LP Spare parts list. Duplex roller. s/n BGF Engine: Hatz 1D Construction Tools EOOD No

Transcription

1 LP 6505 Spare parts list Duplex roller s/n BGF Engine: Hatz 1D Construction Tools EOOD No

2 F1700C Spare parts list General information This spare parts list applies to the following: Part number Description LP 6505 Duplex roller, manual start LP 6505 Duplex roller, electric start LP 6505 Duplex roller, electric start EPA Use only authorized parts. Any damage or malfunction caused by the use of unauthorized parts is not covered by Warranty or Product Liability. Any unauthorized use or copying of the contents or any part thereof is prohibited. This applies in particular to trademarks, model denominations, part numbers, and drawings. Instructions for use This spare parts list contains no safety regulations and is merely intended to assist in the ordering of spare parts. For information about operating, servicing, or repairing, the relevant Safety and operating instructions must be consulted at all costs. Please observe the safety instructions listed in the relevant Safety and operating instructions!

3 Contents Service, repair and wear part kits One year service kit 1 Push stop repair kit 3 Shock absorber repair kit, engine plate 5 Shock absorber repair kit, handle 7 Mechanical Frames and scrapers 9 Sprinkler system 11 Front hood 13 Rear hood 15 Drum 17 Drum installation 19 Eccentric element 21 Handle 23 Engine Engine installation, Hatz 1D42 electric start 27 Engine installation, Hatz 1D 42, manual start 29 Centrifugal clutch 31 Hydraulic system Hydraulic system, drum motor installation 33 Hydraulic system, oil filter, vibrating pump and valve 35 Hydraulic system, oil tank, radiator and pumps. 39 Electric system Electric equipment 43 Labels Labels 45 Options / accessories Crank handle kit 47

4 Service, repair and wear part kits One year service kit Wed Jul 01 04:47:00 MDT

5 Item Part No. Name Qty L One year service kit Oil filter Valve cover gasket Air filter element Fuel filter Oil filter, complete 1 Wed Jul 01 04:47:00 MDT

6 Service, repair and wear part kits Push stop repair kit Wed Jul 01 04:47:00 MDT

7 Item Part No. Name Qty L Push stop complete, repair kit Trigger shaft Spring Plain washer, 17 x 40 x 3 mm Bellow Spring pin Button Hex sock. Screw M6 x 16 1 Wed Jul 01 04:47:00 MDT

8 Service, repair and wear part kits Shock absorber repair kit, engine plate Wed Jul 01 04:47:01 MDT

9 Item Part No. Name Qty L Shock abosorber repair kit, engine plate Shock absorber Hexagon socket head cap screw Screw Washer din125 d13 st 37 4 Wed Jul 01 04:47:01 MDT

10 Service, repair and wear part kits Shock absorber repair kit, handle Wed Jul 01 04:47:01 MDT

11 Item Part No. Name Qty L Shock absorber repair kit, handle Shock absorber Screw DIN Plain washer Hexagon nut 4 Wed Jul 01 04:47:01 MDT

12 Mechanical Frames and scrapers Wed Jul 01 04:47:02 MDT

13 Item Part No. Name Qty L Lifting device Screw Washer lock Screw M10x Engine base Shock absorber Screw Washer din125 d13 st Hexagon socket head cap screw Strap Hex. head screw M12 x Washer 13x36x Lower frame Scraper Plain washer Hood lock rod Set screw 2 Wed Jul 01 04:47:02 MDT

14 Mechanical Sprinkler system Wed Jul 01 04:47:02 MDT

15 Item Part No. Name Qty L 1 - Water tank, complete Filler cap Water tank Hexagon bolt Flat washer M 8.40/ Hex sock. Screw Plain washer(a) 6.4 x 12 x Cover Sprinkler pipe, complete Pipe End plug Pipe clamp Pipe clamp Plain washer(a) 6.4 x 12 x Hexagon bolt Plastic hose T-adapter Plastic hose Hose connection Quick coupling Plastic hose Hose connector Plastic hose Bracket Connection Ball valve Plastic hose Sprinkler pipe, complete End plug Pipe 1 Wed Jul 01 04:47:02 MDT

16 Mechanical Front hood Wed Jul 01 04:47:03 MDT

17 Item Part No. Name Qty L Front hood Flat head screw Flat washer M 8.40/ Lock nut M8 ISO Hinge, right Bushing Screw M8x50 ISO Hinge, left Gas spring Washer-flat:m 5.30/ Nut Bracket, right Bracket, left Bracket, lower Nut M 8.0d Rubber stop Square neck screw, M8 x 40 mm Hood clip Plate 1 Wed Jul 01 04:47:03 MDT

18 Mechanical Rear hood Wed Jul 01 04:47:03 MDT

19 Item Part No. Name Qty L Rear hood Flat head screw Hinge Flat washer M 8.40/ Lock nut M8 ISO Bushing Screw M8x50 ISO Bracket, right Screw M 8x Screw M 8x Bracket, left 1 Wed Jul 01 04:47:03 MDT

20 Mechanical Drum Wed Jul 01 04:47:04 MDT

21 Item Part No. Name Qty L Drum bracket Drum motor Serrated wedge lock washer m Hexagon socket head cap screw Drum Drum shaft Plain washer Screw Oil seal Pipe clamp Bearing bracket Oil seal Ball bearing O-ring, Ø 84.5 x 3 mm, Ø 3.33 x 0.12 in Lock ring Bearing cover Flat washer M 8.40/ Hexagon bolt Lock washer Screw:m16 x 55 Wed Jul 01 04:47:04 MDT

22 Mechanical Drum installation Wed Jul 01 04:47:04 MDT

23 Item Part No. Name Qty L Tight fitting screw, M10 D 12x40 mm, Zn-Ni Hexagon socket head cap screw 16 Wed Jul 01 04:47:04 MDT

24 Mechanical Eccentric element Wed Jul 01 04:47:05 MDT

25 Item Part No. Name Qty L Hexagon bolt Flat washer M 8.40/ Bearing cover O-ring, Ø 84.5 x 3 mm, Ø 3.33 x 0.12 in Ball bearing Plug Plug Eccentric shaft Coupling Bearing cover O-ring Plain washer Screw M10x 30 3 Wed Jul 01 04:47:05 MDT

26 Mechanical Handle Wed Jul 01 04:47:06 MDT

27 Item Part No. Name Qty L Hex sock. screw Plain washer(a) 6.4 x 12 x Direction control, complete Handle and cable support, complete Control cable, complete Control lever Hex. Sock. Screw Locknut Handle Edge trim Shock absorber Plain washer Hexagon nut Screw DIN Screw Bushing Hexagon nut Hook Shock absorber Hex sock. screw Hexagon bolt Pipe clamp Pipe clamp Push stop complete, repair kit Trigger shaft Spring Plain washer, 17 x 40 x 3 mm Bellow Spring pin Button Hex sock. Screw M6 x Vibration control, complete Handle and control cable support Control cable, complete Hexagon nut Flat washer O-ring, 14 x 1.78 mm 1 Wed Jul 01 04:47:06 MDT

28 This page intentionally left blank Wed Jul 01 04:47:06 MDT

29 Item Part No. Name Qty L Hexagon socket head cap screw Housing Holder O-ring, x 1.78 mm Guide sleeve Lock nipple Clamp Throttle control bracket Hex sock. Screw M6 x Throttle control, complete Handle, complete Control cable, complete Clamp Nipple Screw, M6 x 16 mm Screw, M5 x 30mm ISO A Bracket 1 Wed Jul 01 04:47:06 MDT

30 Engine Engine installation, Hatz 1D42 electric start Wed Jul 01 04:47:06 MDT

31 Item Part No. Name Qty L Hex socket head cap screw Plain washer(a) 6.4 x 12 x Air inlet Screw M 8x Flat washer M 8.40/ Hexagon bolt Bracket Holder, control panel Screw, M6 x 16 mm Shaft Bracket, oil cooler Engine, complete Hatz 1D ENGINE Start box, complete Hexagon bolt Lock nut M8 ISO Clutch, complete Heat protection, complete Heat protection Cable tie, stainless Pipe clamp Exhaust pipe Nut Serrated wedge lock washer m Screw, M12 x 50 mm Oil drain hose, complete Hose Plug Screw Ryw-clips Protective plate Edge trim 1 Wed Jul 01 04:47:06 MDT

32 Engine Engine installation, Hatz 1D 42, manual start Wed Jul 01 04:47:07 MDT

33 Item Part No. Name Qty L Hex socket head cap screw Plain washer(a) 6.4 x 12 x Air inlet Screw M 8x Flat washer M 8.40/ Screw DIN912 M8x zn Bracket Holder Screw, M6 x 16 mm Shaft Bracket, oil cooler Engine Hatz 1D42 Manual start, complete Safety crank handle Crank holder Hexagon bolt Lock nut M8 ISO Clutch, complete Heat protection Pipe clamp Exhaust pipe Nut Serrated wedge lock washer m Screw, M12 x 50 mm Oil drain hose, complete Hose Plug Screw Ryw-clips Screw DIN912 M8x zn 2 Wed Jul 01 04:47:07 MDT

34 Engine Centrifugal clutch Wed Jul 01 04:47:08 MDT

35 Item Part No. Name Qty L Clutch, complete Plug Flange Lining Weight Spring Lock washer Screw Hub Cover Retaining ring Retaining ring Screw Pin Bearing Clutch housing Flange Screw M6x12 6 Wed Jul 01 04:47:08 MDT

36 Hydraulic system Hydraulic system, drum motor installation Wed Jul 01 04:47:09 MDT

37 Item Part No. Name Qty L Pipe support Hydraulic pipe Hydraulic pipe Hydraulic pipe Hydraulic pipe Drum motor, complete Hex sock. Screw Hose holder Hex sock. Screw Hose holder Hydraulic pipe Hydraulic pipe Hydraulic pipe Hydraulic hose Nipple, complete(valid to s/n BES043706) O-ring, x 1.78 mm0.49 x 0.07 in. (90 shore) Connection Seal ring Hydraulic hose Hydraulic hose Hydraulic pump Hydraulic hose Connection O-ring Connector Seal ring Hydraulic hose Hydraulic block Hex. Head screw Plain washer(a) 6.4 x 12 x Hydraulic hose Hydraulic hose Straight connector Straight connector Straight connector 2 Wed Jul 01 04:47:09 MDT

38 Hydraulic system Hydraulic system, oil filter, vibrating pump and valve Wed Jul 01 04:47:10 MDT

39 Item Part No. Name Qty L Hydraulic hose Hydraulic pump Hose connection Hydraulic pump Straight connection Connection Seal ring Connection O-ring Hose connection Straight connection Hydraulic hose Hydraulic oil filter, complete Housing Oil filter, complete Oil filter Kit, O-ring 18 - O-ring O-ring Filter spacer T-connection Hudraulic hose Connector Screw, M8 x 60 mm Flat washer M 8.40/ Vibrating valve Pipe connector Hydraulic hose Connector Hydraulic block Hydraulic hose Hydraulic hose Connector Hex sock. Screw Flange fitting O-ring Connector 1 Wed Jul 01 04:47:10 MDT

40 This page intentionally left blank Wed Jul 01 04:47:10 MDT

41 Item Part No. Name Qty L Hydraulic pump Plain washer Hex. Head screw Washer Straight connector Hudraulic pipe Clamp Plain washer(a) 6.4 x 12 x Hex sock. Screw 5 Wed Jul 01 04:47:10 MDT

42 Hydraulic system Hydraulic system, oil tank, radiator and pumps. Wed Jul 01 04:47:11 MDT

43 Item Part No. Name Qty L Hydraulic oil tank, complete Ventilating filter Splash guard Oil tank Hose clamp Hose clamp Hydraulic hose Flat washer M 8.40/ Screw M 8x Hydraulic hose Elbow Hydraulic hose Elbow Nipple, complete(valid to s/n BES043706) O-ring, x 1.78 mm0.49 x 0.07 in. (90 shore) Connection Seal ring Hydraulic pump Washer, 10.5 x 22 x 4 mm Screw M10x Hydraulic pump Screw, M10 x 1.25 x 100 mm Plain washer Fan Bracket Hexagon bolt Flat washer M 8.40/ Screw M6x10 ISO Elbow Oil cooler Bracket, oil cooler Screw Countersunk screw Washer, 8.4 x2 2 x 3 mm Nut M 8.0d Connection O-ring 1 Wed Jul 01 04:47:11 MDT

44 This page intentionally left blank Wed Jul 01 04:47:11 MDT

45 Item Part No. Name Qty L 38 - Connection Seal ring Hexagon bolt Plug, VSTI R 1/4-ED Hydraulic block Hydraulic hose Pipe clamp Plain washer(a) 6.4 x 12 x Wed Jul 01 04:47:11 MDT

46 Electric system Electric equipment Wed Jul 01 04:47:12 MDT

47 Item Part No. Name Qty L Pipe clamp Plain washer(a) 6.4 x 12 x Screw M6x10 ISO Screw, M5 x 8 mm Washer-flat:m 5.30/ Clamp Connection cable, complete (-) Connection cable, complete (+) Screw M10x Plain washer Battery securing plate Rubber protection Battery Rubber protection Battery holder Hex sock. Screw M6 x Screw 4 Wed Jul 01 04:47:12 MDT

48 Labels Labels Wed Jul 01 04:47:12 MDT

49 Item Part No. Name Qty L Safety label, hot surfaces label, lifting point Label, water Safety label, read instruction manual Safety label, maximum slope angle Label, nosie level Safety label, read instructions, ear protection and safety boots Label, hydraulic oil filter Data plate Label, securing point Label, operator panel Safety label, rotating fan blades Label, hydraulic oil level Safety label, handle lock Label. sprinkler Label, start panel Product label, "Atlas Copco" Product label, "LP 6505" Product label, "Atlas Copco" 1 Wed Jul 01 04:47:13 MDT

50 Options / accessories Crank handle kit Wed Jul 01 04:47:13 MDT

51 Item Part No. Name Qty L Safety crank handle kit Safety crank handle Crank holder Screw DIN912 M8x zn Flat washer M 8.40/16 3 Wed Jul 01 04:47:13 MDT

52 F1700C Spare parts list Any unauthorized use or copying of the contents or any part thereof is prohibited. This applies in particular to trademarks, model denominations, part numbers, and drawings.