Automatic Transmission/Transaxle: All Technical Service Bulletins A/T - AOD Diagnostic Information Article No
|
|
- Martina Gray
- 5 years ago
- Views:
Transcription
1 1991 Ford Mustang V L HO Copyright 2004, ALLDATA 8.30 Page 1 Automatic Transmission/Transaxle: All Technical Service Bulletins A/T - AOD Diagnostic Information Article No /10/93 TRANSMISSION - AOD - NO 3-4 UPSHIFT OR SLIPPING 4TH GEAR - DIAGNOSTIC INFORMATION FORD: LTD CROWN VICTORIA MUSTANG, THUNDERBIRD LINCOLN-MERCURY: MARQUIS CONTINENTAL GRAND MARQUIS, TOWN CAR COUGAR MARK VII LIGHT TRUCK: BRONCO, ECONOLINE, F-150 This TSB article is being republished because of the occasional need for the information it contains. Originally published as TSB in June of 1983, this article is not easily locatable in many dealerships today; the model application has been updated. Also, The Service Manual contains this information. ISSUE: A no 3-4 upshift condition or a slipping 4th gear may result from Direct clutch checkball leaking Missing plug in end of output shaft Case bore wear Leakage at O/D band servo piston and/or case bore Seal leakage at 3-4 accumulator piston Blocked hydraulic circuit condition Improper valve body attaching bolt torque Leaking governor circuit Torque converter damper/hub malfunction ACTION: Road test, diagnose and repair the transmission as required. Refer to the following diagnostic and repair procedure for service details. PRELIMINARY CHECKS/INFORMATION 1. Road test the vehicle to verify the customer complaint. A no 3-4 upshift is characterized by staying in 3rd gear. A slipping 4th gear is characterized by engine cut-loose on 3-4 upshifts and limited or no 4th gear drive capability. 2. Check TV rod/cable to see if bent, kinked or sticking. Repair or replace rod/cable as required. 3. Check TV linkage (could be misadjusted long). On older models, bent, sticking or misadjusted TV Linkage will not properly synchronize with the carburetor/throttle body lever at the time a 3-4 upshift should occur.
2 1991 Ford Mustang V L HO Copyright 2004, ALLDATA 8.30 Page 2 4. Check control pressure and throttle pressure to identify that they are within specifications. Use the guide pressure specifications: DIRECT CLUTCH PRESSURE TEST Leakage in the direct clutch circuit is usually caused by a leaking checkball in the direct clutch piston. Replacement of the direct clutch piston will alleviate this condition. However, since other factors can be involved, the following additional checks/verifications will aid in making a comprehensive iagnosis of no 3-4 upshift and/or no 4th gear symptoms. he direct clutch pressure test outlined below will diagnose a low pressure condition or leakage in the direct clutch circuit. A difference of 15 psi or ore between direct clutch pressure and line pressure (read at the forward clutch pressure tap) will prevent a 3-4 upshift. 1. Attach psi ( kpa) pressure gauges to the forward clutch and to the direct clutch pressure tap, Figure 1. a. Gauge accuracy must be capable of distinguishing a 15 psi (110 kpa) difference (if this test is done in conjunction with a control pressure test, pressure gauges will be attached to all pressure taps). b. Connect sufficient flexible hose to be able to read the gauges inside the vehicle. CAUTION: PRESSURE GAUGES AFFECT THE SHIFT QUALITY OF THE TRANSMISSION. DO NOT ACCELERATE OR DECELERATE RAPIDLY WHILE PRESSURE GAUGES ARE ATTACHED. TRANSMISSION FAILURE MAY RESULT. 2. Drive the vehicle. When pressure is applied to the direct clutch, note the difference between line pressure (read at the forward clutch pressure tap) and direct clutch pressure (read at the direct clutch pressure tap). 3. If the difference in pressure is less than 15 psi (110 kpa), the direct clutch circuit is OK. 4. If the difference is greater than 15 psi (110 kpa), there could be a leak in the direct clutch pressure circuit. a. The gauges on the forward and direct clutch pressure taps can be switched to confirm that gauge calibration difference is not the cause. b. If a 15+ psi (110 kpa) pressure differential can be confirmed, proceed to the "DIAGNOSTIC PROCEDURE NO. 1" (leakage indicated), or
3 1991 Ford Mustang V L HO Copyright 2004, ALLDATA 8.30 Page 3 to "DIAGNOSTIC PROCEDURE NO. 2" (slips in 4th), if applicable. c. If a 15+ psi (110 kpa) pressure differential can not be confirmed, proceed to "DIAGNOSTIC PROCEDURE NO. 3" (no leakage indicated). IAGNOSTIC PROCEDURE NO. 1 - NO 3-4 UPSHIFT WITH DIRECT CLUTCH PRESSURE DIFFERENCE GREATER THAN 15 PSI (110 kpa) - indicates leakage In direct clutch circuit) NOTE: BURNT DIRECT CLUTCH PLATES WILL HELP TO CONFIRM LEAKAGE IN THE DIRECT CLUTCH CIRCUIT. REPLACING ONLY THE PLATES AND NOT FINDING THE CAUSE COULD RESULT IN A REPEAT REPAIR. 1. Check valve body bolt torque. Correct torque is 9-11 N-m (80-97 lb.in.). 2. Remove the valve body and check to see if main control gasket is blocking an orifice. 3. Check valve body-to-case mating surfaces for nicks or porosity. 4. Check the direct clutch piston check ball for leakage (inspect check ball for freedom of movement). Improper seating of check ball will cause leakage: a. Turn piston upside down (flat side of piston facing you) allowing the check ball to seat in the piston. b. Pour a small quantity of solvent over the check ball. If solvent drops past the check ball, replace the piston. 5. Inspect the output shaft feed passages and the cup plug for leakage. a. Apply 5-10 psi (34-69 kpa) air to the output shaft feed passages, Figure 2. b. If air comes out of the wrong feed passage, replace the output shaft. 6. Check the direct clutch seal rings (inner and outer) for leakage. 7. Check all direct clutch output shaft seals for freedom of movement and for metal shavings and burrs between the seal and the output shaft, Figure 2
4 1991 Ford Mustang V L HO Copyright 2004, ALLDATA 8.30 Page 4 8. Check the direct clutch cylinder for groove marks on the inner ID of the drum, Figure 3. a. Groove marks indicate that the small cast iron rings are turning with the output shaft and grooving the cylinder. b. Groove marks may also be caused by contamination or burrs in the output shaft seal ring grooves, causing the seal rings to turn with the output shaft. c. Check the seal ring grooves carefully. replace the output shaft, seal rings and/or cylinder as required, and/or replace the case if the output shaft seal bore is grooved. IAGNOSTIC PROCEDURE NO. 2 - SLIPPING IN - 4TH GEAR NOTE: A burnt overdrive band will help to confirm leakage In the overdrive circuit. Replacing only the overdrive band without finding the cause will result in a repeat repair. If the overdrive band is not burnt, the torque converter damper/hub weld may be suspect. 1. Check the overdrive servo cover O-rings and servo piston seal for possible leakage. Replace the O-rings and seal if leakage is evident.. Make sure that the overdrive servo cover is not porous: a. Coat cover with fluid. b. Apply air to overdrive servo apply passage using Servo Piston Remover T80L B or Transmission Test Plate T82L-7006-A. c. Observe to see if air bubbles are present on overdrive servo cover. 3. Check the overdrive servo case apply passage to see if it is blocked (air pressure test). Replace the case if required. 4. Confirm that the overdrive band is seated correctly to the anchor pin. 5. Check the torque converter for damper/hub weld failure by performing the weld check procedure outlined in the Service Manual: a. Use Torque Converter Checking Tool T83L-7902-A. b. Replace the torque converter if shaft turns more than two (2) degrees, or if there is a grinding noise while applying 68 N-m (50 lb.ft.) of torque. 6. Check splines on both ends of the direct drive shaft and in the direct clutch cylinder for damage/wear. DIAGNOSTIC PROCEDURE NO. 3 - NO 3-4 UPSHIFT WITH DIRECT CLUTCH PRESSURE DIFFERENCE LESS THAN 15 PSI (110 kpa) - (indicates no leakage In direct clutch circuit) 1. Clean the valve body:
5 1991 Ford Mustang V L HO Copyright 2004, ALLDATA 8.30 Page 5 a. Check for a "sticking" condition at the following valves: Overdrive servo regulator valve 3-4 shift valve 3-4 TV modulator valve Orifice control valve b. If any valves are sticking and cannot be free, replace the valve body. 2. Reduce the valve body bolt torque to minimum specification, i.e. 9 N-m (80 lb.in.). 3. Check the fit of the governor counterweight on the output shaft. If the fit is sloppy, replace the counterweight. 4. Check the governor-to-output shaft retaining ring to make sure it is properly seated on the output shaft; service as required. 5. Check the last two large seal rings on the output shaft (# 9, # 10), Figure 2. a. The seal rings should move freely on the output shaft. b. Check for metal or other contamination or burrs between the seal and the output shaft; replace the seals and/or output shaft as required. 6. Check the seal ring bore at the rear of the case for scoring. Light scoring is permissable, but deep grooving indicates case wear. Replace the case if deep grooving is found, Figure 4. THER APPLICABLE ARTICLES: NONE UPERSEDES: ARRANTY STATUS: INFORMATION ONLY ASIS CODES: , , ,
DIAGNOSIS AND TESTING
307-01B-1 DIAGNOSIS AND TESTING Special Testing Procedures The special tests are designed to aid the technician in diagnosing the hydraulic and mechanical portion of the transmission. Engine Idle speed
More informationTRANSMISSION - AODE/4R7OW - INTERMITTENT LOSS OF TORQUE DURING OR JUST AFTER 3-4 UPSHIFT - MAY BE INTERMITTENT
Article No. 95-5-15 03/13/95 TRANSMISSION - AODE/4R7OW - INTERMITTENT LOSS OF TORQUE DURING OR JUST AFTER 3-4 UPSHIFT - MAY BE INTERMITTENT FORD: 1992-95 CROWN VICTORIA 1994-95 MUSTANG, THUNDERBIRD LINCOLN-MERCURY:
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Special Testing Procedures Special Tool(s) Air Test Plate, Transmission 307-405 Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A)
More informationDiagnostic Procedures
Section 6 Diagnostic Procedures Learning Objectives: 1. Describe manual transmission, transaxle and transfer case component inspection and diagnostic procedures 2. Identify clutch component inspection
More informationAUTOMATIC TRANSMISSIONS. General Motors Corp. Hydra-Matic 4L60-E Overhaul
1997-98 AUTOMATIC TRANSMISSIONS General Motors Corp. Hydra-Matic 4L60-E Overhaul APPLICATION TRANSMISSION APPLICATIONS Application Corvette Transaxle 4L60-E IDENTIFICATION The 4L60-E transmission can be
More informationA/T - A4LD No 4th Gear TECHNICAL BULLETIN # 127
1992 Ford Truck Explorer 4WD V6-245 4.0L Copyright 2004, ALLDATA 8.30 Page 1 Technical Service Bulletin # ATRATB127 Date: 920801 A/T - A4LD No 4th Gear TECHNICAL BULLETIN # 127 DATE: Aug. 1992 TRANSMISSION:
More informationEngine Controls - MIL ON/Lean DTC Service Tips
Engine Controls - MIL ON/Lean DTC Service Tips TSB 04-17-4 09/06/04 MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS FORD: 2000 Contour 2000-2002
More informationTHROTTLE POSITION SENSOR (TPS) FUNCTION Article No. AND DIAGNOSTIC TIPS RECAP TPS APPLICATION CHART
THROTTLE POSITION SENSOR (TPS) FUNCTION Article No. AND DIAGNOSTIC TIPS RECAP TPS APPLICATION 94-26-4 CHART FORD: LINCOLN: MERCURY: 1993-1994 TEMPO 1993-1995 CROWN VICTORIA, ESCORT, MUSTANG, TAURUS SHO,
More information1 of 25 9/12/2013 9:07 PM
1 of 25 9/12/2013 9:07 PM 46RE Automatic Transmission DISASSEMBLY 1. Clean exterior of transmission with suitable solvent or pressure washer. 2. Place transmission in vertical position. 3. Measure the
More informationASSEMBLY. Transmission Automatic Transmission 5R44E and 5R55E. Special Tool(s)
307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 ASSEMBLY Transmission Special Tool(s) Holding Fixture, Transmission 307-262 (T93T-77002-AH) Special Tool(s) Installer, Transmission Extension Housing
More informationGeo Prizm ( LSi) Toyota Celica 1.8L (1994)
Page 1 of 140 ARTICLE BEGINNING APPLICATION TRANSMISSION APPLICATIONS Application Geo Prizm (1993-94 LSi) Toyota Celica 1.6L (1993) Celica 1.8L (1994) Celica 2.2L (1993) Corolla 1.8L MR2 Paseo Transaxle
More informationAssembly. NOTE: Before beginning assembly, perform/inspect the following:
Page 1 of 31 Home Account Contact ALLDATA Log Out Help DAN GRIMWOOD DAN GRIMWOOD00002 Select Vehicle New TSBs Technician's Reference Component Search: OK 1997 Ford Truck F 150 2WD Pickup V6-4.2L VIN 2
More informationAUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series TRANSMISSION APPLICATION TABLE
Article Text ARTICLE BEGINNING AUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series APPLICATION TRANSMISSION APPLICATION TABLE Vehicle Application Transmission Model Colt 3-Speed (1990-94)... F3A21 Colt Vista
More informationASSEMBLY. Transmission Automatic Transaxle/Transmission. Special Tool(s) Alignment Set, Fluid Pump 307-S039 (T74P X) Special Tool(s)
307-01-1 Automatic Transaxle/Transmission 307-01-1 ASSEMBLY Transmission Special Tool(s) Adjustment Set, Transmission Band 307-S022 (T71P-77370-A) Special Tool(s) Alignment Set, Fluid Pump 307-S039 (T74P-77103-X)
More informationTranspak. Torqueflite Part No (1978½-1996) Part No ( ) 2008, 2002 by B&M Racing and Performance Products
Installation Instructions Transpak for Torqueflite Part No. 10227 (1978½-1996) Part No. 10228 (1962-1978) 2008, 2002 by B&M Racing and Performance Products Congratulations. You have just purchased the
More informationSpecial Testing Procedures
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Special Testing Procedures Special Tool(s) Air Test Plate and
More information2013 NATEF Task Area A-2 Automatic Transmission7-2013
2013 NATEF Task Area A-2 Automatic Transmission7-2013 A. General Transmission & Transaxle Diagnosis B. Transmission & Transaxle Maintenance & Adjustment C. In-Vehicle Transmission & Transaxle Repair D.
More information7/31/2017 TSB : MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP 1999 Ford F-350 MotoLogic
1999 F-350 TSB 98-23-10 MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP Report a problem with this article Publication Date: NOVEMBER 10, 1998 FORD: LINCOLN-MERCURY: LIGHT TRUCK: 1990-1997 THUNDERBIRD
More information6R80 TRANSMISSIONS FLUID LEAK FROM BELL TSB HOUSING BUILT ON OR AFTER 4/15/2011 THROUGH 6/8/2011
6R80 TRANSMISSIONS FLUID LEAK FROM BELL TSB 11-8-4 HOUSING BUILT ON OR AFTER 4/15/2011 THROUGH 6/8/2011 FORD: LINCOLN: 2012 Mustang 2011 Navigator 2011 Expedition, F-150 The article supersedes TSB 11-7-18
More information6R80 TRANSMISSIONS FLUID LEAK FROM BELL TSB HOUSING BUILT ON OR AFTER 4/15/2011 THROUGH 6/8/2011
6R80 TRANSMISSIONS FLUID LEAK FROM BELL TSB 12-11-14 HOUSING BUILT ON OR AFTER 4/15/2011 THROUGH 6/8/2011 FORD: LINCOLN: 2012 Mustang 2011 Navigator 2011 Expedition, F-150 The article supersedes TSB 11-8-4
More informationCONTINENTAL TOWN CAR MARK VIII NAVIGATOR
FUEL SYSTEM FUEL PUMP Article No. WHINING / BUZZING NOISE COMES THROUGH 01-7-3 ENTERTAINMENT OR TWO-WAY RADIO SPEAKER RADIO ENTERTAINMENT OR TWO-WAY COMMUNICATION WHINING / BUZZING NOISE IN SPEAKERS CAUSED
More informationHIGH PERFORMANCE TRANSMISSION PARTS Instructions. Line Pressure Booster Kit. TCC Control Plunger Valve Kit. Line Pressure Modulator Plunger Valve Kit
Performance Pack Ford 4R100 Part No. HP-4R100-01 Line Pressure Booster Kit Line-to-Lube Pressure Regulator Valve Line Pressure Booster Kit Valve Sleeve O-Rings (2) TCC Control Plunger Valve Kit Front Lube/Drainback
More informationTurbo 400 Trans Brake Valve Body Shift Pattern: Park Reverse Neutral 1st 2nd 3rd
TCI 221500 Turbo 400 Trans Brake Valve Body Shift Pattern: Park Reverse Neutral 1st 2nd 3rd This Valve Body will neutralize at shut-down by putting shifter In 2nd gear position This Kit Contains: (1) Turbo
More informationHIGH PERFORMANCE TRANSMISSION PARTS Instructions. Line Pressure Booster Kit. TCC Control Plunger Valve Kit. Line Pressure Modulator Plunger Valve Kit
Performance Pack Ford 4R100 Part No. HP-4R100-01 Line Pressure Booster Kit Line-to-Lube Pressure Regulator Valve Line Pressure Booster Kit Valve Sleeve O-Rings (2) TCC Control Plunger Valve Kit Front Lube/Drainback
More information2011 Dodge or Ram Truck RAM 3500 Truck 4WD L6-6.7L DSL Turbo
1 of 10 10/14/2013 9:23 AM 2011 Dodge or Ram Truck RAM 3500 Truck 4WD L6-6.7L DSL Turbo Vehicle» A L L Diagnostic Trouble Codes ( DTC )» Testing and Inspection» P Code Charts» P0732 P0732-GEAR RATIO ERROR
More informationTorqueflite Trans-Scat Kit
TCI 220000 Torqueflite Trans-Scat Kit This kit can be installed in a few hours by carefully following directions. Read all instructions first to familiarize yourself with the parts and procedures. Work
More informationTorqueflite Manual/Automatic Valve Body
TCI 122400 Torqueflite Manual/Automatic Valve Body This valve body can be installed in a few hours by carefully following directions. Read all instructions first to familiarize yourself with the parts
More information2 of 10. Bronco Parts. Dana 44 Yukon Hardcore Chrome Moly Axle Set $ Dana 44 Chrome Moly 4340 Axle Set With $325.00
1 of 10 Next, remove the long main filter bolts and the 9 shorter VB bolts. Notice the correct location of the ID tag. This picture shows the throttle pressure limit valve and spring have not yet been
More informationInstallation Instructions AOD Transmissions 2014, 1995 B&M Racing & Performance Products
Installation Instructions AOD Transmissions 2014, 1995 B&M Racing & Performance Products Congratulations, you have purchased the best automatic transmission available. We at B&M are proud of our products
More informationCONTINENTAL TOWN CAR NAVIGATOR 2002 BLACKWOOD
FUEL SYSTEM FUEL PUMP Article No. WHINING / BUZZING NOISE COMES THROUGH 02-16-4 ENTERTAINMENT OR TWO-WAY RADIO SPEAKER RADIO ENTERTAINMENT OR TWO-WAY COMMUNICATION WHINING / BUZZING NOISE IN SPEAKERS CAUSED
More informationPage 1 of 5 Printable View (39512 KB) TSB 09-12-12 5R55S/5R55N/5R55W TRANSMISSIONS - SHIFT CONCERNS, LOSS OF 2ND, 3RD AND 5TH GEAR, INCORRECT RATIO DTC'S - PROCEDURE TO INSPECT AND REPAIR SERVO PIN BORE
More informationPage 1 of 6 Printable View (342 KB) TSB 09-8-3 Publication Date: April 13, 2009 FORD: COOLANT LOSS - 6.0L 2003-2005 Excursion 2003-2007 F-Super Duty 2004-2009 E-Series This article supersedes TSB 08-11-3
More information2002 F-Super Duty /Excursion Workshop Manual
Page 1 of 25 SECTION 307-01: Automatic Transaxle/Transmission 2002 F-Super Duty 250-550/Excursion Workshop Manual ASSEMBLY Procedure revision date: 05/23/2001 Transmission Special Tool(s) Remover, O-Ring
More informationPART # 4VB/RPFMTB Reverse Pattern Full Manual Transbrake Valve Body Assembly
PART # 4VB/RPFMTB Reverse Pattern Full Manual Transbrake Valve Body Assembly Extensive research and development was performed during the inception of this product and has continued throughout its production.
More information2002 Ford Crown Victoria LX MIL WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP WITH DTC P0457
MIL WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP WITH DTC P0457 TECHNICAL SERVICE BULLETIN Reference Number(s): 03-20-3, Date of Issue: October 13, 2003 1997-2000 CONTOUR; 1997-2002
More informationEmissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON Article No. 03-20-3 10/13/03 DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL
More informationCOOLANT LOSS 6.0L TSB
COOLANT LOSS 6.0L TSB 09-8-3 FORD: 2003-2005 Excursion 2003-2007 F-Super Duty 2004-2009 E-Series This article supersedes TSB 08-11-3 to update the Service Procedure, which includes the release of a new
More information46RE, 46RH, 47RE, 47RH ZIP KIT
46RE, 46RH, 47RE, 47RH ZIP KIT PART NUMBER 46-47RHE-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram 7 1 Separator
More informationChrysler 46RE, 46RH, 47RE, 47RH SURE CURE KIT
Chrysler 46RE, 46RH, 47RE, 47RH SURE CURE KIT PART NUMBER SC-46-47RHE-OS INSTALLATION GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Sure Cure kit contents.
More informationIf the PCM detects a counter value of two during one trip, then DTC P1811 sets. DTC P1811 is a type C DTC.
Page 1 of 6 2001 Pontiac Montana Montana, Silhoutte, Venture (VIN U) Service Manual Document ID: 654706 DTC P1811 Circuit Description The transmission pressure is modified by an adaptive modifier which
More informationDIAGNOSIS AND TESTING
205-02B-1 DIAGNOSIS AND TESTING Rear Drive Axle and Differential Special Tool(s) Dial Indicator Gauge with Holding Fixture 100-002 (TOOL-4201-C) or equivalent 205-02B-1 4 Has the driveline system been
More informationDISASSEMBLY. Transmission. All vehicles
307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 DISASSEMBLY Transmission Special Tool(s) Holding Fixture, Transmission 307-262 (T93T-77002-AH) Special Tool(s) Remover, Servo 307-347 (T97T-7D021-A)
More informationDISASSEMBLY AND ASSEMBLY
307-01-1 Automatic Transaxle/Transmission 307-01-1 DISASSEMBLY AND ASSEMBLY Transaxle Special Tool(s) Dial Indicator Gauge With Holding Fixture 100-002 (TOOL-4201-C) Special Tool(s) Test Plate Screw Set,
More informationTRANSMISSION PARTS Instructions. Solenoid Regulator Valve Retainer Shim. Main Pressure Regulator Valve
TRANSMISSION PARTS Instructions Sure Cure Kit Part No. SC-AODE NOTE: This kit is fully compatible with '91 '95 only. Identified by alignment pins 13mm heads. This kit will not work on '96 Later units.
More information2004R SHIFT RECALIBRATION KIT #24RSRK-A
2004R SHIFT RECALIBRATION KIT #24RSRK-A This easy to install kit includes all the necessary parts to recalibrate the hydraulic circuitry of the GM2004R transmission for high performance street and drag
More information05/01/06 1er mai 2006 Cruise Control - Diagnostic Updates General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional
05/01/06 1er mai 2006 General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional Reference Information SPEED CONTROL DIAGNOSTICS - W/O SCP FORD: 2000-2003 Escort 2000-2004 Crown
More informationDTC P1811 Maximum Adapt and Long Shift
2000 Buick Century DTC P1811 Maximum Adapt and Long Shift Circuit Description The transmission pressure is modified by an adaptive modifier which controls the shift execution time. This test checks the
More information2012 NATEF Task Area A 2 Automatic Transmission
2012 NATEF Task Area A 2 Automatic Transmission A. General Transmission & Transaxle Diagnosis B. Transmission & Transaxle Maintenance & Adjustment C. In Vehicle Transmission & Transaxle Repair D. Off Vehicle
More informationAODE ( 96 & LATER) SC-AODE-1. Transmission Reconditioning Kit FULL COMPATIBILITY IMPORTANT VALVE BODY PARTS REASSEMBLY PARTS
AODE ( 96 & LATER) Transmission Reconditioning Kit FULL COMPATIBILITY SC-AODE-1 Full compatibility with 1996 and later units. Identified by alignment pins with 10mm head and.173" pin diameter. IMPORTANT
More informationItems Vehicles with 4G63 engine Vehicles with 4D56 engine. Type 4-speed full automatic 4-speed full automatic. 2nd rd
23-2 AUTOMATIC TRANSMISSION General Information/ Service Specifications GENERAL INFORMATION 23100010141 Items Vehicles with 4G63 engine Vehicles with 4D56 engine Transmission model R4AW2-6 V4AW2-6 Type
More informationInspect the truck and, if necessary, use the following service procedure to install a reinforcement kit.
1990 Ford Truck F 350 4WD Pickup V8-7.3L DSL Copyright 2007, ALLDATA 9.90 Page 1 Technical Service Bulletin # 90167 Date: 900801 M/T - Clutch Fluid Leaks/Incomplete Release Article No. 90-16-7 ^ CRACKS
More information1999 F-Super Duty Workshop Manual
Page 1 of 5 SECTION 307-01: Automatic Transaxle/Transmission 1999 F-Super Duty 250-550 Workshop Manual DISASSEMBLY AND ASSEMBLY OF SUBASSEMBLIES Procedure revision date: 01/26/2000 Main Control Valve Body
More informationTIME LAG TEST Check the automatic transmission (each clutch, brake and gear) for wear.
AT2 TROUBLESHOOTING 1. GENERAL INFORMATION (a) Troubles occurring with the automatic transmission can be caused by either the engine, electrical control or the transmission itself. These 3 areas should
More informationMedia Number -SENR Publication Date -01/10/1977 Date Updated -12/10/2001
- - 55, 56, 57, 58 & 59 TOWING WINCHES Page 1 of 21 Testing and Adjusting 55, 56, 57, 58 & 59 TOWING WINCHES Media Number -SENR7217-01 Publication Date -01/10/1977 Date Updated -12/10/2001 Testing And
More informationTRANSMISSION AND TRANSFER CASE
WJ TRANSMISSION AND TRANSFER CASE 21-1 TRANSMISSION AND TRANSFER CASE CONTENTS page page 44RE AUTOMATIC TRANSMISSION... 1 NV247 TRANSFER CASE... 129 44RE AUTOMATIC TRANSMISSION INDEX page GENERAL INFORMATION
More informationMercedes
Mercedes 7.3 7.4 3 4 5 6 7 8 - Clutch K - Brake Band B 3 - Disc Brake B 3 4 - Wide Planet Pinion 5 - One-Way Clutch F 6 - Clutch K 7 - Brake Band B 8 - Narrow Planet Pinion Int. Band Fwd. Band Rev. Clutch
More informationChrysler 48RE SURE CURE KIT
Chrysler 48RE SURE CURE KIT PART NUMBER SC-48RE INSTALLATION GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Sure Cure kit contents. See Sure Cure instruction
More informationINTERMITTENT TRANSMISSION CLUTCH SHUDDER TSB DPS6 AUTOMATIC TRANSMISSION AND/OR TRANSMISSION FLUID LEAK
INTERMITTENT TRANSMISSION CLUTCH SHUDDER TSB 13-9-4 DPS6 AUTOMATIC TRANSMISSION AND/OR TRANSMISSION FLUID LEAK FORD: 2011-2014 Fiesta 2012-2014 Focus This article supersedes TSB 13-4-5, 12-4-6 and c. Clutch
More informationTCI TRANS-SCAT
Page 1 of 9 Return to Instruction Sheet index TCI 360000 TRANS-SCAT Installation Instructions for FORD C-6 Transmissions TCI s TRANS-SCAT kit will allow you to calibrate the performance of your transmission.
More informationReturn to Instruction Sheet index TCI Torqueflite Trans-Scat Kit
Page 1 of 11 Return to Instruction Sheet index TCI 220000 Torqueflite Trans-Scat Kit This kit can be installed in a few hours by carefully following directions. Read all instructions first to familiarize
More informationTCI Turbo 400 Full Manual Valve Body. Shift Pattern: Park Reverse Neutral First Second Third. NOTE: You must reuse stock manual control valve.
TCI 221100 Turbo 400 Full Manual Valve Body Shift Pattern: Park Reverse Neutral First Second Third This Kit Contains: (1) Turbo 400 Full Manual Valve Body (1) Separator Plate & Gaskets (1) Pressure Regulator
More informationFluid Pump. Special Tool(s) Alignment Gauge, Transmission Fluid Pump Alignment Gauge, Transmission Fluid Pump
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DISASSEMBLY AND ASSEMBLY OF SUBASSEMBLIES Procedure revision date: 06/30/2009 Fluid Pump Special Tool(s) Alignment Gauge,
More informationTRANS-SCAT Installation Instructions for Ford AOD
TCI 436000 TRANS-SCAT Installation Instructions for Ford AOD 1980-1993 TCI 436000 Kit Contains: Qty. Description Five (5) Gaskets: Three (3) Valve Body One (1) Filter One (1) Duraprene Pan Two (2) Springs:
More informationInstallation Instructions for TCI Turbo 700R TCI Turbo 700R
Installation Instructions for TCI 378805 Turbo 700R4 1982-1984 TCI 378905 Turbo 700R4 1985-1993 KIT INTRODUCTION Read all instructions first to familiarize yourself with the parts and procedures. Work
More information2000 Jeep Truck Cherokee 4WD L6-4.0L VIN S
2000 Jeep Truck Cherokee 4WD L6-4.0L VIN S Vehicle» Transmission and Drivetrain» Automatic Transmission/Transaxle» Service and Repair» 30-40LE (AW4) 4 Speed» Overhaul (Transmission)» Disassembly DISASSEMBLY
More information1989 Ford Truck F 250 4WD Pickup V L DSL
1989 Ford Truck F 250 4WD Pickup V8-445 7.3L DSL - M/T - Clutch Fluid Leaks/Incomplete Release Page 1 1989 Ford Truck F 250 4WD Pickup V8-445 7.3L DSL Top - Vehicle Transmission and Drivetrain. Clutch..
More informationPRE CHECK DI 456. w/ Tachometer. w/o Tachometer. Hand held Tester AUTOMATIC TRANSMISSION (A340E, A340F) 2003 TOYOTA TACOMA (RM1002U) D10837 D00729
DI456 w/ Tachometer w/o Tachometer D10837 PRECHECK DI8Z403 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that
More informationPART # 4VB/FPFMTB Forward Pattern Full Manual Transbrake Valve Body with Engine Braking and Safe Neutral
PART # 4VB/FPFMTB Forward Pattern Full Manual Transbrake Valve Body with Engine Braking and Safe Neutral NOTE: This product should be installed by a professional transmission mechanic who is fluent with
More information2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis
2002 AUTOMATIC TRANSMISSIONS 5R55W/S Diagnosis APPLICATION WARNING: Vehicles are equipped with Supplemental Inflatable Restraint (SIR) system. When servicing vehicle, use care to avoid accidental air bag
More informationAudio System - Whining/Buzzing Noise From Speakers
Audio System - Whining/Buzzing Noise From Speakers Article No. 02-16-4 08/19/02 ^ FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER ^ RADIO - ENTERTAINMENT
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Pinpoint Tests OSC Equipped Vehicle Special Tool(s) Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A) Special Tool(s) MLP-TR
More informationSTEPS Install the (A) input shaft with long spliced end first. Install the (B) aligning pin.
1999 Ford Truck Econoline E450 Super Duty V10-6.8L VIN S Vehicle > Transmission and Drivetrain > Automatic Transmission/Transaxle > Service and Repair > Overhaul > 4R100 > Assembly STEPS 51-94 51. Install
More informationREAR VIEW MIRROR DETACHES FROM WINDSHIELD SERVICE TIP
REAR VIEW MIRROR DETACHES FROM Article No. WINDSHIELD SERVICE TIP 94-17-2 FORD: LINCOLN: MERCURY: 1990-1994 TEMPO 1990-1995 CROWN VICTORIA, ESCORT, MUSTANG, TAURUS, THUNDERBIRD 1992-1995 PROBE 1995 CONTOUR
More informationCLUTCH - HIGH EFFORT - DASH CRACKED IN CLUTCH MASTER CYLINDER AREA-VEHICLES BUILT BEFORE 6/15/90
Page 1 of 17 HIGH CLUTCH EFFORT/CLUTCH FLUID LEAK - CRACKED MOUNT TECHNICAL SERVICE BULLETIN Reference Number(s): 90-16-7, Date of Issue: August 1, 1990 Related Ref Number(s): 90-16-7 ARTICLE BEGINNING
More informationENGINE 4.6L DIFFERENCES BETWEEN ROMEO Article No. AND WINDSOR BUILT ENGINES SERVICE TIP
ENGINE 4.6L DIFFERENCES BETWEEN ROMEO Article No. AND WINDSOR BUILT ENGINES SERVICE TIP 96-8-6 FORD: MERCURY: 1996 CROWN VICTORIA 1997 F-150 1996 GRAND MARQUIS This TSB article is being republished in
More informationPLEASE READ ALL INSTRUCTIONS BEFORE INSTALLATION
1 68 RFE VALVE BODY UPGRADE Part #: 1030360 Part #: 1030361 2007-11 (Early Model) 2010-12 (Late Model) PLEASE READ ALL INSTRUCTIONS BEFORE INSTALLATION AFTERMARKET TUNERS OR TCMS There is a number of aftermarket
More informationBRAKE SYSTEM Return To Main Table of Contents
BRAKE SYSTEM Return To Main Table of Contents GENERAL... 2 BRAKE PEDAL... 10 MASTER CYLINDER... 13 BRAKE BOOSTER... 16 BRAKE LINE... 18 PROPORTIONING VALVE... 19 FRONT DISC BRAKE... 20 REAR DRUM BRAKE...
More informationDIAGNOSIS AND TESTING
303-05-1 Accessory Drive 303-05-1 DIAGNOSIS AND TESTING Accessory Drive Inspection and Verification CAUTION: Under no circumstances should the accessory drive belt, tensioner or pulleys be lubricated as
More information2002 F-Super Duty /Excursion Workshop Manual
Page 1 of 5 SECTION 205-02D: Rear Drive Axle/Differential Ford 10.50-Inch Ring Gear 2002 F-Super Duty 250-550/Excursion Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 02/02/2005 Rear Drive
More informationor from kneel height to trim height takes Dynamics Module (VDM)/4-Wheel Air Suspension approximately 30 to 45 seconds. Module (4WAS).
SUSPENSION AIR SUSPENSION SYSTEM Article No. OVERVIEW DIAGNOSIS/SCAN TOOL 03-13-2 INFORMATION DTC S C1990 AND C1991 COMPRESSOR NOISE ELECTRICAL AIR SUSPENSION SYSTEM OVERVIEW DIAGNOSIS/SCAN TOOL INFORMATION
More informationThrottle Valve Cable/Linkage: Adjustments Throttle Valve (TV) Control Linkage System (FI) ADJUSTMENTS
1989 Mercury Grand Marquis V8-302 5.0L VIN F FI Copyright 2013, ALLDATA 10.52 Page 1 Throttle Valve Cable/Linkage: Adjustments Throttle Valve (TV) Control Linkage System (FI) ADJUSTMENTS Throttle Valve
More informationINTEGRAL POWER STEERING GEAR FORD Applies to F-100 F-350 (4X2), F-150 F-250 (4X4) And Bronco
Rockcrawler Steering Shop Manual page1 The following is from the Ford 1978 Truck Shop Manual, Volume 1 Chassis. It is provided here as a courtesy to classic Ford owners who would like to perform their
More informationP0733 DTC P0733 A/T 3RD GEAR FUNCTION
2003 Nissan-Datsun Altima L4-2.5L (QR25DE) Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts P0733 DTC P0733 A/T 3RD GEAR FUNCTION Description - This is an OBD-II
More informationPLEASE READ ALL INSTRUCTIONS BEFORE INSTALLATION
1 68 RFE VALVE BODY UPGRADE Part #: 1030360 Part #: 1030361 2007-11 (Early Model) 2010-12 (Late Model) PLEASE READ ALL INSTRUCTIONS BEFORE INSTALLATION 2 K I T C O N T E N T S : Please check to make sure
More informationInstallation Manual. Model T675A Engine Brakes. For Mack 6 Cylinder, 2 valve Head ENDT-673, 675, 676 & E6 Series Engines.
Engine Brakes Installation Manual Model T675A Engine Brakes For Mack 6 Cylinder, 2 valve Head ENDT-673, 675, 676 & E6 Series Engines TecBrake P.O. Box 27822 Houston, Texas 77227 INSTALLATION MANUAL TECBRAKE
More informationGM 4L80-E, 4L85-E SURE CURE KIT
GM 4L80-E, 4L85-E SURE CURE KIT PART NUMBER SC-4L80E INSTALLATION GUIDE Parts are labeled here in order of installation. See page 2 for details on Sure Cure kit contents. See Sure Cure instruction booklet
More informationCYLINDER HEAD OVERHAUL
ENGINE OVERHAUL PROCEDURES - GENERAL INFORMATION -2011 Mercedes-... Page 1 of 20 CYLINDER HEAD OVERHAUL * PLEASE READ THIS FIRST * Examples used in this article are general in nature and do not necessarily
More informationGM 4L80-E, 4L85-E SURE CURE KIT
GM 4L80-E, 4L85-E SURE CURE KIT PART NUMBER SC-4L80E INSTRUCTION BOOKLET Parts are labeled here in order of installation. See page 2 for details on Sure Cure kit contents. See Sure Cure instruction booklet
More informationDirect Clutch Drum Assembly
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DISASSEMBLY AND ASSEMBLY OF SUBASSEMBLIES Procedure revision date: 04/02/2009 Direct Clutch Drum Assembly Special Tool(s)
More information1991 TRANSMISSION SERVICING Automatic Transmission. Mitsubishi: Eclipse, Galant, Mirage, Montero, Pickup, Precis, 3000GT
Article Text ARTICLE BEGINNING 1991 TRANSMISSION SERVICING Automatic Transmission Mitsubishi: Eclipse, Galant, Mirage, Montero, Pickup, Precis, 3000GT IDENTIFICATION MITSUBISHI AUTOMATIC TRANSMISSION APPLICATIONS
More informationService Bulletin TECHNICAL
Service Bulletin File in Section: 07 - Transmission/Transaxle Bulletin No.: 09-07-30-004J Date: February, 2014 TECHNICAL Subject: Slips in Reverse or Third, Delayed Reverse or Drive Engagement, DTC P0776,
More informationPower Train. Chapter 5
Chapter Power Train Spefications................................................................. -3 Test Spefications........................................................ -3 Repair Spefications.......................................................
More information2244 West McDowell Road Phoenix, AZ RACE (fax)
2244 West McDowell Road Phoenix, AZ 85009 602-257-9591 1-800-274-RACE 602-340-8429 (fax) www.hughesperformance.com HUGHES PERFORMANCE HP2215 VALVE BODY Installation Instructions 9/24/16 For over 45 years
More informationTroubleshooting, Service Tips, And Major Improvements For Hydrostatic Transmissions (Special Edition){3200}
Page 1 of 75 Troubleshooting, Service Tips, And Major Improvements For Hydrostatic Transmissions (Special Edition){3200} 943, 953, 963, 973 Loaders Introduction The hydrostatic transmissions used in 943,
More information6.0L TURBOCHARGER CARBON DEPOSIT TSB DIAGNOSTICS AND SERVICE TIPS
6.0L TURBOCHARGER CARBON DEPOSIT TSB 08-16-13 DIAGNOSTICS AND SERVICE TIPS FORD: 2003-2005 Excursion 2003-2007 F-Super Duty 2004-2008 E-350, E-450 This article supersedes TSB 08-4-7 to update the This
More informationOregon Fuel Injection
Cummins PT Fuel Pump Diagnostic No Start, with no smoke 1. This could be caused by the fuel pump not turning or a seized gear pump. Remove the fuel supply hose and the fuel inlet fitting from the gear
More informationk. Components not properly adjusted. Refer to machine technical manual for proper adjustment of components.
General Troubleshooting Charts General Troubleshooting Charts Use the charts on the following pages to help in listing all the possible causes of trouble when you begin diagnosing and testing of a machine.
More information2001 Chevrolet Corvette AUTOMATIC TRANSMISSIONS Hydra-Matic 4L60-E - Overhaul
2001-03 AUTOMATIC TRANSMISSIONS Hydra-Matic 4L60-E - Overhaul APPLICATION CAUTION: Flush oil cooler and oil cooler lines prior to transmission installation. Oil cooling system contamination may cause premature
More information1 Green Pressure Regulator Spring Automatic transmissions operate at temperatures between 150ºF and
Installation Instructions for 603107 Valve Body Kit C-4 1970 & Later Tools Required Speed Handle or Ratchet 3/8 Drive 1/2 Socket 3/8 Drive 7/16 Socket 3/8 Drive 5/16 Socket 3/8 Drive Small Screwdriver
More informationSpring Brake Application
Technical Tip Maxibrake I Series Spring Brakes Disassembly, Inspections and Reconditioning Instructions Maxibrake I Series spring brake products are mechanical devices and are subject to wear after extended
More information