WARNING: OPERATOR MUST READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THIS EQUIPMENT.

Transcription

1 PARTS LIST Automatic Scrubber PAS20BA-BC WARNING: OPERATOR MUST READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THIS EQUIPMENT. Tacony Corporation, All rights reserved Save These 1Instructions PAS20BA-BC PARTMAN 10/2018

2 PAS20BA-BC CHASSIS ASSEMBLY Chassis Wheel Spacer Bearing Wheel Cover Lock Washer M Bolt M8 x Castor Lock Washer M Nut M Screw M8 x Lock Washer M Washer M Screw M8 x 40 2

3 PAS20BA-BC BRUSH MOTOR ASSEMBLY Brush Motor Square Key Bolt M8 x Washer M Brush Cover Brush Skirt Bracket Water Drain Out Driver 10 PAS20PD 1 Pad Driver Bolt M8 x Washer M Screw M5 x Lock Washer M Washer M Bolt M8 x Washer M Spacer Nut M Lock Washer M Washer M Nut M Washer M Washer M Side Pulley Side Pulley Cover Screw M8 x 40

4 PAS20BA-BC VACUUM MOTOR Screw M6 x Motor Bracket Connector Motor Gasket Motor Nut M Hose M39 x Sleeve Muffler Sponge Core Screw M5 x Connector Bolt M5 x12 4

5 PAS20BA-BC SOLUTION TANK Solution Tank Chain Cap Washer M Screw M4.2 x Connector Tube M12 x Hose Hose Clip Washer M Lock Washer M Screw M5 x 10 5

6 PAS20BA-BC RECOVERY TANK Decal Recovery Tank Gasket Connector Washer M Lock Washer M Screw M5 x 12 6

7 PAS20BA-BC VACUUM FLOAT ASSEMBLY Top Lid Seal Fitting Mesh Screw M4.2 x Sponge Plate Float Screw M4.2 x Bucket Connector Hose M39 x Hose Liner Sleeve 7

8 PAS20BA-BC BRUSH LIFT Lift Arm Washer M Cotter Pin Pin Bushing Washer M Lock Washer M Screw M5 x Washer M Bolt M8 x Washer M Pedal Cover Pedal Arm Support Arm Washer M Cotter Pin Pin Lock Washer M Nut M Nut M Pin 8

9 PAS20BA-BC SQUEEGEE LIFT Part Qty Description Bolt M6 x Plate Right Pipe Handle Plate Left Screw M5 x Washer M Screw M4 x Nut M Bushing Steel Wire Clevis Hang Ring Nut M Frame Part Qty Description Pivot Arm Cotter Pin Washer M Pin Nut Supporting Arm Mount Nut M Washer M Washer M Shoulder Bolt Cotter Pin Washer M Pin Adjusting Bolt Knob Pin 9

10 PAS20BA-BC SQUEEGEE ASSEMBLY Squeegee Fame Front Squeegee Blade Front Squeegee Blade Strap Butterfly Nut Nut M Washer M Squeegee Guide Wheel Squeegee Guide Wheel Cover Screw M8 x Knob Knob Rear Squeegee Blade Strap Long Nut M Rear Squeegee Blade Strap Short Bolt M5 x Rear Squeegee Blade Castor 2 10

11 PAS20BA-BC CONTROL PANEL ASSEMBLY Part Qty Description Screw M8 x Control Box Nut M Nut M Lock Washer M Washer M Fuse 40A Fuse 60A Circuit Board Relay Panel Hourmeter Switch Screw M4 x Washer M Keyswitch Assembly Power Indicator Panel Power Indicator Board Washer Screw M3.5 x Part Qty Description Nut M Lock Washer M Washer M Fuse 0.5A Washer M Screw M3.5 x Power Relay Screw M4 x Plate Decal Washer M Lock Washer M Nut M Strain Relief Screw M5 x Cable Tube Sleeve w/clamp

12 PAS20BA-BC BATTERIES Party Qty Description Battery Tray 2 B27TMX 2 Battery Cables w/connector Washer 5 X Nut Jumper Cable 12

13 PAS20BA-BC VALVE and FILTER ASSEMBLY Part Qty Description Gasket Washer Connector Hose Hose Spring Connector Ball Valve Bushing Curved Connector Cover O-Ring Spring Filter Washer M4 13 Part Qty Description Screw M4.2 x Rivet M4 x Filter Support O-Ring Nut M Lock Washer M Washer M Filter Bracket Screw M4.2 x Bracket Hose Bolt M5 x Solenoid Valve Hose Spring

14 PAS20BA-BC VACUUM HOSE Hose Double Hose Clip Gasket 14

15 PAS20BA-BC DRAIN HOSE Drain Hose Assmbly Hose Clamp Screw M4 x Hose Clip Screw M4.2 x

16 Powr-Flite Warranty Statement All Powr-Flite equipment has been tested and inspected at the factory and is guaranteed to be free from defects in material and workmanship for the duration described below. For full details, contact your authorized Powr-Flite Distributor, Service Center, or the Powr-Flite Technical Service Department. 5 Years - Tanks 2 Years - Motors 1 Year - Parts/Labor IMPORTANT WARRANTY CONDITIONS: Warranty starts from the date of sale to the consumer or, at Powr-Flite s discretion, six months after the dealer has purchased the unit from Powr-Flite, whichever comes first. All non-wear parts purchased after machine warranty expiration are warranted for one year. Proof of purchase is required to process all claims. Powr-Flite sales and service representatives are not authorized to waive, alter, or increase the terms of this warranty. Warranty DOES NOT cover the following: Routine wear and tear items such as brushes, filters, points, plugs, bulbs, switches, brooms, wheels/tires, casters, fuses, belts, hoses, and sheer pins/motor couplings. Damage that occurs during shipping. A claim should be filed directly with the carrier to collect damages. Unauthorized machine modifications or parts not purchased directly from Powr-Flite or an authorized reseller. Failure to properly inspect, maintain, operate, and store the machine. Misuse/abuse is determined at Powr-Flite s sole discretion and examples include damage from pressure washing the machine, exposing the machine to rain, cold, or snow, and damage to the vacuum motor caused by failure to use defoamer. Cleaning and refinishing charges or machine downtime. Rentals and other replacement machines are not available from Powr-Flite during the repair period. A Tacony Company 3101 Wichita Court Fort Worth, TX Fax: PAS20BA-BC PARTMAN 10/2018