Groundsmaster 4000 D Traction Unit

Transcription

1 Form No. Groundsmaster 000 D Traction Unit Model No and Up Parts Catalog Ordering Replacement Parts To order replacement parts, please supply: the part number, the quantity, and the description of each part desired. Understanding Reference Numbers Each identified part in an illustration has a reference number. The reference number for a part also appears in the parts list, along with other information about the part. This catalog uses two special reference number formats, one to indicate parts in a service assembly and another to indicate the quantity of a given part in an illustration. Service Assembly Reference Numbers Parts in service assemblies have reference numbers in the form a:b. The a represents the reference number of the entire service assembly and the b represents a sequential number unique to each part within the service assembly. For example, a wheel assembly might be identified by reference number, the tire by :1, the valve by :2, and the wheel by :. When you order the assembly identified by reference number, you receive all parts identified by reference numbers :1, :2, and :. However, you may also order any part individually. Reference numbers of this type appear in illustrations and in part lists. Reference Numbers Indicating Quantity In an illustration, if a reference number indicates more than one part, the reference number has the form nx y. The n represents the quantity of the part, the X is the multiplication symbol, and the y represents the reference number. For example, in an illustration, the reference number 2X 7 means that two of the parts identified by reference number 7 are indicated. The TORO Company 2001 All Rights Reserved

2 Contents Page Page Frame, Rear Axle Mount and Bumper Assembly Rear Axle Assembly No (Continued) Manifold Assembly No Bevel Gear Shaft Assembly Rear WD Axle and Tire Assembly Rear Axle Assembly No (Continued) Motor Assembly No Axle Case Assembly Planetary, Brake and Tire Assembly Rear Axle Assembly No (Continued) Planetary Assembly No Axle Assembly RH Brake Assembly No Front Deck, Idler and Skid Assembly Motor Assembly No Spindle Assembly No (Front Deck). LH Brake Assembly No Spindle Assembly No (Front Deck). PTO Manifold Assembly No Castor Arm and Tire Assembly (Front Deck).. Steering Tower Assembly Spindle Assembly (Front Deck) Steering Valve Assembly No Rear Discharge Chamber and Traction Pedal and Linkage Assembly Cover Assembly (Front Deck) Brake Pedal and Linkage Assembly RH Deck, Idler and Skid Assembly Control Console and Tool Box Assembly Spindle ASM No (RH and LH Deck) 9 Control Console Assembly Castor Arm and Tire ASM (RH and LH Deck). 70 Control Valve Assembly No Spindle Assembly (RH and LH Deck) Fuel Tank, Battery and Roll Over Protection System Rear Discharge Chamber and (ROPS) Assembly Cover ASM (RH Deck) Front Deck Lift Arm and Cylinder Assembly LH Deck, Idler and Skid Assembly Hydraulic Cylinder Assembly No Rear Discharge Chamber and Motor Assembly No Cover Assembly (LH Deck) Side Deck Lift Arm, Cylinder and Latch ASM.. 2 Electrical Schematic Hydraulic Cylinder Assembly No Hydraulic Schematic Side Deck Lift Arm and Damper Assembly.... Crankcase Assembly Hood and Screen Assembly Oil Pan Assembly Air Cleaner and Muffler Assembly Cylinder Head Assembly Air Cleaner Assembly No Gear Case Assembly Filter Assembly No Head Cover Assembly Radiator, Oil Cooler and Support Assembly... 0 Oil Filter Assembly Engine and Mount Assembly Dipstick and Guide Assembly Fan Drive and Flywheel Assembly Oil Pump Assembly Hydraulic Reservoir and Filter Assembly..... Breather Assembly Filter Manifold Assembly No Main Bearing Case Pump Installation and Filter Assembly Camshaft and Idler Gear Shaft Assembly Gear Pump Assembly No Piston and Crankshaft Assembly Gear Pump Assembly No Flywheel Assembly Piston Pump Assembly No Fuel Camshaft and Governor Shaft Assembly. 90 Piston Pump Assembly No Engine Stop Lever Assembly Manual Servo Control Assembly No Injection Pump Assembly Traction Hydraulic Plumbing Assembly Injection Pump Component Parts Assembly... 9 PTO Hydraulic Plumbing Assembly Governor Assembly Lift Arm Hydraulic Plumbing Assembly Speed Control Plate Assembly Steering Hydraulic Plumbing Assembly Nozzle Holder and Glow Plug Assembly Rear Axle Assembly No Fuel Filter Bevel Pinion Shaft Assembly Alternator and Pulley Assembly Rear Axle Assembly No (Continued) Alternator Component Parts Assembly Differential Assembly Starter Assembly Rear Axle Assembly No (Continued) Starter Component Parts Assembly Axle Support Assembly Oil Switch / Thermometer and Plug Assembly. 102 Rear Axle Assembly No (Continued) Water Flange and Thermostat Assembly Bevel Gear Case Assembly

3 Contents (Continued) Page Page Water Pump Assembly Turbo Charger Assembly Water Pipe Assembly Oil Pipe (Turbo Charger) Assembly Fan Assembly Oil Cooler Assembly Valve and Rocker Arm Assembly Muffler Gasket and Glow Controller Inlet Manifold Assembly Label and Operators Manual Exhaust Manifold Assembly Gasket Kit Accessories Model / Model / Guardian Recycler Conversion Kit Deluxe Grammer Seat Suspension Speed Control Kit Road Light Kit Center Cutting Unit Air Condidtioner Mounting Kit Left Cutting Right Cutting Rotary Broom Debris Blower Seat Kit Armrest Kit Test Box Switch Part Abbreviations Part descriptions in this catalog may include the following abbreviations. Abbreviation Meaning Abbreviation Meaning AR as required HYD hydraulic ASM assembly INC incorporated CARR carriage LH left hand DEG degrees NI nylon insert FH flat head PPH Phillips pan head GA gauge PTH Phillips truss head HF hex flange PTO power take off HH hex head RH right hand HHF hex head flange SFH slotted fillister head HLH hex lag head HJ hex jam HOC height-of-cut SHH slotted hex head SQH square head SHWH slotted hex washer head HS hex socket SPH slotted pan head HSBH hex socket button head SRH slotted round head HSFH hex socket flat head STD standard HSH hex socket head TAP self tapping HWH hex washer head TTH Torx truss head HWHTF hex washer head WH wing head thread forming

4 22:2 22: : :1 2:1 20:1 19: :1 17: : :1 18 2: Frame, Rear Axle Mount and Bumper Assembly Frame ASM Screw HH 2 7 Washer Lock Washer Flat Support Frame ASM Washer Thrust Fitting Grease Drive Axle ASM Washer Thrust Screw HWH Pin Rear Axle Rear Mount ASM Washer Thrust Nut Lock NI Nut HF Bumper ASM Adapter 17: O Ring 17: O Ring Fitting Hyd, Straight 18: O Ring Fitting Straight 19: O Ring 19: O Ring Fitting Quick 20: O Ring Cap Fitting, Yellow Fitting Hyd, 90 22: O Ring 22: O Ring Screw HH Manifold wd Fitting Hyd, 2: O Ring 2: O Ring Adapter 2: O Ring 2: O Ring Nut Flange, NI Grommet Rubber Shield Splash Screw HWH Clamp Hose Washer Locknut Bulkhead Sheet No.:2

5 10:1 10 : :2 :1 8: 8:8: 8: 8 8:2 8: :1 1 1:1 9 9: : 7:2 2:2 7:1 2:1 10:1 1 1:1 1 1:1 1 1:1 9 9:1 10:1 1: :1 9 10: :1 2: 18 :1, :2 19 :1 : 20 7:1 7: 21 8:1 8: :2 : : : Parts not listed in part list are not serviced separately :1 1 Manifold Assembly No Valve Solenoid Valve Check Valve Control Valve Relief Valve Reducing Plug Hex, Hollow 9: O Ring Plug Plug Hex, Hollow 1: O Ring Plug 1: O Ring 1 70 Plug Hex, Hollow 1: O Ring Coil Solenoid Seal Kit Seal Kit Seal Kit Seal Kit Seal Kit T 77 Sheet No.:A1

6 18: 18: 18 18: :1 19:2 18: 18: 18: : :1 2:2 : : :1 20: : Rear WD Axle and Tire Assembly Motor Piston Elbow 90 2: O Ring 2: O Ring Adapter Straight, Hyd : O Ring : O Ring Screw HH Washer Flat O Ring Ring Snap, Ext Pinion Ring Snap, Ext Gear Bearing Needle, Roller Plug Hex, Hollow 12: O Ring Nut Hex Slotted Pin Cotter Spacer Ball Joint Washer Axle Spacer Ball Joint Cylinder ASM Steering 18: Joint Ball Not serviced Sheet No.: 18: Joint Ball 18: Ring Retaining, Ext 18: 02 1 Fitting Grease 18: Fitting Lube 18: 1 Cylinder Steering Elbow 19: O Ring 19: O Ring 20 2 Wheel & Tire ASM 20: Tire Off Road 20: Rim 20: Stem Valve Nut Lug 2 2 Washer Lock Screw HH

7 Motor Assembly No Shaft Drive Backplate ASM Housing ASM Rotating Kit ASM Insert Cam Plate Ring Retaining Capscrew Seal Shaft Ring Retaining Race Thrust O Ring Plate Valve Bearing Thrust Washer T 9 Sheet No.:A2 7

8 Parts not listed in part list are not serviced separately Hydraulic Cylinder Assembly Locknut Kit Packing, wd Sheet No.:A 8

9 9: 0 9 9:1 9: :2 1 1:1 :2 :1 7:2 7 7:1 2: :1 1: :2 1:1 10 1: :2 1:1 10: :1 7:1 7: :1 1:2 1:1 1 :1 : : : : Planetary, Brake and Tire Assembly Planetary ASM Ring Retaining, Int Shaft Splined, Brake RH Brake ASM O Ring Motor Piston Fitting Straight 7: O Ring 7: O Ring Fitting Hyd, 90 8: O Ring 8: O Ring Washer Flat Elbow 90 10: O Ring 10:2 0 1 O Ring Screw HH Cap Fitting, Yellow 1 77 Fitting Quick 1: O Ring Adapter 1: O Ring 1: O Ring Adapter 1: O Ring 1: O Ring Sheet No.: Fitting 17: O Ring 17: O Ring Plug Hex, Hollow 18: O Ring Screw HHF LH Brake ASM Screw HH Nut Jam Bracket Manifold Spring Compression Brake Plate Spring Frame ASM, Bolt In Brake Cable ASM R Clamp Screw TAP Nut Flange, NI Adapter 1: O Ring 1: O Ring Fitting 2: O Ring 2: O Ring Manifold PTO 22 8 Screw HH 9

10 9: 0 9 9:1 9: :2 1 1:1 :2 :1 7:2 7 7:1 2: :1 1: :2 1:1 10 1: :2 1:1 10: :1 7:1 7: :1 1:2 1:1 1 :1 : : : : Planetary, Brake and Tire Assembly (Continued) 0 1 Fitting Hyd : O Ring : O Ring Fitting Hyd :1 0 2 O Ring : O Ring Elbow 90 7: O Ring 7: O Ring Nut HF 9 2 Tire & Wheel ASM 9: Tire 9: Rim 9: Stem Valve Nut Lug Adapter 1: O Ring 1: O Ring Screw HHF Clamp Sheet No.: Not serviced 10

11 Planetary Assembly No Spindle Seal Kit Cone Bearing Cup Bearing Stud Wheel Housing Cup Bearing Cone Bearing Washer Thrust Ring Retaining, Ext Ring Gear Ring Retaining, Int Plug Pipe Plate Cover Spacer Input Washer Thrust Shaft Input Carrier ASM Bolt Hex Hd Pin Dowel T 78 Sheet No.:A 11

12 : RH Brake Assembly No Seal Rod Pull Pin Clevis Link Pin Hitch Disc Stationary Disc Rotating Ring Retaining Gasket Actuator Rotating Spring Extension Ball Plug 1: O Ring T 79 Sheet No.:A 12

13 Motor Assembly No Shaft Drive, Splined Backplate ASM Housing ASM Rotating Kit ASM Insert Cam Plate Ring Capscrew Seal Shaft Ring Retaining Race O Ring Plate Valve Bearing Thrust Washer T 9 Sheet No.:A 1

14 : LH Brake Assembly No Seal Rod Pull Pin Clevis Link Pin Hitch Disc Stationary Disc Rotating Ring Retaining Gasket Actuator Rotating Spring Extension Ball Plug 1: O Ring T 70 Sheet No.:A7 1

15 :1 :2 11 :1 :2 1 8:1 8 : :2 :1 2: 9:1 10:1 8 8:1 :2 9 :1 2:2 2: :1 2: or :1 : :1 :2 or :1 :2 1 :1 :2 Parts not listed in part list are not serviced separately 7 PTO Manifold Assembly No Cartridge Spool Logic Cartridge Spool Logic 9 1 Valve Relief Cartridge Relief, Pilot Valve Solenoid : Seal Kit Coil ASM Plug Hex, Hollow 8: O Ring Plug 9: O Ring Plug Hex, Hollow 10: O Ring Plug Orifice Seal Kit Seal Kit Seal Kit 2 T 78 Sheet No.:A8 1

16 2 :1 :2 :1 : :1 1: : : : Platform and Seat Base Assembly Platform ASM 1: Nut Insert 1: Abrasive Floor 1: Abrasive Platform 1: Decal Traction Pedal 1: Decal wd 1: Decal Operator Instruction, Ce Pin Clevis Pin Hair Seat Plate ASM 20 1 Grommet Pin Cotter Shaft Latch Screw HHF E Latch ASM Spring Torsion Rod Prop Screw HHF Pin Cotter Washer Flat Bracket Bulkhead Screw Nut Flange, NI Grommet Rubber Spacer : 1: Sheet No.: Washer Locknut Bulkhead Nut Flange, NI Support Washer Flat Lanyard Nut Jam Nut Lock, NI Washer Flat Cover Tubes Screw HHF Adapter Straight, Hyd : O Ring : O Ring Valve Control, Flow Elbow Swivel, 90 : O Ring Fitting Tee, Bulkhead : O Ring Locknut Bulkhead Fitting Tee 8: O Ring Belt Seat Screw HH Washer Lock 1

17 2 :1 :2 :1 : :1 1: : : : : 1: Platform and Seat Base Assembly (Continued) R Clamp Tube Manual Sheet No.: 17

18 22 7 :1 8 :2 2 8: :1 : : : :1 2: : Steering Tower Assembly Nut Hex Washer Flat Wheel Steering : Cover Wheel, Steering Collar Foam Seal Steering Ring Snap, External Knob Tower Cover ASM 8: Decal Tower 8:2 218 Nut Insert Steering Shaft ASM Spring Compression Cap Vinyl Rod ASM Spring Extension Rod Tilt Nut Lock NI Switch Pin Cotter Brake Pawl ASM Pin Cotter Nut Lock, NI Fitting Hyd, 90 21: O Ring Sheet No.: 21: O Ring Screw HHF Adapter Straight, Hyd 2: O Ring 2: O Ring Washer Thrust Gauge Temperature Lamp Warning Lamp Warning Steering Column ASM 28: Bushing Flange Screw HH Hub Pivot Screw HHF Bracket Switch Nut Flange, NI 21 2 Screw HH Steering Tower ASM : Decal Toro :2 218 Nut Insert 20 2 Screw PPH Pin Clevis Valve Steering Decal Toro Harness Wire, Front 0: Diode 18

19 Steering Valve Assembly No Kit Seal Kit Spring, Centering Ring Retaining Pin Kit Bearing Screw Cap Cap End Gerotor Spacer Drive Plate Wear Plug ASM Valve Relief Parts not listed in part list are not serviced separately T 79 Sheet No.:A9 19

20 : : : Traction Pedal and Linkage Assembly Traction Pedal ASM 2 21 Screw HH Nut Hex Screw Adjust, Level Screw HWH 10 1 Pedal Bracket ASM : Bushing Flange : Fitting Grease Nut Lock, NI Rod Traction Pin Spring Nut Lock, NI Washer Flat Spring Retainer Spring Pin Roll Bracket Spring Shaft Spring Nut Jam Screw HH Bearing End, Rod Spacer Lever Traction Nut Lock, NI Spacer Screw HH Abrasive Pedal Abrasive Pedal Sheet No.:7 20

21 :1 Sheet No.: Brake Pedal and Linkage Assembly Brake Lever ASM Screw CARR Washer Flat Nut Lock Brake Arm ASM RH 9 89 Bearing Pillow Block : Fitting Grease Ring Snap Brake Latch ASM LH Brake Arm ASM Pin Roll Strap Brake Pin Yoke Spring Extension Pin Cotter Screw HH Arm Lock Screw HH Screw HH LH Pedal ASM Pad Left Turn Nut Jam RH Pedal ASM Pad Right Turn 1 21

22 : : 9: : : Control Console and Tool Box Assembly Housing Tool Box Catch Magnetic Bracket Latch Rod Hinge 2 19 Screw HHF Screw HWH Tool Box Cover ASM 7: Decal Warning Console Support ASM 8: Nut Insert Screw CARR Washer Flat Decal Fuses Support Control Panel Nut HF Housing Console Knob Knob Nut Lock, NI Nut Lock, NI Washer Flat Spring Compression Bracket Pivot Disc Friction Throttle Lever ASM Pin Clevis Sheet No.: Clevis Adjustable Nut Hex Cable Throttle Pin Cotter Screw CARR Stop Lift Lever Washer Friction Nut Flange, NI Controller Glow Relay Capacitor : Screw : Washer Lock, Internal R Clamp Ring Retaining Nut Lock Harness Wire, Console 9: Fuse Amp 9: Fuse 10 Amp 9: Diode Board, Circuit Decal Warning Screw Shh 2 2 Washer Flat 22

23 2 22 :8 21: :2 8 :7 7:1 2 9 : 7: : :1 2 1: : : : :1 : : :2 1: : : : : :2 Control Console Assembly Gauge Hourmeter 1: Washer Lock 1: Nut Hex Switch Guage Fuel Control Panel ASM : Nut Insert : Decal International : Decal Level, Noise : Decal Control Panel : Decal Lift : Decal Lock R Clamp Screw CARR Bracket Pivot Point Power Cap Adapter Straight, Hyd 10: O Ring 10: O Ring Adapter 11: O Ring 11: O Ring Screw HH 1 2 Washer Flat Control Valve ASM Sheet No.: Bracket Valve Fitting Hyd, 90 1: O Ring 1: O Ring ASM Valve Plate Valve Washer Flat Screw HH Fitting Hyd, 90 21: O Ring 21: O Ring Screw HH Grommet Mount, Tank Nut Lock, NI Nut Lock, NI LH Lever ASM Link Levers, Valve Center Lever ASM Pin Cotter RH Lever ASM, Welded Spacer Knob Screw HH Screw HH 2

24 : :2 :8 8 2 :7 7:1 2 9 : 7: : :1 2 1: : : :2 0:1 : : :2 : 1: : : : : :2 Control Console Assembly (Continued) Switch PTO R Clamp Switch Ignition 7:1 2 1 Washer Lock, Internal 7: Nut HH Washer Flat Key Ignition Alarm Audio 0: Nut Plastic, Knurled Switch Plug Hole Nipple Test 79 1 Cap Fitting, Yellow 2 2 Screw HH Latch Key, Hood Ring Key Sheet No.:10 2

25 :1 17 :2 : : :1 29:1 1 29: Parts not listed in part list are not serviced separately 1,, :1, :1; :2 11, 12, 18, 2:1 29:1, 29:2, 2:2 29 Control Valve Assembly No Poppet Spacer 8 20 Wiper 8 0 Seat : O Ring 8 0 Plug : Ring : Washer Bushing Cap Poppet O Ring Ring Washer Washer Washer Washer Plug O Ring Spring Spring Plunger Plug 2: O Ring Seal Kit Disc Plunger Plug Assembly 29: O Ring 29: Washer Spring Spring Plug ASM 2: O Ring Plunger T 7 Sheet No.:B1 2

26 2 :1 1 :1 :2 : 2: 2: 2:1 2:2 2: 2: 2:2 2:1 2: :1 : Parts not listed in part list are not serviced separately Valve Assembly No Valve Pilot Valve Relief Plug Hex, Hollow : O Ring Seal Kit Seal Kit Sheet No.:B2 2

27 : Fuel Tank, Battery and Roll Over Protection System (ROPS) Assembly Rops ASM 1: Decal Rops Breather Air Tie Cable 9 1 Hose Female, Barb Tank Support ASM Hose Fuel Nut Flange, NI Screw HHF Washer Flat Screw HH Screw CARR Washer Strap Battery Ring Retaining Cover Battery Washer Flat Knob Star Decal Service Cable Negative Cable Positive Tank Fuel Gasket 2 0 Bushing Sheet No.: Pipe Stand Sender Fuel Washer Lock/Sp Screw Pth Hose Fuel Clamp Hose Fitting Hyd, Cap Fuel Nut Flange, NI Plate Battery Cover Tank 20 1 Screw PPH Tube Vent Clip Closed, Insulated Screw HWH Nut Speed Bracket Fuel Tank Screw CARR Clamp Worm 27

28 :1 : :1 :2 :2 2:2 :1 2 2:1 * :2 17 : :2 11: : * = As Required Front Deck Lift Arm and Cylinder Assembly LH Ball Joint 2 19 Screw HH 28 2 Pin Clevis Chain HOC U Bolt Nut HH Washer Flat Nut Lock NI Nut Lock, NI Lift Arm ASM RH Lift Arm ASM LH 11: Bushing Flange 11: Fitting Lube, Fitting Grease Pin Lift Arm Pin Roll, Slotted Pin Cotter Pin Upper Lift Fitting Grease Cylinder Hydraulic Nut Lock NI Pin ASM Screw HH 22 2 Washer Flat Fitting Hyd, 90 2: O Ring Sheet No.:12 2: O Ring Push Arm Jam Nut Pin Hair Mount Ball Joint Pin Cotter Washer Nut Lock NI Spider Hub Spider Shim A Mount Motor Gear Adapter : O Ring : O Ring 2 2 Screw HHF 0 2 Adapter Straight, Hyd : O Ring : O Ring Spacer Switch Sensor Ferrous Plate Sensing, Front Nut Lock, NI Washer Flat Screw CARR Washer Flat Screw CARR 28

29 :1 : :1 :2 :2 2:2 :1 2 2:1 * :2 17 : :2 11: : * = As Required Sheet No.:12 Front Deck Lift Arm and Cylinder Assembly (Continued) 0 2 Adapter Straight, Hyd : O Ring : O Ring Fitting Hyd, 90 : O Ring : O Ring Nut Lock 29

30 Parts not listed in part list are not serviced separately Hydraulic Cylinder Assembly No Locknut Deform, Top Piston Kit Seal Repair,1 1/2 T 72 Sheet No.:B 0

31 1 Parts not listed in part list are not serviced separately 2 :1 Motor Assembly No Key Woodruff Nut Hex Seal Kit : Washer Tab T 79 Sheet No.:B 1

32 : 7: : 2:2 2: :2 7 7: 7: : : Side Deck Lift Arm, Cylinder and Latch Assembly Lift Arm ASM LH Lift Arm ASM RH 1: Bushing 1: 02 2 Fitting Grease 1: Fitting Lube 1: Bushing Straight Screw Shoulder Pin ASM Cylinder Lift 2 0 Washer Thrust Nut Flange, NI Hub ASM Pivot 7: Bushing Flange 7: Bushing Flange 7: Fitting Lube Shaft Pivot, Lift Arm Washer Thrust Screw HH Pin Spring Pin Cylinder Rivet Bumper Rubber Pin Roll, Slotted 1 29 Nut Lock, NI Washer Flat Latch RH 1: Latch LH Washer Delrin Screw HHF Grip Plastic Cam Bracket ASM Washer Lock Spacer Switch Sensor Ferrous Plate Sensing Nut Lock, NI Washer Flat Screw HSBH Washer Flat Screw CARR Fitting Hyd, 90 2: O Ring 2: O Ring Nut Lock Sheet No.:1 2

33 Parts not listed in part list are not serviced separately T 71 Sheet No.:B7 Hydraulic Cylinder Assembly No Nut Bushing Collar Repair Kit

34 :1: : : Side Deck Lift Arm and Damper Assembly LH Mount ASM RH Mount ASM 28 2 Screw HH Nut Lock, NI Mount Base Shim Washer Flat Screw HH Plate Rubber Plate Pin Hair Pin Clevis Yoke Joint 1:1 1 Yoke Joint 1:1: Cross & Bearing Kit Spacer Washer Thrust Washer Hardened Nut Hex, Slot Shaft Pivot Ring Retaining Cotter Pin Washer Thrust Rear Arm ASM RH Rear Arm ASM LH 22: Bushing Flange Not serviced Sheet No.:1 22: Fitting Grease 2 21 Nut Lock Washer Lock/Sp Nut Lock, NI Screw CARR Nut Hex Screw HH RH Bell Crank ASM LH Bell Crank ASM Damper Rod End Spherical Screw HH Tube Link 29 2 Nut Lock, NI Washer Flat Bushing St Spring Damper Nut Lock, NI 9 2 Screw HH Arm Shaft ASM Spring Compression Bearing Plastic 10 8 Washer Flat Plate Coupler Pin Roll

35 :1: : : Sheet No.:1 Side Deck Lift Arm and Damper Assembly (Continued) Nut Jam End Rod Spacer End Rod Nut HJ

36 :2 1 11: : Hood and Screen Assembly Plate Logo, Toro Nut Tinnerman Screen ASM Seal Bulb Seal Bulb Seal Corner, Screen Pin Hair Screw Screen Pivot ASM Pivot Screen Hood ASM 11: Decal 11: Decal Warning Handle Door 1 2 Screw Deflector Oil Filter Nut Lock Latch Plate Latch Bracket Latch, Hood Latch Draw, Flexible 21: Handle Latch 21: Keeper Latch Bracket Latch, RH Bracket Latch, LH Nut HF :1 1 Sheet No.: Washer Flat Screw HH Screw Taptite Screw Plastite Hood Support ASM R Clamp Rod Hood Pin Clevis Pin Hair

37 Air Cleaner and Muffler Assembly Hose Air Cleaner Clamp Hose Cleaner Air 10 1 Indicator *: Indicator Adapter ASM Strap Air Cleaner Nut Lock Clamp Hose Hose Air Cleaner Bracket Mounting Nut HF Muffler Turbo Clamp Column, Steering Pipe Exhaust Screw HHF Screw HHF Screw HH Washer Flat Spacer Hanger Rubber Screw HH Relay Nut Lock, NI Screw HH Pump Fuel * Not illustrated Filter Water/Fuel Fitting Gasket Muffler Clamp Hose Sheet No.:1 7

38 7 1 Air Cleaner Assembly No Valve Vacuator Cover Assembly Element Assembly Element Assembly T 770 Sheet No.:B9 8

39 Filter Assembly No Head Filter Element Spin On O Ring Base, Filter Base Filter Plug Base, Filter O Ring O Ring Plug Filter, Head Drain Valve ASM T 0 Sheet No.:C1 9

40 18 18: : :2 2: : Radiator, Oil Cooler and Support Assembly Cap Radiator Strip Foam Strip Foam Hose Radiator, Lower Hose Radiator, Upper Clamp Shroud Radiator Nut Lock Radiator Clamp Hose Hose Fuel Screw HHF Grommet Rubber Nut HF Ring Retaining Knob Handle Seal Bulb Radiator Support ASM 18: Decal Fluid, Starting 18: Decal Warning Ring Retaining Bracket Oil Cooler Cooler Oil Screw CARR Fitting 90 2: O Ring 29 0 Sheet No.:17 2:2 0 1 O Ring Screw HHF Clamp Nut Flange, NI Bracket Cooler, LH Bracket Cooler, RH Washer Flat Foam Plug Nut Lock, NI Strip Foam Support Lower 2 2 Screw HHF Seal Bulb Grommet Cover Frame 7 2 Screw HHF Plate Washer Flat Knob Bolt Shoulder Tie Cable Reservior Coolant : Cap Reservoir Bracket Tank 2 Washer Flat Decal Radiator 0

41 Engine and Mount Assembly Engine Turbo, Kubota Mount Engine, RH Mount Engine, LH 90 Washer Lock, Spring 210 Screw HH Union Mini Barb Clamp Worm Hose Hose Fuel Line, Filter Fuel Hose Line, Fuel Hose Breather Clamp Hose Screw HH Hose Female, Barb Fitting Drain Cock LH Mount ASM RH Mount ASM Washer Lock Screw HH Washer Lock Bolt Screw HH Mount Engine, Rubber Nut Flange, NI Washer Rebound Clamp Worm Line Fuel Sheet No.:18 1

42 : : Fan Drive and Flywheel Assembly Fan Clutch Fan Screw HH 2 8 Washer Lock Adapter Fan Screw HH Kit Solenoid 7: Screw HH 7: Screw HH 7: Washer Spring 7: Nut Hex 7: Washer Flat 7: Pin Cotter Spacer Coupling Dowel Washer Bolt Shoulder Screw HH Coupling Spring Pin Plate Screw HH Plate Adapter Washer Lock Screw HH Cylinder ASM Screw :1 7:10 7:9 1 7:8 2 7:11 7:9 7:7 Sheet No.: Fitting Hyd, Straight 21: O Ring 21: O Ring O Ring Piston Cylinder Ring Back Up Ring Retaining Seal Grease Support Cable Joint Ball Washer Flat Nut Lock, NI Sender Temperature Cable Ground Bolt Harness Wire, Engine : Diode Harness Wire Harness Wire, Fusible Link Washer Lock/Ext Washer Lock/Ext Plate Shim 2

43 : :1 22: : :2 2: :2 2:1 1: :1 28 2:2 2 2: Hydraulic Reservoir and Filter Assembly Petcock 1: O Ring Reservoir Hydraulic Strap Felt Strap 0 1 Bushing Clamp Hose Bushing Fitting Hyd, Pipe Stand Hose ASM Filter Screen Oil Dipstick ASM O Ring Plug Plastic Hose Suction Strainer Tank 1: O Ring Cap Fitting, Yellow Nipple Test 19 2 Screw HH Elbow 20: O Ring 20: O Ring Washer Flat Fitting Hyd 22: O Ring 22:2 0 1 O Ring Hose ASM Fitting Hyd 2: O Ring 2: O Ring Fitting Hyd 90 2: O Ring Adapter 2: O Ring 2: O Ring Manifold Filter Fitting 90 28: O Ring Hose Filter Screw HSH Nut Lock, NI Screw HH Clamp Hose Clamp Worm Sheet No.:20

44 :1 2 :1 :2 : 2:1 :2 : 2:2 2: :1 7 7:1 :1 : :1 11 2:1 2: or :1 : 8 12 :1 : Parts not listed in part list are not serviced separately Filter Manifold Assembly No Valve Check Valve Check Valve Check 990 Plug : O Ring 989 Plug Hex, Hollow : O Ring Plug Element Filter Plug Hex, Hollow 10: O Ring Seal Kit Seal Kit T 771 Sheet No.:C2

45 22:1 22 1:1 22: : :1 :2 :1 1:2 2 1:1 10 9:1 8:1 9 1: : 7:1 7 7:2 : :7 :2 1 1:2 12: : :1 1 Pump Installation and Filter Assembly Fitting Hyd 1: O Ring 1: O Ring Pin Roll Fitting Hyd, 90 : O Ring : O Ring 1 Pump ASM : Gear Pump ASM : Pump Piston : Coupler : Screw HH : Washer : O Ring : Spacer Washer Flat Screw HH Fitting Hyd 7: O Ring 7:2 0 1 O Ring Fitting 90 8: O Ring Connector Hose 9: O Ring Hose ASM Tee Fitting Not serviced * Not illustrated :1 : : Sheet No.:21 11: O Ring Fitting Adapter 12: O Ring 12: O Ring Oil Filter ASM *1: Element Filter Elbow 90 1: O Ring 1: O Ring Fitting Hyd, 90 1: O Ring 1: O Ring Tee Fitting 1: O Ring Fitting Hyd Washer Flat Screw HH Cap Fitting, Yellow Clamp Fitting Hyd, Straight 22: O Ring 22: O Ring

46 Gear Pump Assembly No T 72 Sheet No.:C

47 Gear Pump Assembly No Seal Shaft Washer Capscrew O Ring Washer Copper Valve Proportional Plug Plug Seal Kit 7

48 8 Piston Pump Assembly No Sheet No.:C T 78

49 Piston Pump Assembly No Nut Ring Retaining Ring Retaining Washer Seal Screw HSH Rotating Kit ASM Servo Piston ASM Follower Piston Plate Cover Plate Cover Camplate ASM Race Thrust Bearing Thrust Valve Bypass 1 2 Screw HH Valve Relief Screw HSH Plate Valve Housing ASM Backplate ASM Shaft Drive Nut Hex Washer Lock Washer Seal Shaft Valve Relief Arm Control 2: Control ASM Washer Orifice Washer Flat Seal Kit 9

50 Parts not listed in part list are not serviced separately Manual Servo Control Assembly No Switch Safety, Neutral Seal Kit Sheet No.:C 0

51 2 2:1 10 2: :1 10:1 2: OPPOSITE SIDE : Traction Hydraulic Plumbing Assembly Tube Hyd, Drain & Motors Tube Hyd, Drain Motor & Filter Tube Hyd, Motor LH Front Tube Hyd, Motor Front Tube Hyd, Motor RH Tube Hyd, Motor LH Tube Hyd, Traction RH Rear Tube Hyd, Charge LH Tube Hyd, Traction LH Rear Hose ASM 10: O Ring Hose ASM Hose ASM Hose ASM Hose ASM 1: O Ring Hose ASM Hose ASM Hose ASM Washer Sheet No.: Spacer Grommet Rubber Nut Bulkhead Valve Check Fitting Quick 2: O Ring Fitting Bulkhead 2: O Ring Cap Fitting, Yellow Tie Cable 1

52 A 11 A B B Sheet No.:2 PTO Hydraulic Plumbing Assembly Tube Hyd, PTO Front Tube Hyd, Cooler RH Tube Hyd, Cooler LH Hose ASM Hose ASM Hose ASM Hose ASM Hose ASM Hose ASM Hose ASM Hose ASM Hose ASM Hose ASM Hose Hose ASM Hose Hose ASM Washer Spacer Grommet Rubber Nut Bulkhead Clamp Worm Fitting Hydraulic, Tee 2

53 Lift Arm Hydraulic Plumbing Assembly Hose ASM Hose ASM Tube Hyd, Left Return Tube Hyd, Lift Tube Hyd, Charge Hose ASM Hose ASM Hose ASM Hose ASM Front Lift Tube ASM Hose ASM Hose ASM Hose ASM Clamp Tube Screw HH Nut Lock Screw Washer Locknut Bulkhead Tie Cable Sheet No.:2

54 :1 Steering Hydraulic Plumbing Assembly Sheet No.: Hose ASM Hose ASM Tube Hyd, Steer RH Rear Tube Hyd, Steer LH Rear Nut Lock 797 Clamp Tube Screw HH Tube Hyd, Steer LH Front Tube Hyd, Steer RH Front Tube Hyd, Steer Power Beyond Tube Hyd, Steer Pressure Hose ASM Grommet Rubber Spacer Washer Flat Screw HH Tube Hyd, Steer & Drain Fitting Quick 18: O Ring Cap Fitting, Yellow

55 Rear Axle Assembly No Bevel Pinion Shaft Assembly Ring And Pinion Matched Set Bearing Taper Roller Case Bearing O Ring Collar Oil Seal O Ring Seal Oil Washer Lock Nut Lock Shim Shim Case Gear Bolt Stud Washer Spring Nut Plate Cover Gasket Pin Dowel Sheet No.:8

56 Rear Axle Assembly No (Continued) Differential Assembly Sheet No.: Differential ASM Ring And Pinion Matched Set Case Differential Bolt Washer Spring Shaft Differential Pinion Differential Washer Differential Gear Differential Washer Differential Washer Differential Washer Differential Pin Spring Bearing Ball Shim Shim Shim 0.

57 Rear Axle Assembly No (Continued) Axle Support Assembly Support Axle Support Axle O Ring Bushing Flanged Washer Seal Plug Oil Plug ASM Bolt O Ring Extension, Vent Plug O Ring Sheet No.:8 7

58 Rear Axle Assembly No (Continued) Bevel Gear Case Assembly Case Bevel Gear Seal Oil Bushing Knuckle ASM : Knuckle : O Ring Bolt LH Steering Arm ASM RH Steering Arm ASM Shim Shim Shim Pin Dowel Bolt Bolt Stud Nut Washer Spring Tie Rod ASM *18: LH Tie Rod End ASM *18:1: Cover Dust *18:1: Nut Castle 18: RH Tie Rod End ASM 18:2: Cover Dust * Not illustrated 18:2: Nut Castle 18: Bolt 18: Washer Spring 18: Nut Sheet No.:8 T 0 8

59 Rear Axle Assembly No (Continued) Bevel Gear Shaft Assembly Shaft Gear, Differential Shaft Gear, Differential Gear 1 Tooth Bevel Bearing Ball Shim Shim Shim Clip Shaft Bevel Gear Gear 17 Tooth Bevel Bearing Taper Roller Collar Sheet No.:87 9

60 Rear Axle Assembly No (Continued) Axle Case Assembly Case Axle Plug Washer Seal Gear 17 Tooth Bevel Bearing Taper Roller Cover O Ring Plug Washer Seal Bolt Sheet No.:88 0

61 Rear Axle Assembly No (Continued) Axle Assembly Axle Seal Oil 9 7 Clip Spacer Shim Shim Shim Gear 29 Tooth Bevel Bearing Ball Cover Axle O Ring Bearing Ball Clip Bolt Stud Sheet No.:89 1

62 1: 1: : 1: 1:9 1:8 1 1:7 1:1 2 1: Front Deck, Idler and Skid Assembly Front Deck ASM 1: Decal Danger 1: Decal Danger 1: Decal HOC, RH 1: Nut Insert 1: Decal Danger 1: Decal Torque, Blade Bolt 1: Decal HOC 1: Decal HOC, LH 1: Pad Plastic 1: Rivet Screw CARR Spacer Idler Pulley Idler Washer Flat Nut Lock NI Double Driven Spindle ASM V Belt High Driven Spindle ASM Screw CARR Screw HHF LH Skid ASM RH Skid ASM LH 1 RH Nut Flange, NI Screw HHF Screw HH Spacer Roller Deck Nut Flange, NI Pin Hair Sheet No.:2 2

63 1 7 2 : : : :2 Sheet No.:A1 Spindle Assembly No (Front Deck) Nut Lock, NI Pulley Driven, Double 10 1 Seal V Ring Spindle Housing ASM : Spacer Set Bearing : Bearing ASM : Seal Oil : Fitting Lube Spacer Shaft, Spindle 10 1 Shaft ASM Spindle Washer Hardened

64 1 7 2 : : : :2 Sheet No.:A2 Spindle Assembly No (Front Deck) Nut Lock, NI Pulley Driven, High 10 1 Seal V Ring Spindle Housing ASM : Spacer Set Bearing : Bearing ASM : Seal Oil : Fitting Lube Spacer Shaft, Spindle 10 1 Shaft ASM Spindle Washer Hardened

65 2 2: 2: 2:2 2:1 1:2 1: : 10: 10:9 10:10 10:1 10: :8 10:7 10:10: Castor Arm and Tire Assembly (Front Deck) Front LH Castor Arm ASM Front RH Castor Arm ASM 1: Bushing 1: 02 2 Fitting Grease HOC Cap ASM 2: Ring Retaining 2: Washer Cap 2: Spring Compression 2: Cap HOC Spacer Castor 9 80 Washer Thrust Nut Flange, NI Screw HHF Castor Fork ASM Screw HH Nut Lock, NI Wheel ASM Wheel 8 Castor, Foam Filled 10: Tire 10: Tube W/Valve 10: Spacer Bearing, Inner 10: 9 27 Bearing 10: Nut HHF 8 10: Plate 10: Rim Wheel, Half 10: Hub 10: Rim Wheel, Half Sheet No.:

66 1:1 1:8 1:7 1:: 1:2 1: 1:: 1:: 1::2 1::1 1:: 2 1: 1: 1 1:1 1:8 1: 1::2 1:: Spindle Assembly (Front Deck) Driving Spindle ASM 1: Nut Lock, NI 1: Pulley Driving 1: 10 1 Seal V Ring 1: Spindle Housing ASM 1:: Spacer Set Bearing 1:: Bearing ASM 1:: Seal Oil 1:: Fitting Lube 1: Spacer Shaft, Spindle 1: 10 1 Shaft ASM Spindle 1: Mount Drive Motor 1: Washer Hardened Screw HHF Blade Cup Scalp, Anti Bolt Blade Sheet No.:

67 Rear Discharge Chamber and Cover Assembly (Front Deck) Center Chamber ASM RH Chamber ASM LH Chamber ASM Screw CARR Nut Flange, NI Nut Lock NI Roller Screw HH Cover Front, LH Latch Swell Screw HHF Cover Front, Center Cover Front, RH Screw HH Cover Front, RH Sheet No.: 7

68 : 1: 1: : 1: A/R : RH Deck, Idler and Skid Assembly Side Deck ASM RH 1: Decal Danger 1: Decal Danger 1: Decal Rear HOC, RH 1: Nut Insert 1: Decal HOC 1: Decal Danger 1: Decal Torque, Blade Bolt Skid ASM RH Nut Lock NI Washer Flat Spacer Idler Pulley Idler Washer Flat V Belt Screw HHF Spindle ASM Driven, Low Screw FH Pad Bumper Nut Flange, NI Skid ASM Side Nut Flange, NI Screw HHF Screw CARR Sheet No.: Pin Hair Castor Bracket ASM Decal HOC, RH Pin Clevis Shim Bracket Fork Screw HHF 8