Weistec CLK Black Series SUSPENSION

Size: px
Start display at page:

Download "Weistec CLK Black Series SUSPENSION"

Transcription

1 Weistec CLK Black Series SUSPENSION Rear Suspension Bushing Upgrade Installation Guide 1

2 Thank you for your purchase of the Weistec CLK Black Series Rear Suspension Bushing Upgrade for the 2008 Mercedes CLK63 Black Series. Please follow all directions, and keep a clean work space when commencing installation. Tools Required 3/8 Impact Gun 3/8 Drive Ratchet and Socket Set 3/8 Drive Torx set Hydraulic Press Electric Reciprocating Saw 2

3 I. Lower Control Arms 1. Securely lift vehicle(using a lift is recommended) 2. Remove rear wheels 3. Remove Lower Control Arm by unbolting the three bolts shown below. To avoid confusion and incorrect installation of suspension arms, work on only one arm at a time. Be sure to take note of orientation of each arm prior to removal. This will make installation easier. 4. Once the Lower Control Arm has been removed, use a hydraulic press to press out the factory bushings. There are two per arm. 3

4 5. Press in new Lower Control Arm Bushings as shown below. 4

5 6. Press in Lower Control Arm Bushing Sleeve. Be sure to put grease on the sleeve as well as in the bushings 7. Reinstall Lower Control Arm using original hardware. 8. Repeat Steps 3 through 7 for the other Lower Control Arm. 5

6 II. Forward Most Rear Link Arms 1. Remove the forward most Link Arm by a. Loosening the two bolts shown below b. Cutting the bolts off using a reciprocating electric saw. New hardware is included to replace the two bolts that must be cut during removal. c. Remove Bolt holding the other end of the Link Arm 6

7 2. Once the Link Arm has been removed, use a hydraulic press to press out the factory bushings. There are two per arm. 7

8 3. Press in new Link Arm Bushings as shown below. 4. Press in Link Arm Bushing Sleeve. Be sure to put grease on the sleeve as well as in the bushings 8

9 5. Reinstall Link Arm using original and included new hardware. Each arm has either an R or L stamped into it indicating whether it is a Right side or Left Side arm. The arm should be installed with the stamped letter on the corresponding side. 6. Repeat Steps 1 through 5 for the other Forward Most Link Arm. 9

10 III. Remaining Link Arms 1. At this point, there will be 4 remaining link arms. 2. Remove one of the remaining Link Arms 3. Once the Link Arm has been removed, use a hydraulic press to press out the factory bushings. There are two per arm. 4. Press in new Link Arm Bushings as shown below. 10

11 5. Press in Link Arm Bushing Sleeve. Be sure to put grease on the sleeve as well as in the bushings 11

12 IV. 6. Reinstall Link Arm using original hardware. Each arm has either an R or L stamped into it indicating whether it is a Right side or Left Side arm. The arm should be installed with the stamped letter on the corresponding side. 7. Repeat Steps 2 through 7 for the other remaining Link Arms until non remain. Final Steps 1. Double check and make sure all suspension arms are properly installed and that all hardware is torqued properly 2. Bolt on wheels to factory specified torque 3. Lower vehicle onto ground and verify that the rear suspension travels as it should 4. Installation is complete At this point you will be ready to drive the vehicle. Double check you have removed all tools, and also double check that all suspension arms are properly installed and fastened. Improperly installed suspension arms will result in poor alignment as well as excessive suspension noise and movement. 12

13 Thank you from Weistec Engineering! Always enjoy the added performance from your Weistec CLK63 Black Series Rear Suspension Bushing Upgrade responsibly. Use best judgment when driving, and remember to have fun! NOTES: 13

W205 C63 Suspension Adjustable Suspension Installation Guide

W205 C63 Suspension Adjustable Suspension Installation Guide W205 C63 Suspension Adjustable Suspension Installation Guide 2015+ C63 AMG Sedan 2015+ C63S AMG Sedan Thank you for your purchase of the Weistec W205 C63 Adjustable Suspension. Please follow all directions,

More information

Weistec M156/M159 ENGINE

Weistec M156/M159 ENGINE Weistec M156/M159 ENGINE Oil / Air Separator System Installation Guide 2007-2011 S63 AMG 2007-2011 ML63 AMG 2007 R63 AMG 2007-2008 CLK63 AMG 2008 CLK63 Black Series 2007-2011 CLS63 AMG 2008-Present C63

More information

Rusty s JK Wrangler 3.25 Basic Kit RK-325B-JK INSTALLATION INSTRUCTIONS

Rusty s JK Wrangler 3.25 Basic Kit RK-325B-JK INSTALLATION INSTRUCTIONS Rusty s JK Wrangler 3.25 Basic Kit RK-325B-JK INSTALLATION INSTRUCTIONS Last Revised: 5/31/2017 Introduction: Rusty s recommends that this installation is performed by a certified automotive technician

More information

Weistec M113K Supercharger System Installation Guide

Weistec M113K Supercharger System Installation Guide Weistec M113K Supercharger System Installation Guide WARNING! DO NOT HAVE YOUR ECU REPROGRAMMED ANYWHERE BUT AT WEISTEC FOR THIS SUPERCHARGER. THE AMG 55 USES AN ELECTRONIC THROTTLE CONTROL (ETC), WHICH

More information

Rear Subframe Mount Inserts for B8/B8.5 Audi S4/RS4, S5/RS5, Q5/SQ5

Rear Subframe Mount Inserts for B8/B8.5 Audi S4/RS4, S5/RS5, Q5/SQ5 Rear Subframe Mount Inserts for B8/B8.5 Audi S4/RS4, S5/RS5, Q5/SQ5 Supplied Parts: B8/B8.5 Audi S4/RS4/S5/RS5/Q5/SQ5 Rear Subframe Mount Insert Front (601-0033) x 2 B8/B8.5 Audi S4/RS4/S5/RS5/Q5/SQ5 Rear

More information

Weistec True Downpipes

Weistec True Downpipes Weistec True Downpipes Installation Guide, W212, W218, AWD 2014+ E63 2014+ CLS63 WARNING! IF YOU ARE NOT EXPERIENCED IN THE AREA OF AUTOMOTIVE MECHANICS, WE STRONGLY URGE THAT YOU REFER THIS INSTALLATION

More information

J&M Mustang Rear Adjustable Lower Control Arms Installation Guide (99-04)

J&M Mustang Rear Adjustable Lower Control Arms Installation Guide (99-04) J&M Mustang Rear Adjustable Lower Control Arms Installation Guide (99-04) 1. Required Tools: 1.1. 3/8 ratchet 1.2. 1/2 ratchet 1.3. 18mm deep socket 1.4. 18mm standard socket (optional) 1.5. 19mm open

More information

Weistec M157 WMI System

Weistec M157 WMI System Weistec M157 WMI System Installation Guide 2012-2013 E63 2014+ E63 4matic(S) 2011-2013 CLS63 2014+ CLS63 4matic(S) 2015+ S63 AMG (Without ABC Suspension) This product is legal in California for racing

More information

Rusty s XJ Cherokee 4.5 Spring Pack Kit RK-405SP-XJ INSTALLATION INSTRUCTIONS

Rusty s XJ Cherokee 4.5 Spring Pack Kit RK-405SP-XJ INSTALLATION INSTRUCTIONS Rusty s XJ Cherokee 4.5 Spring Pack Kit RK-405SP-XJ INSTALLATION INSTRUCTIONS Last Revised: 1.10.18 Rusty s Off-Road Products Introduction: Rusty s recommends that this installation be performed by a certified

More information

Weistec M177 WMI System

Weistec M177 WMI System Weistec M177 WMI System Installation Guide 2015+ C63(S) Sedan 2016+ C63(S) Coupe This product is legal in California for racing vehicles only and should never be used upon a highway. This product is legal

More information

Remove four screws from radio trim

Remove four screws from radio trim ZSpeedPerformance Remove four screws from radio trim Radio trim removed, Remove 3 screws from shifter trim. The other screw is under the ash tray. Remove shift knob and remove shifter trim. Use caution

More information

ND Shock & Spring installation tips 13-4XXX, 13-5XXX 13-6XXX

ND Shock & Spring installation tips 13-4XXX, 13-5XXX 13-6XXX ND Shock & Spring installation tips 13-4XXX, 13-5XXX 13-6XXX Congratulations on purchasing our ND suspension upgrades! These will transform your car, and are almost a necessity - at least as far as we

More information

Ford Racing Front Rotor Upgrade Kit (05-10 V6) Installation Instructions

Ford Racing Front Rotor Upgrade Kit (05-10 V6) Installation Instructions Ford Racing Front Rotor Upgrade Kit (05-10 V6) Installation Instructions Time Necessary: Approximately 1.5 hours Tools Required: 15 MM Socket Ratchet PryBar Floor Lift or: o Floor Jack o (2) Jack Stands

More information

Installation Instructions for Teraflex 2.5 Inch Lift Kit with Shocks (2010 Jeep Wrangler Unlimited)

Installation Instructions for Teraflex 2.5 Inch Lift Kit with Shocks (2010 Jeep Wrangler Unlimited) Installation Instructions for Teraflex 2.5 Inch Lift Kit with Shocks (2010 Jeep Wrangler Unlimited) Installation Time: 6 Hours Tools Required: Floor Jack Jack Stands Ratchet Torque Wrench 15mm Socket 15mm

More information

IE Audi 3.0T Crank Pulley Upgrade Install Guide IEBAVJ3

IE Audi 3.0T Crank Pulley Upgrade Install Guide IEBAVJ3 IE Audi 3.0T Crank Pulley Upgrade Install Guide IEBAVJ3 Thank you for purchasing your IE 3.0T crankshaft pulley upgrade! This instruction guide is used for installation of IE s lower overdrive pulley for

More information

Installation Manual TWM Performance Short Shift Kit 2003 And Up Saturn Ion

Installation Manual TWM Performance Short Shift Kit 2003 And Up Saturn Ion Installation Manual TWM Performance Short Shift Kit 2003 And Up Saturn Ion It s preferable to park on a flat surface, as you may have to engage and disengage the hand brake and shift from gears to neutral.

More information

5 inch lift kit. WILL FIT E-Z-GO RXV installation instructions. Main Bracket Spindles Shock Mount Brackets Rear Shock Plates Rear Lift Blocks

5 inch lift kit. WILL FIT E-Z-GO RXV installation instructions. Main Bracket Spindles Shock Mount Brackets Rear Shock Plates Rear Lift Blocks PART# 18142 included: 5 inch lift kit WILL FIT E-Z-GO RXV installation instructions Main Bracket Spindles Shock Mount Brackets Rear Shock Plates Rear Lift Blocks WARNING: After installing this lift kit,

More information

05-07 F /2 SUSPENSION KIT

05-07 F /2 SUSPENSION KIT 92147900 05-07 F250 4 1/2 SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

Jeep Grand Cherokee ZJ 4 Suspension Kit

Jeep Grand Cherokee ZJ 4 Suspension Kit 92168800 Jeep Grand Cherokee 93-98 ZJ 4 Suspension Kit Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition

More information

Rusty s TJ Wrangler 3 Advanced Kit RK-300A-TJ INSTALLATION INSTRUCTIONS

Rusty s TJ Wrangler 3 Advanced Kit RK-300A-TJ INSTALLATION INSTRUCTIONS Rusty s TJ Wrangler 3 Advanced Kit RK-300A-TJ INSTALLATION INSTRUCTIONS Rusty s Off-Road Products Introduction: Rusty s recommends that this installation be performed by a certified automotive technician

More information

TENF8046MCD F8X M3/M4 TEST PIPES (REMOVES SECONDARY CATS) **NOT FOR USE ON ROAD VEHICLES / FOR OFF-ROAD AND RACING USE ONLY**

TENF8046MCD F8X M3/M4 TEST PIPES (REMOVES SECONDARY CATS) **NOT FOR USE ON ROAD VEHICLES / FOR OFF-ROAD AND RACING USE ONLY** Turner Motorsport LLC / 1-800-280-6966 / www.turnermotorsport.com DI/DBM 3/21/16 TENF8046MCD F8X M3/M4 TEST PIPES (REMOVES SECONDARY CATS) **NOT FOR USE ON ROAD VEHICLES / FOR OFF-ROAD AND RACING USE ONLY**

More information

How To: Lift the Truck Using Shackles and Torsion Bars A CFans Members Mod Project by gawillet

How To: Lift the Truck Using Shackles and Torsion Bars A CFans Members Mod Project by gawillet How To: Lift the Truck Using Shackles and Torsion Bars A CFans Members Mod Project by gawillet Skill Level: Moderate Disclaimer: Please use caution and seek professional assistance when necessary. ColoradoFans.com,

More information

Ford Racing GT500 Style Strut Mount Upgrade (05-12 All):

Ford Racing GT500 Style Strut Mount Upgrade (05-12 All): Ford Racing GT500 Style Strut Mount Upgrade (05-12 All): Required tools: (2) Jack stands Floor jack (1 is required but 2 is preferred) Torque wrench Spring compressor tool (can be rented at your local

More information

Subaru 5-Speed Double Adjustable Short Throw Shifter

Subaru 5-Speed Double Adjustable Short Throw Shifter Subaru 5-Speed Double Adjustable Short Throw Shifter 1999+ Subaru Impreza 5-Speed 2004-2005 Subaru Forester XT 5-Speed Congratulations on your purchase of the COBB Tuning Double Adjustable Short Throw

More information

GLACIER PRO RANGER MID SIZE MOUNT KIT

GLACIER PRO RANGER MID SIZE MOUNT KIT GLACIER PRO RANGER MID SIZE MOUNT KIT P/N 2880261 APPLICATION FOR USE WITH THE GLACIER PRO MID SIZE PLOW SYSTEM (P/N 2880260) ON 2010 AND NEWER RANGER MID SIZE MODELS BEFORE YOU BEGIN Read these instructions

More information

INSTALLATION INSTRUCTIONS 88029

INSTALLATION INSTRUCTIONS 88029 INSTALLATION INSTRUCTIONS 88029 FOR SUSPENSION SYSTEMS RS6503: JEEP WRANGLER (TJ) READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION REV F IMPORTANT NOTES! WARNING: This

More information

97-06 JEEP TJ/LJ LONG ARM UPGRADE KIT

97-06 JEEP TJ/LJ LONG ARM UPGRADE KIT 921663U00 97-06 JEEP TJ/LJ LONG ARM UPGRADE KIT Thank you for choosing Rough Country for your suspension needs. This kit is an upgrade kit only. This kit includes frame mounting points and adjustable long

More information

TOYOTA FJ CRUISER OFF-ROAD SHOCKS Installation Preparation

TOYOTA FJ CRUISER OFF-ROAD SHOCKS Installation Preparation Installation Preparation Part Number: PTR13-35060 - Front PTR13-35061 - Rear Kit Contents Item # Quantity Reqd. Description 1 1 Front or Rear TRD Off-Road Shock Assy (w/ Dust Cover) 2 1 Cotter Pin Front

More information

LIFT-506 BMF Lift Kit Club Car DS Gas & Electric Installation Instructions

LIFT-506 BMF Lift Kit Club Car DS Gas & Electric Installation Instructions LIFT-506 BMF Lift Kit Club Car DS Gas & Electric 2003.5-09 Installation Instructions Contents of LIFT-506 Club Car DS BMF Lift Kit: a (1 ea.) BMF Front Suspension b (1 ea.) Driver Side Upper A-Arm c (1

More information

BanDiT 4X READ DISCLAIMER & INSTRUCTION COMPLETELY THEN INSTALL. Date Created: 2008 May 20 Edit Date: 2008 June 05

BanDiT 4X READ DISCLAIMER & INSTRUCTION COMPLETELY THEN INSTALL. Date Created: 2008 May 20 Edit Date: 2008 June 05 READ DISCLAIMER & INSTRUCTION COMPLETELY THEN INSTALL. Installation Instructions: BanDiT 4x4 Idler Arm Bushings Date Created: 2008 May 20 Edit Date: 2008 June 05 Version: v4.0 Application(s): Nissan Factory

More information

Installation Instructions for Rough Country Adjustable Control Arms

Installation Instructions for Rough Country Adjustable Control Arms Installation Instructions for Rough Country Adjustable Control Arms Before: Front lowers: 10mm wrench 21mm wrench 18mm wrench 18mm socket 19mm wrench 19mm deep well socket 14mm wrench Jack Jack stand Instructions:

More information

Installation Instructions BILLET/PLUS PISTOL-GRIP SHIFTER Fits: 2016 Camaro V6 with Manual Transmission Catalog #

Installation Instructions BILLET/PLUS PISTOL-GRIP SHIFTER Fits: 2016 Camaro V6 with Manual Transmission Catalog # Installation Instructions BILLET/PLUS PISTOL-GRIP SHIFTER Fits: 2016 Camaro V6 with Manual Transmission Catalog # 3916034 WORK SAFELY! For maximum safety, perform this installation on a clean, level surface

More information

Backside License Plate Mount for Jeep JK Wrangler

Backside License Plate Mount for Jeep JK Wrangler REQUIRED TOOLS 10mm SOCKET 13mm SOCKET 4mm HEX KEY WIRE CRIMPS WIRE STRIPPERS ELECTICAL TAPE SCREW DRIVER KIT CONTAINS BACKSIDE MOUNT LICENSE PLATE BRACKET WITH LEDS PLASTIC PASS-THROUGH GROMMET STAINLESS

More information

Bill of Materials: Please take time to read and understand these installation instructions.

Bill of Materials: Please take time to read and understand these installation instructions. Please take time to read and understand these installation instructions. CORSA recommends that installation of this system be performed by a qualified service center or professional muffler installer who

More information

RTX 2000 Thomas Compressor TG-550 Graco PN

RTX 2000 Thomas Compressor TG-550 Graco PN RTX 2000 Thomas Compressor TG-550 Graco PN 246888 Print of Complete Compressor--------------Page 2 Instruction for Kit 118628-------------------Page 3 Instruction for Kit 287845-------------------Page

More information

LIFT Standard A-Arm Lift Kit Club Car Precedent Installation Instructions

LIFT Standard A-Arm Lift Kit Club Car Precedent Installation Instructions LIFT-563 6 Standard A-Arm Lift Kit Club Car Precedent Installation Instructions Contents of LIFT-563 Club Car Precedent Lift Kit: a (1 ea.) Front Suspension b (1 ea.) Driver Side Upper A-Arm c (1 ea.)

More information

AWE/McNeil Competition Air/Air Intercooler Kit for Audi 2.7T

AWE/McNeil Competition Air/Air Intercooler Kit for Audi 2.7T AWE/McNeil Competition Air/Air Intercooler Kit for 2000-04 Audi 2.7T Congratulations on your purchase of the AWE/McNeil Competition Intercoolers for your 2.7T Audi. Hundreds of hours of design and operational

More information

INSTALLATION OF HOTCHKIS PERFORMANCE DOUBLE ADJUSTABLE TRAILING ARMS

INSTALLATION OF HOTCHKIS PERFORMANCE DOUBLE ADJUSTABLE TRAILING ARMS 1215 DOUBLE ADJUSTABLE UPPER TRAILING ARMS 67-70 CHEVROLET B-BODY This installation will require: A hydraulic jack, jack stands The following wrenches or sockets: 15/16 Adjustable wrench (1-1/4 1-9/32

More information

INSTALLATION INSTRUCTIONS Progress Technology Rear Anti-Sway Bar Honda Civic Part # No Revision (7/20/16)

INSTALLATION INSTRUCTIONS Progress Technology Rear Anti-Sway Bar Honda Civic Part # No Revision (7/20/16) INSTALLATION INSTRUCTIONS Progress Technology Rear Anti-Sway Bar Honda Civic 96-00 Part # 62.1042 No Revision (7/20/16) WHO SHOULD INSTALL THIS PRODUCT? Progress Technology products should only be installed

More information

80703 & Backside License Plate Mount for Jeep JK Wrangler (80707) & 10+ (80703)

80703 & Backside License Plate Mount for Jeep JK Wrangler (80707) & 10+ (80703) 80703 Backside Mount 80707 Backside Mount REQUIRED TOOLS 10mm SOCKET 13mm SOCKET 4mm HEX KEY WIRE CRIMPS WIRE STRIPPERS ELECTICAL TAPE SCREW DRIVER KIT CONTAINS BACKSIDE MOUNT LICENSE PLATE BRACKET WITH

More information

& 6 XJ CHEROKEE LONG ARM KIT

& 6 XJ CHEROKEE LONG ARM KIT 92PERF1689 84-01 4.5 & 6 XJ CHEROKEE LONG ARM KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these

More information

2015+ EcoBoost F150 & Raptor Intercooler Install

2015+ EcoBoost F150 & Raptor Intercooler Install 2015+ EcoBoost F150 & 2017+ Raptor Intercooler Install Note: This entire job can be performed with the truck on the ground - No need to raise the vehicle. The most difficult part is removing the grille

More information

You will be removing the suspension of your vehicle. If you are not comfortable with this or do not have the proper tools, please do not proceed.

You will be removing the suspension of your vehicle. If you are not comfortable with this or do not have the proper tools, please do not proceed. Thank you for purchasing the CorkSport Mazda 3 and Mazdaspeed 3 Coilover Kit. This suspension system features 15-way adjustable dampening settings and full length adjustment to meet every driver s handling

More information

2010 Camaro SS/V Underbody Brace Installation Instructions

2010 Camaro SS/V Underbody Brace Installation Instructions 2010 Camaro SS/V6 20104 Underbody Brace Installation Instructions Thank you for your purchase of this Hotchkis Performance product. Your Underbody Brace set was designed with the performance and durability

More information

Anti-Sway Bars Installation Instructions For Mazda MX-5 PART #

Anti-Sway Bars Installation Instructions For Mazda MX-5 PART # Anti-Sway Bars Installation Instructions For 2006+ Mazda MX-5 PART # 920-330 Tools required: A jack and jack stands, 5mm Allen wrench, ratchet, 10mm, 12mm and 14mm, combination wrenches and sockets, 21mm

More information

Please take time to read and understand these installation instructions.

Please take time to read and understand these installation instructions. Please take time to read and understand these installation instructions. CORSA recommends that installation of this system be performed by a qualified service center or professional muffler installer who

More information

INSTALLATION MANUAL

INSTALLATION MANUAL INSTALLATION MANUAL 2051108 Parts List 1 Driver / left running board 1 Passenger / right running board Level of Difficulty Easy Scan for helpful install tips 2 Mounting bracket, front 2 Mounting bracket,

More information

TOYOTA FJ CRUISER PERFORMANCE SHOCKS Preparation Adjustable Pole Jack

TOYOTA FJ CRUISER PERFORMANCE SHOCKS Preparation Adjustable Pole Jack Preparation Part Number: Adjustable Pole Jack PTR13-35100/Front PTR13-35101/Rear Kit Contents: Item # Quantity Reqd. Description 1 1 Front or Rear TRD Off-Road Shock Assy (w/ Dust Cover) 2 1 Cotter Pin

More information

Product: Variable Height Spring. Part Numbers: N. Applications: BMW F8x, M2/M3/M

Product: Variable Height Spring. Part Numbers: N. Applications: BMW F8x, M2/M3/M Product: Variable Height Spring Part Numbers: 415-503001-N Applications: BMW F8x, M2/M3/M4 2014-17 Contents in the box: Qty Part # Description 1 00P-0A1646-B Front Passenger Sleeve Assembly 1 00P-0A1645-N

More information

Installation Manual TWM Performance Full replacement short shifter assembly Civic all trims and models

Installation Manual TWM Performance Full replacement short shifter assembly Civic all trims and models Installation Manual TWM Performance Full replacement short shifter assembly 2006+ Civic all trims and models Begin the installation by parking on a flat surface, as you will have to engage and disengage

More information

NOTICE TO DEALER AND VEHICLE OWNER

NOTICE TO DEALER AND VEHICLE OWNER 921751200 *1751BAG1* 1751BAG1 Thank you for choosing Rough Country for all your suspension needs. This kit will fit both 4WD and 2WD models, all brackets will be used for 4WD models. On 2WD models the

More information

PRP Seats 570/800/900 RZR 4 Doors

PRP Seats 570/800/900 RZR 4 Doors Install Instructions PRP Seats 570/800/900 RZR 4 Doors Remove all parts from the box and unwrap completely using the packaging to lay out the pieces. Tools Needed: (not included) 7/16 Open end wrench and

More information

Installation Instructions

Installation Instructions Equipment Required: Fastener Kit: F Wrenches: 15/16, 10 mm Drill Bits: 1/4 Other Tools: Drill, Reciprocating Saw 9464/9474 HIDE-A-GOOSE HITCH All Fasteners Typical, Both Sides WARNING: Under no circumstances

More information

8759 Lion Street Rancho Cucamonga, CA (909) TECH SUPPORT (909) FAX RECOMMENDED SERVICE PART NUMBERS

8759 Lion Street Rancho Cucamonga, CA (909) TECH SUPPORT (909) FAX  RECOMMENDED SERVICE PART NUMBERS 8759 Lion Street Rancho Cucamonga, CA 91730 (909) 476-7225 TECH SUPPORT (909) 476-1491 FAX www.volantperformance.com INSTALLATION INTRUCTIONS PART NO. 37640 TOOLS NEEDED FOR INSTALL: 1. FLATHEAD SCREWDRIVER

More information

DODGE 3 SUSPENSION LIFT KIT

DODGE 3 SUSPENSION LIFT KIT 921351200 Kit Contents: 9280:Front Coil Springs 1351BOX1: Upper Control Arms Lower Control Arms Sway bar Brackets Brake Proportioning Valve Bracket Track Bar Relocation Bracket 1351BOX2: 5.75 Blocks U-bolt

More information

Installation Manual TWM Performance Short Shifter Cobalt SS/SC, SS/TC, HHR SS, Ion Redline and Saab 9-3

Installation Manual TWM Performance Short Shifter Cobalt SS/SC, SS/TC, HHR SS, Ion Redline and Saab 9-3 Page 1 Installation Manual TWM Performance Short Shifter Cobalt SS/SC, SS/TC, HHR SS, Ion Redline and Saab 9-3 Please Note: It is preferable to park on a flat surface, as you will have to engage and disengage

More information

034Motorsport Stainless Steel Subframe Locking Collar Upgrade Kit, MkV/MkVI Volkswagen & 8J/8P Audi

034Motorsport Stainless Steel Subframe Locking Collar Upgrade Kit, MkV/MkVI Volkswagen & 8J/8P Audi 034Motorsport Stainless Steel Subframe Locking Collar Upgrade Kit, MkV/MkVI Volkswagen & 8J/8P Audi The installation of your 034Motorsport Stainless Steel Subframe Locking Collar Upgrade Kit for the 8J/8P

More information

TOYOTA 4-RUNNER KIT 5 KIT

TOYOTA 4-RUNNER KIT 5 KIT 92173600 1990-1995 TOYOTA 4-RUNNER KIT 5 KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition to these

More information

OVERVIEW: KIT INCLUDES:

OVERVIEW: KIT INCLUDES: Please visit www.fordracingparts.com for the most current instruction information!!! PLEASE READ ALL OF THE FOLLOWING INSTRUCTIONS CAREFULLY PRIOR TO INSTALLATION. AT ANY TIME YOU DO NOT UNDERSTAND THE

More information

7B1210 COBB BMW N54 Charge Pipe

7B1210 COBB BMW N54 Charge Pipe 7B1210 COBB BMW N54 Charge Pipe Installation Instructions Congratulations on your purchase of the COBB BMW N54 Charge Pipe for your BMW. The following instructions will assist you through your installation

More information

JEEP JK 6 2 DR X-SERIES SUSPENSION KIT

JEEP JK 6 2 DR X-SERIES SUSPENSION KIT 921684X00 Thank you for choosing Rough Country for your suspension needs. JEEP JK 6 2 DR X-SERIES SUSPENSION KIT Rough Country recommends a certified technician install this system. In addition to these

More information

Installation Manual TWM Performance Short throw shifter 2001 and up Hyundai Accent

Installation Manual TWM Performance Short throw shifter 2001 and up Hyundai Accent Installation Manual TWM Performance Short throw shifter 2001 and up Hyundai Accent 1. Place the vehicle on a flat surface with blocks in front and behind the wheels preventing unwanted movement. The car

More information

Installation Guide for the JK Wrangler 2.5 Inch spring lift

Installation Guide for the JK Wrangler 2.5 Inch spring lift Tera Manufacturing, Inc. 5251 South Commerce Dr. Murray, Utah 84107 Phone/801.288.2585 Fax/801.713.2313 www.teraflex.biz INSTALLATION GUIDE Installation Guide for the JK Wrangler 2.5 Inch spring lift Read

More information

Please take time to read and understand these installation instructions.

Please take time to read and understand these installation instructions. 2014- Current C7 Corvette Please take time to read and understand these installation instructions. CORSA recommends that the installation of this system be performed by a qualified service center or professional

More information

TUNDRA 2017 Dual Black Tip Performance Exhaust Part Number: Code: EX3000 Conflicts Kit Contents Item # Qty. Reqd.

TUNDRA 2017 Dual Black Tip Performance Exhaust Part Number: Code: EX3000 Conflicts Kit Contents Item # Qty. Reqd. Doc. 5.250.00 Business Partner: J52 PIO / DIO Rev. A 207 TUNDRA Part Number: 0006-3472 Code: EX3000 Conflicts Standard Cab, D-Cab w 8 Bed Kit Contents Item # Qty. Reqd. 2 3 R/H tailpipe L/H Tailpipe Muffler

More information

Sport Sway Bar Kit (22425) Scion tc

Sport Sway Bar Kit (22425) Scion tc Sport Sway Bar Kit (22425) Scion tc Thank you for your purchase from our new line of Scion tc parts. Please call us at (877) 4NO - ROLL if you have any questions regarding the service or installation of

More information

Safety - Installation and Operation:

Safety - Installation and Operation: 4x4 or 4x2 Instructions EZGO Electric Cars Thank you for purchasing your 4x4 or 4x2 conversion kit. Safety at all times whether during installation or operation is utmost importance. Before After!!!!!!!!!!!!!!

More information

JEEP JK 4 LONGARM. Tools Needed: Thank you for choosing Rough Country for your suspension needs.

JEEP JK 4 LONGARM. Tools Needed: Thank you for choosing Rough Country for your suspension needs. 921786000 Thank you for choosing Rough Country for your suspension needs. JEEP JK 4 LONGARM Rough Country recommends a certified technician install this system. In addition to these instructions, professional

More information

IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED

IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED Please Forward All Attached Information to Consumer Warranty Not Valid Unless Returned to CORSA Exhaust STOP Please take time to read and understand

More information

INSTALLATION MANUAL FOR ROCK KRAWLER SUSPENSION, INC. WJ SHORT ARM SYSTEMS

INSTALLATION MANUAL FOR ROCK KRAWLER SUSPENSION, INC. WJ SHORT ARM SYSTEMS INSTALLATION MANUAL FOR ROCK KRAWLER SUSPENSION, INC. WJ SHORT ARM SYSTEMS FIRST EDITION 8/24/09 Dear customer: Thank you for purchasing the best system on the market for your Jeep Vehicle. We are sure

More information

Installation for Chevrolet Corvette C7 Stingray PNs 60547* 60548, and 60558

Installation for Chevrolet Corvette C7 Stingray PNs 60547* 60548, and 60558 Installation for Chevrolet Corvette C7 Stingray PNs 60547* 60548, and 60558 These instructions have been written to help you with the installation of your Borla Performance Exhaust System. Please read

More information

INSTALLATION INSTRUCTION 88578

INSTALLATION INSTRUCTION 88578 INSTALLATION INSTRUCTION 88578 For Rancho Suspension System RS6579B: 4WD Dodge 1500 & 2500 READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev E IMPORTANT NOTES! WARNING:

More information

IE Audi B9 S4, S5, A4, A5, Allroad FDS Intercooler Install Guide IETPCK1

IE Audi B9 S4, S5, A4, A5, Allroad FDS Intercooler Install Guide IETPCK1 IE Audi B9 S4, S5, A4, A5, Allroad FDS Intercooler Install Guide IETPCK1 Thank you for purchasing the best performing intercooler on the market! This instruction guide is used for installation of IE s

More information

37-39 TCI Chevy Rear 4-Link Kit Installation Instructions

37-39 TCI Chevy Rear 4-Link Kit Installation Instructions 37-39 TCI Chevy Rear 4-Link Kit Installation Instructions 1-800-984-6259 www.totalcostinvolved.com Read and understand these instructions before starting any work! SUPPORT VEHICLE WITH JACK STANDS BEFORE

More information

Installation Manual TWM Performance Short Shifter 2008 Mitsubishi Lancer

Installation Manual TWM Performance Short Shifter 2008 Mitsubishi Lancer Page 1 Installation Manual TWM Performance Short Shifter 2008 Mitsubishi Lancer Please Note: It is preferable to park on a flat surface, as you will have to engage and disengage the hand brake and shift

More information

JEEP JK 4 X-SERIES SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs.

JEEP JK 4 X-SERIES SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. 921673X00A *1673XBAG4* 1673XBAG4 JEEP JK 4 X-SERIES SUSPENSION KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician install this system. In

More information

INSTALLATION INSTRUCTION 88146

INSTALLATION INSTRUCTION 88146 INSTALLATION INSTRUCTION 88146 Rev H FOR RANCHO SUSPENSION SYSTEM RS6547: 4WD SUBURBAN/YUKON XL, 4WD TAHOE/YUKON, & 4WD AVALANCHE READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING

More information

/3500 Dodge 5 Long Arm Kit

/3500 Dodge 5 Long Arm Kit 92138800A 03-07 2500/3500 Dodge 5 Long Arm Kit Thank you for choosing Rough Country Suspension for your Off Road needs. Rough Country recommends a certified technician installs this system. In addition

More information

EVO-1162 EVO Tailgate Tire Carrier

EVO-1162 EVO Tailgate Tire Carrier EVO-1162 EVO Tailgate Tire Carrier Bill of Materials EVO-1162 Tailgate Tire Carrier Part number Description Quantity EVO-12161 EVO Tailgate Tire Carrier 1 EVO-12162 Bolt Plate 1 EVO-12163 Wheel Mount 1

More information

T Intercooler System INSTALLATION GUIDE. Contact us with any installation questions AWE-Tuning.com

T Intercooler System INSTALLATION GUIDE. Contact us with any installation questions AWE-Tuning.com INSTALLATION GUIDE 2000-04 2.7T Intercooler System FOR RACING USE ONLY Congratulations on your purchase of the AWE Tuning Intercooler System for the 2002-04 Audi 2.7T engine. Exquisite build quality with

More information

Exhaust System Installation Turbo Downpipe Audi MKII TT-RS 2.5T CD100028

Exhaust System Installation Turbo Downpipe Audi MKII TT-RS 2.5T CD100028 Please take the time to read and understand installation instructions. APR recommends that installation of this system be performed by a qualified service center or professional muffler installer who has

More information

NOTICE TO DEALER AND VECHICLE OWNER

NOTICE TO DEALER AND VECHICLE OWNER 84-01 4.5 & 6 XJ CHEROKEE LONG ARM KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition to these instructions,

More information

INSTALLATION INSTRUCTION 88051

INSTALLATION INSTRUCTION 88051 INSTALLATION INSTRUCTION 88051 For Rancho Suspension System RS6551: Chevrolet 2500 Suburban & 2500 Avalanche READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev C IMPORTANT

More information

JEEP JK 3 1/4 PROGRESSIVE COIL /SPACER KIT W/ PERFORMANCE 2.2. SHOCK ABSORBERS

JEEP JK 3 1/4 PROGRESSIVE COIL /SPACER KIT W/ PERFORMANCE 2.2. SHOCK ABSORBERS 92PERF693 JEEP JK 3 1/4 PROGRESSIVE COIL /SPACER KIT W/ PERFORMANCE 2.2. SHOCK ABSORBERS Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician

More information

Please take time to read and understand these installation instructions.

Please take time to read and understand these installation instructions. Cat Back Exhaust System 2013+ SRT/ GTS Viper Please take time to read and understand these installation instructions. CORSA recommends that the installation of this system be performed by a qualified service

More information

Page1. ISF Stainless Steel Headers // Part# HDR-004

Page1. ISF Stainless Steel Headers // Part# HDR-004 Congratulations on the purchase of your ISF Stainless Steel Headers and thank you for choosing Sikky Manufacturing. This installation manual is intended to guide you through the removal of the factory

More information

2017 Ford Super Duty Recoil Traction Bar System. Part#:

2017 Ford Super Duty Recoil Traction Bar System. Part#: Part#: 123417 2017 Ford Super Duty Recoil Traction Bar System Rev. 011917 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

Lightweight Tubular Sway Bar Kit Subaru WRX / STi / 09+ FXT

Lightweight Tubular Sway Bar Kit Subaru WRX / STi / 09+ FXT 915250 Lightweight Tubular Sway Bar Kit 2008+ Subaru WRX / STi / 09+ FXT Installation Instructions Congratulations on your purchase of the COBB Lightweight Tubular Sway Bar Kit for your Subaru WRX, STi

More information

Self-Adjust Clutch Installation Guide

Self-Adjust Clutch Installation Guide Self-Adjust Clutch Installation Guide 0 STOP! READ CAREFULLY BEFORE INSTALLING CLUTCH This clutch must be installed by a qualified installer. Improper installation or failure to replace or resurface the

More information

/3500 Dodge 5 Long Arm Kit

/3500 Dodge 5 Long Arm Kit 92137900A 11-12 2500/3500 Dodge 5 Long Arm Kit Thank you for choosing Rough Country Suspension for your Off Road needs. Rough Country recommends a certified technician installs this system. In addition

More information

Dodge 5 Lift Kit Thank you for choosing Rough Country Suspension for your Off Road needs.

Dodge 5 Lift Kit Thank you for choosing Rough Country Suspension for your Off Road needs. *1368BAG4* 1368BAG4 921368200 2014-16 2500 Dodge 5 Lift Kit Thank you for choosing Rough Country Suspension for your Off Road needs. Rough Country recommends a certified technician installs this system.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS AUTOMOTIVE PRODUCTS, INSTALLATION INSTRUCTIONS HDX DROP STEP APPLICATION: 2007-2017 Chevy Silverado / GM Sierra / 1500-2500-3500 Ext. / Double / Crew Cab PART NUMBER: 56-13715, 56-13725 ITEM QUANTITY DESCRIPTION

More information

Audi A4 2.0T Front Mount Intercooler INSTALLATION GUIDE

Audi A4 2.0T Front Mount Intercooler INSTALLATION GUIDE INSTALLATION GUIDE Congratulations on your purchase of the AWE Tuning Front Mount Intercooler for the 2005.5-08 B7 chassis A4 2.0T. 2005.5-08 Audi A4 2.0T Front Mount Intercooler FOR RACING USE ONLY Exquisite

More information

This procedure is best performed on a vehicle lift, however it is possible to install these coilovers using a floor jack and jack stands.

This procedure is best performed on a vehicle lift, however it is possible to install these coilovers using a floor jack and jack stands. Description: FeatherLight Single Adjustable Corvette Coilovers Part Number: 430-401004-N Application: 2014-2015 Chevrolet Corvette (C7) Note: Some models might be equipped with Magnetic Ride electric adjustable

More information

Suspension Upgrade System RS66152 (Upper Adjustable Control Arms)

Suspension Upgrade System RS66152 (Upper Adjustable Control Arms) 89152 Rev B Suspension Upgrade System RS66152 (Upper Adjustable Control Arms) Fits 1997-2006 Jeep Wrangler (TJ / LJ). 89152 Rev B READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING

More information

IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED

IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED IMPORTANT WARRANTY & INSTALLATION INSTRUCTIONS ATTACHED Please Forward All Attached Information to Consumer Warranty Not Valid Unless Returned to CORSA Exhaust STOP Please take time to read and understand

More information

»Product» Safety Warning

»Product» Safety Warning #J1200 Installation Instructions 1987-1995 Jeep Wrangler YJ 2" Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information

STOP---READ THIS FIRST!

STOP---READ THIS FIRST! STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2003-2013 DODGE Ram 2500/3500, 8 LIFT KIT NOTE: * The factory wheels and tires WILL fit on the front of the vehicle once

More information

Suspension System RS6509B

Suspension System RS6509B 88509 Rev H Requires the following for a complete installation: Quick disconnect end link kit RS6756B or solid end link kit RS6753B (for the Rubicon) Rancho exhaust kit RS720001 or RS720002 (or equivalent)

More information

Rear Anti-Sway Bar for S60 AWD, S60R, V70AWD, V70XC & V70R ( )

Rear Anti-Sway Bar for S60 AWD, S60R, V70AWD, V70XC & V70R ( ) Dedicated to improving vehicle fun, safety & performance Installation Instructions Rear Anti-Sway Bar for S60 AWD, S60R, V0AWD, V0XC & V0R (2001-06) PI-2 0/05 Thank you for purchasing this anti-sway bar

More information