SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
|
|
- Lily Martin
- 6 years ago
- Views:
Transcription
1 192 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM DT B1153/25 ircuit Malfunction DESRIPTION The seat position airbag sensor circuit consists of the center airbag sensor assembly and the seat position airbag sensor. DT B1153/25 is recorded when a malfunction is detected in the seat position airbag sensor circuit. DT No. DT Detecting ondition Trouble rea B1153/25 When one of the following conditions is met: The center airbag sensor assembly detects a line short signal, open signal, short to ground signal, or short to B+ signal in the seat position airbag sensor circuit. Seat position airbag sensor malfunction enter airbag sensor assembly malfunction Seat position airbag sensor enter airbag sensor assembly ront seat inner belt assembly LH loor wire No. 2 WIRI DIGRM (*2) (*1) (*2) (*1) ront Seat Inner Belt ssembly LH enter irbag *1: with Side and urtain Shield irbag *2: without Side and urtain Shield irbag E01
2 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 193 INSPETION PROEDURE 1 HEK DT D DL3 enter irbag DT B1153/25 (d) (e) lear the DTs stored in memory (See page -35). Turn the ignition switch to the L position. heck the DTs (See page -35). : DT B1153/25 is not output. odes other than code B1153/25 may be output at this time, but they are not related to this check. Go to step 2 G T E01 USE SIMULTION METHOD TO HEK 2 HEK ONNETO (d) (e) Turn the ignition switch to the L position. Disconnect the negative (-) terminal cable from the battery, and wait for at least 90 seconds. heck that the connectors are properly connected to the center airbag sensor assembly, seat position airbag sensor and front seat inner belt assembly LH. : The connectors are properly connected. If the connectors are not connected securely, reconnect the connectors and proceed to the next inspection. Disconnect the connectors from the center airbag sensor assembly, seat position airbag sensor and front seat inner belt assembly LH. heck that the terminals of the connectors are not damaged. : The terminals are not deformed or damaged.
3 194 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM REPLE WIRE HRNESS 3 HEK SET POSITION IRBG SENSOR IRUIT (OPEN) E D B enter irbag Using a service wire, connect terminals and LSPof connector B. NOTIE: Do not forcibly insert a service wire into the terminals of the connector when connecting. Measure the resistance between the terminals of connector E according to the value(s) in the Tester onnection ondition Specified ondition 1-2 lways Below 1 Ω onnector E onnector B *1: with Side and curtain shield airbag *2: without Side and curtain shield airbag 30 (*1) Go to step 10 Service Wire onnector B Service Wire 31 (*2) E01
4 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM HEK SET POSITION IRBG SENSOR IRUIT (SHORT TO GROUND) E D B enter irbag Disconnect the service wire from connector B. Measure the resistance according to the value(s) in the Tester onnection ondition Specified ondition 1 - Body ground lways 1MΩ or higher 2 - Body ground lways 1MΩ or higher Go to step 11 onnector E E01 5 HEK SET POSITION IRBG SENSOR IRUIT (SHORT) E D B enter irbag Measure the resistance according to the value(s) in the Tester onnection ondition Specified ondition 1-2 lways 1MΩ or higher Go to step 12 onnector E E01
5 196 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 6 HEK SET POSITION IRBG SENSOR IRUIT (SHORT TO B+) E D B enter irbag onnect the negative (-) terminal cable to the battery, and wait for at least 2 seconds. Turn the ignition switch to the ON position. Measure the voltage according to the value(s) in the Standard voltage Tester onnection ondition Specified ondition 1 - Body ground Ignition switch ON Below 1 V 2 - Body ground Ignition switch ON Below 1 V Go to step 13 onnector E E01 7 HEK SET POSITION IRBG SENSOR D G DL3 T enter irbag DT B1153/25 (d) (e) (f) (g) (h) (i) Turn the ignition switch to the L position. Disconnect the negative (-) terminal cable from the battery, and wait for at least 90 seconds. onnect the connectors to the seat position airbag sensor and the center airbag sensor assembly. onnect the negative (-) terminal cable to the battery, and wait for at least 2 seconds. lear the DTs stored in memory (See page -35). Turn the ignition switch to the L position. heck the DTs (See page -35). : DT B1153/25 is not output. odes other than code B1153/25 may be output at this time, but they are not related to this check E01 Go to step 8
6 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 197 USE SIMULTION METHOD TO HEK 8 REPLE SET POSITION IRBG SENSOR Turn the ignition switch to the L position. Disconnect the negative (-) terminal cable from the battery, and wait for at least 90 seconds. Replace the seat position airbag sensor. (See page - 443). Perform the inspection using parts from a normal vehicle if possible. NEXT 9 HEK ENTER IRBG SENSOR SSEMBLY DL3 D enter irbag DT B1153/25 (d) (e) (f) onnect the negative (-) terminal cable to the battery, and wait for at least 2 seconds. lear the DTs stored in memory (See page -35). Turn the ignition switch to the L position. heck the DTs (See page -35). : DT B1153/25 is not output. odes other than code B1153/25 may be output at this time, but they are not related to this check. REPLE ENTER IRBG SENSOR SSEMBLY G T E01 END
7 198 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 10 HEK LOOR WIRE NO. 2 (OPEN) ront Seat Inner Belt ssembly LH E onnector D B loor Wire No. 2 enter irbag onnector B Disconnect the front seat inner belt assembly LH connector from the floor wire No. 2 connector. The service wire has already been inserted into connector B. Measure the resistance of connector according to the value(s) in the Tester onnection ondition Specified ondition -2 () - -4 () lways Below 1 Ω *1: with Side and curtain shield airbag *2: without Side and curtain shield airbag 30 (*1) REPLE LOOR WIRE NO. 2 Service Wire onnector B 31 (*2) Service Wire E01 REPLE RONT SET INNER BELT SSEMBLY LH
8 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM HEK LOOR WIRE NO. 2 (SHORT TO GROUND) ront Seat Inner Belt ssembly LH E D B onnector loor Wire No. 2 enter irbag Disconnect the front seat inner belt assembly LH connector from the floor wire No. 2 connector. Measure the resistance according to the value(s) in the Tester onnection ondition Specified ondition -2 () - Body ground lways 1MΩ or higher -4 () - Body ground lways 1MΩ or higher REPLE LOOR WIRE NO E01 REPLE RONT SET INNER BELT SSEMBLY LH
9 200 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM 12 HEK LOOR WIRE NO. 2 (SHORT) ront Seat Inner Belt ssembly LH E D B loor Wire No. 2 enter irbag Disconnect the front seat inner belt assembly LH connector from the floor wire No. 2 connector. Measure the resistance according to the value(s) in the Tester onnection ondition Specified ondition -2 () - -4 () lways 1MΩ or higher REPLE LOOR WIRE NO. 2 onnector E01 REPLE RONT SET INNER BELT SSEMBLY LH
10 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM HEK LOOR WIRE NO. 2 (SHORT TO B+) ront Seat Inner Belt ssembly LH E D B loor Wire No. 2 enter irbag (d) (e) (f) Turn the ignition switch to the L position. Disconnect the negative (-) terminal cable from the battery, and wait for at least 90 seconds. Disconnect the front seat inner belt assembly LH connector from the floor wire No. 2 connector. onnect the negative (-) terminal cable to the battery, and wait for at least 2 seconds. Turn the ignition switch to the ON position. Measure the voltage according to the value(s) in the Standard voltage onnector Tester onnection ondition Specified ondition -2 () - Body ground Ignition switch ON Below 1 V -4 () - Body ground Ignition switch ON Below 1 V REPLE LOOR WIRE NO E01 REPLE RONT SET INNER BELT SSEMBLY LH
SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 213 DT 1835/58 DT 1836/58 DT 1837/58 DT 1838/58 Short in Front Passenger Side urtain Shield Squib ircuit Open in Front Passenger Side urtain Shield Squib ircuit Short
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
152 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM T B1140/32 ircuit Malfunction IPTION The side airbag sensor assembly RH circuit consists of the safing sensor, the diagnostic circuit and the lateral deceleration
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
122 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM DT 1647/82 Lost ommunication with Front Passenger Side Satellite Sensor us DESRIPTION The side airbag sensor RH and the rear airbag sensor RH consist of parts
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 85 DT 1628/82 Front Passenger Side - Side irbag Sensor ssembly Initialization Incomplete DESRIPTION The side airbag sensor RH and the rear airbag sensor RH consist
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 203 DT 1825/56 DT 1826/56 DT 1827/56 DT 1828/56 Short in Front Passenger Side - Side Squib ircuit Open in Front Passenger Side - Side Squib ircuit Short to GND in
More informationDTC B1154/38 Rear Airbag Sensor RH Circuit Malfunction
202 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM T B1154/38 ircuit Malfunction ESRIPTION The rear airbag sensor RH circuit consists of the safing sensor, the diagnostic circuit and the lateral deceleration
More informationDTC B1805/52 Short in Front Passenger Side Squib Circuit. DTC B1806/52 Open in Front Passenger Side Squib Circuit
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 177 DT 1805/52 Short in Front Passenger Side Squib ircuit DT 1806/52 Open in Front Passenger Side Squib ircuit DT 1807/52 DT 1808/52 Short to GND in Front Passenger
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM. DTC B1800/51 Short in Driver Side Squib Circuit. DTC B1801/51 Open in Driver Side Squib Circuit
170 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM DT 1800/51 Short in Driver Side Squib ircuit DT 1801/51 Open in Driver Side Squib ircuit DT 1802/51 Short to GND in Driver Side Squib ircuit DT 1803/51 Short
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM 191 DT 1815/54 DT 1816/54 DT 1817/54 DT 1818/54 Short in Front Passenger Side Squib 2nd Step ircuit Open in Front Passenger Side Squib 2nd Step ircuit Short to GND
More informationDTC B1810/53 Short in Driver Side Squib 2nd Step Circuit. DTC B1811/53 Open in Driver Side Squib 2nd Step Circuit
184 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM DT 1810/53 Short in Driver Side Squib 2nd Step ircuit DT 1811/53 Open in Driver Side Squib 2nd Step ircuit DT 1812/53 DT 1813/53 Short to GND in Driver Side Squib
More informationDTC B1651/33 Manual Cut off Switch Trouble
137 T 1651/33 Manual ut off Switch Trouble ESRIPTION The airbag cut-off switch circuit consists of the center airbag sensor assembly and the airbag cut off switch. T 1651/33 is set when a malfunction is
More informationSRS Warning Light Remains ON
232 SUPPLEMENTL RESTRINT SYSTEM IRG SYSTEM S Warning Light Remains ON DESRIPTION The S warning light is located on the combination meter. When the S condition is normal, the S warning light illuminates
More informationDTC B1772 Seat Position Sensor Circuit Malfunction
500 SUPPLEMENTL RESTRINT SYSTEM OUPNT LSSIFITION SYSTEM (for T 1772 ircuit Malfunction ESRIPTION The seat position sensor circuit consists of the occupant classification EU and the seat position sensor.
More informationRear Occupant Classification Sensor LH Circuit Malfunction
SUPPLEMENTL RESTRINT SYSTEM OUPNT LSSIFITION SYSTEM 281 T 1782 ircuit Malfunction ESRIPTION The rear occupant classification sensor LH circuit consists of the occupant classification and the rear occupant
More informationDTC B1150/23 Occupant Classification System Malfunction
172 SUPPLMNTL RSTRINT SYSTM IRG SYSTM DT 1150/23 lassification System Malfunction DSRIPTION The occupant classification system circuit consists of the center airbag sensor assembly and the occupant classification
More informationDTC B0101/14 Open in Driver Side Squib Circuit
54 DT 0101/14 Open in ircuit DSRIPTION The driver side squib circuit consists of the center airbag sensor assembly, the spiral cable and the steering pad. The circuit instructs the S to deploy when deployment
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM
262 SUPPLEMENTL RESTRINT SYSTEM IRBG SYSTEM DTC B1825/56 DTC B1826/56 DTC B1827/56 DTC B1828/56 Short in Circuit Open in Circuit Short to GND in Front Passenger Side - Side Squib Circuit Short to B+ in
More informationDTC B1625/22 SIDE AIRBAG SENSOR ASSEMBLY (P SEAT SIDE) MALFUNCTION
051434 IGNOSTIS SUPPLEMENTL RESTRINT SYSTEM T 1625/22 SIE IRG SENSOR SSEMLY (P SET SIE) MLFUNTION 05IXH01 IRUIT IPTION The side airbag sensor assembly (P seat side) consists of the safing sensor, the diagnostic
More informationDTC C1268/68 Transfer "L4" Position Switch Circuit
RKE ONTROL VEHILE STILITY ONTROL SYSTEM 135 DT 1268/68 Transfer "L4" Position Switch ircuit DESRIPTION fter confirming that the transfer is in the L4 position, -TR and downhill assist control will be activated
More informationP0A38/257 GENERATOR TEMPERATURE SENSOR CIRCUIT LOW P0A39/259 GENERATOR TEMPERATURE SENSOR CIRCUIT HIGH
DT DIGNOSTIS P038/257 GENERTOR TEMPERTURE SENSOR IRUIT LOW 05537 05J601 DT P039/259 GENERTOR TEMPERTURE SENSOR IRUIT HIGH IRUIT DESRIPTION The motor temperature sensor No. 2 detects the temperature of
More informationDTC B1153/25 SEAT POSITION AIRBAG SENSOR MALFUNCTION
051094 DIGNOSTICS SUPPLMNTL RSTRINT SYSTM DTC 1153/25 ST POSITION IRG SNSOR MLUNCTION 05UJ01 CIRCUIT DSCRIPTION The seat position airbag sensor circuit consists of the airbag sensor assy center and the
More informationDTC B1650/32 Occupant Classification System Malfunction
SUPPLMNTL RSTRINT SYSTM IRG SYSTM 125 DTC 1650/32 System Malfunction DSCRIPTION The occupant classification system circuit consists of the center airbag sensor assembly and the occupant classification
More informationDTC B1801/51 OPEN IN D SQUIB CIRCUIT
051466 DIGNOSTICS DTC B1801/51 OPEN IN D SQUIB CIRCUIT 05IXN01 CIRCUIT DESCRIPTION The D squib circuit consists of the airbag assy, the spiral cable subassy and the horn button assy. The circuit instructs
More informationDTC B1141/33 Side and Curtain Shield Airbag Sensor Assembly (LH) Malfunction
DTC B1141/33 and Curtain Shield Assembly (LH) Malfunction 05719 05A1N01 CIRCUIT DESCRIPTION The side airbag sensor assy LH circuit consists of the diagnosis circuit and lateral deceleration sensor, etc.
More informationThe driver side squib circuit consists of the center airbag sensor assembly, the spiral cable and the steering pad.
Page 1 of 19 DTC B1800/51 SHORT IN DRIVER SIDE SQUIB CIRCUIT; DTC B1801/51 OPEN IN DRIVER SIDE SQUIB CIRCUIT; DTC B1802/51 SHORT TO GND IN DRIVER SIDE SQUIB CIRCUIT; DTC B1803/51 SHORT TO B+ IN DRIVER
More informationDTC 51 Switch Condition Signal Circuit
EG614 EINE TROUBLESHOOTI DT 51 Switch ondition Signal ircuit IRUIT DESRIPTION Park/Neutral Position Switch Signal The EM uses the signals from the Park/neutral position switch to determine whether the
More informationDTC B1790 AIRBAG SENSOR ASSY CENTER COMMUNICATION CIRCUIT MALFUNCTION
051493 DTC 1790 IRG SNSOR SSY CNTR COMMUNICTION CIRCUIT MLUNCTION 05IX302 CIRCUIT DSCRIPTION The airbag sensor assy center communication circuit consists of the occupant classification CU and the airbag
More informationDTC P0340 Camshaft Position Sensor A Circuit. DTC P0341 Camshaft Position Sensor A Circuit Range/Performance
DIAGNOSTIS EINE (2UZFE) DI637 DIDRK01 DT P0340 amshaft Position Sensor A ircuit DT P0341 amshaft Position Sensor A ircuit Range/Performance DT P0345 amshaft Position Sensor A ircuit (Bank 2) DT P0346 amshaft
More informationDTC B1152/28 PASSENGER AIRBAG ON/OFF INDICATOR LIGHT CIRCUIT MALFUNCTION
051352 DIGNOSTICS DTC 1152/28 PSSEER IRG ON/OFF INDICTOR LIGHT CIRCUIT MLFUNCTION 05IVQ02 CIRCUIT DESCRIPTION The passenger airbag ON/OFF indicator light circuit consists of the airbag sensor assy center
More informationELECTRONIC CIRCUIT INSPECTION PROCEDURE
0 34 INTRODUTION HOW TO TROUBLESHOOT EU ONTROLLED ELETRONI IRUIT INSPETION PROEDURE. BSI INSPETION (a) RESISTNE MESURING ONDITION OF ELETRONI PRTS () Unless stated, all resistance is measured at an ambient
More informationDTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION
05714 DTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION 05A1M01 CIRCUIT DESCRIPTION The side airbag sensor assy RH consists of the diagnosis circuit and lateral deceleration sensor, etc. It receives
More informationSeat Belt Warning Light for Passenger Seat does not Flash
5 TER TER / GUGE SYSTEM Seat elt Warning Light for Passenger Seat does not Flash WIRI DIGRM ench Seat: Instrument Panel J/ No. Hazard Warning Signal Switch P 7 PF 3 PF P 3 IG+ Driver Side J/ IL IL 8 GR-
More informationDTC B1140/32 Side Airbag Sensor Assy (RH) Malfunction
DI428 DIAGNOSTICS DI9HU01 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTION The side airbag sensor assy (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.
More informationDTC B1141/33 Side Airbag Sensor Assy (LH) Malfunction
DI434 DI9HV01 DTC B1141/33 Side (LH) Malfunction CIRCUIT DESCRIPTION The side airbag sensor assy (LH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc. It receives
More informationDTC B1141/33 Side Airbag Sensor Assembly (LH) Malfunction
DI350 DI6ZX04 DTC B1141/33 Side (LH) Malfunction CIRCUIT DESCRIPTI The side airbag sensor assembly (LH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc. It receives
More informationDTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION
05644 DTC B1140/32 SIDE AIRBAG SENSOR ASSY (RH) MALFUNCTION 055Z603 CIRCUIT DESCRIPTION The side airbag sensor assy (RH) consists of the diagnosis circuit and lateral deceleration sensor, etc. It receives
More informationDTC B1156/B1157/15 Front Airbag Sensor (RH) Malfunction
DI309 DI6PW03 DTC B1156/B1157/15 Malfunction CIRCUIT DESCRIPTION The front airbag sensor (RH) circuit consists of the airbag sensor assembly and front airbag sensor (RH). For details of the function of
More informationDTC C2121/21 No Signal from Transmitter ID1. DTC C2122/22 No Signal from Transmitter ID2. DTC C2123/23 No Signal from Transmitter ID3
TIRE ND WHEEL TIRE PRESSURE WRNI SYSTEM 33 DTC C2121/21 No Signal from Transmitter ID1 DTC C2122/22 No Signal from Transmitter ID2 DTC C2123/23 No Signal from Transmitter ID3 DTC C2124/24 No Signal from
More informationDTC B0103/12 SHORT IN D SQUIB CIRCUIT (TO B+)
051246 DIGNOSTICS DTC B0103/12 SHORT IN D SQUIB CIRCUIT (TO B+) 0525G17 CIRCUIT DSCRIPTION The D squib circuit consists of the airbag sensor assy center, the spiral cable subassy and the horn button assy.
More informationDTC B1140/32 Side Airbag Sensor Assembly (RH) Malfunction
DI342 DIAGNOSTICS DI6ZW03 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTI The side airbag sensor assembly (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.
More informationDIAGNOSTIC TROUBLE CODE CHART
18 Cruise Control System DIAGNOSTIC TROUBLE CODE CHART If a trouble code is indicated while checking DTCs, inspect the listed for that code in the table below, and proceed to the applicable page. DTC No.
More informationCIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI248 CIRCUIT INSPECTION DI6P303 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
More informationDTC B0132/61 Short in LH and RH P/T Squib Circuit (to Ground)
DI44 DI58N0 DTC B03/6 Sht in LH and RH P/T Squib Circuit (to Ground) CIRCUIT DESCRIPTI The LH and RH P/T squib circuits consist of the airbag sens assembly and LH and RH seat belt pretensioners. It causes
More informationCIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI388 CIRCUIT INSPECTION DI18Q35 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
More informationCIRCUIT INSPECTION. DTC B0100/13 Short in D Squib Circuit CIRCUIT DESCRIPTION WIRING DIAGRAM
DI254 CIRCUIT INSPECTION DI18Q37 DTC B0100/13 Short in Circuit CIRCUIT DESCRIPTION The D squib circuit consists of the airbag sensor assembly, spiral cable and steering wheel pad. It causes the airbag
More informationSUNROOF. SUNROOF Component Parts and Harness Connector Location RF-10
omponent Parts and Harness onnector Location PFP:91210 NIS0023Q PII6291E 1. Fuse block (J/) 2. Fuse and fusible link box 3. M M1, M2, M3 (View with the glove box assembly removed) 4. Sunroof motor assembly
More informationBRAKE CONTROL VEHICLE STABILITY CONTROL SYSTEM. DTC No. DTC Detecting Conditions Trouble Areas
70 RKE CONTROL VEHICLE STILITY CONTROL SYSTEM DTC C0210/33 Rear Speed Sensor RH Circuit DTC C0215/34 Rear Speed Sensor LH Circuit DTC C1238/38 DTC C1239/39 DTC C1273/73 DTC C1274/74 DTC C1277/77 DTC C1278/78
More informationModel Year: 2008 Model: ES350 Doc ID: RM000002INN009X
1 of 12 Last Modified: 7-13-2007 Service Category: udio/visual/telematics 1.6 C Section: Park ssist/monitoring Model Year: 2008 Model: ES350 Doc ID: RM000002INN009X Title: PRK SSIST / MONITORING: INTUITIVE
More informationDTC C1341/62 MALFUNCTION IN HYDRAULIC SYSTEM (FR) DTC C1342/63 MALFUNCTION IN HYDRAULIC SYSTEM (FL) DTC C1343/64 MALFUNCTION IN HYDRAULIC SYSTEM (RR)
008 DIAGNOSTIS ELETRONIALL ONTOROLLED RAKE SSTEM DT 4/62 MALFUNTION IN HDRAULI SSTEM (FR) 0IZS0 DT 42/6 MALFUNTION IN HDRAULI SSTEM (FL) DT 4/64 MALFUNTION IN HDRAULI SSTEM (RR) DT 44/6 MALFUNTION IN HDRAULI
More informationDTC C0210/33 Rear Speed Sensor RH Circuit. DTC C0215/34 Rear Speed Sensor LH Circuit
RKE CONTROL VEHICLE STILITY CONTROL SYSTEM 65 DTC C0210/33 Rear Speed Sensor RH Circuit DTC C0215/34 Rear Speed Sensor LH Circuit DTC C1238/38 DTC C1239/39 Foreign Object is ttached on Tip of Rear Speed
More informationDTC B0103/12 Short in D and P Squib Circuit (to B+)
DI404 DIAGNOSTICS DI58L02 DTC B0103/12 Short in D and P Squib Circuit (to B+) CIRCUIT DESCRIPTI The D and P squib circuits consist of the airbag sensor assembly, spiral cable, steering wheel pad and front
More informationDTC C2121/21 No Signal from Transmitter ID1 in Main Mode. DTC C2122/22 No Signal from Transmitter ID2 in Main Mode
38 TIRE ND WHEEL TIRE PRESSURE WRNING SYSTEM DTC C2121/21 No Signal from Transmitter ID1 in Main Mode DTC C2122/22 No Signal from Transmitter ID2 in Main Mode DTC C2123/23 No Signal from Transmitter ID3
More informationDTC B0133/62 Short in LH and RH P/T Squib Circuits (to B+)
DI429 DI58O01 Sht in LH and RH P/T Squib Circuits CIRCUIT DESCRIPTI The LH and RH P/T squib circuits consist of the airbag sens assembly and LH and RH seat belt pretensioners. It causes the pretensioner
More informationDTC C1735/35 Exhaust Solenoid Valve Circuit
8 DTC C7/ DTC C74/4 Rear Height Control Gate Solenoid Valve Circuit Malfunction Rear Height Control Leveling Solenoid Valve Circuit Malfunction DTC C75/5 Exhaust Solenoid Valve Circuit DTC C744/44 Tank
More informationTrouble in Passenger Airbag ON / OFF Indicator
8 SUPPLEMENTAL RESTRAINT SYSTEM OCCUPANT CLASSIFICATION SYSTEM Trouble in Passenger Airbag ON / OFF Indicator DESCRIPTION The occupant classification system detects the front passenger seat condition and
More informationON-VEHICLE INSPECTION
32 SUSPENSION CONTROL AIR SUSPENSION SYSTEM ON-VEHICLE INSPECTION 1. CHECK FLUID LEAKAGE Check the connections of tube and parts for fluid leakage. : Supply parts only C099149E01 SUSPENSION CONTROL AIR
More informationNo Answer-Back (Hazard Warning Light and Wireless Door Lock Buzzer)
56 No nswer-ack (Hazard Warning Light and Wireless Door Lock uzzer) DESCRIPTION If there is no answer-back of the hazard warning lights and wireless door lock buzzer while the wireless control function
More informationDTC P0100 MASS AIR FLOW CIRCUIT MALFUNCTION
DIGNOSTICS DTC P0100 MSS IR FLOW CIRCUIT MLFUNCTION 0525 057HI01 CIRCUIT DESCRIPTION The mass air flow meter uses a platinum hot wire. The hot wire air flow meter consists of a platinum hot wire, thermistor
More informationDTC P0130 HEATED OXYGEN SENSOR CIRCUIT MALFUNCTION (BANK 1 SENSOR 1)
DIGNOSTICS SFI SYSTEM (2ZZGE) DTC P0130 HETED OXYGEN SENSOR CIRCUIT MLFUNCTION (NK 1 SENSOR 1) 05203 057HQ03 CIRCUIT DESCRIPTION Refer to DTC P0125 on page 05196. DTC No DTC Detecting Condition Trouble
More informationTIRE AND WHEEL TIRE PRESSURE WARNING SYSTEM. DTC C2121/21 No Signal from Transmitter ID1. DTC C2122/22 No Signal from Transmitter ID2
40 TIRE ND WHEEL TIRE PRESSURE WRNING SYSTEM DTC C2121/21 No Signal from Transmitter ID1 DTC C2122/22 No Signal from Transmitter ID2 DTC C2123/23 No Signal from Transmitter ID3 DTC C2124/24 No Signal from
More informationPRE CHECK 1. SRS WARNING LIGHT CHECK
H08442 PRECHECK DI287 DI4L104 1. SRS WARNING LIGHT CHECK (a) Turn the ignition switch to the ACC or ON position and check that the SRS warning light lights up. (b) Check that the SRS warning light goes
More informationSRS AIRBAG SECTION SR CONTENTS RESTRAINTS SR-1 PRECAUTION... 2 PREPARATION... 4 ON-VEHICLE REPAIR... 5
RSTRTS ST S R TTS RUT... 2 RUTS... 2 recaution for Supplemental Restraint System (S) "R " and "ST T R-T- SR"...2 Service...2 ccupant lassification System...2 recautions ecessary for Steering Wheel Rotation
More information2TR-FE ENGINE CONTROL SYSTEM SFI SYSTEM
116 2TR-FE ENGINE CONTROL SYSTEM SFI SYSTEM P0120 Throttle / Pedal Position Sensor / Switch "" Circuit P0122 Throttle / Pedal Position Sensor / Switch "" Circuit Low Input P0123 Throttle / Pedal Position
More informationDTC P0657 Actuator Supply Voltage Circuit / Open
1GR-FE EINE CONTROL SYSTEM SFI SYSTEM 277 DTC P0657 Actuator Supply Voltage Circuit / Open MONITOR DCRIPTION The ECM monitors the output voltage to the throttle actuator. This self-check ensures that the
More informationSUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM SYSTEM DIAGRAM. Front Airbag Sensor LH Steering Pad (Driver Side Squib)
16 SUPPLEMENTAL RESTRAINT SYSTEM AIRBAG SYSTEM SYSTEM DIAGRAM Front Airbag Sensor LH Steering Pad (Driver Side Squib) Front Airbag Sensor RH Front Passenger Airbag Assembly (Front Passenger Side Squib)
More information13.Curtain Airbag Sensor
urtain Airbag Sensor AIRAG SYSTEM 13.urtain Airbag Sensor A: REMOVAL 1. 4 DOOR MODEL 1) Disconnect the ground cable from battery and wait for at least 60 seconds before starting work. AUTION: Airbag system
More informationDTC P0657 Actuator Supply Voltage Circuit / Open
301 DTC P0657 Actuator Supply Voltage Circuit / Open DCRIPTION The ECM monitors the output voltage to the throttle actuator. This self-check ensures that the ECM is functioning properly. The output voltage
More informationSEAT BELT WARNING SYSTEM
SEAT BELT SEAT BELT WARNING SYSTEM 1 SEAT BELT WARNING SYSTEM System Name Power window control system (with Jam Protection Function) Sliding Roof System PRECAUTION When disconnecting the cable from the
More informationBefore repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable
More informationDTC P0617 STARTER RELAY CIRCUIT HIGH
0534 DTC P067 STARTER RELAY CIRCUIT HIGH 05DJY0 MONITOR DESCRIPTION While the engine is being cranked, the battery positive voltage is applied to terminal STA of the ECM. If the ECM detects the starter
More information1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM
118 1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM P0120 Throttle / Pedal Position Sensor / Switch "" Circuit P0122 Throttle / Pedal Position Sensor / Switch "" Circuit Low Input P0123 Throttle / Pedal Position
More informationRS 44 SUPPLEMENTAL RESTRAINT SYSTEM HINT:
RS44 DIAGNOSIS INSPECTION SRS warning light check (a) Turn the ignition switch to ACC or ON and check that the SRS warning light lights up. (b) Check that the SRS warning light goes out after approx. 6
More informationDTC P1349 VVT SYSTEM MALFUNCTION (BANK 1)
DIGNOSTICS SFI SYSTEM (2ZZGE) DTC P1349 VVT SYSTEM MLFUNCTION (NK 1) 05275 057I803 CIRCUIT DESCRIPTION VVT system controls the intake valve timing to proper timing in response to driving condition. ECM
More informationDI-377 SUPPLEMENTAL RESTRAINT SYSTEM DI58G-01 PRE-CHECK
W01632 PRECHECK DI377 DI58G01 1. SRS WARNING LIGHT CHECK (a) Turn the ignition switch to the ACC or ON position and check that the SRS warning light lights up. (b) Check that the SRS warning light goes
More informationDTC P0136 OXYGEN SENSOR CIRCUIT MALFUNCTION (BANK 1 SENSOR 2)
05122 DIGNOSTICS DTC P0136 OXYGEN SENSOR CIRCUIT MLFUNCTION (NK 1 SENSOR 2) 05CRR03 CIRCUIT DESCRIPTION Refer to DTC P0130 on page 0596. DTC No DTC Detection Condition Trouble rea P0136 The following condition
More informationDTC P0327 KNOCK SENSOR 1 CIRCUIT LOW INPUT (BANK 1 OR SINGLE SENSOR) DTC P0328 KNOCK SENSOR 1 CIRCUIT HIGH INPUT (BANK 1 OR SINGLE SENSOR)
DIGNOSTICS SFI SYSTEM (MZFE) DTC P07 KNOCK SENSOR CIRCUIT LOW INPUT (NK OR SINGLE SENSOR) 0557 05MOO0 DTC P08 KNOCK SENSOR CIRCUIT HIGH INPUT (NK OR SINGLE SENSOR) DTC P0 KNOCK SENSOR CIRCUIT LOW INPUT
More informationBRAKE CONTROL SYSTEM SECTION BRC CONTENTS BRAKES BRC-1 VDC/TCS/ABS BASIC INSPECTION... 5 COMPONENT DIAGNOSIS...57 FUNCTION DIAGNOSIS...
RKES SETION R RKE ONTROL SYSTEM ONTENTS E V/TS/S SI INSPETION... 5 IGNOSIS N REPIR WORKFLOW... 5 Work Flow...5 INSPETION N JUSTMENT... 7 PERFORM INITILIZTION OF LINER SOLE- NOI VLVE N LIRTION...7 PERFORM
More information1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM. DTC P0332 Knock Sensor 2 Circuit Low Input (Bank 2) DTC P0333 Knock Sensor 2 Circuit High Input (Bank 2)
182 1GR-FE EINE CONTROL SYSTEM SFI SYSTEM DTC DTC P0327 P0328 Knock Sensor 1 Circuit Low Input (ank 1 or Single Sensor) Knock Sensor 1 Circuit High Input (ank 1 or Single Sensor) DTC P0332 Knock Sensor
More informationRestraints Special Tools
Restraints Restraints Special Tools... 24-2 Seat Belts Component Location Index... 24-3 Front Seat Belt Replacement... 24-4 Rear Seat Belt Replacement... 24-7 Inspection... 24-12 SRS (Supplemental Restraint
More informationENGINE IMMOBILISER SYSTEM
TO INDEX 1 ENGINE IMMOILISER - ENGINE IMMOILISER SYSTEM ENGINE IMMOILISER SYSTEM ODY ND IMMOILISER ELECTRICL LOCTION STEERING COLUMN UPPER WITH SWITCH RCKET SSEMLY (IMMOILISER COIL) (NON-ROTTION SOLENOID)
More informationINSPECTION. If error is excessive, replace the speedometer.
US (mph) ODY ELETRIL 4WD 2WD M/T 2WD /T E39 E24J01 INSPETION 1. INSPET SPEEDOMETER ONVEHILE Using a speedometer tester, inspect the speedometer for allowable indication error and check the operation of
More informationTaillight Relay Circuit
GHTI GHTI SYSTEM 63 Taillight Relay Circuit DESCRIPTION The headlight dimmer switch sends a signal to the main body ECU. WIRI DIAGRAM Main Body ECU TAIL To Battery TAIL TRLY Outer Rear View Mirror Illumination
More informationDTC P0130 OXYGEN SENSOR CIRCUIT MALFUNCTION (BANK 1 SENSOR 1) DTC P0132 OXYGEN SENSOR CIRCUIT HIGH VOLTAGE (BANK 1 SENSOR 1)
DIGNOSTICS DTC P0130 YGEN SENSOR CIRCUIT MLFUNCTION (BNK 1 SENSOR 1) 05359 0574901 DTC P013 YGEN SENSOR CIRCUIT HIGH VOLTGE (BNK 1 SENSOR 1) DTC P0133 YGEN SENSOR CIRCUIT SLOW RESPONSE (BNK 1 SENSOR 1)
More informationDTC P2440 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN BANK1 DTC P2441 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK CLOSE BANK1
DIAGNOSTICS SFI SYSTEM (2ZZ GE) (May, 2003) DTC P2440 SECONDARY AIR INJECTION SYSTEM SWITCHI VALVE STUCK OPEN BANK1 05 575 05DWI 01 DTC P2441 SECONDARY AIR INJECTION SYSTEM SWITCHI VALVE STUCK CLOSE BANK1
More informationTHEFT DETERRENT SYSTEM
THEFT DETERRENT THEFT DETERRENT SYSTEM 1 System Name Power Window Control System THEFT DETERRENT SYSTEM PRECAUTION NOTICE: For initialization: When disconnecting the cable from the negative (-) battery
More information1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM
348 DTC DTC P200 P203 /F Sensor Circuit Slow Response (ank 1 Sensor 1) /F Sensor Circuit Slow Response (ank 2 Sensor 1) DTC P200 indicates malfunctions related to the bank 1 /F sensor. DTC P203 indicates
More informationDTC C2171/71 TRANSMITTER ID NOT REGISTERED(MAIN) DTC C2172/72 TRANSMITTER ID NOT REGISTERED(2ND)
DIGNOSTICS DTC C2171/71 TRNSMITTER ID NOT REGISTERED(MIN) 05687 05KCT02 DTC C2172/72 TRNSMITTER ID NOT REGISTERED(2ND) CIRCUIT DESCRIPTION DTC No. DTC Detecting Condition Trouble rea C2171/71 C2172/72
More informationDTC P0325 KNOCK SENSOR 1 CIRCUIT (BANK 1 OR SINGLE SENSOR) DTC P0327 KNOCK SENSOR 1 CIRCUIT LOW INPUT (BANK 1 OR SINGLE SENSOR)
DIGNOSTICS SFI SYSTEM (pril, 2003) DTC KNOCK SENSOR 1 CIRCUIT (BNK 1 OR SINGLE SENSOR) 05 163 05DIN 01 DTC P0327 KNOCK SENSOR 1 CIRCUIT LOW INPUT (BNK 1 OR SINGLE SENSOR) DTC P0328 KNOCK SENSOR 1 CIRCUIT
More informationOnly Wireless Control Function is Inoperative
49 Only Wireless Control Function is Inoperative DESCRIPTI The door control receiver receives signals from the transmitter and sends these signals to the multiplex network body ECU. The multiplex network
More information2UZ-FE ENGINE CONTROL SYSTEM SFI SYSTEM
420 2UZ-FE ENGINE CONTROL SYSTEM SFI SYSTEM DTC DTC P200 P203 /F Sensor Circuit Slow Response (ank 1 Sensor 1) /F Sensor Circuit Slow Response (ank 2 Sensor 1) DCRIPTION DTC P200 indicates malfunctions
More informationSRS (SUPPLEMENTAL RESTRAINT SYSTEM)
SRS (SUPPEMENT RESTRINT SYSTEM) NOTICE: When inspecting or repairing the SRS (supplemental restraint system), perform the operation in accordance with the following precautionary instructions and the procedure
More informationSRS AIRBAG CONTROL SYSTEM
RSTRTS ST SRS R TR SYST TTS S ST... 3 SS RR WR W... 3 Work low...3 TRTTT T... 5 nspection rocedure...5 Trouble iagnosis with SUT...5 SYST SRT... 6 SRS R SYST... 6 SRS onfiguration...6 SRS omponent arts
More informationDiag. Code 22 Airbag Warning Light System Malfunction CIRCUIT DESCRIPTION ABT 71
SRS AIRBAG ABT71 Diag. Code 22 Airbag Warning Light System Malfunction CIRCUIT DESCRIPTION The airbag warning light is located on the combination meter. When the airbag system is normal, the airbag warning
More informationRS 413 SUPPLEMENTAL RESTRAINT SYSTEM CURTAIN SHIELD AIRBAG ASSEMBLY REMOVAL
413 REMOVAL Use the same procedures for the RH side and LH side. The procedures listed below are for the LH side. 1. PRECAUTION Be sure to read "PRECAUTION" thoroughly before servicing (See page -1). 2.
More informationOPERATION. 2. SPIRAL CABLE (in COMBINATION SWITCH) A spiral cable is used as an electrical joint from the vehicle body side to the steering wheel.
RS2 RS0UB01 OPERATION 1. STEERING WHEEL PAD (with AIRBAG) The inflater and bag of the SRS are stored in the steering wheel pad and cannot be disassembled. The inflater contains a squib, igniter charge,
More information1GR-FE ENGINE CONTROL SYSTEM SFI SYSTEM. DTC P0332 Knock Sensor 2 Circuit Low Input (Bank 2) DTC P0333 Knock Sensor 2 Circuit High Input (Bank 2)
84 GR-FE EINE CONTROL SYSTEM SFI SYSTEM DTC DTC P037 P038 Knock Sensor Circuit Low Input (ank or Single Sensor) Knock Sensor Circuit High Input (ank or Single Sensor) DTC P033 Knock Sensor Circuit Low
More informationDTC P0488/15 EXHAUST GAS RECIRCULATION THROTTLE POSITION CONTROL RANGE/PERFORMANCE
05 576 DIGNOSTICS ECD SYSTEM (1KD FTV)(From ugust, 2004) DTC P0488/15 EXHUST GS RECIRCULTION THROTTLE POSITION CONTROL RNGE/PERFORMNCE 05NJ5 01 CIRCUIT DESCRIPTION The ECM opens and closes the intake shutter
More informationDTC P0115 ENGINE COOLANT TEMPERATURE CIRCUIT DTC P0117 ENGINE COOLANT TEMPERATURE CIRCUIT LOW INPUT
0577 059VD09 DTC P0115 EINE COOLANT TEMPERATURE CIRCUIT DTC P0117 EINE COOLANT TEMPERATURE CIRCUIT LOW INPUT DTC P0118 EINE COOLANT TEMPERATURE CIRCUIT HIGH INPUT CIRCUIT DESCRIPTION A thermistor is built
More informationSUPPLEMENTAL RESTRAINT SYSTEM (SRS)
GROUP 52B SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTENTS GENERAL INFORMATION........ 52B-3 SERVICE PRES......... 52B-5 SPECIAL TOOLS................ 52B-8 TEST EQUIPMENTS............. 52B-9............ 52B-10
More informationSUPPLEMENTAL RESTRAINT SYSTEM
PRECAUTION CAUTION: PRIUS is equipped with SRS, which consists of a driver airbag, front passenger airbag, side airbag and curtain shield airbag. Failure to carry out service operations in the correct
More information