This document contains troubleshooting guidelines for PEP's standard BMF filters with pumps. REFERENCE DOCUMENTS: W-X-0039 BMF Electrical Wiring Drawing WP0011 BMF Control Panel
More informationLPC 20 MODEL #: LOW PROFILE CHARGER AUTOMATIC SINGLE OUTPUT BATTERY CHARGER INSTRUCTION MANUAL
INSTRUCTION MANUAL LPC 20 LOW PROFILE CHARGER AUTOMATIC SINGLE OUTPUT BATTERY CHARGER Unit supplied with one of these displays MODEL #: 091-207-12 INPUT: 120 Volt, 50/60 Hz, 7 Amps OUTPUT: 20 Amps File:
More informationGrind Pro Series. Operator Manual. Manufacture by:
Grind Pro Series Operator Manual Manufacture by: 1 Bench Sander Series INTRODUCTION The Bench Sander series are compact, durable machine designed for fast, complete finishing work. It will deliver efficient,
More informationCAPACITOR ACTUATED PORTABLE STARTER CAPS USER GUIDE. INST048 Doc 3.01
CAPACITOR ACTUATED PORTABLE STARTER CAPS USER GUIDE INST048 Doc 3.01 CONTENTS General Information...2 Charts...3 Before First Use...4 Safety Requirements...5 What to Expect from the CAPS...5 CAPS Diagram...6
More informationTroubleshooting Title of Bulletin guide for single phase GFCIs Manual machines
Bulletin Number: TB084 Type of Bulletin: Informational Products Affected: Manual TracStars: 250/28, 412/618, 500 series II and III. Rolling 412/618 Date of Notification: October 22, 2012 Reason for Bulletin
More informationInstalling and Removing Power Supplies
Power Supply Overview, page 2 Installing Power Supplies, page 3 Removing Power Supplies, page 8 Finding the Serial Number, page 9 1 Power Supply Overview Power Supply Overview You can install two types
More informationAGRI-COVERTM SWITCH CONTROL INSTRUCTIONS
AGRI-COVERTM SWITCH CONTROL INSTRUCTIONS Use these instructions in place of the rocker switch and solenoid sections in your roll tarp or ROLTECTM Electric Hopper Conversion instructions. Some installs
More informationDP140e. Installation & Operations Manual
Installation & Operations Manual DP140e System Engineering International SEI Incorporated 5115 Pegasus Court, Suite Q Frederick, MD 21704 Phone 301-694-9601 / 800-765-4SEI Fax 301-694-9608 Web http//www.seipower.com
More informationA system fault contribution of 750 mva shall be used when determining the required interrupting rating for unit substation equipment.
General Unit substations shall be 500 kva minimum, 1500 kva maximum unless approved otherwise by the University. For the required configuration of University substations see Standard Electrical Detail
More informationProblems with your 12/24V Booster?
Problems with your 12/24V Booster? Check this Trouble Shooting Manual for your answer 1. Tools Required 2. First Tests to conduct 2.1 Measure the Voltage at the Clamps 2.2 Testing the power (Amps) 3. Testing
More information24 VOLT AUTOMATIC BATTERY CHARGER PART NO
24 VOLT AUTOMATIC BATTERY CHARGER PART NO. 957732 AC Input: DC Output: Battery Type: Specifications 230 volts, 50 hertz, 3.5 amps, single-phase 24 volts, 20 amps initially tapering to 6 amps 24 volt, 12
More information2015 EDITION SUBMERSIBLE MOTORS AIM MANUAL. APPLICATION INSTALLATION MAINTENANCE 60 Hz, Single-Phase and Three-Phase Motors. franklinwater.
0 EDITION AIM MANUAL SUBMERSIBLE MORS APPLICATION INSTALLATION 60 Hz, Single-Phase and Three-Phase Motors franklinwater.com All Motors System Troubleshooting Motor Does Not Start A. No power or incorrect
More informationOBE, OBEXU, ON BOARD Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S OBE, OBEXU, ON BOARD Battery Chargers INTRODUCTION: These chargers are designed for the permanent installation on battery powered vehicles
More informationTroubleshooting Guide: 255 LED Light
Troubleshooting Guide: 255 LED Light Note Use only factory replacement lights (refer to parts list for order number). Caution Carefully handle parts near membranes and wire harnesses. Allow the light to
More informationHPP1 MK5 Owner s Manual
J Wolmarans Page 1 2016/09/15 Page 1 of 9 TABLE OF CONTENTS Page 1 Introduction...2 2 Models...2 3 Safety warnings...3 4 Contents...3 5 Installation...3 5.1 Mounting the unit:...3 5.2 Connecting the battery:...3
More information1. Take the cover off the relay, taking care to not shake or jar the relay or other relays around it.
RC SCOPE This test procedure covers the testing and maintenance of Westinghouse RC relays. The Westinghouse Protective Relay Division was purchased by ABB, and new relays carry the ABB label. Refer to
More informationTJM Products Pty Ltd Robinson Rd 150 AU-4034 Geebung/Brisbane QLD. TJM In-Car Charger with DC/DC-Converter Manual. TJM-DBM_en_v2.2.1.
TJM Products Pty Ltd Robinson Rd 150 AU-4034 Geebung/Brisbane QLD TJM In-Car Charger with DC/DC-Converter Manual TJM-DBM_en_v2.2.1.doc 1 Table of Content Product Description... 3 Warning... 3 Applications...
More informationSection Five - Troubleshooting Procedures
Section Five - Troubleshooting Procedures Note: This section contains troubleshooting procedures specific to the C96X family of treadmills. Please refer to the troubleshooting procedures in the commercial
More informationPOWERLINE 2000 Energy Management System TM
Display Panel TM The PowerLine 00 EMS is a specialized power distribution and energy management system intended to be used in recreational vehicles. The Control Module is housed in the standard main distribution
More informationManaging Electric Vehicle Supply Equipment (EVSE) Installations
Managing Electric Vehicle Supply Equipment (EVSE) Installations Introduction to Electric Vehicle EVSE Electric vehicles create a need to build an infrastructure that will supply the added load of charging.
More informationMODEL 6010A 6 12 VOLT BATTERY CHARGER ASSOCIATE
MODEL 600A 6 VOLT BATTERY CHARGER ASSOCIATE IMPORTANT SAFETY INSTRUCTIONS. SAVE THESE INSTRUCTIONS. This manual contains important safety and operating instructions for the battery charger you have purchased.
More informationUser Manual 123electric Battery Management System 123\BMS Revision 1.4 Augusts 2015
User Manual 123electric Battery Management System 123\BMS Revision 1.4 Augusts 2015 Table of contents Introduction... 3 System structure... 3 Keep the batteries in a perfect condition : ALWAYS!... 5 Specifications...
More informationProfessional Séries. Professional Séries. Model T03828 SUBMERSIBLE SUMP DUPLEX SYSTEM SUBMERSIBLE SUMP DUPLEX SYSTEM. 1/3HP 2400 GPH Head of 20 (6 m)
Model T0828 Primary pump 1/HP 200 GPH Head of 20 (6 m) SUBMERSIBLE SUMP DUPLEX SYSTEM Professional Séries Discharge: 1 1/2 ABS DWV pipe Electric cable: 9 piggyback type Oil cooled Cast iron construction
More informationTroubleshooting Guide
Troubleshooting Guide P/N 0153180 July 1999 P.O. Box 1160 St. Joseph, MO 64502-1160 1-800-255-0317 Fax: 816-360-9379 www.snorkelusa.com GENERAL INFORMATION This manual contains procedures for locating
More informationDor-O-Matic. Series Slide Control. Installation Instructions
Dor-O-Matic Series 96000 Slide Control Installation Instructions DOR - O MATIC 7350 W. Wilson Ave. Harwood Heights, IL 60706 Toll Free: 1-800-543-4635 In Illinois: 708-867-7400 Sales FAX: 708-867-0291
More informationMASTER SALT SAND SPREADER WIRELESS CONTROL MANUAL
MASTER SALT SAND SPREADER WIRELESS CONTROL MANUAL This manual covers 1. Gas spreader wireless controllers (Standard) 2. Gas spreader wireless controllers (Plus) 3. 600DC single motor spreader wireless
More informationThe X, Y, and Z of Circuit Breaker Control
The X, Y, and Z of Circuit Breaker Control BRENT L. CARPER, P.E. Principal Engineer Presented at the 35th Annual Hands-On Relay School March 12-16, 2018 Agenda Importance of Breaker Control The IEEE C37.11
More informationPower Distribution System User s Manual. Model: PDS-100
Power Distribution System User s Manual Model: PDS-0 Section Page Product Overview... 1 I) General Information... 2 II) Important Safety Information... 2 III) Installation... 3 A) Materials Provided...
More informationEnglish - Español - Français - Deutsch - Italiano
English - Español - Français - Deutsch - Italiano INTRODUCTION Thank you for purchasing Power Probe products. The Power Probe is the best professional electrical tester for reducing diagnostic time in
More informationSWITCH MODE BATTERY CHARGER
CURTIS INSTRUMENTS, INC. 200 Kisco Avenue, Mt. Kisco, NY 10549 Tel: (914) 666-2971 FAX (914) 666-2188 www.curtisinst.com MANUAL 1620 SWITCH MODE BATTERY CHARGER MODEL Applicable to 230VAC units only is
More informationAUTO CHARGE DUAL MODEL #: AUTOMATIC DUAL OUTPUT BATTERY CHARGER INSTRUCTION MANUAL. Ph: Fax:
INSTRUCTION MANUAL AUTO CHARGE DUAL AUTOMATIC DUAL OUTPUT BATTERY CHARGER MODEL #: 091-145-12 INPUT: 120 Volt, 50/60 Hz, 3.5 Amps OUTPUT BAT 1: 10 Amps OUTPUT BAT 2: 10 Amps File: IM_091-145-12_revb.indd
More information36 VOLT AUTOMATIC BATTERY CHARGER PART NO
36 VOLT AUTOMATIC BATTERY CHARGER PART NO. 957727 AC Supply: DC Output: Battery Type: Specifications 120 volts, 60 Hertz, 10 amps, single-phase 36 volts, 20 amps initially tapering to 6 amps 36 volt, 18
More informationSeal Beach Police Department
Seal Beach Police Department Emergency Services Trailer Operating Manual Prepared by the Seal Beach/Los Alamitos RACES Group Rick Shab, KB6VCM and Mike Maronta KC6YNQ Emergency Services Trailer Page 1
More informationPUMP PLUS 2000 PLC MODEL #: PP AUTOMATIC DUAL OUTPUT BATTERY CHARGER INSTRUCTION MANUAL
INSTRUCTION MANUAL PUMP PLUS 2000 PLC AUTOMATIC DUAL OUTPUT BATTERY CHARGER Supplied with Dual Bar Graph Display MODEL #: 091-237-12-PP INPUT: 120 Volt, 60 Hz, 3.5 Amps OUTPUT BATTERY 1 and 2: 15 or 18
More informationPowerMax. Power Distribution System. Operation Manual Version 1.0 Copyright 2003 Professional Sound Corporation Printed in the U.S.A.
PowerMax Power Distribution System Operation Manual Version 1.0 Copyright 2003 Professional Sound Corporation Printed in the U.S.A. Thank you for purchasing the Professional Sound Corporation PowerMax
More information