ROV Dirty Work Pack Unit Datasheet

Size: px
Start display at page:

Download "ROV Dirty Work Pack Unit Datasheet"

Transcription

1 Datasheet Examples of features Compact, low weight High reliability valves as standard Simple Custom configurations Remote Start / Stop Remote pressure regulation option Internally pressure compensated option Load sense option Simple Service Friendly Flow sensor option P and T Pressure sensor option The ROV Dirty Work Pack Unit is used to reduce the risk of contamination in the main ROV hydraulic system. By using this equipment you will get two completely separate oil circuits and avoid concerns about contamination in your hydraulic system. The Dirty Work Pack Unit is hydraulically driven which means that there is an external hydraulic pressure source that drives a motor which again drives a pump. In most circumstances the external pressure source will be an ROV. The motor circuit have a built in start/stop valve for remote start/stop operation. The pump can be internally pressure compensated, remote pressure regulated or connected to a load sensing valve system. This unit s pump pressure circuit contains two filters, one in-line Parker P-15 pressure filter and one offline Cardev filter. This method of continuous filtration is ideal as contamination levels are always controlled and the entire hydraulic system is cleaned not just what s in the tank when it s service time. With its unique draw system you can easily make adjustments, fill compensators and carry out maintenance while the unit is still connected to the ROV. The design is based on experience in development and manufacture of underwater equipment.

2 Technical Description The ROV Dirty Work Pack Unit is used to reduce the risk of contamination in the main ROV hydraulic system. By using this equipment you will get two completely separate oil circuits and avoid concerns about contamination in your hydraulic system. The Dirty Work Pack Unit is hydraulically driven which means that there is an external hydraulic pressure source that drives a motor which again drives a pump, in most circumstances an ROV is used as an external pressure source. This unit s pump pressure circuit contains two filters, one in-line Parker P-15 pressure filter and one off-line Cardev filter. The pump pressure and flow depends on the amount of pressure and flow the hydraulic motor is supplied with. The engine can be supplemented with maximum of 210 bar and 90 l / min. Efficiency is rated to 66%.

3 General Technical data ROV Dirty Work Pack Unit ROV Dirty Work Pack Wheigt (Kg) In air / Submerged Dimension (mm) W x H x D 115 Kg / 95 Kg 920 x 460 x 375 mm Capacities Max. supply pressure 210 Bar Max. output 210 Bar Efficiency is rated to 66% Max. supply flow Flow Reservoir Capacity 90 L/min 60 L/min 4 Gallon / 15 L Port Connection Specifications Motor Supply Port Motor Return Port Motor Drain Port Motor Start / Stop Port Pump Pressure Port Pump Suction / Return Port Pump Remote Port Main Comp. /Tank Fill Main Comp. /Tank Bleed Bell Housing Comp. Fill Bell Housing Comp. Bleed ½ Swagelok Male ½ Swagelok Male ½ Swagelok Male ¼ Swagelok Male ½ Swagelok Male 1 Swagelok Male 1/8 NPT Female SS-QC6-B1-600 SS-QC4-B1-400 SS-QC6-B1-600 SS-QC4-B1-400 * All Ports are optional, any deviations to standard to be specified when ordering

4 Hydraulic Component Data Hydraulic Motor Hydraulic Pump Bosch Rexroth A10FM 028-V52 Bosch Rexroth A10VNO 028DRG 53 Off-Line Filter Element In-Line Filter Element Reservoir Bell Housing Comp. Cardev Parker Oceaneering 2 gallon Kystdesign 025L SDU-H8 14P2-10Q 2-Gallon Reservoir AB53-DR02 Note: technical specifications are subject to change without notice. We accept no liability for any inaccuracy or printing errors.

5 ROV Dirty Work Pack Hydraulic Hook-Up Description Port / Valve Specifications 1 Bell Housing Comp. Fill SS-QC6-B Bell Housing Comp. Bleed SS-QC4-B Main Comp. /Tank Fill SS-QC6-B Main Comp. /Tank Bleed SS-QC4-B Pump Suction / Return Port 1 Swagelok Male 6 Pump Pressure Port ½ Swagelok Male 7 Motor Return Port ½ Swagelok Male 8 Motor Supply Port ½ Swagelok Male 9 Motor Drain Port ½ Swagelok Male 10 Motor Start / Stop Port ¼ Swagelok Male 11 Pump Comp. reg. app 25 Bar N/A 12 Pump max pressure regulator N/A 13 Pressure relief valve pre adj. 230 Bar N/A 14 Pressure Remote Controll Port 1/8 NPT Female 15 Motor Flow Regulator 40L/min N/A Note: technical specifications are subject to change without notice. We accept no liability for any inaccuracy or printing errors.

6 Hydraulic ROV Flow Diagram Dirty Work Pack Measuring equipment Description: Parker Service Master Plus Model No.: SMPIM02 Serial No.: 90 L/min Accuracy: 0.20% max. FS Calibration Certificate No.:

7 Hydraulic ROV Schematics Dirty Work Pack

Radial piston pump PR4 Series 1X

Radial piston pump PR4 Series 1X Radial piston pump R4 eries 1X RE 1160 Edition: 07.015 Replaces: 08.005 Fixed displacement izes 0,40 to,00 Maximum working pressure 700 bar Maximum displacement cm 3 R4-1X/1,00-450WA01M01 Features elf-priming,

More information

P2060 P2075 P2105 P2145 P3105 P3145

P2060 P2075 P2105 P2145 P3105 P3145 Technical Information Technical Features P2 Series Compact design Low noise level Service friendly Reliable Long-lasting Flexible Easy to install High self-priming speed Technical Data P3 Series P2 Series

More information

Volume flow measurement

Volume flow measurement Volume flow measurement Volume flow measurement Turbine flow meter, type SCFT Lower fl ow resistance Built-in measurement connections for pressure and temperature Very simple installation into a hydraulic

More information

2.4 HEAVY DUTY SERIES

2.4 HEAVY DUTY SERIES 2 2.4 HEAVY DUTY SERIES CONTENTS PPV102 Ordering Code 2.4.1 Heavy Duty Series 2.4.2 Heavy Duty Series compensator 2.4.3 Standard gear pump models Technical Information 2.4.4 Specifications 2.4.5 Hydraulic

More information

Axial Piston Variable Pump A10VSNO

Axial Piston Variable Pump A10VSNO Electric Drives and Controls Hydraulics inear Motion and Assembly Technologies Pneumatics ervice Axial Piston Variable Pump A10VNO RE 92741/03.11 1/16 Data sheet eries 52 ize 15 Nominal pressure 210 bar

More information

Operation & Service Manual

Operation & Service Manual Operation & Service Manual Model: 06-4035-3600 Hydraulic Service Unit 03/2003 AA Rev. 15 Includes Illustrated Parts List Tronair, Inc. 1740 Eber Road Holland, Ohio 43528-9794 USA Telephone: (419) 866-6301

More information

ATEX instruction for APP / PAH PAHT G 2-90 / PAH Tech

ATEX instruction for APP / PAH PAHT G 2-90 / PAH Tech MAKING MODERN LIVING POSSIBLE Instruction ATEX instruction for APP 0.6-10.2 / PAH 2-100 PAHT G 2-90 / PAH 25-80 Tech danfoss.high-pressurepumps.com Table of Contents 1. Common demands for Category 2 and

More information

Radial piston pump PR4 series 1X

Radial piston pump PR4 series 1X Radial piston pump R4 series 1X RA 1160 Edition: 07.015 Replaces: 08.005 Fixed displacement izes 0,40 to,00 Maximum working pressure 700 bar (10150 psi) Maximum displacement cm 3 (0.1 in 3 ) R4-1X/1,00-450WA01M01

More information

Hydraulic and Commissioning Mannual Module 2A

Hydraulic and Commissioning Mannual Module 2A Hydraulic and Commissioning Mannual Module 2A 2/7 Table of Contents 1 Features 3 2 Hydraulic Commissioning 3 2.1 Functional Purpose 3 2.2 System Description 3 3 Hydraulic Commissioning Instructions 4 4

More information

Installation and Startup Manual Hydraulic Pumps Series VP1-095 /-110/ -130

Installation and Startup Manual Hydraulic Pumps Series VP1-095 /-110/ -130 Visit our homepage for additional support parker.com/pmde Installation and Startup Manual Hydraulic Pumps Series VP1-095 /-110/ -130 Effective: May 01, 2015 Supersedes: January 01, 2013 Important installation

More information

CS-SCB Sander Control Block Manual

CS-SCB Sander Control Block Manual Electric Drives and Controls Hydraulics Linear Motion and Assembly Technologies Pneumatics Service CS-SCB Sander Control Block Manual The Drive & Control Company Copyright 1996 Bosch Rexroth Canada All

More information

Fluke 750P Series Pressure Modules

Fluke 750P Series Pressure Modules Fluke 750P Series Pressure Modules Technical Data Precision pressure measurement for 75X and 720 series calibrators The 750P Series Pressure Modules are the ideal pressure modules to enable gage, differential

More information

P200 SERIES PORTABLE HYDROSTATIC TESTER FEATURES: PUMP TYPE AND PRESSURE RANGES

P200 SERIES PORTABLE HYDROSTATIC TESTER FEATURES: PUMP TYPE AND PRESSURE RANGES P200 SERIES PORTABLE HYDROSTATIC TESTER MODELMODEL P200-SM ( STANDARD MODEL) SHOWN IN PHOTO HEAVY DUTY ROLL FRAME: Powder coated square tubular frame for easy transport. DUAL GAUGE MANIFOLD: 4 dial gauges

More information

MASTER PRIORITY & TWO-PUMPS-COMBINING VALVE

MASTER PRIORITY & TWO-PUMPS-COMBINING VALVE TWO-PUMPS-COMBINING SVILUPPO APPLICAZION FRENI INDUSTRIALI TWO-PUMPS-COMBINING -- 00.01 MASTER & TWO-PUMPS-COMBINING FUNCTIONING: Two pumps supply oil to the valve. Steering unit of load sensing type is

More information

SERVICE MANUAL No. I-0019

SERVICE MANUAL No. I-0019 Bettis Canada Ltd. 4112 91A Street Edmonton, Alberta, Canada T6E 5V2 Tel: (403) 450-3600 Fax: (403) 450-1400 SERVICE MANUAL No. I-0019 Edmonton CUSTOMER: P.O.#: W.O.#: TAG: DATE: APPLIES TO OPERATOR MODEL:

More information

2S500B-S. Oil Filtration and Coolant Handling Specialists. Removes Contaminants. Extends Oil Life. Reduces Component Wear.

2S500B-S. Oil Filtration and Coolant Handling Specialists. Removes Contaminants. Extends Oil Life. Reduces Component Wear. Oil Filtration and Coolant Handling Specialists Removes Contaminants Extends Oil Life Reduces Component Wear Removes all Water Saves Machine Downtime Reduces Disposal Costs Simple to Install & Use Low

More information

Hydraulic Pump Series F1plus Fixed Displacement

Hydraulic Pump Series F1plus Fixed Displacement Fixed Displacement Catalog 9129 8218-02 February 1999, GB Content General information, design 3 Specifications 4 Pump cross section 4 Pump and line selection 5 Ordering code 6 Standard versions 6 Installation

More information

Hydraulic Pump Series VP1 Variable Displacement

Hydraulic Pump Series VP1 Variable Displacement Variable Displacement Catalog 9129 8222-02 February 1999, GB Content Page General information 3 Design 3 Specifications 4 Ordering information 4 VP1 cross section 4 Installation dimensions 5 Line dimensioning

More information

Variable Vane Pump, Direct Controlled PV7...A Series 1X / 2X

Variable Vane Pump, Direct Controlled PV7...A Series 1X / 2X Variable Vane Pump, Direct Controlled PV7...A Series 1X / X RE 1 Issue: 1.13 Replaces: 8.8 Sizes 1 to Maximum pressure 1 bar Displacement volume 1 to cm 3 Features Very short control times Low noise Mounting

More information

Variable Displacement Open Loop Circuit Axial Piston Pumps AR Series

Variable Displacement Open Loop Circuit Axial Piston Pumps AR Series HYDRAULIC COMPONENTS HYDROSTATIC TRANSMISSIONS GEARBOXES - ACCESSORIES Via M.L. King, 6-41122 MODENA (ITALY) Tel: +39 59 415 711 Fax: +39 59 415 729 / 59 415 73 INTERNET: http://www.hansatmp.it E-MAIL:

More information

Fluke 750P Series Pressure Modules

Fluke 750P Series Pressure Modules TECHNICAL DATA Fluke 750P Series Pressure Modules Precision pressure measurement for 750 and 720 series calibrators The 750P Series Pressure Modules are the ideal pressure modules to enable gage, differential

More information

UNIVERSAL, INDEPENDENT DUAL SYSTEM HYDRAULIC TEST STAND

UNIVERSAL, INDEPENDENT DUAL SYSTEM HYDRAULIC TEST STAND UNIVERSAL, INDEPENDENT DUAL SYSTEM HYDRAULIC TEST STAND Our Competent Engineering Staff Ensures You are Provided with the Exact Hydraulic Testing Equipment for Current and Future Applications Which Will

More information

Axial Piston Variable Pump A18VLO Series 11

Axial Piston Variable Pump A18VLO Series 11 Axial Piston Variable Pump A18VLO eries 11 RE 92280 Issue: 06.2012 Replaces: 06.2009 ize 80 Nominal pressure 350 bar Maximum pressure 400 bar For commercial vehicles Open circuit Features Variable pump

More information

Pressure gauge in stainless steel version. Suitable for aggressive media and environments. Aluminium, white with black lettering

Pressure gauge in stainless steel version. Suitable for aggressive media and environments. Aluminium, white with black lettering Ed.17.01 Application in stainless steel version. Suitable for aggressive media and environments Design EN 837-1 Series 2840 WIKA model 232.50 Case size Nominal size dim 100 mm Accuracy Class 1,0% Case

More information

10 Pressure/temperature measurement SCPT analogue

10 Pressure/temperature measurement SCPT analogue 10 Pressure/temperature measurement SCPT analogue Pressure/temperature measurement SCPT analogue Robust stainless steel design Response times of 1 ms Capturing of pressure peaks Accuracy ±0.5 % Fast response

More information

Low Pressure Series - Accessories. High Pressure Series - Accessories

Low Pressure Series - Accessories. High Pressure Series - Accessories Low Pressure Series - Accessories STCO 50 Low Pressure Variable Spray Gun - Bronze Max. Pressure: 0Bar(50PSI) Inlet: /2 FBSP Max. Flow: 6GPM(23Lt/Min) 60 C(40 F) STCO 50-SS Low Pressure Variable Spray

More information

Truck Hydraulics. Serie VP1 Variable Displacement Pumps

Truck Hydraulics. Serie VP1 Variable Displacement Pumps ruck Hydraulics Variable Displacement Pumps aerospace climate control electromechanical filtration fluid & gas handling hydraulics pneumatics process control sealing & shielding Contents Pump and line

More information

mass flowmeter for compressed air

mass flowmeter for compressed air mass flowmeter for compressed air VARIOMASS LC pressure and temperature compensated flowmeter easy and cost effective installation of the senor no pressure loss caused by the sensor no moving parts, i.e.

More information

Installation & Operation Manual. IMPORTANT: This manual contains important information. READ AND KEEP FOR REFERENCE.

Installation & Operation Manual. IMPORTANT: This manual contains important information. READ AND KEEP FOR REFERENCE. Elecronic Preset Meter 2 Industrial Handheld Series Model EPM2-IND Standard Series IMPORTANT: This manual contains important information. READ AND KEEP FOR REFERENCE. IOM-139-02-EN (1-12) 53400-139 Rev.

More information

S0300-BV-CAT-010 PUMPING SYSTEM, SBM, HYD, 2" TO 4", 1500-GPM. System - S " to 4" Hydraulic Submersible Pumping System S18250

S0300-BV-CAT-010 PUMPING SYSTEM, SBM, HYD, 2 TO 4, 1500-GPM. System - S  to 4 Hydraulic Submersible Pumping System S18250 2" to 4" Hydraulic Submersible Pumping System S18250 Page 1 The 2" to 4" Hydraulic Submersible Pumping System S18250 consists of an ancillary set with 2", 3", and 4", hydraulically driven, submersible

More information

Axial Piston Pumps for Commercial Vehicles from Bosch Rexroth

Axial Piston Pumps for Commercial Vehicles from Bosch Rexroth Axial Piston Pumps for Commercial Vehicles from Bosch Rexroth Geert Geven(DCBN/SLM) 1 Overview - Truck pump A17/A18 Model A17FO (KFA) A17FNO A17VO (KVA) A18VO A18VLO Design fix displacement middle pressure

More information

Axial Piston Variable Pump A10VSNO

Axial Piston Variable Pump A10VSNO Electric Drives and Controls Hydraulics inear Motion and Assembly Technologies Pneumatics ervice Axial Piston Variable Pump A10VNO RE 92740/07.10 1/16 Data sheet eries 32 ize 63 Nominal pressure 210 bar

More information

Catalog Little Champ Hydraulic Power Unit Kits

Catalog Little Champ Hydraulic Power Unit Kits Catalog Little Champ Hydraulic Power Unit Kits Table of Contents Continental Hydraulics Little Champ Power Unit Kits can be assembled at your facility, and at your convenience. You save time and money.

More information

Refinery Supply Company, Inc.

Refinery Supply Company, Inc. Refinery Supply Company, Inc. OPERATING INSTRUCTIONS Super Pressure Dead Weight Tester Catalog No. 35260 Serving the Oil & Gas Industry since 1923 9133-A East 46th Street Tulsa, Oklahoma 74145-4823 Voice

More information

EAGLE TUGS. Transit Pro Option. Vehicle Types: TT-4, TT-5, TT-6, & TT-8 Engine Type: Yanmar Diesel 4TNV98 Tier II & Tier III Engine Models

EAGLE TUGS. Transit Pro Option. Vehicle Types: TT-4, TT-5, TT-6, & TT-8 Engine Type: Yanmar Diesel 4TNV98 Tier II & Tier III Engine Models EAGLE TUGS Transit Pro Option Vehicle Types: TT-4, TT-5, TT-6, & TT-8 Engine Type: Yanmar Diesel 4TNV98 Tier II & Tier III Engine Models QA018 REV00 10.20.09 QA018 REV03 02.11.12 A-2 QA018 REV03 02.11.12

More information

- BPV-F1-25 and BPV-F BPV-F1/-T BPV-T BPV-L, line mounted BPV-VP

- BPV-F1-25 and BPV-F BPV-F1/-T BPV-T BPV-L, line mounted BPV-VP Auxiliary Valves Auxiliary s Bypass Valves for F1, F2, 1 and VP1 pumps Contents Page Bypass : - BPV-F1-25 and -81...40 - BPV-F2... 41 - BPV-F1/-1... 42 - BPV-1... 43 - BPV-L, line mounted...44 - BPV-VP1...

More information

Palletized Fixture Accessories

Palletized Fixture Accessories Frequently Asked Questions Some questions about pallet and tombstone clamping systems are common to both novices and experienced users. The answers to the following questions may help you better understand

More information

HYDRAULIC PUMPS. Performance under Pressure

HYDRAULIC PUMPS. Performance under Pressure HYDRAULIC PUMPS LARZEP Pumps are available in a wide range of models: Hand pumps, Air hydraulic pumps, Modular pumps, Manual, Electric, Air and Petrol hydraulic powerpacks, Split-Flow powerpacks, Hydrotest

More information

AMETEK Model PPC Series Electronic Pressure Calibrator

AMETEK Model PPC Series Electronic Pressure Calibrator Specification Sheet CP-2176-0399 March 1999 Issue 1 AMETEK Model PPC Series Electronic Pressure Calibrator Two Models, Two Accuracies - PPC Accuracy +0.05% of Full Scale +1 LSD - PPCE Accuracy +0.04% of

More information

3-Way heavy duty flow control, with pressure compensated, solenoid and load sensing controlled priority flow

3-Way heavy duty flow control, with pressure compensated, solenoid and load sensing controlled priority flow 3-Way heavy duty flow control, with pressure compensated, solenoid and load sensing controlled priority flow A-VRFC3C-VEI-VS-LS 0M.43.21.80 - Y - Z RE 18309-63 Edition: 03.2018 Replaces: 03.2016 Technical

More information

Radial piston pump, fixed displacement

Radial piston pump, fixed displacement Radial piston pump, fixed displacement RE 11260/08.05 Replaces: 07.02 1/8 Type R4 izes 0.40 to 2.00 cm 3 Component series 1X Maximum operating pressure 700 bar R4_d R4-1X/1,00-450WA01M01 Table of contents

More information

Inline Flow meter for compressed air and gases DN15 (1/2 ) - DN80 (3 )

Inline Flow meter for compressed air and gases DN15 (1/2 ) - DN80 (3 ) EE771/EE772 Inline Flow meter for compressed air and gases DN15 (1/2 ) - DN80 (3 ) The inline flow meter EE771/EE772, based on the measurement principle of thermal mass flow, is ideally suited for the

More information

15 Flow Meter SCQ. Measurement principle: spring/piston system

15 Flow Meter SCQ. Measurement principle: spring/piston system 15 Flow Meter SCQ Measurement principle: spring/piston system Flow measurement with direction indication Response time < 2 ms Compact design Withstands pressures up to 420 bar Wide range of viscosity p/t/q

More information

Axial Piston Fixed Pump A17FNO Series 10

Axial Piston Fixed Pump A17FNO Series 10 Axial Piston Fixed Pump A17FNO Series 10 RE 91510 Issue: 06.2012 Replaces: 03.2010 Size 125 Nominal pressure 250 bar Maximum pressure 300 bar For commercial vehicles Open circuit Features Fixed pump with

More information

Displacement. (cc/rev) Tap Water Sea Water PC PV

Displacement. (cc/rev) Tap Water Sea Water PC PV J anus Pumps - Axial Piston Totally oil free, clean and completely safe for people, processes and products. As a result of employing advanced materials, high velocity and loaded sliding surfaces can operate

More information

HIGH CAPACITY CENTRIFUGAL & SPRINKLER PUMPS

HIGH CAPACITY CENTRIFUGAL & SPRINKLER PUMPS HIGH CAPACITY CENTRIFUGAL & SPRINKLER PUMPS FW0724 0707 Supersedes 1005 Straight Centrifugal Pumps Electric Motors Heavy Duty Straight Centrifugal Pumps High Head Straight Centrifugal Pumps Stainless Steel

More information

Full Range Pressure Compensating Variable Flow Control

Full Range Pressure Compensating Variable Flow Control Engineering & Manufacturing Solutions Specifications: See flow chart for capacity. Rated for 3000 psi (207 bar). Weighs 7- ¾ lbs. (3.52 kg). 30-Micron Filtration Recommended. Torque to turn side lever

More information

HYDRAULICS VINCKE HYDRAULIC PUMPS

HYDRAULICS VINCKE HYDRAULIC PUMPS VINCKE HYDRAULIC PUMPS TECH-VHP200.1 index 3 link to your page / link a su página Gear pumps Introduction 3 Group 0 3 Group 1 3 Group 2 3 Group 3 4 6 7 12 18 Variable displacement pumps 21 Hand pumps 3

More information

VINCKE HYDRAULIC PUMPS

VINCKE HYDRAULIC PUMPS : VNK BA10VS 21 Variable displacement axial piston pump of swashplate design for hydraulic open circuit systems. Flow is proportional to drive speed and displacement. It can be infinitely varied by adjustment

More information

HBT SERIES HYDROSTATIC BURST TESTER FEATURES: PUMP TYPE PRESSURE RANGES HYDROSTATIC PRESSURE GAUGE

HBT SERIES HYDROSTATIC BURST TESTER FEATURES: PUMP TYPE PRESSURE RANGES HYDROSTATIC PRESSURE GAUGE HBT SERIES HYDROSTATIC BURST TESTER MODELMODEL HBT ( STANDARD MODEL) SHOWN IN PHOTO FEATURES: BENCH MOUNT: Powder coated cabinet with removable back, base plate for bench mounting. PANEL MOUNTED: Gauges,

More information

External gear motor High Performance AZMB

External gear motor High Performance AZMB External gear motor High Performance AZMB RE 14027 Edition: 0.201 Platform B Fixed displacement Sizes 2.5 to 7.1 Continuous pressure up to 220 bar Intermittent pressure up to 2 bar Features Consistently

More information

INSTRUMENTATION & CONTROL

INSTRUMENTATION & CONTROL Irrigation Controller.................... 172 Window Controller.................... 174 Water Meter Controller.................. 176 Digital Level Switch.................... 177 Filtration Controller Set..................

More information

OFX7 Operating Maintenance and Troubleshooting Manual L-4219

OFX7 Operating Maintenance and Troubleshooting Manual L-4219 OFX7 Operating Maintenance and Troubleshooting Manual L-4219 L-2999 Created 9.2012 User Manual OFX7 L-4219 - Table of Contents - Preface. 4 Customer Service. 4 Modifications to the Product 4 Warranty.

More information

High Capacity Centrifugal & Sprinkler Pumps

High Capacity Centrifugal & Sprinkler Pumps High Capacity Centrifugal & Sprinkler Pumps FW0724 1016 Supersedes 0212 Stainless steel or cast iron construction Stainless steel impellers Discharge rotates in 90 increments on some models Pressures to

More information

Axial Piston Pump Series PV Design 45 Variable Displacement. Catalogue HY /UK February 2007

Axial Piston Pump Series PV Design 45 Variable Displacement. Catalogue HY /UK February 2007 Design 45 Variable Displacement February 2007 Introduction With thru drive for single and multiple pumps Swash plate type for open circuit Technical Features Low noise level Fast response (eg. PV046: upstroke

More information

DODGE COOL LUBE 2 for Sleevoil Pillow Blocks Part Numbers , , ,

DODGE COOL LUBE 2 for Sleevoil Pillow Blocks Part Numbers , , , DODGE COOL LUBE for Sleevoil Pillow Blocks Part s 063487, 063488, 07889, 07890 These instructions must be read thoroughly before installing or operating this product. WARNING: To ensure the drive is not

More information

SSI Technologies Application Note PS-AN3 MediaGauge Digital Pressure Gauges Product Overview

SSI Technologies Application Note PS-AN3 MediaGauge Digital Pressure Gauges Product Overview Product Description The MediaGauge digital pressure gauges have better accuracy, longer life and standard multiple functions which make it a better choice than mechanical pressure gauges. The MediaGauge

More information

MP18/SIC & SIO Stacking Valve System Technical Information Manual

MP18/SIC & SIO Stacking Valve System Technical Information Manual Electric Drives and Controls Hydraulics Linear Motion and Assembly Technologies Pneumatics Service MP18/SIC & SIO Stacking Valve System Technical Information Manual The Drive & Control Company Copyright

More information

Axial piston variable pump. A10VNO series 53. RE Edition: Replaces:

Axial piston variable pump. A10VNO series 53. RE Edition: Replaces: Axial piston variable pump A10VNO series 52 and 53 RE 92735 Edition: 04.2015 Replaces: 03.2012 ize 28 to 85 Nominal pressure 210 bar Maximum pressure 250 bar open circuit A10VNO series 52 A10VNO series

More information

XRT PTO Matrix System

XRT PTO Matrix System Installation and Operators Manual XRT PTO Matrix System Ford Super Duty (F-250 / F-450 / F-550) Model Years: 2011 to Present Engine: 6.7 Liter Power Stroke Diesel Transmission: 6R140 Torqshift Automatic

More information

Nominal sizes 08 to 10, special cavities

Nominal sizes 08 to 10, special cavities Nominal sizes 08 to 10, special cavities RE 18301-91 Edition: 05.2016 Replaces: 07.2012 Contents Relief, direct acting guided poppet type Common cavity, Size 10 2 Relief, direct acting guided poppet type

More information

Hydraulic Pump VP1-120

Hydraulic Pump VP1-120 REECHSROY GROUP REECHNOLOGY Bulgaria, Varna 9000 Industrial Zone Str. Studentska 1 U/UK1 odernization, complex repair and maintenance of heavy industrial equipment. Infrastructure construction and management

More information

1S24V 250. Oil Filtration and Coolant Handling Specialists. Removes Contaminants. Extends Oil Life. Reduces Component Wear.

1S24V 250. Oil Filtration and Coolant Handling Specialists. Removes Contaminants. Extends Oil Life. Reduces Component Wear. Oil Filtration and Coolant Handling Specialists 1S24V 250 Removes Contaminants Extends Oil Life Reduces Component Wear Removes all Water Saves Machine Downtime Reduces Disposal Costs Simple to Install

More information

Special Purpose Transmitters

Special Purpose Transmitters Special Purpose Transmitters Type UT-10/UT-11 UNITRANS Universal Pressure Transmitter User Adjustable Turndown of up to 1:20 Large, Easy-to-Read LCD includes Bar Graph and Trend Display The UniTrans pressure

More information

Pressure/temperature/RPM measurement

Pressure/temperature/RPM measurement Pressure/temperature/RPM measurement Pressure/temperature/RPM measurement Various sensors are available depending on the measurement requirements. Pressure sensors, type SCP Robust stainless steel design

More information

Hydraulic comparison test pump Model CPP1200-X

Hydraulic comparison test pump Model CPP1200-X Calibration technology Hydraulic comparison test pump Model CPP1200-X WIKA data sheet CT 91.08 Applications Simple hydraulic test pressure generation on-site, in the laboratory or in the workshop For the

More information

YOUR EFFICIENCY IS OUR CHALLENGE

YOUR EFFICIENCY IS OUR CHALLENGE Parts Manual YOUR EFFICIENCY IS OUR CHALLENGE All rights reserved. No part of this manual may be copied and/or published by means of printing, photocopying, microfilm or by any other means without prior

More information

PRESSURE TRANSMITTER PYRP-28 INDUSTRIAL & INTRINSICALLY SAFE PRESSURE TRANSMITTER PRESSURE TRANSMITTER

PRESSURE TRANSMITTER PYRP-28 INDUSTRIAL & INTRINSICALLY SAFE PRESSURE TRANSMITTER PRESSURE TRANSMITTER PRESSURE PYRP-28 INDUSTRIAL & INTRINSICALLY SAFE PRESSURE The PYRP-28 pressure transmitter is suitable for the measurement of pressure, vacuum and absolute pressure of gases, vapours and liquids for industrial

More information

:1 3:1 5:1 3:1 3:1 5:1 3:1 3:1 5:

:1 3:1 5:1 3:1 3:1 5:1 3:1 3:1 5: trolley for drums 30-60 kg kit for drums 30-60 kg 35260 35250 37500 35249 35259 37499 35264 35254 37504 3:1 3:1 5:1 3:1 3:1 5:1 3:1 3:1 5:1 20 14 18 20 14 18 20 14 18 35076 35173 36073 35076 35173 36073

More information

ATEX instruction APP S 674 pumps APP S , APP S and APP S

ATEX instruction APP S 674 pumps APP S , APP S and APP S MAKING MODERN LIVING POSSIBLE Instruction APP S 674 2.0-3.5, APP S 674 5.1-9.0 and APP S 674 21-38 ro-solutions.com Table of Contents 1. General information....2 2. Common demands for Category 2 and 3

More information

Filter cooler unit with inline filter according to DIN Type ABUKG. Contents. Features. RE Edition: Replaces: 50126

Filter cooler unit with inline filter according to DIN Type ABUKG. Contents. Features. RE Edition: Replaces: 50126 Filter cooler unit with inline filter according to DIN24550 Type ABUKG RE 50125 Edition: 2013-04 Replaces: 50126 Component series 4X With gerotor pump, external gear pump SILENCE PLUS or screw spindle

More information

ZDM Positive Displacement Flow Meter User Instructions

ZDM Positive Displacement Flow Meter User Instructions ZDM Positive Displacement Flow Meter User Instructions USA 1801 Parkway View Drive Pittsburgh, PA 15205 PH 412-788-2830 Canada 9A Aviation Point Claire, QC H9R 4Z2 PH 514-428-8090 www.koboldusa.com ZDM_manual_05/17

More information

Axial Piston Variable Pump A2VK

Axial Piston Variable Pump A2VK Axial Piston Variable Pump A2VK RE 94001/06.10 1/12 Replaces: 07.04 Data sheet Size 12 to 107 Series 1 and 4 Nominal pressure 250 bar Maximum pressure 315 bar Version for pumping plastic components Contents

More information

ARL1 Series Piston Pumps. ARL1 Series Piston Pumps. Geometric Displacement. Maximum cm 3 /rev

ARL1 Series Piston Pumps. ARL1 Series Piston Pumps. Geometric Displacement. Maximum cm 3 /rev ARL1 Series Piston Pumps Geometric Displacement Maximum cm 3 /rev Operating Pump Type Graphic Symbol Pressure Page 1 2 5 10 20 50 100 150 MPa ARL1-6 Piston Pump ARL1-8 ARL1-12 7 8 ARL1-16 5 Hydraulic Fluids

More information

Piston Pumps Series P2 / P3 Variable Displacement

Piston Pumps Series P2 / P3 Variable Displacement Piston Pumps Series P2 / P3 Variable Displacement Catalogue HY11-2600/UK July 2003 Contents Series P2/P3 Description Technical information 3 Ordering code 4 Control options LA and LB 6 Control options

More information

PARTS ORDERING INFORMATION

PARTS ORDERING INFORMATION RP-268 REPAIR PARTS FOR VE268 Roll Grooving Tool PARTS ORDERING INFORMATION When ordering parts the following information is necessary for the Victaulic Tool Company to promptly process the order and send

More information

INLINE 1100 COMPACT, MULTI-PUMP SYSTEM

INLINE 1100 COMPACT, MULTI-PUMP SYSTEM INLINE 00 COMPACT, MULTI-PUMP SYSTEM The Franklin Electric Inline 00 SpecPAK TM Pressure Boosting System connects easily to nearly any commercial, industrial, or multi-residential plumbing configuration

More information

Dynaswivel. Air Line Connectors. Ball-Swivel Plug. Never Fight an Air Tool Again! For Use with Most Air Tools THE PROBLEM THE SOLUTION

Dynaswivel. Air Line Connectors. Ball-Swivel Plug. Never Fight an Air Tool Again! For Use with Most Air Tools THE PROBLEM THE SOLUTION Dynaswivel Air Connectors Never Fight an Air Tool Again! For Use with Most Air Tools THE PROBLEM Aluminum and Stainless Steel Construction Single Pivot Right angle single-pivot swivels 360 at one location.

More information

ENGINEERING DATA. Quick Reference Chart. Variable Volume Vane Pumps Models SV-20 & SV-25 Flange & Subplate Mounted. Industrial Hydraulics

ENGINEERING DATA. Quick Reference Chart. Variable Volume Vane Pumps Models SV-20 & SV-25 Flange & Subplate Mounted. Industrial Hydraulics ENGINEERING DATA Industrial Hydraulics Variable Volume Vane Pumps Models SV-20 & SV-25 Flange & Subplate Mounted SYMBOL Quick Reference Chart GPM @ MAXIMUM PRESSURE THEORETICAL INPUT HP MODEL 100 PSI &

More information

TRAILER MOUNTED PUMP MODEL B50 DRIVE CYLINDER CIRCUIT HYDRAULIC COMPONENTS & SCHEMATIC

TRAILER MOUNTED PUMP MODEL B50 DRIVE CYLINDER CIRCUIT HYDRAULIC COMPONENTS & SCHEMATIC DRIVE CYLINDER CIRCUIT HYDRAULIC COMPONENTS & SCHEMATIC PAGE 01 SINGLE SHIFT SWING TUBE CIRCUIT HYDRAULIC COMPONENTS & SCHEMATIC PAGE 02 DUAL SHIFT SWING TUBE CIRCUIT HYDRAULIC COMPONENTS & SCHEMATIC PAGE

More information

Complete. Pressure Systems

Complete. Pressure Systems Complete Pressure Systems Ready-to Use Calibration Solutions Pump Systems Designed for Your Specific Requirements AMETEK offers a variety of solutions for pressure generation and measurement. Our line

More information

Axial Piston Variable Pump A1VO Series 10

Axial Piston Variable Pump A1VO Series 10 Features Axial Piston Variable Pump A1VO eries 10 Variable pump in axial piston swashplate design for hydrostatic drives in an open circuit The flow is proportional to the drive speed and displacement.

More information

Table of Contents WARRANTY

Table of Contents WARRANTY H.E.R.O. Industries a division of Middlefield Bancorp Limited 2719 Lake City Way, Burnaby, B.C., Canada Phone: ( 604 ) 420-6543 Fax: ( 604 ) 420-8725 Toll Free: 1-800-494-4376 E-mail: sales@hero.ca Website:

More information

Axial piston variable pump A1VO Series 10

Axial piston variable pump A1VO Series 10 Axial piston variable pump A1VO eries 10 RE 92650 Edition: 06.2016 Replaces: 08.2015 For load-sensing-systems in smaller working machines izes 18, 28, 35 Nominal pressure 250 bar Maximum pressure 280 bar

More information

Axial piston variable pump A1VO series 10

Axial piston variable pump A1VO series 10 Axial piston variable pump A1VO series 10 RE 92650 Edition: 09.2013 Replaces: 02.2013 izes 18, 35 Nominal pressure 250 bar Maximum pressure 280 bar Open circuit Features Variable axial piston pump of swashplate

More information

3000 psi (207 bar) Output/ min. 115 VAC 10cc (0.61 cu. in.) 24 VDC 12cc (0.73 cu. in.) Discharge Element Output Port.

3000 psi (207 bar) Output/ min. 115 VAC 10cc (0.61 cu. in.) 24 VDC 12cc (0.73 cu. in.) Discharge Element Output Port. MultiPort Lubricator Grease, Injector General The MultiPort Lubricator is an electrically driven multiple outlet lubrication unit design primarily for use with injector systems. The unit includes two pumping

More information

Series P2/P3 Variable Volume Piston Pumps

Series P2/P3 Variable Volume Piston Pumps Variable Volume Piston Pumps A Bulletin HY13-2656-B1/US A3 Introduction General information The newly developed variable displacement piston pumps from Parker Hannifin, designated P2 and P3, are mainly

More information

PAHT pump PAHT X

PAHT pump PAHT X MAKING MODERN LIVING POSSIBLE Data sheet PAHT pump PAHT X 674 444 danfoss.high-pressurepumps.com Table of Contents 1. Introduction...3 2. Benefits...3 3. Application areas...3 4. Technical data...4 5.

More information

Variable Displacement Piston Pumps Series P2/P3. General Information. P3 Series

Variable Displacement Piston Pumps Series P2/P3. General Information. P3 Series General Information General Information P2 Series The newly developed variable displacement piston pumps from Parker Hannifin, designated P2, are intended for mobile applications, featuring a very compact

More information

Catalog Little Champ Hydraulic Power Units

Catalog Little Champ Hydraulic Power Units Catalog Little Champ Hydraulic Power Units 3 AND 5 Gallon Capacity General Specifications/Table of Contents Little Champ Power Units are designed for use in locations where space is limited and larger,

More information

3-Way heavy duty flow control, with pressure compensated and solenoid controlled priority flow

3-Way heavy duty flow control, with pressure compensated and solenoid controlled priority flow 3-Way heavy duty flow control, with pressure compensated and solenoid controlled priority flow A-VRFC3C-VEI-VS 0M.43.20.80 - Y - Z RE 18309-3 Edition: 03.2018 Replaces: 03.2016 Technical data Description

More information

OEM Pressure Transmitters

OEM Pressure Transmitters OEM Pressure Transmitters Type ECO-1 Applications Hydraulics and pneumatics Mechanical engineering General industrial applications Special Features Pressure ranges from 0-15psi to 0...15,000psi 4-20 ma

More information

Andover Controls Duct and Immersion Temperature Sensors provide accurate measurement of air

Andover Controls Duct and Immersion Temperature Sensors provide accurate measurement of air Infinity Duct & Immersion Temperature Sensors Andover Controls Duct and Immersion Temperature Sensors provide accurate measurement of air temperature and fluid as part of an Andover Controls building automation

More information

Pressure Instrument Testing Equipment

Pressure Instrument Testing Equipment Pressure Instrument Testing Equipment BULLETIN TE-1 A Halliburton Company A Durable, Portable Primary Standard Model 1305D Deadweight Tester The Ashcroft 1305D Deadweight Tester is an affordable, portable

More information

HIGH PRESSURE SPRAYERS

HIGH PRESSURE SPRAYERS S S STRAIGHT THROUGH QDS FITTINGS AND SWIVELS NOZZLES SPRAY GUNS AND WANDS 337 NOZZLES QUICK DISCONNECT NOZZLE 0-degree red tip nozzle, 15-degree yellow tip nozzle, 25-degree green tip nozzle, 40-degree

More information

Axial Piston Variable Pump A15VSO

Axial Piston Variable Pump A15VSO Electric Drives and Controls Hydraulics Linear Motion and Assembly Technologies Pneumatics Service Axial Piston Variable Pump A15VSO RE 92800/03.10 1/32 Datenblatt Data sheet Series 10 Size 280 Nominal

More information

Filtrec elements are tested according to ISO 2941, ISO 2942 and ISO 23181

Filtrec elements are tested according to ISO 2941, ISO 2942 and ISO 23181 Common HYDRAULIC FILTRATION Side wall mounting suction filters Technical Information Connection Ports: 1-1 1/4-1 1/2 BSP (other thread options on request) 1 1/2 SAE J518-3000/M12 Housing Materials: Cover:

More information

4.2 FIXED DISPLACEMENT DOUBLE PUMP

4.2 FIXED DISPLACEMENT DOUBLE PUMP 4.2 FIXED DISPLACEMENT DOUBLE PUMP CONTENTS PVF101 Ordering Code 4.2.1 Fixed Displacement Technical Information 4.2.2 Specifications 4.2.3 Hydraulic fluids 4.2.4 Viscosity range 4.2.5 Temperature range

More information

BOLTING TECHNOLOGY.

BOLTING TECHNOLOGY. BOLTING TECHNOLOGY www.cmco.eu Bolting Technology Yale bolting technology is the general term of reliable and proven equipment renowned world-wide for controlled tightening or loosening of bolted connections.

More information

5.2 MEDIUM HEAVY DUTY SERIES SIZE 3

5.2 MEDIUM HEAVY DUTY SERIES SIZE 3 .2 MEDIUM HEAVY DUTY SERIES SIZE 3 CONTENTS PGI101 Ordering Code.2.1 Medium Heavy Duty Series Technical Information.2.2 Specifications.2.3 Hydraulic fluids.2.4 Viscosity range.2. Temperature range.2.6

More information