ALLISON IDENTIFICATION TAG
|
|
- Loren Andra Berry
- 6 years ago
- Views:
Transcription
1 ALLISON IDENTIFICATION TAG MH 2400 Heavy duty automatic transmission with parking pawl. maximum GVW = lb. Heavy duty automatic transmission without parking pawl. maximum GVW = lb. Heavy duty automatic transmission without parking pawl. Limited release in motor home application only maximum GVW = lb. Heavy duty automatic transmission with parking pawl. maximum GVW = lb. Transmission fluid capacity Initial fill* Refill* Transmission Pan Qts liters Qts liters deep /2000/2400 shallow *All quantities are approxamate. All models except 2000 MH series use 2000 MH series must use Transynd or a TES 295 Approved Fluid. dexron III! TRANS FLUID SPEED SENSOR LOCATIONS ENGINE SPEED SENSOR SOME MODELS TURBINE SPEED SENSOR ALL MODELS OUTPUT SPEED SENSOR 2 WHEEL DRIVES ONLY
2 RANGE C1 CL. C2 CL. C3 CL. C4 CL. C5 CL. SOL A SOL B SOL C SOL D SOL E SOL F P ON!! Ω Ω Ω R ON ON!! Ω Ω N ON!! Ω Ω Ω O/D 1 ST ON ON!! Ω O/D 2 ND ON ON!! O/D 3 RD ON ON!! Ω O/D 4 TH ON ON!! Ω Ω O/D 5 TH ON ON!! Ω Ω = ELECTRICAL POWER APPLIED TO SOLEID = APPLY SOLEID "F" TO APPLY CONVERTER CLUTCH! = SOLEIDS "A" AND "B" ARE "TRIM" SOLEIDS USED TO CONTROL ONCOMING, OFF-GOING AND HOLDING PRESSURE TO THE FIVE CLUTCH PACKS. MAIN PRESSURE TAP Pressure test specifications
3 Prior to serial number Range 600 RPM 2100 RPM Park/Neutral kpa ( psi ) kpa ( psi ) Reverse kpa ( psi ) kpa ( psi ) Forward ( TCC off ) kpa ( psi ) kpa ( psi ) Forward ( TCC on ) kpa ( psi ) Starting with serial number Range 600 RPM 2100 RPM Park/Neutral kpa ( psi ) kpa ( psi ) Reverse kpa ( psi ) kpa ( psi ) Forward ( TCC off ) kpa ( psi ) kpa ( psi ) Forward ( TCC on ) kpa ( psi ) J2 RECEPTICLE J1 RECEPTICLE "J2" RED RECEPTICALE "J1" GRAY RECEPTICALE "J2" Red harness connector to TCM Receptical ( front) "J1" Gray harness connector to TCM Receptical (front) "J2" Red harness connector full view "J1" Gray harness connector full view
4 full view full view TRANSMISSION CONTROL MODULE PIN IDENTIFICATION CHART J2 Red connector J1 Gray connector PIN COLOR CIRCUIT FUNCTION PIN COLOR CIRCUIT FUNCTION 1 BLUE PSA Input Trans - D 1 GRAY Battery ground 2 PINK PSA Input Trans - F 2 YELLOW power 3 WHITE PSA Input Trans - E 3 PINK Battery power 4 GREEN PSA Input Trans - K 4 YELLOW Ignition power 5 BLUE NSBU Input NSBU- 4A 5 GRAY Battery ground 6 YELLOW NSBU Input NSBU- 4D 6 BLUE GPI 1 7 GRAY NSBU Input NSBU- 4B 7 ORANGE GPI 2 8 WHITE NSBU Input NSBU- 4C 8 GREEN GPI 3 9 BLUE Throttle position sensor TPS - B 9 WHITE GPI 4 10 TAN Transmission pan temp sensor Trans - G 10 YELLOW GPI 5 11 ORANGE Retarder temp input (opt.) R temp- A 11 GREEN GPI 6 12 BLUE Engine coolant temp ECTS - A 12 BLUE GPI 7 13 ORANGE Turbine speed sensor (high) TSS - A 13 PINK GPI 8 14 BLUE Turbine speed sensor (low) TSS - B 14 ORANGE GPI 9 15 YELLOW Output speed sensor (high) OSS - A 15 YELLOW Retarder mod. Reg. (opt.) RMR - B 16 GREEN Output speed sensor (low) OSS - B 16 WHITE PWM throttle 17 TAN Engine speed sensor (high) ESS - A 17 PINK Sensor power RMR - C 18 ORANGE Engine speed sensor (low) ESS - B 18 GREEN Analog ground RMR - A 19 PINK TPS voltage supply TPS - C 19 TAN GPO 1 20 GREEN Analog ground Trans-H, ECTS-A Temp-B, NSBU-7D, R-Temp-B, TPS-A 20 ORANGE GPO 2 21 YELLOW Transmission identification Trans - T 21 WHITE GPO 3 22 YELLOW Trim solenoid A (high) Trans - L 22 BLUE GPO 4 23 WHITE Trim solenoid A (low) Trans - M 23 PINK Range inhibit indicator 24 PINK Trim solenoid B (high) Trans - N 24 WHITE GPO 6 25 ORANGE Trim solenoid B (low) Trans - P 25 GREEN Check trans 26 GREEN Solenoid C ground (on/off) Trans - A 26 TAN Vehicle speed 27 BLUE Solenoid D ground (on/off) Trans - B 27 PINK Vehicle speed 28 GRAY Solenoid E ground (on/off) Trans - W 28 YELLOW Digital ground 29 WHITE Solenoid F low (PMW) Trans - J 29 RED CAN high J 1939 A or H 30 ORANGE Solenoid G low (PWM opt.) Trans - J 30 BLUE ISO TAN Solenoid C, D, E volt supply Trans - C 31 GREEN CAN shield J 1939 C or 32 GREEN solenoid F high (PWM) Trans - S 32 BLACK CAN low J 1939 B or L S
5 DTC P0117 P0118 P0121 P0122 P0123 P0218 P0562 P0563 P0602 P0606 P0701 P0703 P0705 P0706 P0708 P0711 P0712 P0713 P0716 P0717 P0721 P0722 P0726 P0727 P0731 P0732 P0733 P0734 P0735 P0736 P0741 P0742 P0748 P0763 P0768 Diagnostic trouble code (DTC) & definitions Description Engine coolant temp circuit low voltage (High temp) Engine coolant temp circuit high voltage (Low temp) Throttle position sensor performance problem Throttle position sensor circuit low voltage Throttle position sensor circuit high voltage Transmission fluid over temperature System voltage low System voltage high Transmission control module not programmed Transmission control module internal performance Transmission control system performance Brake switch circuit Transmission range sensor circuit (PRNDL input) Transmission range sensor circuit performance Transmission range sensor circuit high input Transmission fluid temperature circuit performance Transmission fluid temperature circuit low voltage (high temp) Transmission fluid temperature circuit low voltage (low temp) Turbine speed sensor circuit performance Turbine speed sensor circuit no signal Output speed sensor circuit performance Output speed sensor circuit no signal Engine speed sensor circuit performance Engine speed sensor circuit no signal incorrect 1st gear ratio incorrect 2nd gear ratio incorrect 3rd gear ratio incorrect 4th gear ratio incorrect 5th gear ratio incorrect reverse gear ratio Torque converter clutch system stuck off Torque converter clutch system stuck on Pressure control trim solenoid "A" electrical Shift solenoid "C" electrical Shift solenoid "D" electrical Trans Light DTC P0773 P0778 P0840 P0841 Diagnostic trouble code (DTC) & definitions Description Shift solenoid "E" electrical Pressure control trim solenoid "B" electrical Transmission pressure switch solenoid C circuit Transmission pressure switch solenoid C circuit stuck open Trans Light
6 P0842 P0843 P0845 P0846 P0847 P0848 P1688 P1709 P1710 P1711 P1712 P1713 P1714 P1715 P1716 P1720 P1721 P1723 P1724 P1726 P1727 P1760 P1835 P1860 P1891 P1892 U1016 U1300 U1301 U2104 U2105 Transmission pressure switch solenoid C circuit stuck closed Transmission pressure switch solenoid C circuit high Transmission pressure switch solenoid D circuit Transmission pressure switch solenoid D circuit stuck open Transmission pressure switch solenoid D circuit stuck closed Transmission pressure switch solenoid D circuit high Unmanaged engine torque delivered to TCM Transmission pressure switch solenoid E circuit Transmission pressure switch solenoid E circuit stuck open Transmission pressure switch solenoid E circuit stuck closed Transmission pressure switch solenoid E circuit high Transmission pressure switch reverse circuit Transmission pressure switch reverse circuit stuck open Transmission pressure switch reverse circuit stuck closed Transmission pressure switch reverse circuit high Trim solenoid "A" controlled clutch not engaged Trim solenoid "B" controlled clutch not engaged Trim solenoid "A" controlled clutch not engaged Trim solenoid "A" controlled clutch not engaged Trim solenoid "D" controlled clutch not engaged Trim solenoid "E" controlled clutch not engaged TCM supply voltage Kickdown circuit TCC (PMW) solenoid circuit electrical Throttle position sensor clutch PMW signal low input Throttle position sensor clutch PMW signal high input Class Two powertrain controller state of health Serial data communication link low (class Two) Serial data communication link high (class Two) CAN bus reset counter overrun CAN bus error ECM TORQUE SPECIFICATION CHART AND BOLTS DESCRIPTION Bolt size Detent spring to V/B M6 X 1.0 X 12 Main V/B to shift V/B M6 X 1.0 X 50 V/B assembly to case M6 X 1.0 X 50 Main V/B to shift V/B M6 X 1.0 X 65 Speed sensor retaining bolt M6 X 1.0 X 13 NSBU switch to main case M8 X 1.25 X 15 Bottom pan to main case M8 X 1.25 X 20 Bottom pan drain plug - Manual shaft nut - Cooler manifold to bell hsg M8 X 1.25 X 30 Cooler manifold to bell hsg M8 X 1.25 X 40 Pump cover to pump body M8 X 1.25 X 55 PTO cover to main case M10 X 1.5 X 20 Extension hsg to main case M10 X 1.5 X 40 Bell housing to pump cover w/ oring M10 X 1.5 X 50 Bell housing to main case M10 X 1.5 X 50 QTY N.M. FT. LBS
7 Bell housing to main case M10 X 1.5 X 70 Rear yoke nut when used - Transmission to engine - Transfer case to transmission - Transmission mount to adapter hng - Transmission mount nuts WE WOULD LIKE TO THANK ATSG FOR THE INFORMATION THEY PROVIDED IN HELPING TO CREATE THIS PRECISION POINTER. REVISED: 9/10 All of this information is based on the latest technical data available at time of printing. Although every care has been taken to detail & accuracy, Precision International accepts no liability for inaccuracies, updates, changes &/or misprints in this publication.! COPYRIGHT 2001, PRECISION INTERNATIONAL TECHNICAL DEPARTMENT IS G
SECTION 5 DIAGNOSTIC TROUBLE CODES (DTC)
5 1. DTC MEMORY SECTION 5 Diagnostic Trouble Codes (DTCs) are logged in a list in TCM memory. The DTCs contained in the list have information recorded as shown in Table 5 1 (DTC example). The TCM is capable
More information27 E. Front wheel drive. 1. Transmission Description (Ford Focus 2000 only) 4 4 Speed Transmission F
1. Transmission Description (Ford Focus 2000 only) 4 4 Speed Transmission F Front wheel drive 27 E Maximum input torque after torque converter: 270 Lb-ft (365 N-m) Fully Electronic control Note: Mazda
More information2003 CVT when used with 2.2L L61 engine in the Saturn ION TRANSMISSION DIAGNOSTIC PARAMETERS
TCM Memory ROM P0601 The code is designed to verify ROM checksum at key up. TCM Not Programmed P0602 The code is designed to verify that the TCM has been programmed. TCM Long Term Memory Reset P0603 This
More informationAllison LCT1000. Presented by: Mike Souza ATRA Senior Research Technician Allison LCT1000 Webinar 2014 ATRA. All Rights Reserved.
Allison LCT1000 Presented by: Mike Souza ATRA Senior Research Technician Allison LCT1000 Webinar 2014 ATRA. All Rights Reserved. Generation Changes 2000 to 2005 Gen I Allison LCT1000 are 5 speeds. In
More information2003 4L80-E when used in Heavy Duty (>8600 GVW) trucks with these engines: 4.8L (LR4), 6.0L (LQ4), 8.1L (L18) TRANSMISSION DIAGNOSTIC PARAMETERS
TRANSMISSION DIAGNOSTIC S Vehicle Speed Sensor - Low Input Vehicle Speed Sensor - Loss Trans Fluid Temp Sensor Circuit Range/ Performance (Contains 2 tests) Trans Fluid Temp Sensor Circuit - Low Input
More informationTRANSMISSION DIAGNOSTIC PARAMETERS
SENSED PARAMETER FAULT CODE ACCEPTALE OPERATING RANGE AND RATIONALITY PRIMARY FAIL ENALING CONDITIONS SECONDARY FAIL ENALING CONDITIONS MONITORING TIME LENGTH & FREQUENCY OF CHECK DTC TYPE Vehicle Speed
More informationL (L36) F-car 4L60-E TRANSMISSION DIAGNOSTIC PARAMETERS. 97c38K_F at.doc
Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent Trans Fluid Temp Sensor Circuit - Range / Performance P0502 P0503 0 RPM to 6000 RPM low vehicle speed when the vehicle has a large engine
More information07 GRP13_4T80E LD8_L37.doc. Page 1 of 7
Module Read Only Memory Module Not Programmed P0601 EPROM/Flash memory corruption (Incorrect program/calibrations checksum) ROM fail count > 5 None Immediate P0602 Non-programmed TCM (calibrations) KbCOND_NoStartCal
More information2006trans13_a.doc MONITORING TIME & DTC TYPE. 600 sec. Type C seconds Type C seconds Type C- Type A. Type A.
S S DE ACTIONS S Over Temperature P0218 High transmission fluid temperature for long period of time Trans Temp > 130 C. 8.0V < Ignition < 18.0V -39 C. < Trans Temp < 149 C. for 5 sec 600 sec FA Trans Temp
More informationSECONDARY FAIL ENABLING. 4.8L = 4.0 sec
Vehicle Speed Sensor - Low Input Vehicle Speed Sensor - Loss Trans Fluid Temp Sensor Circuit Range/ (Contains 2 tests) Trans Fluid Temp Sensor Circuit - Low Input (High Temperature indicated) P0502 P0503
More informationMEDIUM DUTY TRUCK. Presented By. ATSG s PETE LUBAN
MEDIUM DUTY TRUCK Presented By ATSG s PETE LUBAN 1/3/2M WWW.ATSG.COM 2/3/1M 3/3 1000/2000 SERIES Transmission code identification PPT 1 0 0 0 MHS HS Highway Series MHS Motor Home Series EVS Emergency Vehicle
More informationL (LS1) F-car (Camaro, Firebird), Y-car (Corvette) 4L60-E TRANSMISSION DIAGNOSTIC PARAMETERS. 99c57G_FY_aT.DOC
SECONDRY S ND Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent P0502 0 RPM to 6000 RPM low vehicle speed when the vehicle has a large engine speed in a drive gear range. P0503 0 RPM
More information2006trans13_b.doc ACCEPTABLE OPERATING RANGE AND RATIONALITY SENSED PARAMETER FAULT CODE PRIMARY MALF DETECTION PARAMETERS
S S DE ACTIONS S Over Temperature P0218 High transmission fluid temperature for long period of time Trans Temp > 130 C. 8.0V < Ignition < 18.0V -39 C. < Trans Temp < 149 C. for 5 sec 600 sec FA Trans Temp
More informationL SUPERCHARGED (L67) C-car, G-car, H-car and W-car 4T65-E TRANSMISSION DIAGNOSTIC PARAMETERS. 97c381_CGHWT.doc
Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent Trans Fluid Temp Sensor Circuit - Range / Performance Input/Turbine Speed Sensor Range /Performance P0502 P0503 P0711 P0716 low vehicle
More informationSHIFT SELECTOR OPERATION AND CODE MANUAL
SHIFT SELECTOR OPERATION AND MANUAL How to use the shift selector to read oil level and diagnostic codes on 3000/4000 Series Allison transmissions P.O. Box 894, Speed Code 462-470-PF3 Indianapolis, Indiana
More informationIntroduction to the GM 6L80. Presented By: Steve Garrett
Introduction to the GM 6L80 Presented By: Steve Garrett 6L80 (RPO MYC) Introduction The first of ten 6 speed automatics was introduced in the 2006 model year. The 6L80 (RPO MYC) is currently available
More informationFelkodslista Allison MY 09 med översättningstabell för Scania
Felkodslista Allison MY 09 med översättningstabell för Scania (På Scania presenteras Felkoder i decimal format i IVD displayen.) Allison DTC number Scania display code (Hex) Scania display code (Dec) Description
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Diagnostic Trouble Code Charts Diagnostic Trouble Code Chart P0102, MAF MAF concerns MAF system High/low EPC REFER to the P0103,
More informationTRANSMISSION DIAGNOSTIC PARAMETERS
TCM, Internal P0605 ROM checksum or RAM error Calculated checksum differs from stored. Ignition ON Number of failed calculations: 2 Lost communication with ECM (Engine) U0100 Frame missing from ECM Detect
More information2004 4T40-E transmission when used with 2.2L L61 engine in these vehicles Saturn LS, Grand Am, Alero, Cavalier, Sunfire, Saturn VUE, Chevrolet Classic
SECONDARY AND ENABLE Vehicle Speed Sensor: Low Input Vehicle Speed Sensor: Intermittent/Loss Range/ Low Input High Input P0502 P0503 P0711 P0712 P0713 Low vehicle speed with large engine speed in Drive
More informationAISIN WARNER. 1. With the selector lever in Park, start the engine and warm it to operating temperature.
AISIN WARNER 249 Manual Code Retrieval Preliminary Test: 1. With the selector lever in Park, start the engine and warm it to operating temperature. 2. Turn the ignition switch to the Off position, then
More information6T30/6T40/6T45 - AUTOMATIC TRANSMISSION
2010 GMC Truck Terrain AWD L4-2.4L Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts > P0717 6T30/6T40/6T45 - AUTOMATIC TRANSMISSION DTC P0716 or P0717 Diagnostic
More informationTROUBLESHOOTING BASIC TROUBLESHOOTING AT1 14 A340E A340F AUTOMATIC TRANSMISSION
AT114 BASIC Before troubleshooting an electronically controlled transmission, first determine whether the problem is electrical or mechanical. To do this, just refer to the basic troubleshooting flowchart
More informationTechnical Service Information
TOYOTA/LEXUS U/U0 PRELIMINARY INFORMATI Starting at the beginning of production for the 00 model year for Lexus and 00 for Toyota, a spin-off of the U10/U0 Four speed transaxle, designated as the U/U0
More informationDiagnostic Trouble Codes (continued) GM Specific Codes
85 GM Specific Codes P11XX Fuel and Air Metering P1106 MAP Sensor Circuit Intermittent High Voltage P1107 MAP Sensor Circuit Intermittent Low Voltage P1108 BARO to MAP Signal Comparison Too High P1111
More informationSECTION Electronic Engine Controls
303-14-i Electronic Engine Controls 303-14-i SECTION 303-14 Electronic Engine Controls CONTENTS PAGE DIAGNOSIS AND TESTING Electronic Engine Controls... 303-14-2 DTC Charts... 303-14-2 303-14-2 Electronic
More informationDTC Summaries. W5A-580 Transmission Control System 1998 MY
DTC Summaries W5A-580 Transmission Control System 1998 MY OBD II MONITORING CONDITIONS: When testing for OBD II DTC reoccurrence, it can be determined if the Service Drive Cycle was of sufficient length
More informationValve Body: Service and Repair
2007 Chevy Truck TrailBlazer 2WD L6-4.2L Copyright 2013, ALLDATA 10.52SS Page 1 Valve Body: Service and Repair Valve Body and Pressure Switch Replacement Removal Procedure 1. Ensure that removal of the
More informationDTC Summaries. 5 HP 24 Transmission Control System 1997 MY
DTC Summaries 5 HP 24 Transmission Control System 1997 MY OBD II MONITORING CONDITIONS: When testing for OBD II DTC reoccurrence, it can be determined if the Service Drive Cycle was of sufficient length
More informationDiagnostic Trouble Code (DTC) Charts
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Diagnostic Trouble Code (DTC) Charts DTC Chart **May also be
More informationTechnical Service Information
BMW - A4S (THM 4L30-E) DIAGNOSTIC TROUBLE CODE 40 (Pressure Control Circuit) Adapted from BMW s Service Bulletin 24 06 94 COMPLAINT: CAUSE: BMW s A4S transmission is otherwise known as the 4L30-E. This
More information1. Range Reference Chart
. Range Reference Chart Range Gear Sol A N.C. Sol B N.C. O/D Roller Clutch Overrun Clutch (OC) Fouth Clutch (C4) Third Clutch (C) Reverse Clutch (RC) Second Clutch (C) Principle Sprag Assembly Band Assembly
More information07 GRP04_All Transmissions.xls
Component/ Fault Monitor Strategy Malfunction Threshold Secondary Parameters / Time MIL Extra System Code Description Criteria Value Enable Conditions Required Illumin. Prep TCM, Internal Fault P0605 ROM
More informationPRE CHECK DI 456. w/ Tachometer. w/o Tachometer. Hand held Tester AUTOMATIC TRANSMISSION (A340E, A340F) 2003 TOYOTA TACOMA (RM1002U) D10837 D00729
DI456 w/ Tachometer w/o Tachometer D10837 PRECHECK DI8Z403 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that
More informationDIAGNOSTIC TROUBLE CODE CHART HINT:
DIAGNOSTICS DIAGNOSTIC TROUBLE CODE CHART HINT: SFI SYSTEM (1MZFE) 05241 Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. If a
More informationTIME LAG TEST Check the automatic transmission (each clutch, brake and gear) for wear.
AT2 TROUBLESHOOTING 1. GENERAL INFORMATION (a) Troubles occurring with the automatic transmission can be caused by either the engine, electrical control or the transmission itself. These 3 areas should
More information2002 Chevrolet Silverado 1500
For the specific DTCs required for each system, see table. Systems such as fuel delivery, misfire, and comprehensive components may not be listed in a system status list. These tests run continuously on
More informationOIL CIRCUIT DIAGRAMS:
Toyota U660-E WWW.ATSG.BIZ INDE Introduction... 2 Component Application Chart... 4 Sprag Rotation... 5 Pressure Testing... 6 Fluid Specification... 8 Transmission Range Sensor... 10 TCM Location... 13
More informationOperator s Manual and 2000 Product Families OM3063EN MT4108EN
Operator s Manual 1000 and 2000 Product Families OM3063EN MT4108EN Operator s Manual 2003 JUNE Rev. 1 2004 JULY OM3063EN Allison Transmission On-Highway 1000 and 2000 Product Families Allison Transmission,
More informationF o r d I n s t a l l a t i o n I n s t r u c t i o n s
1 DO NOT USE WATER-BASED TRANSMISSION FLUSHING FLUID THE LINING IN THE CONVERTOR CLUTCHES WILL DISINTIGRATE, RENDERING THE CONVERTOR USELESS AND WARRANTY WILL BE VOIDED. BD PERFORMANCE TRANSMISSION F o
More informationAllison Lockup Controller
19 February 2018 1031311/1031312/1031313 Allison Transmission Lockup and Pressure Module (I-00413) 1 Allison Lockup Controller Transmission Lockup and Pressure Controller 1031311 1031312 1031313 2001-2010
More information07 GRP14_All Transmissions.DOC. Page 1 of 10
CCEPTLE RNGE LI 07 GRP14_ll Transmissions.DOC M RTION TY PR ETERS TCM ROM Test P0601 This detects an error in the flash memory containing the program and calibration. Power up copy of P0603 This detects
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.0 L 2002.25 Model Year Refer to page 2 for important information regarding the use of Powertrain DTC Summaries. Jaguar X-TYPE 2.0
More information4.0L CEC SYSTEM Jeep Cherokee DESCRIPTION OPERATION FUEL CONTROL DATA SENSORS & SWITCHES
4.0L CEC SYSTEM 1988 Jeep Cherokee 1988 COMPUTERIZED ENGINE Controls ENGINE CONTROL SYSTEM JEEP 4.0L MPFI 6-CYLINDER Cherokee, Comanche & Wagoneer DESCRIPTION The 4.0L engine control system controls engine
More informationDiagnostic Trouble Code (DTC) List - Vehicle
Document ID# 850406 2002 Pontiac Firebird Diagnostic Trouble Code (DTC) List - Vehicle DTC DTC 021 and/or 031 DTC 022 and/or 032 DTC 023 or 033 DTC 24/34 DTC 025 and/or 035 DTC 041 DTC 042 DTC 043 DTC
More informationDI 244 DIAGNOSTICS AUTOMATIC TRANSMISSION DIB30 01 PRE CHECK
DI244 DIAGNOSTICS PRECHECK DIB3001 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle
More information1 of 9 5/29/2014 6:01 AM
1 of 9 5/29/2014 6:01 AM Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid, TCC Solenoid, and Wiring Harness Tools Required ^ J28458 Seal Protector Retainer Installer Removal Procedure
More information1994 Toyota LAND CRUISER TROUBLESHOOTING. Submodel: Engine Type: L6 Liters: 4.5 Fuel Delivery: FI Fuel: GAS
1994 Toyota LAND CRUISER Submodel: Engine Type: L6 Liters: 4.5 Fuel Delivery: FI Fuel: GAS TROUBLESHOOTING Trouble occurring in the electronically controlled transmission can stem from one of three sources:
More informationTRANSMISSION DIAGNOSTIC PARAMETERS
Transmission Fluid Overtemperature Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent Trans Fluid Temp Sensor ircuit - Performance Test P0218 This DT detects a high transmission temperature
More informationIN-VEHICLE REPAIR. Output Shaft Speed (OSS) Sensor. Removal
307-01-1 Automatic Transaxle/Transmission 6F50 307-01-1 IN-VEHICLE REPAIR Output Shaft Speed (OSS) Sensor Material Item MERCON V Automatic Transmission Fluid XT-5-QM (or XT-5-QMC) (US); CXT-5-LM12 (Canada)
More informationShift Solenoid "B" Performance (Shift Solenoid Valve S2)
86 A750E AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM DTC P0756 Shift Solenoid "B" Performance (Shift Solenoid Valve S2) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input
More informationShift Solenoid "B" Performance (Shift Solenoid Valve S2)
88 A750F AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM DTC P0756 Shift Solenoid "B" Performance (Shift Solenoid Valve S2) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input
More informationZF4HP16. Technical Bulletin # Signal Combination L1 L2 L3 L4 P R N D
Transmission: Subject: Application: Issue Date: Technical Bulletin # 1308 ZF4HP16 Electronical Components Description 2005 Suzuki Forenza L4-2.0L February, 2010 ZF4HP16 Electronical Components Description
More informationSECONDARY MONITORING PARAMETERS AND CONDITIONS
S S MIL Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent P0502 nalog 0 RPM to 6000 RPM a low vehicle speed vehicle has a large engine speed in a drive gear range. P0503 nalog 0 RPM
More informationFord CFT 30 Introduction. Presented by: Bill Brayton ATRA Senior Research Technician
Ford CFT 30 Introduction Presented by: Bill Brayton ATRA Senior Research Technician Connections Handout Webinars@ATRA.com Questions Survey Welcome To Today s Presentation Sponsored By: Thank you to our
More informationPROBLEM SYMPTOMS TABLE
Last Modified: 4262007 Service Category: Drivetrain 1.6 T Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W7304AX Title: A750E AUTOMATIC TRANSMISSION: AUTOMATIC
More informationShift Solenoid "A" Performance (Shift Solenoid Valve S1)
78 DTC P0751 Shift Solenoid "A" Performance (Shift Solenoid Valve S1) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input speed sensor to detect the actual gear position (1st,
More informationElectronic Control System
Electronic Control System PRECAUTION AT79 Do not open the cover or the case of the ECM and various computer unless absolutely necessary. (If the IC terminals are touched, the IC may be destroyed by static
More informationDIAGNOSIS AND TESTING
307-01B-1 DIAGNOSIS AND TESTING Special Testing Procedures The special tests are designed to aid the technician in diagnosing the hydraulic and mechanical portion of the transmission. Engine Idle speed
More informationPROBLEM SYMPTOMS TABLE
A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Last Modified: 4262007 Service Category: Drivetrain 1.6 T Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner
More informationTechnical Service Bulletin
Subject ATA SOLENOID DIAGNOSTIC CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770 Date Model [X] PARTS MANAGER JANUARY, 2006 1999~ SONATA, 2001~ ELANTRA, SANTA FE & XG,
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Special Testing Procedures Special Tool(s) Air Test Plate, Transmission 307-405 Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A)
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Transmission Connector Layouts Connector Reference and Terminal Readings Powertrain Control module (PCM) 1 Pressure control solenoid
More informationInstallation Manual v3.0: Dodge Cummins. Please read all instructions before the installation of the ATS Co-Pilot
Installation Manual v3.0: 2004-2005 Dodge Cummins Please read all instructions before the installation of the ATS Co-Pilot Thank you for purchasing the ATS Co-Pilot Torque converter/exhaust brake controller.
More informationFig.11 Powertrain Control Module (PCM)
2003 Dodge or Ram Truck Caravan V6-3.3L VIN R Vehicle > Powertrain Management > Relays and Modules - Powertrain Management > Relays and Modules - Computers and Control Systems > Engine Control Module >
More informationSERVICE MANUAL Gearbox - Allison AT545 - Gearbox Installation
Gearbox - Allison AT545 - Gearbox Installation Oil level dipstick Gearbox oil cooler Auxiliary oil filter Modulator Page 3.4 Gearbox - Allison AT545 Checking Oil Level The dipstick and filler are situated
More informationIGNITION TIMING (GASOLINE)
IGNITION TIMING (GASOLINE) 4-CYLINDER IGNITION TIMING 2.5L (VIN E) 1. Set parking brake, block drive wheels and place transmission in Neutral or Park. Warm engine to normal operating temperature. Turn
More informationDTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M)
Page 1 of 5 1996 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 49145 DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M) Circuit Description The Vehicle
More informationElectronic Control System
AT440 AUTOMATIC TRANSMISSION A340F 4WD Electronic Control System PRECAUTION Do not open the cover or the case of the ECU and various computer unless absolutely necessary. (If the IC terminals are touched,
More information2002 Explorer/Mountaineer Workshop Manual
Page 1 of 20 SECTION 307-01: Automatic Transmission - 5R55W/S 2002 Explorer/Mountaineer Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 10/20/2004 Pinpoint Tests OSC Equipped Vehicles Special
More informationOBD-II Diagnostic Powertrain (P) Trouble Codes
OBD-II Diagnostic Powertrain (P) Trouble Codes Please use our new & improved search engine to find information on your trouble codes. Search Now! This list contains standard diagnostic trouble codes (DTC
More informationLX AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION TABLE OF CONTENTS
LX AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION 21-495 AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION TABLE OF CONTENTS page AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION DESCRIPTION...496
More informationGM Enhanced Parameters
GM Enhanced Parameters # of 4x Ref Pulses between CAM Counter # OF EGR ADAPTIVE LEARN MATRIX CELLS OUT OF RANGE High # OF EGR ADAPTIVE LEARN MATRIX CELLS OUT OF RANGE LOW 1-2 Adapt High Cell 1-2 Adapt
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar S-TYPE V6, V8 N/A and V8 SC 2002.5 Model Year Refer to pages 2 9 for important information regarding the use of Powertrain DTC Summaries.
More informationDISASSEMBLY. Transmission. All vehicles
307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 DISASSEMBLY Transmission Special Tool(s) Holding Fixture, Transmission 307-262 (T93T-77002-AH) Special Tool(s) Remover, Servo 307-347 (T97T-7D021-A)
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Pinpoint Tests OSC Equipped Vehicle Special Tool(s) Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A) Special Tool(s) MLP-TR
More informationC6 Corvette DIC Codes
C6 Corvette DIC Codes B0159 Outside Air Temp Sensor B2910 Steering Column Lock Password Incorrect B0164 Pass Compartment Temp Sensor B2981 Right Front Door Handle Switch B0174 Output Air Temp Sensor 1
More informationTechnical Bulletin # 1251
Transmission: Subject: Application: Issue Date: CD4E TCC Slip Code Diagnosis Ford, Mercury and Mazda May 2009 CD4E TCC Slip Code Diagnosis Once the check engine light illuminates, the transmission will
More informationINTRODUCTION PRELIMINARY DIAGNOSIS
NO: 21-11-98 SUBJECT: Transmission Simulator Diagnostic Tool DATE: Dec. 11, 1998 NOTE: THIS INFORMATION APPLIES TO VEHICLES EQUIPPED WITH A 45RFE TRANSMISSION. DISCUSSION: A new transmission simulator
More informationTELORVEK TPI WIRING INSTRUCTIONS FOR TH-90 (95 CK TRUCK) 4.3,5.0,5.7,7.4 TBI Fuel Injection System W/4L60-E or 4L80-E Transmission
Page #1 TELORVEK TPI WIRING INSTRUCTIONS FOR TH-90 (95 CK TRUCK) 4.3,5.0,5.7,7.4 TBI Fuel Injection System W/4L60-E or 4L80-E Transmission Thank you for purchasing the absolute finest of wiring kits for
More informationAllison Service Tip. #1099H Page 1 of 19
Allison Service Tip Page 1 of 19 SUBJECT: Transmission Fluid/Filter Change Recommendations New Schedule One TES 389 Fluid Specification DEXRON -VI, Removal of C4 Fluids, and Release of Fluid and Filter
More informationLB-47 TELORVEK TPI. WIRING INSTRUCTIONS FOR Olds / Aurora 4.0 V-8 ENGINE
Page #1 LB-47 TELORVEK TPI WIRING INSTRUCTIONS FOR Olds / Aurora 4.0 V-8 ENGINE Thank you for purchasing the absolute finest of wiring kits for the General Motors fuel injection. We have taken considerable
More informationDISASSEMBLY AND ASSEMBLY
307-01-1 Automatic Transaxle/Transmission 307-01-1 DISASSEMBLY AND ASSEMBLY Transaxle Special Tool(s) Dial Indicator Gauge With Holding Fixture 100-002 (TOOL-4201-C) Special Tool(s) Test Plate Screw Set,
More informationA750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GR-FE)... Model Year: 2007 Model: 4Runner Doc ID: RM000000W80023X
Last Modified: 4-26-2007 Service Category: Drivetrain 1.6 C Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W80023X Title: A750F AUTOMATIC TRANSMISSION: AUTOMATIC
More informationP0777-SECONDARY PRESSURE SOLENOID STUCK ON (LOW PRESSURE)
009 - MK - JEEP COMPASS/PATRIOT -.0L 4 CYL DOHC 6V DUAL V.V.T. P0777-SECONDARY STUCK ON (LOW ) / LINE SECONDARY ON/OFF 3 4 T0 DG/LB T9 T9 T60 YL/DB YL/LB YL/GY C C 3 C 4 C LINE SECONDARY ON/OFF MODULE-
More informationTRANSMISSION SERVICING - A/T
TRANSMISSION SERVICING - A/T 1992 Infiniti G20 1991-92 TRANSMISSION SERVICING Automatic Transmission G20 IDENTIFICATION INFINITI AUTOMATIC TRANSMISSION APPLICATIONS Model Transmission Model G20... (1)
More informationINDEX BACK AUTOMATIC TRANSMISSION SERVICE GROUP SW 107TH AVENUE MIAMI, FLORIDA (305) Copyright ATSG 2005
BACK INDEX MITSUBISHI F4A4, F4A42, F4A5 IDENTIFICATION CODE STAMPING LOCATION... GEAR RATIO IDENTIFICATION... INTERNAL COMPONENT AND SOLENOID APPLICATION CHART... FLUID REQUIREMENTS... CASE CONNECTOR TERMINAL
More informationDiagnostic Trouble Codes (continued) SAE Defined Codes
78 SAE Defined Codes P01XX Fuel and Air Metering P0100 Mass or Volume Airflow Circuit Problem P0101 Mass or Volume Airflow Circuit Range or Performance Problem P0102 Mass or Volume Airflow Circuit Low
More informationWTEC III SHIFT SELECTOR
WTEC III SHIFT SELECTOR P.O. Box 894, Speed Code PF3 Indianapolis, Indiana 46206-0894 www.allisontransmission.com Oil level information, diagnostic codes and prognostic features for SA7297EN (2012/12)
More information12.Electrohydraulic Control System
W1860BE.book Page 67 Tuesday, January 28, 2003 11:01 PM 12.Electrohydraulic Control System A: DESCRIPTION The electrohydraulic system for the transmission and transfer consists of various sensors and switches,
More information2001 Chevrolet Corvette ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette
2001 ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette DESCRIPTION Cruise control is a speed control system that maintains a desired vehicle speed under normal driving conditions. Steep grades
More informationSYTY Trouble Code: ALDL INFORMATION
SYTY Trouble Code: ALDL INFORMATION A -- Ground G -- Fuel Pump B -- Diagnostic Terminal H -- Brake Sense Speed Input F -- TCC M -- Serial Data (special tool needed - Do Not Use) For ECM Trouble Codes,
More information2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis
2002 AUTOMATIC TRANSMISSIONS 5R55W/S Diagnosis APPLICATION WARNING: Vehicles are equipped with Supplemental Inflatable Restraint (SIR) system. When servicing vehicle, use care to avoid accidental air bag
More information1 of 1 7/1/17, 2:02 PM. Air Cleaner Assembly Replacement ALLDATA, LLC. All Rights Reserved. (Version )
Air Cleaner Housing Service and Repair, Removal and Replacement: Ai... http://repair.alldata.com/alldata/article/display.action?componentid=367... 1 of 1 7/1/17, 2:02 PM Air Cleaner Assembly Replacement
More informationHyundai - Specific Trouble Codes
Hyundai - Specific Trouble Codes P1100 Map Sensor - Malfunction P1101 Map Sensor - Abnormal P1102 Map Sensor - Low Input P1103 Map Sensor - High Input P1104 Air Flow P1105 Air Flow - Abnormal P1106 Air
More informationAisin Warner LE 1998-Up Nissan UD Isuzu RNJ Mitsubishi FUSO
Aisin Warner 450-43LE 1998-Up Nissan UD Isuzu RNJ Mitsubishi FUSO AISIN SEIKI CO., LTD. SERIAL NO. 9A0001 Year: 1999 Month: January Ex. B: February C: March D: April * * L: December Serial Numbers Component
More informationAUTO TRANS DIAGNOSIS - 4T65-E
AUTO TRANS DIAGNOSIS - 4T65-E 1998 Pontiac Bonneville 1997-98 AUTOMATIC TRANSMISSIONS General Motors - 4T65-E Electronic Controls Buick; LeSabre, Park Avenue, Regal, Riviera Chevrolet; Lumina, Monte Carlo
More informationTELORVEK TPI WIRING INSTRUCTIONS FOR LS Camaro/Firebird LS-1 Fuel Injection System
Page #1 TELORVEK TPI WIRING INSTRUCTIONS FOR LS-85 98 Camaro/Firebird LS-1 Fuel Injection System Thank you for purchasing the absolute finest of wiring kits for the General Motors fuel injection. We have
More informationservice bulletin MCM 454 Magnum EFI, MIE 454 EFI Ski GM Gen V Engine Specifications No Magnum 454 EFI Model EFI Ski (Average Octane Rating)
service bulletin TO: SERVICE MANAGER MECHANICS PARTS MANAGER No. 93-25 MCM 454 Magnum EFI, MIE 454 EFI Ski GM Gen V Engine Specifications NOTE: Generation V Engines Have the Fuel Pump Mounted on the Belt
More informationTELORVEK III. WIRING INSTRUCTIONS FOR LT-40 LT-1 Fuel Injection System
TELORVEK III WIRING INSTRUCTIONS FOR LT-40 LT-1 Fuel Injection System Page #1 Thank you for purchasing the absolute finest of wiring kits for the General Motors fuel injection. We have taken considerable
More information