CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

Size: px
Start display at page:

Download "CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation."

Transcription

1 CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description for Serial Numbers: Serial Number Location - Rear Cabinet top right hand side. Example: 0192A Month MFG. 92 Year MFG. A Serial Rev Number of Units Built. NOTES: MRC-400/450 WITH A DATE CODE OF XX92 AND EARLY XX93 MAY HAVE THE LETTERS A, B, OR C. THESE ARE SERIAL A UNITS. PLEASE CONFIRM BY CHECKING SOFTWARE LEVEL, SEE BELOW. SERIAL A SOFTWARE STARTS WITH 1. XX ON POWER UP. KEY NS = Not Shown * = Ford # = Crysler 12/98 Page 4-1

2 CHAPTER 4 PARTS (A) FRONT VIEW ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1a. Headsign, Sun Decal Switch, Service b. FOR GENERIC P/N's SEE PAGE Label, Service Control Panel, Assy. See Page 4-5 8a. Master Filter Kit R Suction Separator Bowl See Page 4-9 8b. Master Filter Kit (R134a)¼ Moisture Indicator N.S. Desiccant Bags (Qty. 10) a. Caster, W / Brake (Shaft) N.S. Master Filter Drier b. Caster, W / Brake (Bolt) N.S. Gasket NOTE: * = Included in Master Filter Kit NOTE: Casters for Sun version use shaft type. Casters for Snap-On version use bolt type. Page /98

3 CHAPTER 4 PARTS (A) REAR VIEW WARNING CAUTION MACHINE MUST BE LEVEL TO OPERATE PROPERLY FOR USE WITH R134a ONLY HIGH LOW VIRGIN & OIL TANKS MOUNTED UPSIDE DOWN ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Label, "Caution Vent" Degree Fitting Label, "French Use of" Plastic Bottle Label, "Caution Use of" a. Heater Blanket 110VAC Bracket b. Heater Blanket 220VAC Label,"Service Procedure" Bumpers Label, "Warning" Tank Switches (2) Bulkhead fittings R Label, Info Guide Bulkhead fittings R134a * Label, R134a ONLY a. Strap Right (30 lb.) * CPC 4 Pin Connector b. Strap Right (50 lb.) Label, Caution c. Strap Left Label, Eye Warning a. Caster, W/O Brake (Shaft) On/Off/Circuit Breaker b. Caster, W/O Brake (Bolt) A.C. Socket a. Bracket, Oil Latch b. Thumb screw a. R12 Reclm. tk. 30 lb a. Cyl. Disposable Oil b. R12 Reclm. tk. 50 lb b. Cyl. FORD Oil c. R134a Reclm. tk. 30 lb c. Cyl. R134a Polyol Ester Oil EAK0163L00A 28d. R134a Reclm. tk. 50 lb a. Load Cell Switch Double Float b. Scale Assembly a. R12 Inline Filter 1/4" c. Scale Assembly b. R134a Inline Filter 1/2" d. Scale Assy.400 (220VAC) Tank Float Cable e. Scale Assy. 450 (220v) N.S. A.C. Cord f Shock Mount Assy N.S. Temp. Probe (Vehicle) Oil switch /98 Page 4-3

4 CHAPTER 4 PARTS (A) TOP VIEW OF PUMP COMPARTMENT HP TRANS LP CO MT1 HP CO LP TRANS PRG TRANS 2 1 ROTATION ROTATION INLET OUTLET OIL MT2 MT3 7 13a 13b OUTLET INLET IN 14 OUT OIL ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Condenser a. Relay (On Pump 110v) a. Fan, Axial (115v) b. Relay (On Pump 220v) b. Fan, Axial (220v) a. Cap (Pump Relay 110v) Connector, 14 Pin b. Cap (Pump Relay 220v) Plumbing Board c. Resister Manifold Block See Page Switch (Momentary) a. Compressor (110) a. Oil Reservoir, Temprite b. Compressor (220) b. Oil Separator, Small NS. Compressor Oil Solenoid, Separator GS/300 viscosity (24oz.) 7. Relay Board /4 Flare fitting (Ser. A) a. Capacitor, Start (110v) Elbow, 90º b. Capacitor, Start (220v) Nipple, Hex Klixon, Overload protector Page /98

5 HOLD/ENTER RESTART AUTO SEQUENCE RECLAIM ONLY CANCEL AMOUNT TEMP UP DOWN ON/OFF CHAPTER 4 PARTS (A) TOP OF HEADFRAME SUCTION PRESSURE TANK ENTER FUNCTION RECLAIM FULL RECLAIM EMPTY VACUUM TIME HOLD-TIME CHARGE AMOUNT AUTO SEQUENCE RECLAIMING VACUUM VACUUM HOLD CHARGING TEMPERATURE AMOUNT DISCHARGE PRESSURE 12 OUTLET TEMPERATURE STATUS IN PROGRESS COMPLETED HOLD AMBIENT TEMPERATURE HOLD FUNCTION VALUE ADJUST POWER MRC/MTC CONTROL PANEL UNDER CONTROL PANEL 5 2a 2b 2c 1 3 TOP VIEW 4 ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1a. Power Supply (110V.A.C.) LCD Driver Bd b. Power Supply (220V.A.C.) W. H. (Rt. Display) c. Power Supply (100V.A.C.) Led Driver Bd a. Fuse F1 (.25 amp) W.H. (Led Display) b. Fuse F2 (1 amp) Processor Board c. Fuse F3 (3 amp) W.H. (Left Display) Alarm a. Control Panel MRC400A Transformer b. Control Panel Generic For labels see page a. Varistor (115 V) a. MRC-400, label b. Varistor (220 V) b. MRC-450, label NS. A.C. Cord /98 Page 4-5

6 CHAPTER 4 PARTS (A) MANIFOLD BLOCK ASSEMBLY S4 S1 S5 S6 6 LP TRANS HP CO PRG HP TRANS TRANS RELF S11 S8 S9 S10 R S3 S1 S7 LP CO ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Manifold Assembly Transducer Low Pres Solenoid N.C Transducer Purge Pres Solenoid N.O.(S11 Liquid) Switch, High Pressure Solenoid N.O.(S7 X-Over) Switch, Low Pressure Transducer, High Pressure NS. Check Valve Close to Scale Thickness =.070" ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. O-Ring (Tiny S7) (od 7/32) O-Ring (Liq. Sol.) (od.309) O-Ring (Small) (od ½) O-Ring 2 oz. oil cyl.(od.1.5) O-Ring (Medium) (od 11/16) O-Ring Block Kit (Qty 37) O-Ring (Large) (od 15/16) NS Screw, Phillips O-Ring Inline valve (od 3/8) NS Permabond NS Super Lube, 3 oz Page /98

7 CHAPTER 4 PARTS (A) HOSE PART NUMBERS H15 FRONT SOLENOID MANIFOLD TO LOW PRESSURE HOSE H1 H18 H17 Hand Valve H20 H19 NC NO H16 NC NC NC REAR SOLENOID MANIFOLD IN NC NC TO HIGH PRESSURE HOSE H2 NC REAR BOTTOM BLOCK IN NO "0" SOLENOID NC NC H14 VIRGIN TANK H13 OIL BOTTLE H12 RECOVERY TANK H11 H10 H8 H9 CONDENSER H7 H22 PURGE BOTTLE H6 H5 OUT RETURN IN H4 VACUUM PUMP H3 VACUUM H21 SCALE OIL SEPARATOR RESERVOIR H24 H25 ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER H1. Red 16" H16. Red 16" H2. Red 10" H17. Blue 96" H3. Red 18" NS. Blue Multi. (W/90º ) 96" H4. Red 24" H18. Red 96" H5. Yel. 18" NS. Red Multi. (W/90º ) 96" H6. Red 18" H19. Hand Valve w/blue 10" H7. Red 16" H20. Hand Valve w/red 10" H8. Blue 21" H21. R134a (6") adapter H9. Blue 33" H22. Vent tube to bottle H10. Red 27" H23. Hand Valve H11. Blue 38" H24. R134a Red 96 (W90º) EAH0001C01A H12. Blue 37" H25. R134a Blue 96 (W90º) EAH0001C02A H13. Yel. 33" NS. Crush Washer, Copper H14. Blue 45" NS. Anti-Blow Back Val. ¼" H15. Blue 18" NS. Anti-Blow Back Val. ½" /98 Page 4-7

8 CHAPTER 4 PARTS (A) ADAPTERS / FITTINGS GM ADAPTER FORD ADAPTER LARGE GM ADAPTER QUICK DISCONNECT GM/FORD ADAPTER QUICK DISCONNECT O-RING SCREEN INLINE FILTER (R-12) (R134a) FILTER WRENCH HIGH HIGH LOW LOW O-Ring Kit EAK0027C00AS ARG (10 each) Page /98

9 CHAPTER 4 PARTS (A) SUCTION SEPARATOR ITEM DESCRIPTION EQUI SERV # 1. Cap and shield Fitting, nipple Atomizer Fitting a. Float Switch Assembly b. Float Plate Fitting, nipple Gasket, Bowl Thumbscrew Washer Ring, Mounting Bowl Bowl, Suction Separator (Aluminum) Gauge, Liquid Level O-Ring, Bottom Cap Bowl, Bottom Cap Metal Bowl Kit (Solid bowl) EAA0088C00A 12/98 Page 4-9

10 CHAPTER 4 PARTS (A) PARTS IN ALPHABETICAL ORDER NAME PART NUMBER COMMENTS Adapter, Ford X Adapter, GM X Adapter, GM, X Large, QK. Dis., 90º Adapter, GM/Ford X Adapter, R134a X Adapter, R134a X Alarm X X Board, LCD Driver X X Board, Led Driver X X Board, Plumbing X X Board, Processor X X Board, Relay X X Bottle, Plastic X X Bowl X X Bowl, Separator X X Metal bowl Bowl, Bottom Cap X X Metal bowl Bowl, Metal Kit EAK0071C00AS Bowl, Metal (Solid) EAA0088C00A X X Solid Metal bowl Bracket, Oil X Bracket, Rear hose X X Breaker, On/Off/Circuit X X Bulkhead fittings R X Bulkhead fittings R134a X Bumpers X X Cable, Tank Float X X Cap and Shield X X Top of S. S. bowl Capacitor X X (Pump Relay 110v) Capacitor X (Pump Relay 220v) Capacitor, Start X X (110v) Capacitor, Start X X (220v) Caster, W / Brake X X Caster, W / O Brake X X Caster, W / Brake X X Caster, W / O Brake X X Compressor X X 110 VAC Compressor X X 220 VAC Compressor Oil X X 3GS/300 viscosity (24oz.) Condenser X X Connector, 14 Pin X X Connector, CPC 4 Pin X X Control Panel X X Generic Control Panel X MRC-400A Cord, A.C X X Crush Washer, X X Copper Cylinder, Disposable Oil X Naphtheric, minerial oil Cylinder, Disposable Oil X Ford, Paraffinic mineral oil Cylinder, R134a Oil EAK0163L00A X Ester oil in a Disposable cylinder Desiccant Bags X (Qty. 10) Desiccant Bags X (Qty. 10) Elbow, 90º X X Fan, Axial X X (115v) Fan, Axial X X (220v) Filter, Inline 1/2" X R134a Filter, Inline 1/4" X R12 Fitting X X 90 Degree Page /98

11 CHAPTER 4 PARTS (A) NAME PART NUMBER COMMENTS Fitting X X 1/4 Flare Fitting, Atomizer X X Fitting, nipple X X S.S. Bowl Float Switch Assembly X X Float X X Fuse, F X X (.25 amp) Fuse, F X X (1 amp) Fuse, F X X (3 amp) Gasket X X Suction Separator Bowl Gauge, Liquid level X X Metal bowl Headsign, Sun Decal X X Heater Blanket X X 220VAC Heater Blanket X X 110VAC Hose, Blue 10" X Hose, Blue 18" X X Hose, Blue 21" X X Hose, Blue 33" X X Hose, Blue 37" X X Hose, Blue 38" X X Hose, Blue 45" X X Hose, Blue 96" X Hose, Blue Multi X 96" (W/90º ) Hose, R134a X (6") adapter Hose, R134a Blue EAH0001C02A X 96 (W90º) Hose, Red 10" X X Hose, Red 10" X Hose, Red 16" X X Hose, Red 16" X X Hose, Red 16" X X Hose, Red 18" X X Hose, Red 18" X X Hose, Red 24" X X Hose, Red 27" X X Hose, Red 96" X Hose, Red Multi X 96" (W/90º ) Hose, Red, EAH0001C01A X 96 (W90º) R134a Hose, Yel. 18" X X Hose, Yel. 33" X X Inlet Tube X X Kit, Master Filter X R-12 (1/4 Fittings) Kit, Master Filter X R-134a Serial A (1/4" Fittings) Kit, Master Filter X R-134a Serial B (1/2" Fittings) Label X X "Caution Vent" Label X X "Caution Use of" Label X X "Warning" Label X X Caution Label X X Eye Warning Label X Front panel MRC-400 label Label X Front panel MRC-450 label Label X X Info Guide Label X R134a ONLY Label X X "Service Procedure" Label X X "French Use of Latch X X Rear Glove Box Load Cell X X Manifold Assembly X X Master Filter Drier X R-134a, 1/2 fitting Master Filter Drier X R-12, 1/4 fitting 12/98 Page 4-11

12 CHAPTER 4 PARTS (A) NAME PART NUMBER COMMENTS Moisture Indicator X X Nipple, Hex X X O-Ring X X (Liq. Sol.) (od.309) O-Ring Block Kit X X (Qty 37, for pneumatic block) O-Ring X X (Large) O-Ring X X (Medium) O-Ring X X (Small) O-Ring (Small) X X (Small) O-Ring X X Inline hand valve O-Ring X X 2 ounce oil charge cylinder O-Ring, bottom of bowl X X Metal bowl Oil Reservoir, Temprite X X Oil Separator, Small X X Permabond X X Power Supply X X (100V.A.C.) Power Supply X X (110V.A.C.) Power Supply X X (220V.A.C.) Relay X X (On Pump 110v) Relay X X (On Pump 220v) Resister X X Scale Assembly X X Scale Assembly X X (220VAC) Scale Assembly X X Scale Assembly X X (220VAC) Screw, Phillips X X In Block. (Qty. = 4) Screw, Thumb X For Oil Bracket Shock Mount Assy X-brace for scale Socket, A.C X X Solenoid N.C X X Most solenoids. Solenoid N.O.(S11) X X Liquid Solenoid N.O.S X X X-Over Solenoid, Separator X X Small oil separator Strap, Velcro X X Left Strap, Velcro Right X X (30 lb.) Strap, Velcro Right X X (50 lb.) Suction Separator Assy X X Super Lube, X X 3 oz. Switch Float X X Switch Oil X X Switch, (Momentary) X X Switch, Double Float X X Switch, High Pressure X X Switch, Low Pressure X X Switch, Service X X Switch, Tank (2) X X Tank, R12 Recovery X 30 lb. Tank, R12 Recovery X 50 lb. Tank, R134a Recovery X 30 lb. Tank, R134a Recovery X 50 lb. Temp. Probe X X (Vehicle) Thumbscrew X X Metal bowl Transducer, High Pres X X Transducer, Low Pres X X Transducer, Purge Pres X X Transformer X X Valve, Anti-Blow Back X 1/2", (R134a) Valve, Anti-Blow Back X 1/4", (R-12) Valve, Hand X X Page /98

13 NAME PART NUMBER COMMENTS Varistor X X (115 V) Varistor X X (220 V) Vent tube to bottle X X Washer X X Metal bowl CHAPTER 4 PARTS (A) 12/98 Page 4-13

14 CHAPTER 4 PARTS (A) PARTS IN NUMERICAL ORDER NAME PART NUMBER COMMENTS Condenser X X Oil Separator, Small X X Cylinder, Disposable Oil X Naphtheric, minerial oil Cylinder, Disposable Oil X Ford, Paraffinic mineral oil Relay X X (On Pump 220v) Relay X X (On Pump 110v) Capacitor, Start X X (110v) Capacitor, Start X X (220v) Solenoid, Separator X X Small oil separator Solenoid N.C X X Most solenoids. Solenoid N.O.(S11) X X Liquid Solenoid N.O.S X X X-Over Alarm X X Gauge, Liquid level X X Metal bowl Bowl X X Bottle, Plastic X X Bowl, Separator X X Metal bowl Bowl, Bottom Cap X X Metal bowl Washer X X Metal bowl Screw, Phillips X X In Block. (Qty. = 4) Strap, Velcro X X Left Strap, Velcro Right X X (30 lb.) Strap, Velcro Right X X (50 lb.) Transducer, Low Pres X X Transducer, High Pres X X Transducer, Purge Pres X X Heater Blanket X X 110VAC Heater Blanket X X 220VAC Float X X Switch, Low Pressure X X Switch, High Pressure X X Fan, Axial X X (115v) Fan, Axial X X (220v) O-Ring (Small) X X (Small) O-Ring X X (Small) O-Ring X X (Medium) O-Ring X X (Large) O-Ring Block Kit X X (Qty 37, for pneumatic block) O-Ring X X (Liq. Sol.) (od.309) O-Ring X X Inline hand valve O-Ring X X 2 ounce oil charge cylinder O-Ring, bottom of bowl X X Metal bowl Permabond X X Elbow, 90º X X Adapter, GM X Adapter, GM/Ford X Fitting X X 90 Degree Adapter, GM, X Large, QK. Dis., 90º Adapter, Ford X Fitting X X 1/4 Flare Bulkhead fittings R X Bulkhead fittings R134a X Adapter, R134a X Adapter, R134a X Crush Washer, X X Copper Vent tube to bottle X X Page /98

15 CHAPTER 4 PARTS (A) NAME PART NUMBER COMMENTS Desiccant Bags X (Qty. 10) Desiccant Bags X (Qty. 10) Screw, Thumb X For Oil Bracket Compressor Oil X X 3GS/300 viscosity (24oz.) Super Lube, X X 3 oz. Label X R134a ONLY Label X X "Caution Use of" Headsign, Sun Decal X X Label X X "Warning" Label X X "Service Procedure" Label X X Info Guide Label X X "Caution Vent" Label X X "French Use of Label X X Eye Warning Label X X Caution Label X Front panel MRC-400 label Label X Front panel MRC-450 label Resister X X Fuse, F X X (1 amp) Fuse, F X X (3 amp) Fuse, F X X (.25 amp) Switch, Double Float X X Switch, (Momentary) X X Switch, Service X X Switch, Tank (2) X X Thumbscrew X X Metal bowl Kit, Master Filter X R-134a Serial A (1/4" Fittings) Kit, Master Filter X R-134a Serial B (1/2" Fittings) Kit, Master Filter X R-12 (1/4 Fittings) Bumpers X X Breaker, On/Off/Circuit X X Switch Oil X X Caster, W / O Brake X X Caster, W / Brake X X Caster, W / O Brake X X Caster, W / Brake X X Hose, Red 10" X Hose, Blue 10" X Hose, Blue 96" X Hose, Red 96" X Hose, Blue 38" X X Hose, Red 16" X X Hose, Red 16" X X Hose, Red 16" X X Hose, Red 10" X X Hose, Blue 21" X X Hose, Blue 33" X X Hose, Red 27" X X Hose, Yel. 18" X X Hose, Blue 37" X X Hose, Blue 18" X X Hose, Blue 45" X X Hose, Red 18" X X Hose, Red 18" X X Hose, Red 24" X X Hose, Yel. 33" X X Hose, R134a X (6") adapter Hose, Blue Multi X 96" (W/90º ) Hose, Red Multi X 96" (W/90º ) 12/98 Page 4-15

16 CHAPTER 4 PARTS (A) NAME PART NUMBER COMMENTS Gasket X X Suction Separator Bowl Connector, CPC 4 Pin X X Connector, 14 Pin X X Socket, A.C X X Valve, Anti-Blow Back X 1/4", (R-12) Valve, Anti-Blow Back X 1/2", (R134a) Fitting, nipple X X S.S. Bowl Inlet Tube X X Nipple, Hex X X Valve, Hand X X Latch X X Rear Glove Box Cord, A.C X X Cable, Tank Float X X Temp. Probe X X (Vehicle) Board, LCD Driver X X Board, Led Driver X X Board, Plumbing X X Board, Processor X X Board, Relay X X Control Panel X MRC-400A Control Panel X X Generic Varistor X X (115 V) Varistor X X (220 V) Master Filter Drier X R-12, 1/4 fitting Oil Reservoir, Temprite X X Float Switch Assembly X X Switch Float X X Suction Separator Assy X X Compressor X X 110 VAC Compressor X X 220 VAC Shock Mount Assy X-brace for scale Power Supply X X (110V.A.C.) Power Supply X X (100V.A.C.) Power Supply X X (220V.A.C.) Scale Assembly X X Scale Assembly X X Scale Assembly X X (220VAC) Scale Assembly X X (220VAC) Tank, R12 Recovery X 30 lb. Tank, R12 Recovery X 50 lb. Tank, R134a Recovery X 30 lb. Tank, R134a Recovery X 50 lb. Transformer X X Load Cell X X Moisture Indicator X X Manifold Assembly X X Capacitor X X (Pump Relay 110v) Capacitor X (Pump Relay 220v) Filter, Inline 1/4" X R12 Filter, Inline 1/2" X R134a Master Filter Drier X R-134a, 1/2 fitting Bracket, Rear hose X X Bracket, Oil X Cap and Shield X X Top of S. S. bowl Hose, Red, EAH0001C01A X 96 (W90º) R134a Hose, R134a Blue EAH0001C02A X 96 (W90º) Bowl, Metal Kit EAK0071C00AS Cylinder, R134a Oil EAK0163L00A X Ester oil in a Disposable cylinder Page /98

17 CHAPTER 4 PARTS (A) GRAPHICS KITS P/N'S FOR GENERIC UNITS IN BRAND NAME ORDER: NOTE: 1091 KITS ARE IN FINISHED GOODS STOCK. Kit # HEADSIGN # FRONT FACIA # DESCRIPTION ATLAS EAC ATLAS EAC NA CAR QUEST MTC NA CAR QUEST MTC NA EVERCO MTC NA EVERCO MTC NA MURRAY MTC MURRAY MTC NA NAPA MTC NA NAPA MTC NAPA MTC NAPA MTC-4500 SPECIAL CONSIDERATIONS NA ROTUNDA MTC-4000 "WARNING" LABEL "CAUTION" LABEL NA ROTUNDA MTC-4500 "R134a ONLY" "WARNING" "DO NOT MIX" /98 Page 4-17

18 CHAPTER 4 PARTS (A) Page /98

19 CHAPTER 4 PARTS (A) All information contained or disclosed in this document is considered confidential and proprietary by Sun Electric Corporation. All manufacturing, use, reproduction and sales rights are reserved by Sun Electric Corporation and the information contained herein shall not be used in whole or in part without the express written consent of Sun Electric Corporation. MAIN POWER SWITCH CIRCUIT BREAKER 1 TB1 1 T1 TRANSFORMER H2 PROCESSOR BD J2 H3 J1 LCD BD (LEFT) LED BOARD AC PLUG 3 H1 LINE FILTER 4 5 J4 J5 H4 J1 2 6 HEATER BLANKET FAN FAN 2 J1 H5 ALARM H20 H20 H19 K1 K2 J8 H6 J1 H H H H H H H H H H H H H H H H H H H H COMPRESSOR ASSY. PROTECTOR C S M K1 3 C1 1 2 C2 R1 RELAY BD. J H18 SOLENOIDS H17 HIGH PRESS. SWITCH H16 H16 J12 J4 J7 J7 J3 J6 H9 H8 H7 J1 J5 J8 PLUMBING BD J11 J2 J3 H10 H10 H10 H11 H11 H11 H11 H13 H13 LCD BD (RIGHT) HIGH PRESSURE TRANSDUCER LOW PRESSURE TRANSDUCER PURGE PRESSURE TRANSDUCER SS PRESSURE SWITCH SS FLOAT SWITCH SUCTION SEPARATOR SERVICE SWITCH OIL ON VIRGIN ON H12 EXTERNAL TEMPERATURE PROBE H15 P9 H14 J9 J10 H13 RECOVERY ON LOAD CELL RECOVERY TANK SUN ELECTRIC CORPORATION One Sun Parkway Crystal Lake, Illinois U.S.A. MODEL: MRC-400/450 DWG REV: 0895 REV A. DWG BY: T. WILSON CHK BY: F. ZOFINSKI / T. WILSON TITLE: INTERCONNECTION DIAGRAM SERIAL A DWG: PAGE:

20 CHAPTER 4 PARTS (A)

21 CHAPTER 4 PARTS (A)

22 CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description for Serial Numbers: Serial Number Location - Rear Cabinet top right hand side. Example: 0194B Month MFG. 94 Year MFG. B Serial Rev Number of Units Built. SERIAL B SOFTWARE STARTS WITH 2. XX ON POWER UP. KEY NS = Not Shown * = Ford # = Crysler 12/98 Page 4-1

23 CHAPTER 4 PARTS (B) FRONT VIEW ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Headsign, Sun Decal Label, Service Control Panel, Assy. See Page 4-5 8a. Master Filter Kit R Suction Separator See Page 4-9 8b. Master Filter Kit (R134a)½ Moisture Indicator Latch a. Caster, W / Brake (Post) N.S.* Desiccant Bags (Qty. 10) b. Caster, W / Brake (Bolt) N.S.* Master Filter Drier Switch, Service N.S.* Gasket NOTE: * = Included in Master Filter Kit NOTE: Casters for Sun version use shaft type. Casters for Snap-On version use post type. 12/98 Page 4-2

24 WARNING CAUTION CHAPTER 4 PARTS (B) REAR VIEW MACHINE MUST BE LEVEL TO OPERATE PROPERLY FOR USE WITH R134a ONLY HIGH LOW VIRGIN & OIL TANKS MOUNTED UPSIDE DOWN ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Label, "Caution Vent" a. Heater Blanket, 110VAC Label, "French Use of" b. Heater Blanket, 220VAC Label, "Caution Use of" Bumpers Bracket Switch, Tank (2) Label, "Service Procedure" Connector, CPC 4 Pin Label, "Warning" Label, Info Guide Fitting, R12 Bulkhead * Label, R134a ONLY Fitting, R134a Bulkhead Label, Caution Sensor, Temperature Label, Eye Warning a. Strap, Right (30 lb.) Switch, On/Off/ b. Strap, Right (50 lb.) A.C. socket c. Strap, Left Latch a. Caster, W/O Brake, (Shaft) a. Tank, 30 lb. R b. Caster, W/O Brake, (Bolt) b. Tank, 50 lb. R a. Bracket, Oil c. Tank, 30 lb. R134a b. Screw, Thumb d. Tank, 50 lb. R134a a. Cyl. Disposable Oil Switch, Double Float b. Cyl. FORD Oil a. Filter, R12 Inline c. Cyl. R134a Polyol Ester Oil EAK0163L00A 30b. Filter, R134a Inline a. Load Cell Cable, Tank Float b. Mount, Shock (4) N.S. Cord, A.C Switch, Oil N.S. Probe, Temp. (Vehicle) Fitting, 90 Degree /98 Page 4-3

25 HP TRANS LP TRANS HP CO PRG TRANS LP CO CHAPTER 4 PARTS (B) TOP VIEW OF PUMP COMPARTMENT MT1 2 1 ROTATION ROTATION INLET OUTLET OIL MT2 MT3 7 11a OUTLET b INLET IN OUT OIL ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Condenser c. Relay (On Pump 110v) a. Fan, Axial (115v) d. Relay (On Pump 220v) b. Fan, Axial (220v) e. Resistor Connector, 14 Pin Switch, (Momentary) Board, Plumbing a. Oil Reservoir, Temprite Manifold Block See Page b. Oil Separator, Small a. Compressor (110) Solenoid, Separator b. Compressor (220) Fitting, Tubo Board, Relay Elbow, 90º a. Capacitor, Start (110v) Nipple, Hex b. Capacitor, Start (220v) NS. Kilxon Overload Protector a. Cap (Pump Relay 110v) NS. Compressor Oil GS/300 viscosity (24oz.) 9b. Cap (Pump Relay 220v) /98 Page 4-4

26 HOLD/ENTER RESTART AUTO RECLAIM CANCEL AMOUNT TEMP SEQUENCE ONLY RECLAIM FULL RECLAIM EMPTY VACUUM TIME HOLD-TIME CHARGE AMOUNT AUTO SEQUENCE RECLAIMING VACUUM VACUUM HOLD CHARGING TEMPERATURE AMOUNT IN PROGRESS COMPLETED HOLD RECLAIM FULL RECLAIM EMPTY VACUUM TIME HOLD-TIME CHARGE AMOUNT AUTO SEQUENCE RECLAIMING VACUUM VACUUM HOLD CHARGING TEMPERATURE AMOUNT IN PROGRESS COMPLETED HOLD UP DOWN ON/OFF HOLD/ENTER RESTART UP DOWN CANCEL AMOUNT TEMP ON/OFF CHAPTER 4 PARTS (B) TOP OF HEADFRAME SUCTION PRESSURE OUTLET TEMPERATURE TANK ENTER FUNCTION STATUS DISCHARGE PRESSURE AMBIENT TEMPERATURE 12 HOLD FUNCTION VALUE ADJUSTPOWER UNDER CONTROL PANEL MRC/MTC CONTROL PANEL SUCTION PRESSURE DISCHARGE PRESSURE Snap-on 13 OUTLET TEMPERATURE AMBIENT TEMPERATURE TANK 5 2a 2b 2c ENTER FUNCTION HOLD CONTROLS VALUE ADJUST FUNCTION POWER STATUS AUTO SEQUENCE RECLAIM ONLY ACT CONTROL PANEL 1 3 TOP VIEW 4 ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1a. Power Supply (110V.A.C.) W. H. (Rt. Display) b. Power Supply (220V.A.C.) Board, Led Driver c. Power Supply (100V.A.C.) W.H. (Led Display) a. Fuse, F1 (.25 amp) Board, Processor b. Fuse, F2 (1 amp) W.H. (Left Display) c. Fuse, F3 (3 amp) a. Control Panel MRC Alarm b. Control Panel MRC Transformer Control Panel, Snap-on a. Varistor (115 V) N.S. Cord, A.C b. Varistor (220 V) N.S. Pem-Nut Board, LCD Driver /98 Page 4-5

27 CHAPTER 4 PARTS (B) MANIFOLD BLOCK ASSEMBLY PUMP S5 9 LP CO Prg. Trans S4 MT3 S6 S14 S1 S3 S7 8 5 HP CO HP Trans MT1 MT2 Low Pres. Trans ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. Manifold Transducer, Low Pres Solenoid, N.C Transducer, Purge Pres * Solenoid, N.O.(S7 X-Over) Switch, High Pressure * Solenoid, N.C. (Purge) Switch, Low Pressure Transducer, High Pressure N.S. Plunger, (In Solenoid) * Refers to Feed Through N.S. Allen Screw (Qty.=5) Close to Scale ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1. O-Ring (Tiny S7) O-Ring 2oz O-Ring (Small) NS O-Ring Block Kit (Qty 42) O-Ring (Medium) NS Screw, Phillips O-Ring (Large) NS Permabond O-Ring (Front Blocks) NS Super Lube, 3 oz /98 Page 4-6

28 CHAPTER 4 PARTS (B) HOSE PART NUMBERS Hand Valve H11 V1 H12 H13 LOW PRESSURE TRANSDUCER 30"HG PSI TO LOW PRESSURE HOSE T1 S6 VACUUM SOLENOID NC IN S7 CROSSOVER SOLENOID NO IN HIGH PRESSURE TRANSDUCER 30"HG PSI HIGH PRESSURE CUTOFF - N.C. OPEN AT 375 PSI T2 TO HIGH PRESSURE HOSE T3 T4 CHECK VALVE S9 VIRGIN SOLENOID CHECK VALVE S8 OIL SOLENOID CHECK VALVE S10 RECLAIM SOLENOID PURGE TRANSDUCER 30"HG to 500 PSI S14 PURGE SOLENOID S3 VENT SOLENOID LOW PRESSURE CUTOFF - N.O. CLOSES AT 20 PSI NC NC NC NO NC SUCTION SEPARATOR IN IN IN NC S12 "0" SOLENOID IN NC VENT FROM BLOCK S13 LIQUID SOLENOID IN S1 CONDENSER SOLENOID NC IN BYPASS SOLENOID (not used) IN NC S5 SUCTION SEPARATOR SOLENOID NC IN IN IN H6 MOISTURE INDICATOR H1 H10 H9 OIL BOTTLE H8 LIQUID H7 VAPOR H5 CONDENSER T6 T5 IN PRESSURE H2 VACUUM PUMP VACUUM VIRGIN TANK MASTER FILTER H4 OUT S4 OIL RETURN SOLENOID IN H3 RECLAIM TANK RETURN OIL SEPARATOR/RESERVOIR NC SCALE ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER T1 Tube (Aluminum) H8a Hose, 37 R-12 Blue T2 Tube (Aluminum) H8b Hose, 37 R-134a Blue T3 Tube (Aluminum) H9a Hose, 33 R-12 Yel T4 Tube (Aluminum) H9b Hose, 33 R-134a Yel T5 Tube (Aluminum) H10a Hose, 46 R-12 Blue T6 Tube (Aluminum) H10b Hose, 46 R-134a Blue H1 Hose, 18: Red H11a Hose, 96 Blue (90º) H2 Hose, 24 Red H11b Hose, 96 Red (90º) H3 Hose, H12a Hose, 10 Blue H4a Hose, 22 R-12 Blue H12b Hose, 10 Red H4b Hose, 22 R-134a Blue H13a Hose, 96 Blue (90º) EAH0001C02A H5a Hose, 22 R-12 Blue H13b Hose, 96 Red (90º) EAH0001C01A H5b Hose, 22 R-134a Blue V1 Valve, Hand H6a Hose, 36 R-12 Red N.S. R134a Utility (36 ) H6b Hose, 36 R-134a Red N.S. R134a Utility (8 ) H7a Hose, 46 R-12 Red H7b Hose, 46 R-134a Red NOTE: The first production run of MRC-450 s (0093) were made with ¼ flare fitting, this kit will update unit to current level. 12/98 Page 4-7

29 CHAPTER 4 PARTS (B) ADAPTERS / FITTINGS GM ADAPTER FORD ADAPTER LARGE GM ADAPTER QUICK DISCONNECT GM/FORD ADAPTER QUICK DISCONNECT O-RING SCREEN INLINE FILTER FILTER WRENCH (R-12) (R134a) HIGH HIGH LOW LOW O-Ring Kit EAK0027C00AS O-Ring Kit ARG /98 Page 4-8

30 CHAPTER 4 PARTS (B) SUCTION SEPARATOR VIEW ITEM DESCRIPTION EQUI SERV # 1. Cap and shield Fitting, nipple Atomizer Fitting a. Float Switch Assembly b. Float Plate Fitting, nipple Gasket, Bowl Thumbscrew Washer Ring, Mounting Bowl Bowl, Suction Separator (Aluminum) Gauge, Liquid Level O-Ring, Bottom Cap Bowl, Bottom Cap Bowl Kit, Metal (Solid bowl) EAK0071C00AS 12/98 Page 4-9

31 CHAPTER 4 PARTS (B) PARTS IN ALPHABETICAL ORDER NAME PART NUMBER COMMENTS Adapter, FORD X Standard Screw Fitting Adapter, GM X Standard Screw Fitting Adapter, GM X Quick Disconnect Adapter, GM/FORD X Quick Disconnect Adapter, High X Uniweld Adapter, Low X Uniweld Alarm X X Board, LCD Driver X X Board, Led Driver X X Board, Plumbing X X Board, Processor X X Board, Relay X X Bowl X X Bowl, Separator X X Bowl, Bottom Cap X X Bowl, Metal Kit EAK0071C00AS X X Bracket X X Rear Hose Bracket, Oil X X Bumpers X X Fitting, Bulkhead X Fitting, Bulkhead X Cable, Tank Float X X Cap and Shield X X Top of S. S. bowl Capacitor X X (Pump Relay 110v) Capacitor X X (Pump Relay 220v) Capacitor, Start X X (110v) Capacitor, Start X X (220v) Caster, W / Brake X X Caster, W/O Brake X X Caster, W / Brake X X Caster, W/O Brake X X Compressor X X (110) Compressor X X (220) Compressor Oil X X 3GS/300 viscosity (24oz.) Condenser X Connector, 14 Pin X Connector, CPC 4 Pin X Control Panel X MRC-400 Control Panel X MRC-450 Control Panel X X ACT-4100/ACT-4500 Cord, A.C X X Crush Washer X X Copper Cylinder, Disposable Oil X Cylinder, FORD Oil X Desiccant Bags X (Qty. 10) Desiccant Bags X (Qty. 10) Elbow, 90º X X Fan, Axial X X (115v) Fan, Axial X X (220v) Filter, Inline X ¼ Flare Filter, Inline X ½ Acme Fitting, 90 Degree X X Fitting, Atomizer X X Fitting, nipple X X In S. S. bowl 12/98 Page 4-10

32 NAME PART NUMBER COMMENTS Fitting, Tubo X X Fitting, nipple X X In S. S. bowl Float X X Fuse, F X X (.25 amp) Fuse, F X X (1 amp) Fuse, F X X (3 amp) Gasket X X Gauge, Liquid level X X Metal Bowl Headsign, Sun Decal X X Heater Blanket, X X 110VAC Heater Blanket, X X 220VAC Hose, 10 Blue X X Vehicle Hose Hose, 10 Red X X Vehicle Hose Hose, 18 Red X X Input Side of Compressor Hose, 22 R-12 Blue X Output Side of Master Filter Hose, 22 R-12 Blue X Input Side of Master Filter Hose, 22 R-134a Blue X Input & Output Side of Master Filter Hose, 24 Red X X Output Side of Compressor Hose, 33 R-134a Yel X Output Side of Oil Cylinder, R134a Hose, 33 R-12 Yel X Output Side of Oil Cylinder, R12 Hose, 36 R-12 Red X Output Side of Moisture Indicator Hose, 36 R-134a Red X Output Side of Moisture Indicator Hose, 37 R-12 Blue X Output Side of Recovery Tank Hose, 37 R-134a Blue X Output Side of Recovery Tank Hose, 46 R-12 Blue X Output Side of Virgin Tank Hose, 46 R-12 Red X Input Side of Recovery Tank Hose, 46 R-134a Blue X Output Side of Virgin Tank Hose, 46 R-134a Red X Input Side of Recovery Tank Hose, 96 Blue (90º) X Vehicle Hose Hose, 96 Blue (90º) EAH0001C02A X Vehicle Hose Hose, 96 Red (90º) X Vehicle Hose Hose, 96 Red (90º) EAH0001C01A X Vehcile Hose Indicator, Moisture X X Inlet Tube X X Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Kit, O-Ring ARG04040 X For R-134a Adapters -09/-10 Kit, O-Ring EAK0027C00AS X For R-134a Adapters -07/-08 Label X R134a ONLY Label X X "Caution Use of" Label X X "Warning" Label X X "Service Procedure" Label X X Info Guide Label X X "Caution Vent" Label X X "French Use of" Label X X Eye Warning Label X X Caution Latch X X Load Cell X X Master Filter Drier X Master Filter Drier X Mount, Shock X X Qty. (4) Nipple, Hex X X O-Ring X X (Tiny S7) O-Ring X X (Small) O-Ring X X (Medium) O-Ring X X (Large) CHAPTER 4 PARTS (B) 12/98 Page 4-11

33 CHAPTER 4 PARTS (B) NAME PART NUMBER COMMENTS O-Ring X X Between the front 2 blocks O-Ring X X O-ring kit for entire block, Qty. 42 O-Ring X Inline hand valve O-Ring X 2 ounce oil charge cylinder O-Ring, Bottom of bowl X X Metal bowl Permabond X X Plate X X In S. S. bowl Power Supply X X (110V.A.C.) Power Supply X X (100V.A.C.) Power Supply X X (220V.A.C.) Probe, Temp X X (Vehicle) Relay X X (On Pump 220v) Relay X X (On Pump 110v) Resistor X X Screw, Phillips X X Screw, Thumb X X Oil Bracket Sensor X X Temperature Solenoid X X Normally Closed Solenoid X X Normally Open; (S7 Xover / S14 Purge) Solenoid, Separator X X Strap, Velcro X X Left Strap, Velcro X X Right (30 lb.) Strap, Velcro X X Right (50 lb.) Suction Separator X X Super Lube X X 3 oz. Switch X X Low Pressure Switch X X High Pressure Switch X X Double Float Switch X X (Momentary) Switch X X Service Switch X X Tank (2) Switch X X On/Off Switch X X Oil Switch X X Float Tank, Recovery X 30 lb. Tank, Recovery X 50 lb. Tank, Recovery X X Vehicle temperature probe Thumbscrew X X Metal Bowl Tank, Recovery X 50 lb. Temperature Probe X X Vehicle Transducer X X Low Pressure Transducer X X High Pressure Transducer X X Purge Pressure Transformer X X Tube (Aluminum) X X To Low Pressure Side Tube (Aluminum) X X To High Pressure Side Tube (Aluminum) X X Input Side of Condenser Tube (Aluminum) X X Output side of Oil Separator Tube (Aluminum) X X Input Side of Suction Separator Bowl Tube (Aluminum) X X Output Side of Suction Separator Bowl Valve, Hand X Varistor X X (115 V) Varistor X X (220 V) Wrench, Filter X X Washer X X Metal bowl 12/98 Page 4-12

34 PARTS IN NUMERICAL ORDER CHAPTER 4 PARTS (B) NAME PART NUMBER COMMENTS Wrench, Filter X X Condenser X Cylinder, Disposable Oil X Cylinder, FORD Oil X Relay X X (On Pump 220v) Relay X X (On Pump 110v) Capacitor, Start X X (110v) Capacitor, Start X X (220v) Solenoid, Separator X X Solenoid X X Normally Closed Solenoid X X Normally Open; (S7 Xover / S14 Purge) Alarm X X Gauge, Liquid level X X Metal Bowl Bowl X X Bowl, Separator X X Bowl, Bottom Cap X X Washer X X Metal bowl Screw, Phillips X X Strap, Velcro X X Left Strap, Velcro X X Right (30 lb.) Strap, Velcro X X Right (50 lb.) Transducer X X Low Pressure Transducer X X High Pressure Transducer X X Purge Pressure Heater Blanket, X X 110VAC Heater Blanket, X X 220VAC Float X X Switch X X Low Pressure Switch X X High Pressure Mount, Shock X X Qty. (4) Fan, Axial X X (115v) Fan, Axial X X (220v) O-Ring X X (Tiny S7) O-Ring X X (Small) O-Ring X X (Medium) O-Ring X X (Large) O-Ring X X Between the front 2 blocks O-Ring X X O-ring kit for entire block, Qty. 42 O-Ring X Inline hand valve O-Ring X 2 ounce oil charge cylinder O-Ring, Bottom of bowl X X Metal bowl Permabond X X Elbow, 90º X X Adapter, GM X Standard Screw Fitting Adapter, GM/FORD X Quick Disconnect Fitting, 90 Degree X X Adapter, GM X Quick Disconnect Adapter, FORD X Standard Screw Fitting Fitting, Tubo X X Fitting, Bulkhead X Fitting, Bulkhead X Adapter, Low X Uniweld Adapter, High X Uniweld Crush Washer X X Copper Desiccant Bags X (Qty. 10) Desiccant Bags X (Qty. 10) 12/98 Page 4-13

35 CHAPTER 4 PARTS (B) NAME PART NUMBER COMMENTS Screw, Thumb X X Oil Bracket Compressor Oil X X 3GS/300 viscosity (24oz.) Super Lube X X 3 oz. Label X R134a ONLY Label X X "Caution Use of" Headsign, Sun Decal X X Label X X "Warning" Label X X "Service Procedure" Label X X Info Guide Label X X "Caution Vent" Label X X "French Use of" Label X X Eye Warning Label X X Caution Resistor X X Fuse, F X X (1 amp) Fuse, F X X (3 amp) Fuse, F X X (.25 amp) Switch X X Double Float Switch X X (Momentary) Switch X X Service Switch X X Tank (2) Thumbscrew X X Metal Bowl Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Kit, Master Filter X Filter, 10 Desiccant Bags, & O-Ring Bumpers X X Switch X X On/Off Switch X X Oil Caster, W/O Brake X X Caster, W / Brake X X Caster, W/O Brake X X Caster, W / Brake X X Hose, 10 Red X X Vehicle Hose Hose, 10 Blue X X Vehicle Hose Hose, 33 R-12 Yel X Output Side of Oil Cylinder, R12 Hose, 22 R-134a Blue X Input & Output Side of Master Filter Hose, 46 R-134a Red X Input Side of Recovery Tank Hose, 37 R-134a Blue X Output Side of Recovery Tank Hose, 46 R-134a Blue X Output Side of Virgin Tank Hose, 36 R-134a Red X Output Side of Moisture Indicator Hose, 18 Red X X Input Side of Compressor Hose, 24 Red X X Output Side of Compressor Hose, 96 Blue (90º) X Vehicle Hose Hose, 96 Red (90º) X Vehicle Hose Hose, 22 R-12 Blue X Output Side of Master Filter Hose, 46 R-12 Red X Input Side of Recovery Tank Hose, 37 R-12 Blue X Output Side of Recovery Tank Hose, 46 R-12 Blue X Output Side of Virgin Tank Hose, 36 R-12 Red X Output Side of Moisture Indicator Hose, 22 R-12 Blue X Input Side of Master Filter Hose, 33 R-134a Yel X Output Side of Oil Cylinder, R134a Gasket X X Connector, CPC 4 Pin X Connector, 14 Pin X Fitting, nipple X X In S. S. bowl Fitting, nipple X X In S. S. bowl 12/98 Page 4-14

36 CHAPTER 4 PARTS (B) NAME PART NUMBER COMMENTS Plate X X In S. S. bowl Valve, Hand X Latch X X Cord, A.C X X Cable, Tank Float X X Probe, Temp X X Vehicle Temperature Probe X X Vehicle Board, LCD Driver X X Board, Led Driver X X Board, Processor X X Board, Relay X X Board, Plumbing X X Control Panel X MRC-400 Control Panel X MRC-450 Control Panel X X ACT-4100/ACT-4500 Varistor X X (115 V) Varistor X X (220 V) Master Filter Drier X Switch X X Float Suction Separator X X Compressor X X (110) Compressor X X (220) Power Supply X X (110V.A.C.) Power Supply X X (100V.A.C.) Power Supply X X (220V.A.C.) Tank, Recovery X 30 lb. Tank, Recovery X 50 lb. Tank, Recovery X X Vehicle temperature probe Tank, Recovery X 50 lb. Transformer X X Load Cell X X Indicator, Moisture X X Capacitor X X (Pump Relay 110v) Capacitor X X (Pump Relay 220v) Sensor X X Temperature Filter, Inline X ¼ Flare Filter, Inline X ½ Acme Master Filter Drier X Tube (Aluminum) X X To Low Pressure Side Tube (Aluminum) X X To High Pressure Side Tube (Aluminum) X X Input Side of Condenser Tube (Aluminum) X X Output side of Oil Separator Tube (Aluminum) X X Input Side of Suction Separator Bowl Tube (Aluminum) X X Output Side of Suction Separator Bowl Bracket X X Rear Hose Bracket, Oil X X Cap and Shield X X Top of S. S. bowl Fitting, Atomizer X X Kit, O-Ring ARG04040 X For R-134a Adapters -09/-10 Hose, 96 Red (90º) EAH0001C01A X Vehcile Hose Hose, 96 Blue (90º) EAH0001C02A X Vehicle Hose Kit, O-Ring EAK0027C00AS X For R-134a Adapters -07/-08 Bowl, Metal Kit EAK0071C00AS X X 12/98 Page 4-15

CHAPTER 4 PARTS PARTS BY PICTORIAL. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS PARTS BY PICTORIAL. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description for Serial

More information

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description for Serial

More information

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description of the Serial

More information

Parts Reference Manual

Parts Reference Manual KOOL KARE XTREME EEAC319A EEAC320A Parts Reference Manual April, 2004 All information contained or disclosed in this document is considered confidential and proprietary by Snap-on Tools Company. All manufacturing,

More information

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description of the Serial

More information

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS. This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS BY PICTORIAL This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description of the Serial

More information

CHAPTER 4 PARTS. 1234av This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation.

CHAPTER 4 PARTS. 1234av This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. CHAPTER 4 PARTS PARTS LIST 1234av This chapter describes assemblies/subassemblies/parts considered replaceable at on-site field installation. NOTE: The following is a breakdown description of the Serial

More information

Prodigy Eclipse ECC, EH330 and EH430 C or D Service Parts

Prodigy Eclipse ECC, EH330 and EH430 C or D Service Parts This part list contains the service parts for the Eclipse 00, 00, and 800 systems. D series models began early 0 The models that are covered include: EH0 C & D EH0 C & D ECC00 ECC00 ECC800 Contents Head

More information

Prodigy Eclipse 600, 800, 1000 Service Parts

Prodigy Eclipse 600, 800, 1000 Service Parts Prodigy Eclipse 600, 800, 000 Service Parts This part list contains the service parts for the Eclipse 600, 800 and 000 systems. The B series references changes to panels. The models that are covered include:

More information

Eclipse 2000 Service Parts

Eclipse 2000 Service Parts This part list contains the service parts for the Eclipse 000 systems. The models that are covered include: CME08 CP08 ERC08 Eclipse 000 Service Parts Table of Contents CME08 Cabinet Page CME08 Interior

More information

348002K/348012K Manifold Block Style Service Manual 12/2000

348002K/348012K Manifold Block Style Service Manual 12/2000 348002K/348012K Manifold Block Style Service Manual 12/2000 Service Manual 348002K/348012K Manifold Block Style Recovery/Recycling/Recharging Unit For R-12 or R-134a Only TABLE OF CONTENTS: Theory of Operation

More information

SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL-ICE0250, ICE0400, ICE0500, ICE0606

SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL-ICE0250, ICE0400, ICE0500, ICE0606 MODEL-ICE0250, ICE0400, ICE0500, ICE0606 ICE SERIES CUBERS SERVICE PARTS MANUAL Includes 50Hz. Units Ice-O-Matic 11100 East 45th Ave Denver, Colorado 80239 Part Number 9081299-01 Date 6/13 Table Of Contents

More information

Rev.2.06A www.cmadishmachines.com Table of Contents EST-44 1. PARTS MANUAL... 3 1.1. Initial Parts Kit... 3 1.2. Exploded View Drawings... 4 1.2.1. Cabinet Assembly... 4 1.2.2. Control Box Assembly (3

More information

Prodigy Eclipse 600, 800, 1000 Service Parts

Prodigy Eclipse 600, 800, 1000 Service Parts Prodigy Eclipse 600, 00, 000 Service Parts This part list contains the service parts for the Eclipse 600, 00 and 000 systems. The B series references changes to panels. The models that are covered include:

More information

Centrifugal Chiller PE046, PE047, PE048, PE050 PEH PF083, PF096, PF105, PF116 PH PHH PL

Centrifugal Chiller PE046, PE047, PE048, PE050 PEH PF083, PF096, PF105, PF116 PH PHH PL Centrifugal Chiller PE046, PE047, PE048, PE050 PEH046-050 PF083, PF096, PF105, PF116 PH046-050 PHH046-050 PL-906-49 Unit ASSY. - Labels / 1987 to Present Unit ASSY. - Labels / 1987 to Present No. Index

More information

Parts List. Modular Flaker Serenity Series. Model FS-1022MLH-C. hoshizakiamerica.com

Parts List. Modular Flaker Serenity Series. Model FS-1022MLH-C. hoshizakiamerica.com Parts List Modular Flaker Serenity Series Model hoshizakiamerica.com Number: 71320 Issued: 3-17-2011 Revised: 9-26-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main Assembly & Refrigeration

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Low-Profile Modular Crescent Cuber Models KML-61MAH KML-61MWH KML-61MRH A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 7126 Issued: -1-2007 Revised: 9--201

More information

Parts List. Modular Cubelet Serenity Series Models FS-1500MLH-C. hoshizakiamerica.com

Parts List. Modular Cubelet Serenity Series Models FS-1500MLH-C. hoshizakiamerica.com Parts List Modular Cubelet Serenity Series Models FS-1500MLH-C hoshizakiamerica.com Number: 71333 Issued: 7-25-2011 Revised: 9-26-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Flaker Models FD-1001MAH-C, MRH-C A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71302 Issued: 4-14-2010 Revised: 5-13-2015 CONTENTS Auxiliary Codes...

More information

Parts List. Self-Contained Cubelet. Models C-80BAJ C-80BAJ-DS C-80BAJ-AD C-80BAJ-ADDS. hoshizakiamerica.com

Parts List. Self-Contained Cubelet. Models C-80BAJ C-80BAJ-DS C-80BAJ-AD C-80BAJ-ADDS. hoshizakiamerica.com Parts List Self-Contained Cubelet Models C-80BAJ C-80BAJ-DS C-80BAJ-AD hoshizakiamerica.com Number: 7198 Issued: 1-7-017 CONTENTS Auxiliary Codes... Note About Ordering Parts... A. Main Assembly... 4 B.

More information

Centrifugal Chiller PEH087 PL

Centrifugal Chiller PEH087 PL Centrifugal Chiller PEH087 PL-906-39 Unit Assy. - Unit Labels Unit Assy. - Unit Labels No. Index Parts No. Parts Name Drwg. No. Parts Model & Specifi cation Q ty/unit Wiring Symbol Notes 931 6006215 LABEL

More information

Item MF CMF EMF LP Code Part Description Part #

Item MF CMF EMF LP Code Part Description Part # 32.0 MF SERIES FLAKERS MF2006-CMF2306-EMF2306 AIR, WATER & REMOTE Item MF CMF EMF LP Code Part Description Part # 2006 2306 2306 2306 AIR COOLED 5 Air Condenser 9141056-01 X X X 10 Fan Blade 9131053-01

More information

PARTS MANUAL. American Dish Service MODELS: ADC-44 L-R/R-L ADS CONVEYOR DISHWASHER EFFECTIVE: MAY, 2008

PARTS MANUAL. American Dish Service MODELS: ADC-44 L-R/R-L ADS CONVEYOR DISHWASHER EFFECTIVE: MAY, 2008 EFFECTIVE: MAY, 2008 ADS CONVEYOR DISHWASHER MODELS: ADC-44 L-R/R-L PARTS MANUAL 900 Blake Street Edwardsville, Kansas 66111 (913)422-3700 05/08 211-0044L-R / 212-0044R-L ADC-44 Conveyor Dishwasher 2 211-0044L-R

More information

Parts List. Stackable Crescent Cuber. Models KM-1601MRJ/3. hoshizakiamerica.com

Parts List. Stackable Crescent Cuber. Models KM-1601MRJ/3. hoshizakiamerica.com Parts List Stackable Crescent Cuber Models KM-1601MRJ/3 hoshizakiamerica.com Number: 71394 Issued: 11-1-2017 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main Assembly & Refrigeration

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Stackable Crescent Cuber Models A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71332 Issued: 7-7-2011 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts...

More information

PARTS MANUAL. American Dish Service ADS CONVEYOR DISHWASHER MODELS: ADC-66 L-R/R-L EFFECTIVE: MAY, 2011

PARTS MANUAL. American Dish Service ADS CONVEYOR DISHWASHER MODELS: ADC-66 L-R/R-L EFFECTIVE: MAY, 2011 EFFECTIVE: MAY, 2011 ADS CONVEYOR DISHWASHER MODELS: ADC-66 L-R/R-L PARTS MANUAL 900 Blake Street Edwardsville, Kansas 66111 (913)422-3700 05/08 213-0066 L-R / 214-0066 R-L ADC-66 Conveyor Dishwasher 2

More information

Centrifugal Chiller. PF/PFH Size: 063. Replacement Parts List No Revision V 05/2012

Centrifugal Chiller. PF/PFH Size: 063. Replacement Parts List No Revision V 05/2012 Replacement Parts List No. 057113900 Revision V 05/2012 Centrifugal Chiller PF/PFH Size: 063 To find your Daikin McQuay parts distributor, call 1-800-377-2787 or visit www.daikinmcquay.com Contents Parts

More information

Rev.2.05 www.cmadishmachines.com Table of Contents EST-44 1. PARTS MANUAL... 3 1.1. Initial Parts Kit... 3 1.2. Exploded View Drawings... 4 1.2.1. Cabinet Assembly... 4 1.2.2. Control Box Assembly... 5

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Flaker Models F-1500MAH(-C) F-1500MWH(-C) F-1500MRH(-C) A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71223 Issued: 11-11-2004 Revised: 10-8-2014

More information

No. F ISSUED: Jul. 1, 2010 REVISED: Nov. 26, 2013 HOSHIZAKI MODULAR CRESCENT CUBER KMD-270AA MODEL

No. F ISSUED: Jul. 1, 2010 REVISED: Nov. 26, 2013 HOSHIZAKI MODULAR CRESCENT CUBER KMD-270AA MODEL No. F049-3353 ISSUED: Jul. 1, 2010 REVISED: Nov. 26, 2013 HOSHIZAKI MODULAR CRESCENT CUBER MODEL KMD-270AA S LIST (GENERAL) V-1 JUL. 2010 A-2 APR. 2011 AUXILIARY CODE U - 1 The auxiliary code is the first

More information

CATALOG OF REPLACEMENT PARTS HQC QUICKCHILLS. A product of HOBART CORPORATION 701 S. RIDGE AVENUE TROY, OHIO FORM (June 2001)

CATALOG OF REPLACEMENT PARTS HQC QUICKCHILLS. A product of HOBART CORPORATION 701 S. RIDGE AVENUE TROY, OHIO FORM (June 2001) CATALOG OF REPLACEMENT PARTS HQC QUICKCHILLS HQC135 HQC200 ML-124045 ML-124046 A product of HOBART CORPORATION 701 S. RIDGE AVENUE TROY, OHIO 45374-0001 FORM 43009 (June 2001) 28 PRB1 PRB2 PRB3 6 27 11

More information

MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.04A

MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.04A MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.04A CMA DISHMACHINES 12700 KNOTT STREET GARDEN GROVE, CALIFORNIA 92841 800-854- 6417 FAX 714-895-2141 www.cmadishmachines.com TABLE OF CONTENTS PARTS

More information

PARTS LIST PONY 20 SCA

PARTS LIST PONY 20 SCA PARTS LIST PONY 20 SCA WIRING DIAGRAM PART NO. PART DESCRIPTION 4990601 GEARMOTOR - 120 VOLT 4990581 GEARMOTOR - 240 VOLT 4890391 VAC MOTOR - 115 VOLT 4891251 VAC MOTOR - 240 VOLT 4991321 BRUSH MOTOR -

More information

Section 4. Reference Materials

Section 4. Reference Materials Section 4. Reference Materials. A00 Refrigeration Schematic 2. A00 Refrigeration Schematic- Mode. A00 Refrigeration Schematic- Mode 2 4. A00 Refrigeration Schematic- Mode. A00 Refrigeration Schematic-

More information

CHAPTER 4 PARTS AND DIAGRAMS

CHAPTER 4 PARTS AND DIAGRAMS CHAPTER 4 PARTS AND DIAGRAMS FRONT VIEW 2 1 3 6 5 4 ITEM DESCRIPTION PART NUMBER ITEM DESCRIPTION PART NUMBER 1 Gauge, Vacuum Asmb. MV2008010 5 Drawer, Plastic MV0105002 1a Lens, Vacuum Gauge MV0501910

More information

C1448, C1848, C2148 Service Parts

C1448, C1848, C2148 Service Parts C8, C88, C8 Service Parts This part list contains the service parts for the air cooled, water cooled and remote air cooled C8, C88, C8 ice machines. To avoid costly and time consuming errors, double check

More information

QUEST NT. Illustrated Parts List. Release Date: August 17, 2004 Publication Number: IPL Revision Date: July 28, 2015 Revision: J

QUEST NT. Illustrated Parts List. Release Date: August 17, 2004 Publication Number: IPL Revision Date: July 28, 2015 Revision: J QUEST NT Illustrated Parts List Release Date: August 17, 2004 Publication Number: 720901117IPL Revision Date: July 28, 2015 Revision: J Visit the Cornelius web site at www.cornelius.com for all your Literature

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Flaker Models F-1001MAH(-C)(-22C) F-1001MWH(-C) F-1001MRH(-C) F-1001MLH(-C) A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71196 Issued: 10-29-2001

More information

Parts Catalog. Generator Set TGHAA (Spec A C) Printed in U.S.A. Replaces (Spec A) 1 97

Parts Catalog. Generator Set TGHAA (Spec A C) Printed in U.S.A. Replaces (Spec A) 1 97 Parts Catalog TGHAA Generator Set Printed in U.S.A. 9 00 (Spec A C) 9 Replaces 9 00 (Spec A) 97 To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from

More information

Parts List. Self-Contained Cubelet. Models C-101BAH C-101BAH-DS C-101BAH-AD C-101BAH-ADDS. hoshizakiamerica.com

Parts List. Self-Contained Cubelet. Models C-101BAH C-101BAH-DS C-101BAH-AD C-101BAH-ADDS. hoshizakiamerica.com Parts List Self-Contained Cubelet Models C-101BAH C-101BAH-DS C-101BAH-AD hoshizakiamerica.com Number: 7150 Issued: 8--01 Revised: 11--016 CONTENTS Auxiliary Codes... Note About Ordering Parts... A. Main

More information

34.0 EMF SERIES FLAKERS EMF 450, EMF800, EMF1106 AIR, WATER AND REMOTE

34.0 EMF SERIES FLAKERS EMF 450, EMF800, EMF1106 AIR, WATER AND REMOTE Shaded Code indicates updated information AIR COOLED 5 Air Condenser 9141002-01 X 5 Air Condenser 9141017-01 X 5 Air Condenser 9141046-01 X 10 Fan Blade 9131133-02 10 Fan Blade 9131133-01 X 10 Fan Blade

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Self-Contained Crescent Cuber Models A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71260 Issued: 12-11-2006 CONTENTS Auxiliary Codes... 3 Note About Ordering

More information

QGD-20/25/30 & QGD-40/50

QGD-20/25/30 & QGD-40/50 QGD-0/5/0 & QGD-40/50 Direct Drive Rotary Screw Air Compressor Parts Manual This manual contains important safety information and should be made available to all personnel who operate and/or maintain this

More information

Date 1/31/ E. 45th Avenue Denver, CO

Date 1/31/ E. 45th Avenue Denver, CO SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL-ICE0250A1,A2,A3-T1,T2,T3-W1,W2,W3 MODEL-ICE0400A1,A2-T1,T2-W1,W2 MODEL-ICE0500A1,A2-T1,T2-W1,W2-R1,R2,R3 MODEL-ICE0606A1,A2-T1,T2-W1,W2-R1,R2,R3 Includes 50Hz.

More information

Parts List. Cubelet Icemaker/Dispenser. Models DCM-270BAH-OS. hoshizakiamerica.com

Parts List. Cubelet Icemaker/Dispenser. Models DCM-270BAH-OS. hoshizakiamerica.com Parts List Cubelet Icemaker/Dispenser Models hoshizakiamerica.com Number: 1231 Issued: 2-11-2004 Revised: 9-18-201 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts... 3 A. Main Assembly... 4 B.

More information

MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.03B

MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.03B MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.03B C M A D I S H M A C H I N E S 1 2 7 0 0 K N O T T S T R E E T GARDEN GROVE, CALIFORNIA 92841 800-8 5 4-6 4 1 7 FAX 714-895-2141 www.cmadishmachines.com

More information

AFD-280U Parts List AFD-280U. (350 gm) (450 gm) (700 gm)

AFD-280U Parts List AFD-280U. (350 gm) (450 gm) (700 gm) AFD-80U (350 gm) (50 gm) (700 gm) I 0 Major Assemblies, AFD-80U AFD-80U Front View AFD-80U Parts List AFD -80U Front View ITEM P/N DESCRIPTION NO. FUNCTION 036 Hopper Lid Cover for the Fry Hopper. 99 Fry

More information

Item MF CMF EMF LP Code Part Description Part # GRP

Item MF CMF EMF LP Code Part Description Part # GRP MF SERIES FLAKERS MF2006-CMF2306-EMF2306 AIR, WATER & REMOTE Item MF CMF EMF LP Code Part Description Part # GRP 2006 2306 2306 2306 AIR COOLED 5 Air Condenser 9141056-01 AC X X X 10 Fan Blade 9131053-01

More information

For more Parts Information: https://manitowocfsg.sysonline.com/default.aspx

For more Parts Information: https://manitowocfsg.sysonline.com/default.aspx For more Parts Information: https://manitowocfsg.sysonline.com/default.aspx TABLE OF CONTENTS Manitowoc Foodservice [Updated: Sep. 30, 2013] Manitowoc - Ice & Related Parts Catalog Ice Machine S Series

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Models KMD-450MAH KMD-450MWH A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71275 Issued: 7-2-2009 CONTENTS Auxiliary Codes... 3 Note

More information

MODELS AH/B/C/Scullery/Pizza/Bowl PARTS MANUAL Rev 1.03B

MODELS AH/B/C/Scullery/Pizza/Bowl PARTS MANUAL Rev 1.03B MODELS AH/B/C/Scullery/Pizza/Bowl PARTS MANUAL Rev 1.03B C M A D I S H M A C H I N E S 1 2 7 0 0 K N O T T A V E N U E GARDEN GROVE, CALIFORNIA 92841 800-8 5 4-6 4 1 7 FAX 714-895-2141 TABLE OF CONTENTS

More information

HVH-100E ELECTRIC HYDROVECTION HELIX OVEN REPLACEMENT PARTS LIST

HVH-100E ELECTRIC HYDROVECTION HELIX OVEN REPLACEMENT PARTS LIST HVH-00E ELECTRIC HYDROVECTION HELIX OVEN REPLACEMENT PARTS LIST EFFECTIVE JULY 8, 0 Superseding All Previous s Lists. The Company reserves the right to make substitution in the event that items specified

More information

DISCONTINUED VERSION Parts listed in this catalog may no longer be available. ILLUSTRATED PARTS CATALOG

DISCONTINUED VERSION Parts listed in this catalog may no longer be available. ILLUSTRATED PARTS CATALOG BUNN COMBO BREWER DISCONTINUED VERSION Parts listed in this catalog may no longer be available. ILLUSTRATED PARTS CATALOG Designs, materials, weights, specifications, and dimensions for equipment or replacement

More information

Parts List. Self-Contained Flaker. Models F-300BAF. hoshizakiamerica.com

Parts List. Self-Contained Flaker. Models F-300BAF. hoshizakiamerica.com Parts List Self-Contained Flaker Models hoshizakiamerica.com Number: 71126 Issued: 10-20-2016 CONTENTS Auxiliary Codes... Note About Ordering Parts... A. Main Assembly... B. Icemaking Unit... 7 C. Water

More information

MODELS YCRL0064, 0074, 0084, 0096, 0118, 0126, 0156, 0177, 0198, 0200, 0230, 0260, 0300, 0345, 0385, 0445, 0530 and YCRL0610 STYLE "A"

MODELS YCRL0064, 0074, 0084, 0096, 0118, 0126, 0156, 0177, 0198, 0200, 0230, 0260, 0300, 0345, 0385, 0445, 0530 and YCRL0610 STYLE A WATER-COOLED LIQUID CHILLERS HERMETIC SCROLL RENEWAL PARTS Supercedes: 150.7-RP1 (709) Form: 150.7-RP1 (810) MODELS YCRL0064, 0074, 0084, 0096, 0118, 016, 0156, 0177, 0198, 000, 030, 060, 0300, 0345, 0385,

More information

MODELS CMA-180/180TALL Including 480V MACHINES PARTS MANUAL Rev 2.08A

MODELS CMA-180/180TALL Including 480V MACHINES PARTS MANUAL Rev 2.08A MODELS CMA-180/180TALL Including 480V MACHINES PARTS MANUAL Rev 2.08A C M A D I S H M A C H I N E S 1 2 7 0 0 K N O T T A V E N U E GARDEN GROVE, CALIFORNIA 92841 800-8 5 4-6 4 1 7 FAX 714-895-2141 www.cmadishmachines.com

More information

DFG-50 GAS CONVECTION OVEN REPLACEMENT PARTS LIST

DFG-50 GAS CONVECTION OVEN REPLACEMENT PARTS LIST DFG-50 GAS CONVECTION OVEN REPLACEMENT PARTS LIST EFFECTIVE APRIL 19, 2012 Superseding All Previous Parts Lists. The Company reserves the right to make substitution in the event that items specified are

More information

For more Parts Information:

For more Parts Information: For more Parts Information: https://manitowocfsg.sysonline.com/default.aspx TABLE OF CONTENTS Manitowoc Foodservice [Updated: Apr. 23, 2015] Manitowoc - Ice & Related Parts Catalog Ice Machine Indigo Series

More information

Centrifugal Chiller Single Compressor WSC048, WSC050 TSC048, TSC050 HSC048, HSC050 PL

Centrifugal Chiller Single Compressor WSC048, WSC050 TSC048, TSC050 HSC048, HSC050 PL Centrifugal Chiller Single Compressor WSC048, WSC050 TSC048, TSC050 HSC048, HSC050 PL-906-47 Nomenclature Nomenclature END VIEW- MICROTECH 200 UNITS 6003231 UNIT DATAPLATE 070191901 UNITS WITH FACTORY

More information

34.0 EMF SERIES FLAKERS EMF 450, EMF800, EMF1106 AIR, WATER AND REMOTE

34.0 EMF SERIES FLAKERS EMF 450, EMF800, EMF1106 AIR, WATER AND REMOTE AIR COOLED 5 Air Condenser 9141002-01 AC X 5 Air Condenser 9141017-01 AC X 5 Air Condenser 9141046-01 AC X 10 Fan Blade 9131133-02 AC 10 Fan Blade 9131133-01 AC X 10 Fan Blade 9131204-01 AC X 15 Fan Motor

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Flaker Models FD-1001MAH(-C) FD-1001MRH-C A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71302 Issued: 4-14-2010 CONTENTS Auxiliary Codes... 3 Note

More information

SERVICE MANUAL / PARTS LIST MODEL XSG-5

SERVICE MANUAL / PARTS LIST MODEL XSG-5 ation SERVICE MANUAL / PARTS LIST MODEL XSG-5 1055 Mendell Davis Drive Jackson MS 39272 888-994-7636 601-372-3903 Fax 888-864-7636 unifiedbrands.net PART NUMBER 158634 REV B (11/11) TABLE OF CONTENTS 2

More information

MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.05A

MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.05A MODELS EAH / EC/E TALL/3-Door Parts Manual Revision 1.05A C M A D I S H M A C H I N E S 1 2 7 0 0 K N O T T S T R E E T GARDEN GROVE, CALIFORNIA 92841 800-8 5 4-6 4 1 7 FAX 714-895-2141 www.cmadishmachines.com

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Models KML-250MAH, MWH A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71192 Issued: 9-18-2001 Revised: 2-23-2015 CONTENTS Auxiliary

More information

ASTRO AMC-2000 SERIES ENVELOPE FEEDER

ASTRO AMC-2000 SERIES ENVELOPE FEEDER ASTRO AMC-2000 SERIES ENVELOPE FEEDER PARTS CATALOG GROUP 1 Page 1 KEY # PART # DESCRIPTION QTY. KEY # PART # DESCRIPTION QTY. 1. 84-100-56B FRONT FRAME CLOSURE 1 24. 84-125-108 RETAINER STRAP ASSEMBLY

More information

MODELS AH/B/C/Scullery/Pizza/Bowl PARTS MANUAL Rev 1.04B

MODELS AH/B/C/Scullery/Pizza/Bowl PARTS MANUAL Rev 1.04B MODELS AH/B/C/Scullery/Pizza/Bowl PARTS MANUAL Rev 1.04B C M A D I S H M A C H I N E S 1 2 7 0 0 K N O T T A V E N U E GARDEN GROVE, CALIFORNIA 92841 800-8 5 4-6 4 1 7 FAX 714-895-2141 TABLE OF CONTENTS

More information

COS-8G & COS-8GDS COMBI OVENS BCS-G STEAMER CNV-8G CONVECTION OVEN REPLACEMENT PARTS LIST

COS-8G & COS-8GDS COMBI OVENS BCS-G STEAMER CNV-8G CONVECTION OVEN REPLACEMENT PARTS LIST COS-G & COS-GDS COMBI OVENS BCS-G STEAMER CNV-G CONVECTION OVEN REPLACEMENT PARTS LIST EFFECTIVE APRIL 0, 0 Superseding All Previous Parts Lists. The Company reserves the right to make substitution in

More information

REPLACEMENT PARTS MANUAL

REPLACEMENT PARTS MANUAL REPLACEMENT PARTS MANUAL WALL MOUNTED PACKAGED AIR CONDITIONER Models: W1AA-A WAA-A WAA-B WAA-C WAA-D WAA-F General Notes Revised and/or additional pages may be issued from time to time. A complete and

More information

AF200. 6/25/2014 9:47:21 AM Page 1 of 23

AF200. 6/25/2014 9:47:21 AM Page 1 of 23 AF200 1 UNIT PANELS - up to S.N. 01675 2 UNIT PANELS - from S.N. 01676 3 REFRIGERANT SYSTEM - AIR COOLED - UP TO S.N. 04192 4 REFRIGERANT SYSTEM - AIR COOLED - FROM S.N. 04193 5 REFRIGERANT SYSTEM WATER

More information

Parts List. Cubelet Icemaker/Dispenser. Models DCM-751BAH DCM-751BAH-OS DCM-751BWH DCM-751BWH-OS. hoshizakiamerica.com

Parts List. Cubelet Icemaker/Dispenser. Models DCM-751BAH DCM-751BAH-OS DCM-751BWH DCM-751BWH-OS. hoshizakiamerica.com Parts List Cubelet Icemaker/Dispenser Models DCM-751BAH DCM-751BAH-OS DCM-751BWH DCM-751BWH-OS hoshizakiamerica.com Number: 71321 Issued: 7-18-2011 Revised: 7-27-2017 CONTENTS Auxiliary Codes... 3 Note

More information

LChevrolet Camaro Supercharger Kit

LChevrolet Camaro Supercharger Kit PART #92000A Important Notes: 2010-2013 6.2LChevrolet Camaro Supercharger Kit The use of fuel additives (ie. octane boosters) is not recommended. There is a possibility that these chemicals can damage

More information

For more Parts Information:

For more Parts Information: For more Parts Information: https://manitowocfsg.sysonline.com/default.aspx TABLE OF CONTENTS Manitowoc Foodservice [Updated: Sep. 30, 2013] Manitowoc - Ice & Related Parts Catalog Ice Machine S Series

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Models KMD-700MAH KMD-700MWH KMD-700MRH A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71221 Issued: 5-29-2003 Revised: 1-9-2008 CONTENTS

More information

MP GS/GD. Toll Free Phone, (US & Canada): (800) Toll Free Fax, (US & Canada): (800)

MP GS/GD. Toll Free Phone, (US & Canada): (800) Toll Free Fax, (US & Canada): (800) MP GS/GD Toll Free Phone, (US & Canada): (800) 427-6668 Toll Free Fax, (US & Canada): (800) 36-7745 http://www.garland-group.com Page 2 Moisture + MP-GS/GD DESCRIPTION PAGE Deluxe Control Panel 4 Standard

More information

For more Parts Information:

For more Parts Information: For more Parts Information: https://manitowocfsg.sysonline.com/default.aspx TABLE OF CONTENTS Manitowoc Foodservice [Updated: Sep. 30, 2013] Manitowoc - Ice & Related Parts Catalog Ice Machine S Series

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Models KM-515MAH KM-515MWH KM-515MRH A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71274 Issued: 1-28-2008 Revised: 2-24-2015 CONTENTS

More information

Standard Accessories for HA

Standard Accessories for HA MODEL HA06-322 HA06-322 É 26.5 200 324. Specifications Model HA06-322 38 Max. Throat Depth Punching Capacity (for Mild Steel) Diameter Thickness 2-3/8" (60) 7/8" (22) /2" (3) 76 2 50.5 83 30 4.5 24 60.

More information

SECTION 5 PARTS LISTS & EXPLODED VIEWS

SECTION 5 PARTS LISTS & EXPLODED VIEWS Model 506 (UC Ice Maker) Parts Lists & Exploded Views SECTION 5 PARTS LISTS & EXPLODED VIEWS 5-1 #3752200 - Revision B - May, 2006 Parts Lists & Exploded Views Model 506 (UC Ice Maker) 506 CABINET, LINER

More information

ASTRO AMC-2000 SERIES ENVELOPE FEEDER

ASTRO AMC-2000 SERIES ENVELOPE FEEDER ASTRO AMC-2000 SERIES ENVELOPE FEEDER PARTS CATALOG GROUP 1 Page 1 GROUP 1 1. 84-100-56B FRONT FRAME CLOSURE 1 25. 84-130-20 SKID WHEEL ASSEMBLY 1 2. 71-140-08 FRONT ENV. GUIDE ASSEMBLY, R/H 1 26. 123-0407

More information

M O D E L S E S T / E S T T A L L PARTS MANUAL Rev 1.07B C M A D I S H M A C H I N E S K N O T T S T R E E T GARDEN GROVE, CALIFORNIA 92841

M O D E L S E S T / E S T T A L L PARTS MANUAL Rev 1.07B C M A D I S H M A C H I N E S K N O T T S T R E E T GARDEN GROVE, CALIFORNIA 92841 M O D E L S E S T / E S T T A L L PARTS MANUAL Rev 1.07B C M A D I S H M A C H I N E S 1 2 7 0 0 K N O T T S T R E E T GARDEN GROVE, CALIFORNIA 92841 800-8 5 4-6 4 1 7 FAX 714-895-2141 www.cmadishmachines.com

More information

NM650 SERVICE PARTS TABLE OF CONTENTS. Cabinet Air Cooled Refrigeration Water Cooled Refrigeration Water System Gearmotor...

NM650 SERVICE PARTS TABLE OF CONTENTS. Cabinet Air Cooled Refrigeration Water Cooled Refrigeration Water System Gearmotor... This parts list contains the service parts and wiring diagrams for this model. Check the model number in question to be sure that it is applicable to this parts list. Caution: This model ice maker has

More information

MDT5N25 & MTD5N40 SERVICE PARTS

MDT5N25 & MTD5N40 SERVICE PARTS This parts list contains the service parts and wiring diagrams for this model. Check the model number of the machine requiring the parts to be sure that this is the correct parts list. MDTNs & MDTN0s have

More information

Parts List. Self-Contained Cubelet. Models AM-50BAE AM-50BAE-DS AM-50BAE-AD AM-50BAE-ADDS. hoshizakiamerica.com

Parts List. Self-Contained Cubelet. Models AM-50BAE AM-50BAE-DS AM-50BAE-AD AM-50BAE-ADDS. hoshizakiamerica.com Parts List Self-Contained Cubelet Models AM-50BAE AM-50BAE-DS AM-50BAE-AD hoshizakiamerica.com Number: 71211 Issued: 9-23-2002 Revised: 2-15-2018 CONTENTS Auxiliary Codes... 3 Note About Ordering Parts...

More information

Parts List. Cubelet Icemaker/Dispenser. Models DCM-500BAH DCM-500BWH. hoshizakiamerica.com

Parts List. Cubelet Icemaker/Dispenser. Models DCM-500BAH DCM-500BWH. hoshizakiamerica.com Parts List Cubelet Icemaker/Dispenser Models DCM-500BAH DCM-500BWH hoshizakiamerica.com Number: 785 Issued: 7-8-00 Revised: -5-08 CONTENTS Auxiliary Codes... Note About Ordering Parts... A. Ice Dispenser

More information

Vision 17B/BT. Section II Parts and Service Manual (78454B) CLARKE TECHNOLOGY Operator's Manual - Vision 17B/BT Page -23-

Vision 17B/BT. Section II Parts and Service Manual (78454B) CLARKE TECHNOLOGY Operator's Manual - Vision 17B/BT Page -23- Vision 17B/BT Section II Parts and Service Manual (78454B) Operator's Manual - Vision 17B/BT Page -23- HOW TOO CORRECT PROBLEMS IN THE MACHINE PROBLEM CAUSE ACTION There isn't any solution flow. The solution

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Modular Crescent Cuber Model A Superior Degree of Reliability PARTS LIST www.hoshizaki.com 89/336 73/23 Number: 71289 Issued: 9-22-2008 CONTENTS Auxiliary Codes... 3 Note About

More information

SECTION 6 PARTS LIST

SECTION 6 PARTS LIST SECTION FIGURE NO. DESCRIPTION PAGE NO. -1 - - -4-5 - - -8-9 Oven Panels, Window and Legs Exploded Drawing Air Finger Exploded Drawing Control Panel Exploded Drawing Blower and Shroud Exploded Drawing

More information

www.cmadishmachines.com Table of Contents CMA-44 1. PARTS MANUAL... 4 1.1. Initial Parts Kit (P/N 13996.81)... 4 1.2. Initial Parts Kit (P/N 13996.80)... 5 1.3. Exploded View Drawings... 6 1.3.1. Cabinet

More information

SPARE PARTS CATALOG OFFICE PRO 18. DocID: 00G00077EB

SPARE PARTS CATALOG OFFICE PRO 18. DocID: 00G00077EB SPARE PARTS CATALOG DocID: 00G00077EB Table of Contents No. UNIT PART NUMBER SERIAL NUMBER RANGE REFRIGERANT SECTION 1 GX8000-711 GX8000-710 007XXXX180 to Present (From April 2007 to Present) R10A Page

More information

www.cmadishmachines.com Table of Contents CMA-66 1. PARTS MANUAL... 4 1.1. Initial Parts Kit (P/N 13996.81)... 4 1.2. Initial Parts Kit (P/N 13996.80)... 5 1.3. Exploded View Drawings... 6 1.3.1. Cabinet

More information

Hoshizaki America, Inc.

Hoshizaki America, Inc. Hoshizaki America, Inc. Self-Contained Cubelet Models C-100BAE-AD C-100BAE-ADDS A Superior Degree of Reliability PARTS LIST www.hoshizaki.com Number: 71278 Issued: 3-25-2008 Revised: 6-14-2012 CONTENTS

More information

REPLACEMENT PARTS MANUAL with Illustrations

REPLACEMENT PARTS MANUAL with Illustrations H. C. Duke & Son, Inc. P/N 184930-01 January 2000 Printed in U.S.A. REPLACEMENT PARTS MANUAL with Illustrations MR. MISTY Model 185 184930-01 01/00 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6

More information

Ariazone 5001 Automotive A/C Service Station

Ariazone 5001 Automotive A/C Service Station Ariazone 5001 Automotive A/C Service Station Spare Parts List 1 COMPONENT LOCATION AND IDENTIFICATION Ariazone 5001FAHD - Modules 1. Vacuum Pump 2.Recovery Pump (Compressor) 3. Oil Separator 4. Air Cooled

More information

REPLACEMENT PARTS MANUAL

REPLACEMENT PARTS MANUAL REPLACEMENT PARTS MANUAL WALL MOUNTED PACKAGED AIR CONDITIONER Models: WLB-A WLB-A WLB-B WLB-F General Notes Revised and/or additional pages may be issued from time to time. A complete and current manual

More information

PARTS LIST WRANGLER 2625 DB

PARTS LIST WRANGLER 2625 DB PARTS LIST WRANGLER 2625 DB 1 NOTES 2 BRUSH GEAR MOTOR ITEM PART NO. PART DESCRIPTION QTY. 2393501 COMPLETE MOTOR ASSEMBLY 1 101 3391221 NEGATIVE LEAD 1 102 3391201 1/4-20 X 7 3/4THRU BOLT 2 103 10-24

More information

Crescent Cuber. Model KM-101BAH PARTS LIST

Crescent Cuber. Model KM-101BAH PARTS LIST Crescent Cuber Model KM-101BAH S LIST Number: M007-3039 Issued: 7-16-2007 Revised: 9-14-2015 Auxiliary Codes KM-101BAH S-1 Jury 2007 S-2 September 2007 S-3 December 2007 T-0 January 2008 T-1 May 2008 U-0

More information

PARTS LIST FOR WLP-40-0M10 WATER RECYCLING TREATMENT SYSTEM

PARTS LIST FOR WLP-40-0M10 WATER RECYCLING TREATMENT SYSTEM PARTS LIST FOR WLP-40-0M10 WATER RECYCLING TREATMENT SYSTEM Copyright 2006, Mi-T-M Corporation 1 Congratulations on the purchase of your new Mi-T-M water treatment system! This parts listing has been complied

More information

SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0806A3-W3-R4, ICE1006A3-W3-R4 Includes 50Hz. and 3 Phase Units

SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0806A3-W3-R4, ICE1006A3-W3-R4 Includes 50Hz. and 3 Phase Units SERVICE PARTS MANUAL ICE SERIES CUBERS MODEL - ICE0806A3-W3-R4, ICE1006A3-W3-R4 Includes 50Hz. and 3 Phase Units Ice-O-Matic 11100 East 45th Ave Denver, Colorado 80239 Part Number 9081307-02 Date 1/09

More information

Toll Free Phone, (US & Canada): (800) Toll Free Fax, (US & Canada): (800)

Toll Free Phone, (US & Canada): (800) Toll Free Fax, (US & Canada): (800) Toll Free Phone, (US & Canada): (800) 427-6668 Toll Free Fax, (US & Canada): (800) 361-7745 http://www.garland-group.com MODEL: MCO-GS/GD-10 MU - CE UNITS Oven Manufactured Up To May 29, 2008 DESCRIPTION

More information

Model: J TRANSFLOW Transmission Cooling System Service Tool

Model: J TRANSFLOW Transmission Cooling System Service Tool PANZITTA SALES & SERVICE 72 George Avenue Wilkes-Barre, PA 18705 570-822-6720 800-822-6720 www.panzittasales.com Model: J-45096 TRANSFLOW Transmission Cooling System Service Tool 3 Plumbing Diagram & Parts

More information