Collector Drive for 44 Mower
|
|
- Timothy Daniel
- 5 years ago
- Views:
Transcription
1 FORM NO. -80 Collector Drive for Mower Model No & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the safety of others. Also become familiar with the controls and their proper use before you operate the product. Ce INTERNATIONAL ENGLISH (GB)
2 Introduction We want you to be completely satisfied with your new product, so feel free to contact your local Authorized Service Dealer for help with service, genuine replacement parts, or other information you may require. Whenever you contact your Authorized Service Dealer or the factory, always know the model of your product. This number will help the Service Dealer or Service Representative provide exact information about your specific product. The warning system in this manual identifies potential hazards and has special safety messages that help you and others avoid personal injury, even death. DANGER, WARNING and CAUTION are signal words used to identify the level of hazard. However, regardless of the hazard, be extremely careful. DANGER signals an extreme hazard that will cause serious injury or death if the recommended precautions are not followed. WARNING signals a hazard that may cause serious injury or death if the recommended precautions are not followed. CAUTION signals a hazard that may cause minor or moderate injury if the recommended precautions are not followed.. Model and Serial Number Plate For your convenience, write the product model and serial numbers in the space below. Two other words are also used to highlight information. Important calls attention to special mechanical information and Note emphasizes general information worthy of special attention. The left and right side of the machine is determined by sitting on the seat in the normal operator s position. Model No: Serial No.:
3 Contents Page Safety and Instruction Decals... Installation... Loose Parts... Mower Preparation... Leveller Stopper & Idler Mounting Bracket Installation... 5 Idler & Drive Belt Installation... 6 Baffle Installation... 6 Mower Installation... 7 Boot Installation... 7 Operation... 8 Maintenance... 8 Troubleshooting... 8
4 Safety Safety Decals and Safety Instructions Safety decals and instructions are easily visible to the operator and are located near any area of potential danger. Replace any decal that is damaged or lost. () ON BOOT BRACKET (Part No ) DANGER POTENTIAL HAZARD Without the discharge chute or complete grass catcher assembly mounted in place, you and others are exposed to blade contact and thrown debris. WHAT CAN HAPPEN The rotating mower blade will throw debris through the boot in all directions and may cause injury or death. HOW TO AVOID THE HAZARD Do not cut grass with the boot on mower if the collector & suction tube are not in place. DANGER POTENTIAL HAZARD Rotating V-belt can cut off fingers, hands or other body parts and throw objects WHAT CAN HAPPEN This V-belt may get tangled with the mower V-belt & destroy both belts or get caught on mower spindle and be spun around giving a whip like effect causing injury or death. HOW TO AVOID THE PROBLEM Do not run the mower if the collector drive V-belt is not properly installed in its place on the jack shaft s top pulley located on the left side of tractor rear axle. Either fully install the V-belt or fully remove. Do not run if partially installed.
5 Loose Parts Note: Use the chart below to identify parts used for assembly. DESCRIPTION QTY. USE Boot Assembly Install on mower under discharge chute. Double Idler Assembly Install on top of mower. V-Belt Install on pulley. Double pulley Install on right side mower spindle. Idler Arm Replace the one on mower. Spacer Install on leveller shaft. Idler Mounting Bracket Install on top of mower. Stopper Install on top of mower. Mower Baffle Install under mower. Mower Baffle Install under mower. Mower Baffle Install under mower. Leveller Outside Replace one on mower. Leveller Inside Replace one on mower. Hardware Bag Parts installation. Operators Manual Read before operation.
6 Mower Preparation Remove mower from tractor if installed. Refer to Operators Manual, section: Removing Mower.. Remove the belt guard on top of the right side spindle (fig. ).. Remove the V-belt (fig. ).. Remove the right side spindle pulley by unscrewing the spindle nut (fig. ). Figure. Double pulley. Spindle nut 5. Remove the idler arm from mower and idler and replace with the one supplied in kit. Reinstall as dismounted (fig. ). 6. Reinstall the mower belt as shown in Fig.. Be sure to install the belt on the lower mower deck pulley and on the lower spindle pulley (right hand side). Figure. Belt guard. Spindle pulley. V-belt. Spindle nut. Install the double pulley on spindle. Secure with lockwasher and nut. Tighten the nut to lbs.- ft. (68 0 Nm) (fig. ). Figure Top View. Mower belt. Idler arm. Mower deck pulley. Spindle pulley
7 Leveller Stopper & Idler Mounting Bracket Installation. Remove the two flat leveller bars on right side and the rear leveller shaft from left leveller bars by removing bolts, pins & washers (fig. ). 5. On left side reinstall the bracket guide but with the leveller stopper underneath using the same bolt and nut (fig. 5). 6. On right side install the idler mounting bracket with the leveller stopper underneath using the same bolts and nuts. Do not tighten yet (fig. 5).. Remove the locking collar (fig. ).. Remove the eye bolt by disconnecting the trunnion (fig. ).. Remove both bracket guides (fig. ) Figure Figure 5. Leveller stopper. Bracket guide. Idler mounting bracket. Outside right leveller. Eye bolt. Inside right leveller 5. Locking collar. Trunnion 6. Leveller shaft 7. Bracket guide 5
8 7. Flip leveller shaft 80 and reinstall to left leveller bar. Shaft must be flipped to allow space for collector belt (fig. 6). 8. Slide the spacer on the leveller shaft on the right side (fig. 6). 9. Reinstall the eye bolt and trunnion as dismounted but on the other side of the flat bar (right side) as shown (fig. 6). Idler & Drive Belt Installation. Install the double idler assembly on the mounting bracket. Secure with cotter pin. Align the support rod on top of the inside leveller bar as shown. Tighten the mounting bracket securely (fig. 7). 0. Slide the locking collar on the right side against the eye bolt and secure in place (fig. 6).. Install the leveller bars supplied with kit in the same fashion as original bars were mounted, the raised portion upwards (fig. 6). Figure 7. Idler mounting bracket. Cotter pin. Double idler asembly. Support rod. Route the V-belt under the leveller bars to the top pulley of the blade spindle and in front of idler pulleys, then towards the back (fig. 8) Figure 6. Outside right leveller 5. Eye bolt. Inside right leveller 6. Spacer. Locking collar 7. Leveller shaft. Trunnion Figure 8. V-belt. Top pulley. Leveller bar. Idler pulley 5. Double pulley 6
9 Baffle Installation. Flip the mower upside down. Assemble short & long baffles together with 5/6 x / (9mm.) carriage bolts (fig. 9).. Assemble baffle assembly to deck using /8 x / (9mm.) carriage bolts supplied and the deck bolts in place.. Using the longest baffle as a template, drill a hole 0.06 (0mm.) (item ) through the deck (fig. 9). Secure using /8 x / (9mm.) carriage bolt (fig. 9).. Install end baffle using hex bolt 5/6 x / (9mm.) (fig. 9). 5. Place the mower uprite. Verify if everything is well installed and tighten all bolts securely. Mower Installation. Install the mower on tractor as per Mower Operator Manual. Install the collector drive belt to the top pulley on the jack shaft located under the left rear axle. If not installed, see: Quiet Collector Operator Manual for instructions. Be sure the belt is properly routed on all idlers and pulleys before operation.. Reinstall the belt guard on right side spindle pulley using two spacers, hex bolts / x (5mm.) flat and lock washers. Tighten securely (fig. 0). 5 Figure 0 Figure 9. Belt guard. Flat washer 5/6 dia.hole. Hex bolts / x 5. Spacers. Lock washers /. Long baffle. End baffle. Short baffle. Hole location 7
10 Boot Installation. Install the boot on mower by lifting the mower discharge chute (do not remove it) and introducing the boot bracket between the chute and the mower deck. Release the chute. It should lock the boot in place behind the bolt head. If the bolts are not positioned correctly to lock the boot in place, loosen the bolts, slide them to the correct position so that the chute locks the boot in place. Tighten the bolts. The boot must be touching the mower snuggly (fig. ). See Collector set up for continued instructions. 5 Figure. Boot. Channel. Mower 5. Bolt. Discharge chute 8
11 Operation Read: Mower and Collector Operator s Manuals operations sections. The operation of mower itself is the same with or without the collector drive. Baffles, idlers and belt can be left in place for side discharge operation. Maintenance Read: Mower and Collector Operator s Manuals, maintenance sections. The maintenance on mower is the same with or without the collector drive except for the extra belt and idler inspection. Troubleshooting PROBLEM POSSIBLE CAUSES CORRECTIVE ACTION Belt comes off pulley or slips Belt tension is incorrect Verify if the V-belt idler tensioner slides freely. Apply oil if necessary. Verify if the spring is not damaged. Install a new belt. 9
Collector Drive for 60 Mower
FORM NO. -66 Collector Drive for 60 Mower Model No. 7965-990000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the
More informationQuiet Collector. Model No & Up
FORM NO. -0 Quiet Collector Model No. 79-990000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the safety of others.
More informationQuiet Collector. Model No & Up
FORM NO. -8GB Rev A Quiet Collector Model No. 795-890000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety and the safety
More informationGROUNDSMASTER. 52 Recycler. for 120 Traction Unit. Model No & UP. Operator s Manual
FORM NO. 8-980 Rev A GROUNDSMASTER 5 Recycler for 0 Traction Unit Model No. 077 79000 & UP Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationWheel Horse. 44 Snowthrower. for 5xi Lawn and Garden Tractors. Model No & Up. Operator s Manual
FORM NO. 8 Rev A Wheel Horse Snowthrower for 5xi Lawn and Garden Tractors Model No. 7966 890050 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information
More informationProLine. 44 Mower. for 120 Traction Unit. Model No & Up. Operator s Manual
FORM NO. 9 ProLine Mower for 0 Traction Unit Model No. 05 99000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety of others. Also become
More informationWheel Horse. 52 Mowers. Model No & Up Model No & Up. Operator s Manual
FORM NO. 9-567 Wheel Horse 5 Mowers for Lawn & Garden Tractors Model No. 7880 890000 & Up Model No. 7885 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about
More informationWheel Horse. 42 Mower. for Lawn and Garden Tractors. Model No & Up. Operator s Manual
FORM NO. 9 559 Rev A Wheel Horse 4 Mower for Lawn and Garden Tractors Model No. 78 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the
More information44 and 52 Twin Bagger 100 Series Z Master
Form No. 7 87 and 5 Twin Bagger 00 Series Z Master Model No. 7855 Serial No. 000000 and Up Operator s Manual English (CE) Contents Page Introduction................................ Safety.....................................
More informationZ Master. 62 Mower. for Z Master Z 255 Traction Unit. Model No & UP. Operator s Manual
FORM NO. 9 88 Z Master 6 Mower for Z Master Z 55 Traction Unit Model No. 7408 89000 & UP Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationWheel Horse 48 Blade for 5xi Garden Tractors
Form No. -9 Wheel Horse 8 Blade for 5xi Garden Tractors Model 7955 0000000 Operator s Manual Domestic English (EN) Contents Page Introduction................................ Installation.................................
More information36 Rear Discharge Mower
FORM NO. 8 95 Rev. A Wheel Horse 6 Rear Discharge Mower for Classic Garden Tractor Model No. 7805 790000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your
More information48 Side Discharge Mower
FORM NO. 9 7GB Wheel Horse 48 Side Discharge Mower for Lawn & Garden Tractors Model No. 7868 790000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety
More informationProLine. 36 Mower. for Mid-Size Traction Unit. Model No & Up. Operator s Manual
FORM NO. 8 77 Rev A ProLine 6 Mower for Mid-Size Traction Unit Model No. 05 79000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationWheel Horse. 48 Snow/Dozer Blade. Model No & Up. Operator s Manual
FORM NO. 9 878 Rev A Wheel Horse 8 Snow/Dozer Blade for 5xi Lawn and Garden Tractors Model No. 7955 890000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain
More informationWheel Horse. 36 Tiller. Model No & Up. Operator s Manual
FORM NO. 8 9 Rev. A Wheel Horse 6 Tiller for Classic Garden Tractors Model No. 7970 690000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the
More information48 Side Discharge Mower
FORM NO. 9 650 Rev A Wheel Horse 8 Side Discharge Mower for Classic Garden Tractor Model No. 786 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your
More informationWheel Horse. 48 Snow Blade. Model No & Up. Operator s Manual
FORM NO. 8 8 Wheel Horse 8 Snow Blade for Classic Graden Tractors Model No. 7950 890000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationWheel Horse. 48 Mower. for Lawn and Garden Tractors. Model No & Up. Operator s Manual
FORM NO. 5 Wheel Horse 48 Mower for Lawn and Garden Tractors Model No. 786 990000 & Up Operator s Manual IMPORTANT: Read this manual carefully. It contains information about your safety and the safety
More informationDFS Vac Collection System 400 Series Z Master
Form No. 0 DFS Vac Collection System 00 Series Z Master Model No. 780 Serial No. 000000 and Up Operator s Manual Register your product at www.toro.com Original Instructions (EN/GB) Contents Page Introduction................................
More information36 Tiller Wheel Horse Lawn and Garden Tractor Attachment
Form No. 9 6 Rev B 6 Tiller Wheel Horse Lawn and Garden Tractor Attachment Model No. 797 890000 and Up Operator s Manual English(En) Contents Page Introduction................................ Safety.....................................
More information52 inch Twin Bagger and Finishing Kit 200 Series Z Master
Form No. 9 68 inch Twin Bagger and Finishing Kit 00 Series Z Master Model No. 7898 Serial No. 000000 and Up Model No. 780 Operator s Manual English (EN) Contents Page Introduction................................
More information48in Snow Blade TimeCutter Z Riding Mower Attachment
Form No. 9-8 8in Snow Blade TimeCutter Z Riding Mower Attachment Model No. 796 Serial No. 000000 and Up Operator s Manual Register your product at www.toro.com Original Instructions (EN, GB) Contents Page
More information62 Deck Idler Kit High Speed
Part No. 00 FORM NO. -899 6 Deck Idler Kit High Speed For Model 70 Serial No. 99000 to 99000 For Model 7 Serial No. 9900 to 99000 INSTALLATION INSTRUCTIONS Loose Parts Note: Use the chart below to identify
More informationForm No Wheel Horse. 52 in. Mower 5xi Tractor Attachment. Model No and Up. Operator s Manual. Domestic English (EN)
Form No. -50 Wheel Horse 5 in. Mower 5xi Tractor Attachment Model No. 7870 0000000 and Up Operator s Manual Domestic English (EN) Contents Page Introduction................................ Safety and Instruction
More information42 Mower Wheel Horse Classic Garden Tractor Attachment
Form No. 6 9 Mower Wheel Horse Classic Garden Tractor Attachment Model No. 78 000000 and Up Operator s Manual Domestic English (EN) Contents Page Introduction................................ Slope Chart..............................
More information48 Mower Wheel Horse Classic Garden Tractor Attachment
Form No. 6 96 Rev B 8 Mower Wheel Horse Classic Garden Tractor Attachment Model No. 786 000000 and Up Operator s Manual Domestic English (EN) Contents Page Introduction.................................
More informationWheel Horse. 48 Mower. for 5xi Tractors. Model No & Up. Operator s Manual
FORM NO. 9 Wheel Horse 48 Mower for 5xi Tractors Model No. 786 990000 & Up Operator s Manual IMPORTANT: Read this manual, and your tractor manual, carefully. They contain information about your safety
More informationDIAMONDBACK/EDGE GRASS COLLECTION SYSTEM PARTS & OPERATORS MANUAL
DIAMONDBACK/EDGE GRASS COLLECTION SYSTEM PARTS & OPERATORS MANUAL GRASS CATCHER W/WEIGHT: TUBE KIT: BLOWER KIT: 48 5101305 632093 632078 52 5101305 542119 632074 60 632086 542120 632081 3 WORLDLAWN POWER
More informationGRASS CATCHER PART S & OPERATORS MANUAL
GRASS CATCHER PART S & OPERATORS MANUAL WORLDLAWN POWER EQUIPMENT, INC. WORLDLAWN.COM 2415 ASHLAND AVE BEATRICE, NE 68310 800-267-4255 FAX 402-223-4103 2 3 4 OPERATORS MANUAL This catcher manual is for
More informationReproduction. Not for OPERATOR S MANUAL. Turbo Vacuum System. Model Description Turbo Vacuum Collection System (For 60 Mower Decks)
OPERATOR S MANUAL Turbo Vacuum System Model Description 1695759 Turbo Vacuum Collection System (For 60 Mower Decks) Copyright Briggs & Stratton Power Products Group, LLC Milwaukee, WI USA. All Rights Reserved.
More informationKING COBRA/CALIBER GRASS COLLECTION SYSTEM PARTS & OPERATORS MANUAL
KING COBRA/CALIBER GRASS COLLECTION SYSTEM PARTS & OPERATORS MANUAL GRASS CATCHER W/WEIGHTS: TUBE KITS: BLOWER KITS: 52 542128 52 542119 5101002 60 542129 60 542120 5101003 2 WORLDLAWN POWER EQUIPMENT
More informationAuger Dingo Attachment
Form No. 334-5 Auger Dingo Attachment Model No. 400 0000000 & Up Operator s Manual English (CE) Contents Page Introduction................................ Safety..................................... Safety
More informationSETUP, PARTS & MAINTENANCE MANUAL 2 BAG CATCHER
SETUP, PARTS & MAINTENANCE MANUAL 2 BAG CATCHER MODELS: 970338 2 BAG CATCHER, 36 970339 2 BAG CATCHER, 42 970340 2 BAG CATCHER, 48 970341 2 BAG CATCHER, 52 WARNING: If incorrectly used this machine can
More informationMulti-Purpose Tool Sitework Systems Attachment
FORM NO. 22 648 Multi-Purpose Tool Sitework Systems Attachment Model No. 2242 89000 & Up Operator s Manual English (CE) Contents Page Introduction................................. 2 Safety......................................
More informationBackhoe for Dingo Compact Utility Loaders
Form No. 50-5 Backhoe for Dingo Compact Utility Loaders Model No. 60 000000 & Up Operator s Manual Original Instructions (EN/GB) Contents Page Introduction................................. Safety......................................
More informationBoring Unit Sitework Systems Attachment
FORM NO. 6 Boring Unit Sitework Systems Attachment Model No. 0 89000 & Up Operator s Manual English (CE) Contents Page Introduction................................. Safety......................................
More informationThatching Reel Reelmaster 450 D, 4500 D, 335 D & 3500 D
Form No. 3350 8 Thatching Reel Reelmaster 450 D, 4500 D, 335 D & 3500 D Model No. 0373 Serial No. 5000000 and Up Model No. 03730 Serial No. 5000000 and Up Operator s Manual English (EN) Introduction Read
More information38 and 42 Twin Bagger TimeCutter Z Attachment
Form No. 9-78 Rev B 8 and Twin Bagger TimeCutter Z Attachment Model No. 79 Serial No. 000000 and Up Model No. 795 Serial No. 000000 and Up Operator s Manual Original Instructions (EN) Contents Page Introduction.................................
More informationBackhoe for Compact Utility Loaders
Form No. 54-4 Rev A Backhoe for Compact Utility Loaders Model No. 6 6000000 and Up Operator s Manual Register your product at www.toro.com. Original Instructions (EN) Contents Page Introduction.................................
More information27 Rotary Cutting Deck Groundsmaster 3500 Traction Unit
Form No. 336-56 7 Rotary Cutting Deck Groundsmaster 3500 Traction Unit Model No. 308 00000 and Up Operator s Manual English (EN) Contents Page Introduction................................ Safety.....................................
More informationWorldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE Toll Free Number:
Operator s Manual R WYZ48/52/60CS BAGGER Worldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Toll Free Number: 1-800-267-4255 OPERATOR S MANUAL This catcher manual is for
More informationSafety Instructions, Installation & Operator s Manual For
Safety Instructions, Installation & Operator s Manual For #6-3173 TWIN BAG GRASS CATCHER KIT FOR 38 YARD CRUISERS SERIES 2 MODEL YZ145382BVE IMPORTANT! THIS KIT NOT INTENDED FOR USE ON ANY SERIES OF HZ/HZS
More informationOPERATOR S MANUAL FABRIC 3-BAG GRASS CATCHER PART NO PRINTED 8/2012 PRINTED IN USA
OPERATOR S MANUAL FABRIC -BAG GRASS CATCHER Models: GC-STC-V This manual contains the operating instructions and safety information for your Scag mower accessory. Reading this manual can provide you with
More informationTrencher Dingo Attachment
Form No. 3326-453 Trencher Dingo Attachment Model No. 22459 2000000 & Up Operator s Manual English (CE) Contents Page Introduction................................ 2 Safety.....................................
More informationBEFCO. Operator s Manual BABY HOP & HOP FERTILIZER SPREADERS ACCESSORIES SIDE ROW DISCHARGE. AA4-120 (fits models Hop 209 & 212) DEFLECTOR
BEFCO Operator s Manual BABY HOP & HOP FERTILIZER SPREADERS ACCESSORIES SIDE ROW DISCHARGE AA-0 (fits models Hop 09 & ) DEFLECTOR AA-0 (fits models Baby Hop 0 & 06) 009-95 (fits models Hop 0 & 06) 009-968
More informationSetup, Parts and Maintenance Manual. EC Cutter Decks GB (rev.a)
4122042-GB (rev.a) Setup, Parts and Maintenance Manual EC Cutter Cutting Unit Models: 933506 Cutter Deck 36 Rear Discharge EC 933407A Cutter Deck 36 Side Discharge EC (Safety & Operation Manual: 4122571,
More informationINSTALLATION INSTRUCTIONS BUMPER WINCH MOUNTING KIT Part Number: Application: Polaris Ranger 400, 500, 800 HO 2012+
INSTALLATION INSTRUCTIONS BUMPER WINCH MOUNTING KIT Part Number: 90794 Application: Polaris Ranger 400, 500, 800 HO 2012+ GENERAL SAFETY PRECAUTIONS Your safety, and the safety of others, is very important.
More informationINSTALLATION INSTRUCTIONS
PZ 60 inch Side Discharge Deck Kit - 966555302 Tools Required ½" socket or wrench (battery terminals, strut shaft). ½" breaker bar with 2-3" extension (relieve tension on idler arms). Refer to Operators
More informationOPE R AT O R S MANU A L QUICK-HITCH ADAPTER. 5BP (Field conversion kit)
OPE R AT O R S MANU A L 5BP006750 (Field conversion kit) Manual 5BP97378B Date 06/8/05 SAFETY Take note! This safety alert symbol found throughout this manual is used to call your attention to instructions
More informationINSTALLATION INSTRUCTIONS WINCH MOUNTING KIT Part Number: Application: Kubota RTV500
INSTALLATION INSTRUCTIONS WINCH MOUNTING KIT Part Number: 82001 Application: Kubota RTV500 Your safety, and the safety of others, is very important. To help you make informed decisions about safety, we
More informationWOOD CHIPPER WC1103 5PQ (8/02/12)
O P E R A T O R ' S M A N U A L WOOD CHIPPER WC1103 5PQ990101 (8/02/12) To the Owner; Thank-You for choosing a quality product from Frontier Equipment. We strive to give you the best equipment and the
More informationRM42G MOWER Deck and Chute... 5 Spindles, Belts and Pulleys... 7 Mounting Brackets and Axle... 9 Decals... 39, 41
RM42G RM38, RM44, RM48 R Ingersoll RM42G MOWER Deck and Chute... 5 Spindles, Belts and Pulleys... 7 Mounting Brackets and Axle... 9 Decals... 39, 41 RM38, RM44, RM44GR, RM48 MOWER Deck, Belts, Backside
More informationReproduction. Not for OPERATOR S MANUAL. Turbo Vacuum System ATTACHMENT. Mfg. No. Description
ATTACHMENT OPERATOR S MANUAL Turbo Vacuum System Mfg. No. Description 1695757 Turbo Vacuum Collection System (For 54 Mower Decks) Copyright 2013 Briggs & Stratton Corporation Milwaukee, WI USA. All Rights
More informationTrench Filler for Compact Utility Loaders
Form No. 3353-608 Rev A Trench Filler for Compact Utility Loaders Model No. 22472 260000001 and Up Operator s Manual Register your product at www.toro.com Original Instructions (EN) Contents Page Introduction................................
More informationENGINE DRIVEN ROTARY MOWER
ENGINE DRIVEN ROTARY MOWER Operation, Service & Parts Manual For Models ERM-413, 416, & 617 April 2009 Form: ERMHydMower TABLE OF CONTENTS SECTION DESCRIPTION...PAGE 1 Introduction... 1 2 Preparation...2
More information42in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor
Form No. 5 70 in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor Part No. 06 858 Installation Instructions Original Instructions (EN) This kit is for installing an existing
More informationINSTALLATION INSTRUCTIONS SKID PLATE FRONT MOUNTING KIT Part Number: Application: Polaris Ranger 400, 500, 800 HO
INSTALLATION INSTRUCTIONS SKID PLATE FRONT MOUNTING KIT Part Number: 90812 Application: 2012+ Polaris Ranger 400, 500, 800 HO GENERAL SAFETY PRECAUTIONS Your safety, and the safety of others, is very important.
More information36 Tiller XT Series Garden Tractor Attachment
Form No. 9 6 6 Tiller XT Series Garden Tractor Attachment Model No. 79484 000000 and Up Operator s Manual English(En) Contents Page Introduction................................ Safety.....................................
More informationOPERATOR S MANUAL MODEL GC-STC-V
MODEL GC-STC-V THIS MANUAL CONTAINS THE OPERATING INSTRUCTIONS AND SAFETY INFORMA- TION FOR YOUR SCAG ACCESSORY. READ- ING THIS MANUAL WILL PROVIDE YOU WITH MAINTENANCE AND ADJUSTMENT PROCEDURES TO KEEP
More informationBAD BOY GRASS BAGGING SYSTEM
BAD BOY GRASS BAGGING SYSTEM TABLE OF CONTENTS WILL FIT ALL 2019 OUTLAW SERIES MOWERS SAFETY RULES AND INFORMATION.. 2 GENERAL OPERATION.... 3 WARRANTY INFORMATION.... 5 INSTALLATION INSTRUCTIONS.. 6 PAGE
More informationAgri-Fab OWNERS MANUAL. Model No " ROUGH CUT TRAILMOWER. CAUTION: Read Rules for Safe Operation and Instructions Carefully
Agri-Fab OWNERS MANUAL Model No. 45-0362 CAUTION: Read Rules for Safe Operation and Instructions Carefully Safety Assembly Operation Maintenance Parts 42" ROUGH CUT TRAILMOWER NOTE: Your mower deck will
More informationG3 UHT TRANSMISSION. G3 UHT Transmission Replacement. G3 UHT Transmission Removal
G3 UHT Transmission Replacement The following procedures cover replacing the left hand UHT Transmission. The same procedures can be followed to remove the right hand UHT Transmission. 5. Raise the seat
More information42in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor
Form No. 9 66 in GT Classic Single Stage Snowthrower Conversion Kit XT Series Garden Tractor Part No. 06 88 Installation Instructions English (EN) This kit is for installing an existing 00 Series Classic
More informationForm No Rev A. Adjustable Forks. For Compact Utility Loaders. Model No Serial No and Up G001351
Form No. 335-367 Rev A Adjustable Forks For Compact Utility Loaders Model No. 364 Serial No. 6000000 and Up G0035 Register your product at www.toro.com Original Instructions (EN) Contents Introduction...
More informationHORTICULTURE EQUIPMENT & SERVICES
HORTICULTURE EQUIPMENT & SERVICES OPERATOR S MANUAL PEAT BALE PROCESSOR Model Number: LH00 Serial Number: 30000 & UP Contents Introduction Page Safety Safety 2 Safety Decal Instructions 2 Specifications
More informationWalk-Behind Lawn Mowers
Walk-Behind Lawn Mowers Parts Manual Models 171 LM21 16 LM21S 17 LM21SW 04502100 / Printed in USA THE MANUAL Before you operate your unit, carefully and completely read manuals supplied with the unit.
More informationINSTALLATION INSTRUCTIONS WINCH MOUNTING KIT Part Number: Application: YAMAHA GRIZZLY 700, 07
INSTALLATION INSTRUCTIONS WINCH MOUNTING KIT Part Number: 74496 Application: YAMAHA GRIZZLY 700, 07 Your safety, and the safety of others, is very important. To help you make informed decisions about safety,
More informationINSTALLATION INSTRUCTIONS WINCH MOUNTING KIT Part Number: Application: Honda Rancher TRX420
INSTALLATION INSTRUCTIONS WINCH MOUNTING KIT Part Number: 75660 Application: Honda Rancher TRX420 Your safety, and the safety of others, is very important. To help you make informed decisions about safety,
More informationINSTALLATION INSTRUCTIONS Winch Mounting Kit Winch Mount Kit: Application: Kawasaki Brute Force
INSTALLATION INSTRUCTIONS Winch Mounting Kit Winch Mount Kit: 70207 Application: Kawasaki Brute Force Your safety, and the safety of others, is very important. To help you make informed decisions about
More informationSET-UP INSTRUCTION & PRE-OPERATION CHECKLIST SNAPPER 21" STEEL DECK COMMERCIAL WALK BEHIND MOWERS
SET-UP INSTRUCTION & PRE-OPERATION CHECKLIST SNAPPER 21" STEEL DECK COMMERCIAL WALK BEHIND MOWERS INTRODUCTION: The SNAPPER Walk Behind Mowers are shipped almost fully assembled and require minimal set-up.
More information(31 ) ZEON CONTROL PACK RELOCATION KIT
ORIGINAL INSTRUCTIONS SYMBOL INDEX (31 ) ZEON CONTROL PACK RELOCATION KIT SYMBOL EXPLANATION Read All Product Literature SYMBOL EXPLANATION Always Wear Leather Gloves INSTALLATION GUIDE Always Wear Hearing
More informationOPERATOR S MANUAL. 20-bu 3-Point Hitch Material Collection System. LP65048 Supplier ST /07/2017 English. North American Edition Printed in USA
OPERATOR S MANUAL 20-bu 3-Point Hitch Material Collection System LP65048 Supplier ST48289 11/07/2017 English North American Edition Printed in USA Introduction Using Your Operator s Manual Read this entire
More informationTHIS MANUAL CONTAINS THE ILLUSTRATED PARTS LIST FOR MODELS: GC-2B
ILLUSTRATED PARTS IPLMANUAL 0 0 FABRIC -BAG GRASS CATCHER Model GC-B THIS MANUAL CONTAINS THE ILLUSTRATED PARTS LIST FOR MODELS: GC-B with a serial number of M0000 to M 0 Scag Power Equipment Division
More informationAgri-Fab OWNERS MANUAL. Model No " ROUGH CUT TRAILMOWER. CAUTION: Read Rules for Safe Operation and Instructions Carefully
Agri-Fab OWNERS MANUAL Model No. 45-03071 45-0361 CAUTION: Read Rules for Safe Operation and Instructions Carefully Safety Assembly Operation Maintenance Parts 42" ROUGH CUT TRAILMOWER the fastest way
More informationATTACHMENTS COMPONENT LOCATION
42-Inch Mower Deck ATTACHMENTS COMPONENT LOCATION C D E F G H I H G M A B J O K L N M J A - Gage Wheel (Left Front) B - Belt Cover C - Primary Drive Belt D - Flat Idler (fixed) E - Gage Wheel (Right Front)
More informationTree Forks Sitework Systems Attachment
Form No. 3323-274 Tree Forks Sitework Systems Attachment Model No. 22438 890001 & Up Operator s Manual English (CE) Contents Page Introduction................................. 2 Safety......................................
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS 89-95 Toyota Pickup Front Winch Bumper P/N 68450 Your safety, and the safety of others, is very important. To help you make informed decisions about safety, we have provided installation
More informationVerticutter Reelmaster 5510/5610 Series Cutting Unit with 7in Reel
Form No. 3354 79 Rev B Verticutter Reelmaster 550/560 Series Cutting Unit with 7in Reel Model No. 03684 Serial No. 6000000 and Up Operator s Manual English (EN) Contents Page Introduction................................
More informationModel 858-RH. Operating and Assembly Manual. Palmor Products Inc Serum Plant Road Thorntown, IN 46071
Model 5-RH Operating and Assembly Manual Palmor Products Inc. 55 Serum Plant Road Thorntown, IN 6071 3/31/015 SAFETY RULES Remember, any power equipment can cause injury if operated improperly or if the
More informationTO THE OWNER ASSEMBLY
TO THE OWNER This is an operational and general maintenance manual only and does not cover repair. All repair work must be performed by an authorized BOLENS DEALER or the factory warranty is void. Bolens
More informationINSTALLATION INSTRUCTIONS SEMI Hidden Kit Part Number: Application: Toyota Tacoma
INSTALLATION INSTRUCTIONS SEMI Hidden Kit Part Number: 100044 Application: 2016+ Toyota Tacoma GENERAL SAFETY PRECAUTIONS Your safety, and the safety of others, is very important. To help you make informed
More informationWalk-Behind Lawn Mowers
Walk-Behind Lawn Mowers Parts Manual Models 160 - LM21 182 - LM21 18 - LM21S 184 - LM21SW 04056800 6/10 Printed in USA THE MANUAL Before you operate your unit, carefully and completely read manuals supplied
More informationTHE GIANT-VAC PTO BLOWER MODELS 2000*/3200**/4000***
THE GIANT-VAC PTO BLOWER MODELS 2000*/3200**/4000*** Congratulations! ASSEMBLY INSTRUCTIONS AND OPERATOR S MANUAL You have just purchased one of the finest pieces of outdoor power equipment on the market
More informationOPERATOR S MANUAL MODEL GC-SFZ
R Made in the USA by MODEL GC-SFZ THIS MANUAL CONTAINS THE OPERATING INSTRUCTIONS AND SAFETY INFORMA- TION FOR YOUR SCAG ACCESSORY. READ- ING THIS MANUAL WILL PROVIDE YOU WITH MAINTENANCE AND ADJUSTMENT
More informationHydroTote Trailer Hydroject Aerator
Form No. 3355 89 Rev. C HydroTote Trailer Hydroject Aerator Model No. 09833 Serial No. 6000000 and Up Operator s Manual English (EN, GB) Contents Page Introduction................................. Safety......................................
More informationOperating and Assembly Manual
Model 1080 Operating and Assembly Manual Midwest Equipment Manufacturing, Inc. 5225 Serum Plant Road Thorntown, IN 46071 08-02-16 SAFETY RULES Remember, any power equipment can cause injury if operated
More information(31 ) ZEON CONTROL PACK RELOCATION KIT
Warn Industries, Inc. 12900 S.E. Capps Road Clackamas, OR USA 97015-8903 1-503-722-1200 FAX: 1-503-722-3000 www.warn.com Customer Service / Service Clients: 1-800-543-9276 International Sales Support /
More informationHustler X-ONE i Parts Manual
Hustler X-ONE i Parts Manual 00 South Ridge Road Hesston, Kansas 6706 Table of Contents General Information Service Literature...................................... - Options Available From Your Dealer........................
More information27 Verticutting Reel Reelmaster 3100-D Attachment
Form No. 5 54 7 Verticutting Reel Reelmaster 00-D Attachment Model No. 07 Serial No. 000000 and Up Operator s Manual English (EN) Contents Page Introduction................................ Safety.....................................
More informationKubota Rear Discharge Mowers 1.3m
Operating instructions and parts manual for Kubota Rear Discharge Mowers 1.3m (For G2160 Tractors) autoguide equipment Heddington, Nr Calne, Wiltshire, SN11 0PS Telephone: +44 (0) 1380 850885 Fax: +44
More informationCollection System Operators Manual Model: Parts Manual
Collection System Operators Manual Model: 113706 Parts Manual Please read these instructions carefully and make sure you understand them before using the machine. MANUAL NO. 539 113763 REV 01 (09/18/06)
More informationHustler Raptor CE Parts Manual
Hustler Raptor CE Parts Manual 00 South Ridge Road Hesston, Kansas 70 Table of Contents General Information Service Literature.................................................. - Options Available From
More informationINSTALLATION INSTRUCTIONS HD BUMPER AND WINCH MOUNTING KIT Part Number: 74777, Application: 08-NEWER FORD SUPER DUTY WARNING
INSTALLATION INSTRUCTIONS HD BUMPER AND WINCH MOUNTING KIT Part Number: 74777, 76250 Application: 08-NEWER FORD SUPER DUTY Your safety, and the safety of others, is very important. To help you make informed
More informationAG PRODUCTS, LTD. YOU RE ALWAYS AHEAD... WITH A MODERN BEHIND.
SUMMER 2016 BADGER DISC HARROW Operator s Manual 011-1156 011-1166 001-1501 001-1501-1 011-1167 001-1501-2 001-1501-3 011-1176 001-1501-4 011-1177 MODERN AG PRODUCTS, LTD. YOU RE ALWAYS AHEAD... WITH A
More informationCollection System. Please read the operator s manual carefully and make sure you understand the instructions before using the machine.
Collection System 967004601 Please read the operator s manual carefully and make sure you understand the instructions before using the machine. 2012 All rights reserved. Swainsboro, GA. Printed in U.S.A.
More informationJUNGLE JACK ASSEMBLY INSTRUCTIONS
JUNGLE JACK ASSEMBLY INSTRUCTIONS SAFETY IMPORTANT: READ BEFORE OPERATION OF THE JUNGLE JACK 1. Please read ALL instructions before using your Jungle Jack. The following are safety specifics, but do not
More informationGrass Catcher. Instructional / Parts Manual Part Number: January ( & ) & Drive Kits ( , , )
Grass Catcher Instructional / Parts Manual Part Number: January 200 5020 ( 507 & 5026 ) & Drive Kits ( 52030, 5203, 52032) Table of Contents Z RIDER GRASS CATCHER TWO PACKAGED ITEMS LIST 507 BLOWER ASSEMBLY
More informationA1062 & A1072 AUGER ASSEMBLY MANUAL. Read & understand all instructions pertaining to this auger prior to use!
A1062 & A1072 AUGER ASSEMBLY MANUAL Read & understand all instructions pertaining to this auger prior to use! Safety Alert Watch for this ALERT Symbol. It identifies potential hazards to Personal SAFETY
More informationWOOD CHIPPER WC1105 5PQ (8/08/2012)
O P E R A T O R ' S M A N U A L WOOD CHIPPER WC1105 5PQ990102 (8/08/2012) To the Owner; Thank-You for choosing a quality product from Frontier Equipment. We strive to give you the best equipment and the
More information