SCION tc SWAY BAR SET Preparation
|
|
- Madison McKenzie
- 6 years ago
- Views:
Transcription
1 SCION tc SWAY BAR SET Preparation Part Number: PTR Kit Contents: Item # Quantity Reqd. Description 1 1 Front Stabilizer Bar 2 1 Rear Stabilizer Bar 3 1 Hardware Bag 4 1 Instructions Hardware Bag Contents Item # Quantity Reqd. Description 1 2 Front Bushings 2 2 Rear Bushings 3 4 Rear Cushions 4 4 Rear Cushion Retainers 5 1 Lubricant Additional Items Required For Installation Item # Quantity Reqd. Description 1 Light Oil (WD-40 or air tool oil) 2 3 Conflicts None Recommended Tools Personal & Vehicle Protection Notes Recommended Sequence of Application Item # Accessory 1 Springs 2 Strut Brace 3 Sway Bars 4 Big Brakes Vehicle Service Parts (may be required for reassembly) Item # Part Number Description Link Assy, RR Stab* Lock Nut* *Only if damaged during disassembly Legend STOP: Damage to the vehicle may occur. Do not proceed until process has been complied with. OPERATOR SAFETY: Use caution to avoid risk of injury. CAUTION: A process that must be carefully observed in order to reduce the risk of damage to the accessory/vehicle and to ensure a quality installation. TOOLS & EQUIPMENT: Used in Figures calls out the specific tools and equipment recommended for this process. REVISION MARK: This mark highlights a change in installation with respect to previous issue. SAFETY TORQUE: This mark indicates that torque is related to safety. Special Tools Notes Installation Tools Notes Sockets 12, 14,17, 19, 21, 22 Impact Gun Wrench 10mm Special Chemicals Notes General Applicability All models 2011~ Issue A: 6/16/ of 8 PPO / DIO
2 Care must be taken when installing this accessory to ensure damage does not occur to the vehicle. The installation of this accessory should follow approved guidelines to ensure a quality installation These guidelines can be found in the "Accessory Installation Practices" document. This document covers such items as: Vehicle Protection (use of covers and blankets, cleaning chemicals, etc.). Safety (eye protection, rechecking torque procedure, etc.). Vehicle Disassembly/Reassembly (panel removal, part storage, etc.). Electrical Component Disassembly/Reassembly (battery disconnection, connector removal, etc.). 1. Remove Front OE Sway Bar (a) Remove front wheel Manual Trans - driver side wheel. Automatic Trans - passenger side wheel. (b) Disconnect sway bar from end links. (Fig 1-1) 1-1 (c) Remove no. 2 engine under cover. (1) Remove five clips. (Fig 1-2) 1-2 Issue A: 6/16/ of 8 PPO / DIO
3 (d) Lower sub-frame assembly 30mm on passenger side. (Automatic Trans Only!) (1) Place adjustable tall stand under front subframe assembly (2) Loosen bolts A showing 5mm of threads on both sides of vehicle. (Fig 1-3) (3) Remove four bolts B. (Fig 1-4) 1-3 (4) Loosen driver side bolts C just enough to remove tension from the sub-frame assembly. (5) Remove passenger side bolts D. 1-4 (6) Lower sub-frame 30mm exposing front bolt of lower control arm. (e) Remove lower control arm. Automatic Trans = Passenger Side Manual Trans = Driver Side (1) Remove two nuts and one bolt from outer portion of lower control arm. (Fig 1-5) 1-5 (2) Pull down arm and dislocate lower ball joint assembly from the arm then allow arm to rise up to a neutral position. Issue A: 6/16/ of 8 PPO / DIO
4 (3) Remove two bolts from inner portion of lower control arm. (Fig 1-6) (4) Pull arm from vehicle. 1-6 Passenger Side Driver Side (f) Remove front sway bar straps. (Fig 1-7) HINT: Remove strap opposite of removed suspension arm first. 1-7 (g) Remove front sway bar. (Fig 1-8) Install TRD front sway bar. (a) Install front stabilizer bar bushings. (1) Apply silicon based grease to inner surface of polyurethane bushing before assembly. NOTICE: Install the front stabilizer bar bushing so that the dust lips face the outside of the vehicle. (Fig 2-1) 2-1 Install the front stabilizer bar bushing so that the cutouts face the rear of the vehicle. Issue A: 6/16/ of 8 PPO / DIO
5 (b) Install the front stabilizer bar to the sub-frame assembly in the same position as the OE bar. (c) Install sway bar straps. (Fig 2-2) 2-2 Torque: 87 N m (887 kgf cm, 64ft lbf) HINT: Install strap on removed control arm side of vehicle first. (d) Install lower control arm back into position on the sub-frame assembly. (1) Loosely fasten the two inner bolts. (e) Raise sub-frame back into position. (Automatic Trans Only) (1) Using the adjustable stand raise the subframe to the body of the vehicle. (2) Tighten bolts. (Fig 2-3) Bolt A - Torque: 145 N m (1479 kgf cm, 107ft lbf) 2-3 Bolt B - Torque: 96 N m (979 kgf cm, 71ft lbf) Bolt C - Torque: 93 N m (948 kgf cm, 69ft lbf) (Fig 2-4) 2-4 (f) Tighten inner bolts of lower control arm. (Fig 2-5) (1) Position end of control arm above lower ball joint assembly. The control arm should be horizontal. 2-5 Torque: 233 N m (2376 kgf cm, 172ft lbf) Issue A: 6/16/ of 8 PPO / DIO
6 (g) Assemble outer portion of lower control arm to the lower ball joint assembly. (Fig 2-6) Torque: 89 N m (908 kgf cm, 66ft lbf) 2-6 (h) Attach the front stabilizer link assemblies. Torque: 74 N m (755 kgf cm, 55ft lbf) (i) Install no. 2 engine under cover. (1) Attach five clips. (j) Install front wheel assembly. Torque: 103 N m (1050 kgf cm, 76ft lbf) 3. Remove Rear Sway Bar. (a) Remove the 3 bolts and LH member brace from the suspension member. Remove RH member brace as well. (Fig 3-1) 3-1 (b) Remove the rear sway bar link assemblies. (Fig 3-2) (1) Apply light weight oil to threads on lower end of the sway bar link before removing lock nut. 3-2 (c) Remove rear sway bar. (Fig 3-3) (1) Remove the 4 bolts and 2 stabilizer brackets from the suspension member. (2) Momentarily pulling down on exhaust pipe will allow removal of sway bar. 3-3 Issue A: 6/16/ of 8 PPO / DIO
7 4. Install TRD Rear Sway Bar. (a) Install rear sway bar bushings. (1) Apply silicon based grease to inside of rear polyurethane bushings. 4-1 (2) Install the 2 rear stabilizer bushings to the rear stabilizer bar on the outside of the bushing stoppers as shown in the illustration. (Fig 4-1) (b) Install rear sway bar. (1) Install the rear stabilizer bar and rear sway bar brackets to the rear suspension member with the 4 bolts. Torque: 78 N m (795 kgf cm, 58ft lbf) (c) Install rear sway bar link assemblies. (1) Install supplied upper polyurethane cushion and cushion retainer to the link assemblies. (Fig 4-2) (2) Temporarily install rear sway bar link to the rear No. 2 suspension arm. (3) Tighten upper nuts. 4-2 Torque: 95 N m (969 kgf cm, 70ft lbf) (4) Tighten lower lock nuts Torque: 30 N m (306 kgf cm, 22ft lbf) (5) Rotate link assembly so that it is parallel to the sway bar end. (Fig 4-3) (6) Install the rear suspension member brace to the rear suspension member with the 3 bolts. 4-3 Torque: 32 N m (326 kgf cm, 24ft lbf) (7) Automatic transmission vehicles will require an alignment. Issue A: 6/16/ of 8 PPO / DIO
8 Checklist. These points MUST be checked to ensure a quality installation. CHECK FOR: LOOK FOR: Accessory Function Checks There should be no noise from the polyurethane bushings. If there is a squeak, the bushing is not properly lubricated. Vehicle Function Checks Issue A: 6/16/ of 8 PPO / DIO
SCION xb LOWERING SPRINGS Preparation
Preparation Part Number: PTR07-52080 Kit Contents Item # Quantity Reqd. Description 1 2 Front Springs 2 2 Rear Springs 3 1 Instruction Form Hardware Bag Contents Item # Quantity Reqd. Description 1 2 3
More informationSCION tc LOWERING SPRINGS Preparation
Preparation Part Number: PTR11-21100 PTR11-21100-50 Kit Contents Item # Quantity Reqd. Description 1 2 Front Spring 2 2 Rear Spring 3 2 Locking Nut 4 2 Spring Bumper, Front 5 1 Instruction Form Hardware
More informationToyota PRIUS Sway Bar, Rear Preparation
Toyota PRIUS 010- Sway Bar, Rear Preparation Part Number: PTR11-47010 Kit Contents: 1 1 PLUS Rear Sway Bar 1 Hardware Kit 3 Hardware Box Contents 1 1 Left - Sway Bar End Link with () M10 nuts 1 Right Sway
More informationTOYOTA COROLLA LOWERING SPRINGS Preparation
Preparation Part Number: PTR07-02140 Kit Contents Item # Quantity Reqd. Description 1 2 Front Spring 2 2 Rear Spring 3 1 Hardware 4 1 Instruction Form Hardware Bag Contents Item # Quantity Reqd. Description
More informationTOYOTA COROLLA/MATRIX LOWERING SPRINGS Preparation
Preparation Part Number: PTR40-02080 Kit Contents: Item # Quantity Reqd. Description 1 2 Front Springs 2 2 Rear Springs 3 1 Instruction Form Vehicle Service Parts (may be required for reassembly) Item
More informationTOYOTA PRIUS PLUS LOWERING SPRINGS Preparation
Preparation Part Number: PTR07-47100 Kit Contents Item # Quantity Reqd. Description 1 2 Front Spring 2 2 Rear Spring 3 2 Nut 4 1 Instructions Hardware Bag Contents Item # Quantity Reqd. Description 1 2
More informationTOYOTA FJ CRUISER OFF-ROAD SHOCKS Installation Preparation
Installation Preparation Part Number: PTR13-35060 - Front PTR13-35061 - Rear Kit Contents Item # Quantity Reqd. Description 1 1 Front or Rear TRD Off-Road Shock Assy (w/ Dust Cover) 2 1 Cotter Pin Front
More informationLEXUS IS 250/350/250 AWD REAR GS SHOCK ABSORBERS Preparation. Part Number: PTR PTR PTR
Preparation Part Number: PTR13-53082 PTR13-53092 PTR13-53095 Kit Contents Item # Quantity Reqd. Description 1 1 Shock Absorber 2 1 Hardware Bag 3 Hardware Bag Contents Item # Quantity Reqd. Description
More informationTOYOTA TACOMA TRD EXHAUST Installation Preparation. Part Number: PTR (XL) PTR (SL)
TOYOTA TACOMA 016 - TRD EXHAUST Installation Preparation Part Number: PTR0-5161 (XL) PTR0-516 (SL) Kit Contents 1 1 Muffler Assembly Hardware Bag Contents 1 1 Installation Instructions Additional Items
More informationTOYOTA FJ CRUISER PERFORMANCE SHOCKS Preparation Adjustable Pole Jack
Preparation Part Number: Adjustable Pole Jack PTR13-35100/Front PTR13-35101/Rear Kit Contents: Item # Quantity Reqd. Description 1 1 Front or Rear TRD Off-Road Shock Assy (w/ Dust Cover) 2 1 Cotter Pin
More informationTOYOTA TUNDRA LOWERING KIT Installation Preparation
Installation Preparation Part Number: PTR11-34070-01 (FRONT) PTR11-34070-02 (REAR) PTR11-34070-03 (SPRING) Kit Contents Part # Quantity Reqd. Description PTR11-34070- 01 1 Tundra Lowering System Front
More informationTOYOTA FJ CRUISER SKID PLATE Preparation
Preparation Part Number: PT1-5071 Kit Contents 1 1 Skid Plate Assembly 1 RH Bracket Assembly 1 LH Bracket Assembly Hardware Bag Contents 1 1 Instruction Sheet 4 M8 Stainless Steel Bolt 4 5 Additional Items
More informationLEXUS RX/RXh CROSS BARS Preparation. Part Number: PT
Preparation Part Number: PT278-48161 Kit Contents 1 2 Roof Rack Crossbar Assembly 2 1 Cover, LH Front 3 1 Cover, LH Rear 4 1 Cover, RH Front 5 1 Cover, RH Rear 6 1 Hardware Bag Hardware Bag Contents 1
More informationTOYOTA TUNDRA BUMPER STEP ASSIST Preparation
Preparation Part Number: PT392-34140 Kit Contents Item # Quantity Reqd. Description 1 1 Linkage Assembly 2 1 Mounting Bracket 3 1 Step Pad 4 1 Hardware Bag 5 1 Bumper Support Bracket 6 1 Bumper Re-enforcement
More informationTOYOTA TUNDRA SKID PLATE Preparation
Preparation Part Number: PT98-4140 Kit Contents Item # Quantity Reqd. Description 1 1 Skid Plate (Pre-Assembled with Hardware) 2 1 Hardware Bag Hardware Bag Contents Item # Quantity Reqd. Description 1
More informationTOYOTA TUNDRA STAINLESS STEEL EXHAUST TIP Preparation
Preparation Part Number: PT9-460 Kit Contents Stainless Steel Exhaust Tip Stainless Steel Clamp Assembly Aluminum Spacers Hardware Bag Contents Additional Items Required For Installation Conflicts Vehicles
More informationTOYOTA 4RUNNER CROSS BARS Preparation
Preparation Part Number: PT78-8970 Kit Contents Front Crossbar Assembly Rear Crossbar Assembly Hardware Bag Hardware Bag Contents Rubber Stopper 4 M6 Wafer Head Screw Load Label, 60kg 4 User Manual Additional
More informationTOYOTA TUNDRA SKID PLATE Preparation
Preparation Part Number: PT98-4140 Kit Contents Item # Quantity Reqd. Description 1 1 Skid Plate (Pre-Assembled with Hardware) 2 1 Hardware Bag Hardware Bag Contents Item # Quantity Reqd. Description 1
More informationTOYOTA TUNDRA LARGE ENGINE UNDER COVER SEQUOIA SKID PLATE (LEUC) Preparation Part Number: PT
SEQUOIA 008 - SKID PLATE (LEUC) Preparation Part Number: PT1-4071 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents 1 1 Skid Plate Assembly 1 RH Bracket Assembly
More informationLEXUS GS 350/GS 450h/GS-F WHEEL LOCKS Preparation
S Preparation Part Number: PT76-0986 (PPO) 0076-00900 (DIO) Kit Contents 4 Wheel Lock Key Tool Stuffing Pack w/id Card Hardware Bag Contents Additional Items Required For Installation Pouch P/N: PT76-06999
More informationTOYOTA TUNDRA BUMPER STEP ASSIST Preparation
Preparation Part Number: PT392-34140 Kit Contents 1 1 Linkage Assembly 2 1 Mounting Bracket 3 1 Step Pad 4 1 Hardware Bag 5 1 Bumper Support Bracket 6 1 Bumper Re-enforcement Bracket Hardware Bag Contents
More informationTOYOTA HIGHLANDER FOG LIGHTS Preparation Part Number: PT , BLACK Part Number: PT , ALUMINIZED
Preparation Part Number: PT413-42191, BLACK Part Number: PT413-42190, ALUMINIZED Kit Contents Item # Quantity Reqd. Description 1 1 RH Fog Light 2 1 LH Fog Light Hardware Bag Contents Item # Quantity Reqd.
More informationLEXUS CT 200h ILLUMINATED DOOR SILLS Preparation
Preparation Part Number: PT922-89100 Kit Contents Item # Quantity Req'd. Description 1 1 Door Sill, Front Right Hand 2 1 Door Sill, Front Left Hand 3 1 Door Sill, Rear Right Hand 4 1 Door Sill, Rear Left
More informationSCION FR-S CENTER ARMREST Preparation
Preparation Part Number: PT478 18130 Kit Contents Item # Quantity Reqd. Description 1 1 LH Bracket 2 1 RH Bracket 3 1 LH Extrusion 4 1 RH Extrusion 5 1 Slide Assembly 6 4 4.0mm PT (Torx) Screws 7 1 Armrest
More informationTOYOTA TUNDRA REAR SWAY BAR Installation Preparation
Installation Preparation Part Number: PTR11-34070 Kit Contents 1 1 Rear Sway Bar 2 2 End Links 3 1 Hardware Bag 4 1 Installation Instructions Hardware Bag Contents 1 2 Upper End Link Bolts M14 x 1.5 x
More informationSCION tc STRUT TIE BAR Preparation
SCION tc 2005 - STRUT TIE BAR Preparation Part Number: 00016-80440 Code: YY1 Kit Contents 1 1 DS Mount Plate 2 1 PS Mount Plate 3 1 Cross Bar 4 1 Hardware Bag Hardware Bag Contents 1 4 8mm Screws 2 4 8mm
More informationSCION iq AUDIO Preparation
Preparation Part Number: PT546-00140 (Base Radio) Kit Contents Item # Quantity Reqd. Description 1 1 Receiver Assembly, Radio Unit 2 1 Hardware Bag Hardware Bag Contents Item # Quantity Reqd. Description
More informationPart Number: Code: YU1 Kit Contents Item # Quantity Reqd. Description 1 1 RH Lamp Assy. 2 1 LH Lamp Assy.
Document # 3263 5/16/05 SCION tc 2005 - TAIL LIGHT ENHANCEMENT Preparation Part Number: 00016-21550 Code: YU1 Kit Contents 1 1 RH Lamp Assy. 2 1 LH Lamp Assy. 3 1 Hardware Bag Hardware Bag Contents 1 1
More informationLEXUS RX350/450h TOWING HITCH Preparation. Part Number: PT General Applicability All Vehicles with tow package
Preparation Part Number: PT228-48210 Kit Contents Item # Quantity Reqd. Description 1 1 Trailer Hitch 2 1 Trailer Hitch Plug 3 1 LH Mounting Bracket 4 1 RH Mounting Bracket General Applicability All Vehicles
More informationLEXUS IS250/350 CONVERTIBLE WIND SCREEN Preparation
Preparation Part Number: PT933-53100 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Reqd. Description 1 1 Wind screen 2 1 Installation Instructions
More informationTOYOTA PRIUS CONSOLE APPLIQUES Preparation
Preparation Part Number: PT948-47160-02 Kit Contents Item # Quantity Reqd. Description 1 1 Console Applique 2 1 Front Face Cover Applique 3 Hardware Bag Contents Item # Quantity Reqd. Description 1 2 3
More informationLEXUS RX/RXh RUNNING BOARDS Preparation
Preparation Part Number: PT938-48171 Kit Contents Item # Quantity Reqd. Description 1 1 Running Board Assembly, LH 2 1 Running Board Assembly, RH 3 1 Hardware Pack Hardware Bag Contents Item # Quantity
More informationSCION tc ILLUMINATED DOOR SILLS Preparation
Preparation Part Number: PTS21-21070 Kit Contents Item # Quantity Reqd. Description 1 2 Hardware Kit w/ power harness 2 1 Front Left Illuminated Door Sill Protector 3 1 Front Right Illuminated Door Sill
More informationLEXUS NX/NXh CROSS BARS Preparation. Part Number: PZ41B-X PZ41B-X PW
Preparation Part Number: PZ41B-X2620-00 PZ41B-X2622-00 PW301-78000 1Kit Contents (see next page for description) Item # Quantity Reqd. Description 1 1 Front cross bar 2 1 Rear cross bar 3 2 Cross bar rubber
More informationTOYOTA COROLLA DOOR SILL ENHANCEMENTS Preparation
Preparation Part Number: PT228-02140 Kit Contents 1 2 Front (w/logo) 2 2 Rear (w/o logo) Hardware Bag Contents 1 2 3 Additional Items Required For Installation 1 2 3 Conflicts Recommended Tools Personal
More informationTOYOTA TUNDRA BIG BRAKE KIT Section I - Installation Preparation
TOYOTA TUNDRA 2007- BIG BRAKE KIT Section I - Installation Preparation Part Number: PTR09-34070 Kit Contents Item # Quantity Reqd. Description 1 1 Brake Rotor, LH Front 2 1 Brake Rotor, RH Front 3 1 Brake
More informationTOYOTA RAV CROSSBAR KIT Preparation. Part Number: PT
Preparation Part Number: PT278-42130 Kit Contents 1 1 Crossbar Assembly Front (long) 2 1 Crossbar Assembly Rear (short) 3 1 Hardware Bag Hardware Bag Contents 1 1 Key 2 2 Forward Limit Label 3 1 Installation
More informationTOYOTA YARIS (HB) CARGO NET Preparation
Preparation Part Number: PT347-52110 Kit Contents 1 1 Convenience Net 2 1 Hardware Bag NOTE: Part number of this accessory may not be the same as the part number shown. Recommended Sequence of Application
More informationTOYOTA TACOMA INTERFACE KIT FOR IPOD Preparation
Preparation Part Number: PT545-00082 Kit Contents Item # Quantity Reqd. Description 1 1 Unit Assembly Kit 2 1 Mounting Kit 3 1 Hardware Bags 4 1 Unit and Fit Kit List 5 1 Owner s Manual Unit Assembly Kit
More informationSCION tc PREMIUM AUDIO Preparation. Part Number: PT (Extension Module w/ AHA)
Preparation Part Number: PT296-12160 Kit Contents Item # Quantity Reqd. Description 1 1 Extension Module 2 1 BT cable 3 1 DA/Ext Harness 4 1 GPS Antenna kit 5 6 Bolt (M5x8) 6 5 Wire tie (10 ) Hardware
More informationTOYOTA TUNDRA BED EXTENDER Preparation. Part Number: PT
Preparation Part Number: PT392-34000 Kit Contents 1 1 Curved Tube Assembly - Right 2 1 Curved Tube Assembly - Left 3 3 Center Tube 4 1 Hardware Bag 5 1 Right Mounting Bracket 6 1 Left Mounting Bracket
More informationSCION tc 2005 LEATHER STEERING WHEEL Preparation. Part Number: (Silver/Dark Gray)
Preparation Part Number: 08460 21810 (Silver/Dark Gray) NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Reqd. Description 1 1 Steering Wheel
More informationLEXUS RC 350/RC-F ILLUMINATED DOOR SILLS Preparation
Preparation Part Number: PT944-24150 Kit Contents Item # Quantity Reqd. Description 1 2 Inner LED Scuff 2 2 Outer Scuff 3 1 Hardware Bag Hardware Bag Contents Item # Quantity Reqd. Description 1 15 20
More informationTOYOTA CAMRY BODY SIDE MOLDING Installation Preparation
Installation Preparation Part Number: PT29A-00140-XX Kit Contents 1 1 Molding, LH Front Door 2 1 Molding, LH Rear Door 3 1 Molding, RH Front Door 4 1 Molding, RH Rear Door Hardware Bag Contents 1 2 Additional
More informationTOYOTA TUNDRA 2007 CARGO NET Part Number: PT NOTE: Kit Contents Vehicle Service Parts Hardware Bag Contents Legend STOP: OPERATOR SAFETY:
Preparation Part Number: PT347-34070 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents 1 1 Convenience Net 2 1 Installation Instructions Hardware Bag Contents
More informationTOYOTA Matrix XM SATELLITE RADIO Preparation
Preparation Part Number: Mounting Kit PT546-12080 Tuner Assembly 86180-0W031 (Music Only) Tuner Assembly PT546-00090 (Music Plus Data) NOTE: Part number of this accessory may not be the same as the part
More informationLEXUS GX TOWING HITCH Preparation
LEXUS GX460 2014 - TOWING HITCH Preparation Part Number: PT228-60140 Kit Contents Item # Quantity Reqd. Description 1 1 Hitch Assembly 2 1 Wiring Harness Bracket 3 1 Hardware Bag 4 1 Hitch Cover 5 2 Center
More informationTOYOTA TUNDRA COLD AIR INTAKE Preparation SEQUOIA
Preparation SEQUOIA 2008 - Part Number: PTR03-34070 (5.7L) PTR03-34072 (4.7L) Kit Contents: 5.7L Item # Quantity Reqd. Description 1 1 Lid: Air Filter 2 1 Inlet Pipe: 5.7L 3 1 Air Filter: TRD Conical 4
More informationTOYOTA RAV DOOR SILL PROTECTORS Preparation
Preparation Part Number: PT747-4230 Kit Contents 2 Front Door Sill Protector 2 2 Rear Door Sill Protector Hardware Bag Contents Additional Items Required For Installation Conflicts Recommended Tools Personal
More informationTOYOTA HIGHLANDER RUNNING BOARD HIGHLANDER HV Preparation
Preparation Part Number: PT738-48080 Kit Contents Item # Quantity Reqd. Description 1 1 Driver Side Running Board 2 1 Passenger Side Running Board 3 4 /Middle Mount Bracket 4 2 Rear Mount Bracket 5 2 Rear
More informationSCION iq ALLOY WHEEL Preparation. Part Number: PT NOTE: Part number of this accessory may not be the same as the part number shown.
Preparation Part Number: PT904-74100 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents 1 1 16" Alloy Wheel 2 1 Center Cap 3 1 Hardware Bag 4 1 Care Card Hardware
More informationSCION tc BIG BRAKE KIT Section I - Installation Preparation
SCION tc 2005- BIG BRAKE KIT Section I - Installation Preparation Part Number: PTR09-21080 Kit Contents Item # Quantity Reqd. Description 1 1 Brake Rotor, LH Front 2 1 Brake Rotor, RH Front 3 1 Brake Caliper
More informationLEXUS IS 250/350 Sedan (RWD Only) IS 250/350Convertible Preparation
Preparation Part Number: 08457-30813(Mesh type Fr) 08457-53811(Mesh type Rr) PT533-53060(Spoke type Fr) PT533-53061(Spoke type Rr) Kit Contents Item # Quantity Reqd. Description 1a 1 Alloy Wheel mesh type
More informationTOYOTA 4RUNNER COLD AIR INTAKE FJ CRUISER Preparation
Preparation Part Number: PTR03-89100 Kit Contents Item # Quantity Reqd. Description 1 1 Air Filter (P/N: PTR43-00083) 2 1 Upper Air Box 3 1 Lower Air Box 4 1 Hump Coupler 5 1 Throttle Body Coupler 6 1
More informationTOYOTA RAV4/HV INTERIOR LIGHT KIT Preparation
Preparation Part Number: PT413-42130 Kit Contents Item # Quantity Reqd. Description 1 1 Wire Harness 2 3 Hardware Bag Contents Item # Quantity Reqd. Description 1 20 Cable Tie 2 2 Scotchlok 3 2 Foam Pad
More informationTOYOTA PRIUS DOOR EDGE GUARD Preparation
Preparation Part Number: PT936-47100 Kit Contents Item # Quantity Reqd. Description 1 1 Front Driver Door Guard 2 1 Front Passenger Door Guard 3 1 Rear Driver Door Guard 4 1 Rear Passenger Door Guard Hardware
More informationTOYOTA TUNDRA BED EXTENDER Preparation. Part Number: PT
Preparation Part Number: PT329-34073 Kit Contents 1 1 Curved Tube Assembly - Right 2 1 Curved Tube Assembly - Left 3 3 Center Tube 4 1 Hardware Bag 5 1 Right Bracket Assembly 6 1 Left Bracket Assembly
More informationLEXUS GS 350/450h ILLUMINATED DOOR SILLS Preparation
Preparation Part Number: PT922-30120 (GS350) PT922-30130 (GS450h) NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Req'd. Description 1 1 Illuminated
More informationTOYOTA COROLLA ILLUMINATED DOOR SILLS Preparation
Preparation Part Number: PT942-02140 Kit Contents Item # Quantity Reqd. Description 1 1 Illuminated Scuff plate, Front Right Hand 2 1 Illuminated Scuff plate, Front Left Hand 3 1 Door Scuff plate, Rear
More informationTOYOTA 4-RUNNER TOWING HITCH Preparation
Preparation Part Number: PT228-89460 Kit Contents 1 1 High Assembly 2 1 Wiring Harness Bracket 3 1 Hardware Bag 4 1 Hitch Cover 5 2 Frame Spacer 6 2 Center Spacer 7 1 Close-out Panel Hardware Bag Contents
More informationTOYOTA PRIUS MID-DECK CARGO TRAY Preparation. Part Number: PT
Preparation Part Number: PT908-476 Kit Contents Cargo Tray Seat Back Cover driver side Seat Back Cover pass. side 4 Hinge Cover driver side 5 Hinge Cover pass. side Hardware Bag Contents Additional Items
More informationSCION xb AUTO-DIMMING MIRROR Preparation
Preparation Part Number: PT374-02090 Kit Contents Item # Quantity Reqd. Description 1 1 AD Mirror Assembly w/ PRNDL 2 1 Hardware bag Hardware Bag Contents Item # Quantity Reqd. Description 1 2 T-tap Connectors,
More informationClick to check the pricing on Amazon. Trust me, you ll be glad you did. And don t be afraid to install them yourself. It s easy.
This download was hosted by LanderFan.com, your source of tips, tricks, hacks, how-to articles, and other newsy tidbits related to the new (2014+) Toyota Highlander. Please note that these instructions
More informationPart Number: PT
Preparation Part Number: PT374-02090 Kit Contents Item # Quantity Reqd. Description 1 1 Auto Dimming Mirror Assembly w/ shift area light 2 1 Hardware bag Hardware Bag Contents Item # Quantity Reqd. Description
More informationTOYOTA Yaris Hatchback EC REARVIEW MIRROR Preparation
Preparation Part Number: PT374-02090 Kit Contents Item # Quantity Reqd. Description 1 1 Auto Dimming Mirror Assembly w/ shift area light 2 1 Hardware bag Hardware Bag Contents Item # Quantity Reqd. Description
More informationTOYOTA RAV FOG LIGHT KIT Preparation
Preparation Part Number: PT413-42163 Kit Contents Item # Quantity Reqd. Description 1 7 7 Wire Tie 2 4 #10-16 Cross Pan-Washer Head Screws 3 1 Switch 4 1 Relay 5 1 LH Fog Light Bezel 6 1 RH Fog Light Bezel
More informationSCION tc EC REARVIEW MIRROR Preparation
Preparation Part Number: 00016-79025 Code: YM3 Kit Contents Item # Quantity Reqd. Description 1 1 AD Mirror Assembly w/ Ambient Lighting 2 1 Hardware bag 3 Hardware Bag Contents Item # Quantity Reqd. Description
More informationTOYOTA SOLARA CONVERTIBLE XM SATELLITE RADIO Preparation. Part Number: Mounting Kit PT
Preparation Part Number: Mounting Kit PT546-06061 Tuner Assy 86180-0W030 Tuner Assy Kit Contents (86180-0W030) 1 1 Tuner Assy, Stereo Component Mounting Kit Contents (PT546-06061) 1 Ground Cable 1 1 Wire,
More informationTOYOTA RAV INTERFACE KIT FOR IPOD Preparation Part Number: PT
Preparation Part Number: PT545-00082 NOTE: Part number of this accessory may not be the same as the part number shown. General Applicability Note: Kit Contents Item # Quantity Reqd. Description 1 1 Unit
More informationTOYOTA TACOMA XM SATELLITE RADIO Preparation
Preparation Part Number: Mounting Kit PT546-35090 Tuner Assembly 8680-0W03 NOTE: Part number of this accessory may not be the same as the part number shown. Tuner Assembly Kit Contents (8680-0W03) Item
More informationScion xb EC Rearview Mirror w/ Shift Light Preparation
2008 - Preparation Part Number: 00016-79800 Accessory Code: YM10 Kit Contents Item # Quantity Reqd. Description 1 1 Mirror Assembly w/ PRNDL 2 1 Hardware bag 3 1 Installation Manual Hardware Bag Contents
More informationTOYOTA SIENNA XM SATELLITE RADIO Preparation
Preparation Part Number: Mounting Kit: PT546-08070 Tuner Assy: 86180-0W031 Tuner Assy Kit Contents (86180-0W031) Item # Quantity Reqd. Description 1 1 Tuner Assy, Stereo Component Mounting Kit Contents
More informationTOYOTA PRIUS LOW-DECK CARGO TRAY Preparation
Preparation Part Number: PT908-476 Kit Contents Cargo Tray Seat Back Cover driver side Seat Back Cover pass. side Hardware Bag Contents Additional Items Required For Installation Conflicts Vehicles with
More informationTOYOTA YARIS QUICK SHIFTER SCION xd Section I Installation Preparation. Part Number: PTR Color Applicability/Trim Level
Section I Installation Preparation Part Number: PTR46-52081 Kit Contents Item # Quantity Reqd. Description 1 1 TRD Shift Reduction Adaptor 2 1 Spring Clip 3 1 TRD Cable Bracket 4 2 10mm Washers 5 1 TRD
More informationSCION xb EC REARVIEW MIRROR Preparation
Preparation Part Number: PT374-02090 Kit Contents Item # Quantity Reqd. Description 1 1 AD Mirror Assembly w/ PRNDL 2 1 Hardware bag Hardware Bag Contents Item # Quantity Reqd. Description 1 2 T-tap Connectors,
More informationTOYOTA TACOMA EC REARVIEW MIRROR Preparation
Preparation Part Number: PT374-35052 Kit Contents Item # Quantity Reqd. Description 1 1 AD Mirror Assembly 2 1 Hardware bag Hardware Bag Contents Item # Quantity Reqd. Description 1 1 T-tap Connectors,
More informationSCION xb OVERHEAD CONSOLE Preparation. Part Number:
SCION xb 2008 - OVERHEAD CONSOLE Preparation Part Number: 08253-12800 Kit Contents Item # Quantity Reqd. Description 1 1 Overhead Console 2 1 Bracket 3 1 Plastic cover 4 1 Photo Mount Sheet 5 1 Installation
More informationSCION XB SUBWOOFER ENCLOSURE Preparation
Preparation Part Number: Kit Contents Item # Quantity Reqd. Description 1 1 Subwoofer enclosure 2 1 Wire Harness 3 1 Paper Template 4 1 Plastic Drill Template 5 1 Hardware Bag Hardware Bag Contents 1 Item
More informationTOYOTA TUNDRA ALLOY WHEEL Preparation. Part Number: PT
Preparation Part Number: PT758-34090 Kit Contents Item # Quantity Reqd. Description 1 1 Alloy Wheel 2 3 4 Hardware Bag Contents Item # Quantity Reqd. Description 1 1 Center Cap (PT385-34090-CC) NOTE: Part
More informationTOYOTA im INTERIOR LIGHT KIT Preparation
Preparation Part Number: PT922-12170 Kit Contents Item # Quantity Reqd. Description 1 1 Main Wire Harness 2 1 Switch 3 1 Switch Header 4 1 ECU 5 1 ECU Bracket 6 1 Hardware Kit 7 1 Instruction Card 8 1
More informationLEXUS RX 350/450h DOOR EDGE GUARD Preparation
Preparation Part Number: PT936-48160-XX Kit Contents Item # Quantity Reqd. Description 1 1 Front Driver Door Guard (Reference Pink Sticker) 2 1 Front Passenger Door Guard (Reference Blue Sticker) 3 Rear
More informationScion xa SATELLITE RADIO TUNER Preparation
Preparation Part Number: PTS31-00051 Kit Contents Item # Quantity Reqd. Description 1 1 Antenna, Interior 2 1 Antenna Tape Pad 3 1 Wire Harness 4 1 Bracket, Floor 5 3 Hardware Bags 6 3 Templates 7 1 SIRIUS
More informationTOYOTA COROLLA ILLUMINATED DOOR SILLS Preparation
Preparation Part Number: PT942-02140 Kit Contents Item # Quantity Reqd. Description 1 1 Illuminated Scuff plate, Front Right Hand 2 1 Illuminated Scuff plate, Front Left Hand 3 1 Door Scuff plate, Rear
More informationSCION tc 2005 FRONT END MASK Preparation. Part Number: PT
Preparation Part Number: PT218 21050 Kit Contents Item # Quantity Reqd. Description 1 1 Hood Piece 2 1 Bumper Piece 3 1 Installation Instructions 4 1 Hardware Bag Hardware Bag Contents Item # Quantity
More informationSCION xb PERFORMANCE AIR INTAKE Section I Installation Preparation 2.4L I-4
Section I Installation Preparation 2.4L I-4 Part Number(s): PTR03-52110 Kit Contents Item # Quantity Description Reqd. 1 1 TRD Inlet Tube 2 1 TRD Upper Air Box with HC Trap 3 1 Hump Hose Coupler 4 1 Hump
More informationSCION FR-S FOG LIGHTS
Part #: PT413-18130 Conflicts: Lowering Springs PTR07-18130-LL (California only) Kit Contents: For Anniversary Edition, Monogram & RS 2.0 vehicles, additional parts need to be ordered (PT413-18130-LL)
More informationTOYOTA COROLLA MUDGUARDS Preparation
Preparation Part Number: PU060 12114 P1 Kit Contents 1 1 Front Passenger Side Splashguard 2 1 Front Driver Side Splashguard 3 1 Rear Passenger Side Splashguard 4 1 Rear Driver Side Splashguard 5 1 Hardware
More informationSCION im PREMIUM AUDIO Preparation
SCION im 2016 - PREMIUM AU Preparation Part Number: PT296-12160 (Extension Module w/ AHA) Kit Contents Item # Quantity Reqd. Description 1 1 Extension Module 2 1 BT cable 3 1 DA/Ext Harness 4 1 GPS Antenna
More informationTOYOTA FJ CRUISER TRD ALLOY WHEEL Preparation
Preparation Part Number: PTR20-35080 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents (5 wheels required per vehicle) 1 1 16 x 7.5 Painted Alloy Wheel 2 1
More informationTOYOTA HIGHLANDER TRAILER WIRE HARNESS Preparation
Preparation Part Number: PT219-48111 Kit Contents Item # Quantity Reqd. Description 1 1 Converter 2 1 Flat 4-pin wire harness 3 5 Plastic tie 4 1 Special plastic tie for stud mount 5 1 Packing 6 2 Bolt
More informationTOYOTA COROLLA EC REARVIEW MIRROR Preparation
Preparation Part Number: PT374-02090 Kit Contents Item # Quantity Reqd. Description 1 1 AD Mirror Assembly w/ PRNDL 2 1 Hardware bag Hardware Bag Contents Item # Quantity Reqd. Description 1 2 T-tap Connectors,
More informationTOYOTA PRIUS XM SATELLITE RADIO Preparation
Preparation Part Number: Mounting Kit PT546-4700 Tuner Assy 8680-0W03 NOTE: Part number of this accessory may not be the same as the part number shown. Tuner Assembly Kit Contents (8680-0W03) Item # Quantity
More informationSCION tc 2014 FOG LIGHT KIT
Part #: PT413-21140 Conflicts: P/N PTR11-21100 Lowering Springs (CA only) Kit Contents: Wire Ties Self-Tapping Screws Switch Relay Fog Light Bezel, Left and Right Side Wire Harness Fog Lamp, Left and Right
More informationSCION xb SIRIUS SATELLITE RADIO TUNER Preparation
Preparation Part Number: PTS3-52050 NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Reqd. Description Antenna, Exterior 2 Wire Harness 3 Bracket,
More informationTOYOTA HIGHLANDER TVIP V2 (GBS ADD ON) Preparation
Preparation Part Number: 08586-48070 Kit Contents Item # Quantity Reqd. Description 1 1 Wire Harness 2 1 GBS ECU 3 1 ECU Mounting Bracket Hardware Bag Contents Item # Quantity Reqd. Description 1 1 Microphone
More informationTOYOTA CAMRY REAR BUMPER APPLIQUE Preparation
Preparation Part Number: PT747-0350 Kit Contents Applique, RR Bumper Hardware Bag Contents Additional Items Required For Installation Conflicts Recommended Tools Personal & Vehicle Protection None Special
More informationLEXUS IS 250/ PERFORMANCE GS BRAKE KIT IS 250/350 Conv (FRONT) IS 250/350 Conv (REAR) Preparation
Preparation Part Number: PTR09-53108: All IS 250 Models - Front PTR09-30102: IS 350 & GS 350 - Front PTR09-53109: IS 250 AWD & RWD - Rear PTR09-53110: All IS 350 Models - Rear PTR09-53103: IS 250 C & GS
More informationLEXUS GS 350/450h REAR BUMPER APPLIQUE GS-F Preparation
Preparation Part Number: PT747-3020 Kit Contents Applique, RR Bumper Hardware Bag Contents Additional Items Required For Installation Conflicts None Recommended Tools Personal & Vehicle Protection None
More informationTOYOTA RAV RUNNING BOARD
TOYOTA RAV4 2013 - RUNNING BOARD Part Number: 00016-42020 Accessory Code:TR1 Conflicts Mudguard Kit Contents Item # Quantity Reqd. Description 1 1 LH Board Assembly 2 1 RH Board Assembly 3 1 LH Rear Mounting
More informationTOYOTA YARIS REAR BUMPER APPLIQUE Preparation
Preparation Part Number: PT747-5250 Kit Contents Applique, RR Bumper Hardware Bag Contents Additional Items Required For Installation Conflicts Recommended Tools Personal & Vehicle Protection None Special
More information