Toyota/Lexus A340E, A340F 00-LATER, V6 & V8 ZIP KIT
|
|
- Joel Melton
- 5 years ago
- Views:
Transcription
1 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT PRT NUMER 40-LTE-ZIP QUIK GUIDE NOTE: Type 4 EP-style valve body is shown. Parts will fit in the same locations in a throttle cable-style and Type EP-style valve body except where noted. Parts are labeled here in order of installation. See other side of sheet for details on kit contents. 9 installation Diagram * Not used on Type valve bodies. * Upper Valve ody Type 4 Shown 9 0 These checkballs may or may not belong! 0 0 UTION! Note the location of OE checkballs during disassembly! Usage of checkballs vary greatly! 5 UTION: If replacing an OE 6 sleeve with NO dot or three dots, use Sonnax EP valve with flat on large spool diameter. Flat on large spool diameter. Lower Valve ody Type 4 Shown If replacing an OE sleeve with two dots, use Sonnax EP valve with flat on small spool diameter. Flat on small spool diameter If replacing an OE sleeve with two or three dots, do NOT add shims. Discard the Sonnax EP valve that is not used. 7 If replacing an OE sleeve with no dots, add shims. NOTE: Detailed instructions are included on page 8 of installation and testing booklet. In addition to general rebuilding tips and technical information, the technical booklet included in this kit contains vacuum testing and additional repair options for higher mileage units or for repairing specific complaints which are beyond the scope of this kit. 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany 40-LTE-ZIP-Guide F: Page
2 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Quick Guide Kit ontents & Installation s Packaging Pocket Replace OE End Plugs Secondary Regulator Valve, Reverse ontrol Valve* *(Type 4 Valve ody Only) End Plugs, Large () O-Rings (4) extra Packaging Pocket Replace OE End Plugs -, - & -4 Shift Valves End Plugs, Medium () O-Rings (5) extra Packaging Pocket Replace OE End Plug nd oast Modulator Valve End Plug, Small O-Rings () extra Packaging Pocket 4 Replace OE End Plug ccumulator ontrol Valve End Plug, Extra Large O-Rings () extra Packaging Pocket 5 Valve Replace OE Lockup ssembly Sleeve Select orrect Replacement EP oost Valve Look at end of the OE boost sleeve for number of identification dots. If replacing an OE sleeve with NO dots or three dots, use the Sonnax EP boost valve with flat on large spool diameter. If replacing an OE sleeve with two dots, use the Sonnax EP boost valve with flat on small spool diameter. (See page 8 of Installation & Testing ooklet for more details.) Packaging Pocket 6 EP oost Valve EP oost Valve Flat on Large Spool Dia. (for no/three ID dots) Flat on Small Spool Dia. (for two ID dots) ssemble oost ssembly Place small reverse valve into sleeve. Place selected EP boost valve from step 6 into sleeve, smaller diameter first. Place cutback boost valve into sleeve with longer stem facing outboard. Packaging Pocket 7 oost Sleeve Reverse oost Valve utback oost Valve Pressure Regulator Valve Shims Look at the end of OE boost sleeve for the number of identification dots. If replacing an OE sleeve with two or three dots, do NOT add shim. If replacing an OE sleeve with no dots, add both shims. Shims should be added, if used, between the OE washer and pressure regulator valve. (See page 8 of installation and testing booklet for more details.) Packaging Pocket 8 Shim,.05" thick Shim,.0" thick Replace OE Large heckballs See checkball caution notes on page. Packaging Pocket 9 heckballs, Large.50" dia. () Replace OE Small heckballs See checkball caution notes on page. Packaging Pocket 0 heckballs, Small.8" dia. (9) NOTE: These items also are available separately; s,, & 4 Part No K s 6, 7 & 8 Part No K The parts listed here may be protected by patent number 8,955,5. 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany 40-LTE-ZIP-Guide F: Page
3 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT PRT NUMER 40-LTE-ZIP INSTLLTION & TESTING OOKLET Valve ody Identification This Zip Kit 40-LTE-ZIP is designed for 000-later, V6 & V8 applications using Type (valve body casting identification #895) or Type 4 (valve body casting identification #898) style valve bodies. Type (asting ID #895) Valve ody V8 applications, EP style throttle control only. Type 4 (asting ID #898) Valve ody V6 or V8 applications, EP (shown) or throttle cable style throttle control. Valve ody asting ID Valve ody asting ID SLT Type ontour ID SLT Type 4 ontour ID Figure Type, Upper Valve ody Figure Type 4, Upper Valve ody Separator Plate ID Valve ody asting ID T ontrol Valve (visible here if used) Separator Plate ID Valve ody asting ID T ontrol Valve (visible here if used) Pressure Regulator Valve (visible) Pressure Regulator Valve (visible) S Shift S Shift SL Shift S Shift S Shift SL Shift ccumulator Piston ssembly Type ontour ID ccumulator Piston ssembly Pressure Relief heck Valve Type 4 ontour ID lternate onfiguration: May have same lineup as Type, Figure Pressure Relief heck Valve Figure Type, Lower Valve ody Figure 4 Type 4, Lower Valve ody 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany 40-LTE-ZIP-ooklet F: Page
4 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Installation & Testing ooklet olt Locations & Torque Specifications Torque Specifications Detent Spring olt 89 in-lbs (0 N.m) Oil Pan olt 65 in-lbs (7. N.m) Type Valve ody to ase olts olt olor ode olt Length Red mm Green 8mm Type 4 Valve ody to ase olts olt olor ode olt Length Purple mm White 8mm Type & 4 Oil Pan Filter olts olt olor ode olt Length Pink 4mm lack 0mm Type & 4 Valve ody Disassembly olts olt olor ode olt Length Lt. Purple 0mm Teal 8mm -to-valve ody olt 89 in-lbs (0 N.m) lue 6mm Torque all to 8 ft-lbs Yellow 6mm Torque all to 8 ft-lbs Orange mm Torque to 7 ft-lbs rown 40mm Torque to 57 in-lbs Type (asting ID #895) Valve ody V8 applications, EP style throttle control only. Type 4 (asting ID #898) Valve ody V6 or V8 applications, EP (shown) or throttle cable style throttle control. Figure 5 Figure 7 Type, Lower Valve ody, ase Removal - olt Locations Type 4, Lower Valve ody, ase Removal - olt Locations Figure 6 Figure 8 Type, Upper Valve ody, Valve ody Disassembly - olt Locations Type 4, Upper Valve ody, Valve ody Disassembly - olt Locations LTE-ZIP-ooklet 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany Page F:
5 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Installation & Testing ooklet lutch & and pplication hart Figure 9 Shift hart Figure 0 Selector Position - Gear Park 0 0 F0 F F ON Reverse ON ON ON ON Neutral ON D-st Gear ON ON ON ON D-nd Gear ON ON ON ON ON D-rd Gear ON ON ON ON ON D-Overdrive ON ON ON ON -st Gear ON ON ON ON -nd Gear ON ON ON ON ON ON -nd Gear ON ON ON ON ON Low-st Gear ON ON ON ON ON Low-nd Gear ON ON ON ON ON ON Diagnostic Trouble hart DT P0750 P075 P0755 P0758 P0770 P077 Description Shift S ()/S () Malfunction Shift S ()/S () Electrical Malfunction Shift S ()/S () Malfunction Shift S ()/S () Electrical Malfunction Shift SL (E) Malfunction Shift SL (E) Electrical Malfunction Figure Selector Position - Gear Shift S Shift S D - st Gear ON Off D - nd Gear ON ON D - rd Gear Off ON D - Overdrive Off Off - st Gear ON Off - nd Gear ON ON - rd Gear Off ON Low - st Gear ON Off Low - nd Gear ON ON Shift Strategies The computer (EM) controls the ON/Off combination of the shift solenoids S () and S () to shift between st gear and overdrive (O/D). If an electrical failure occurs in one of these two solenoids, the computer continues to control the other solenoid to allow the vehicle to operate as smoothly as possible while in Fail Safe mode. The EM also turns off the SL (E) solenoid during Fail Safe. Should both solenoids S () and S () fail, shifting must be done manually. Figures and give typical solenoid codes and solenoid malfunctioning shift strategies. Figure 4 Malfunctioning Shift Strategies Figure Selector Position - Normal Gear Shift S () Malfunctioning S () S () Gear Shift S () Malfunctioning S () S () Gear oth s Malfunctioning Gear When selector position in manually operated D-st Gear X ON rd ON X st Overdrive D-nd Gear X ON rd Off X O/D Overdrive D-rd Gear X ON rd Off X O/D Overdrive D-Overdrive X Off O/D Off X O/D Overdrive -st Gear X ON rd ON X st rd -nd Gear X ON rd Off X rd rd -nd Gear X ON rd Off X rd rd Low-st Gear X Off st ON X st st Low-nd Gear X ON nd ON X st st Figure To test shift solenoids S (), S () or SL (E) for sticking, force 7 psi of compressed air into the snout (Figure, arrow); it should not leak. Energizing the solenoids should cause them to open and allow air flow. Resistance on these three shift solenoids should be 5 ohm at 68 F, and resistance on the SLT solenoid should be ohm at 68 F. Some valve bodies have an accumulator piston assembly (Figure 4) that can be mistaken for a solenoid. This is actually an accumulator for lockup and should be checked to ensure the piston can move freely. 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany 40-LTE-ZIP-ooklet F: Page
6 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT ritical Wear reas & Vacuum Test Locations Installation & Testing ooklet NOTE: OE valves are shown in rest position and should be tested in rest position unless otherwise indicated. Test locations are pointed to with an arrow. Springs are not shown for visual clarity. Low vacuum reading indicates wear and Sonnax parts noted for replacement. Upper Valve ody Type, EP Style Shown Here 9 4. Primary Regulator Valve Low line pressure High line pressure Poor shift quality Low lube oil flow urnt clutches K EP valve spool.46 dia.; replaces OE -dot boost sleeve K EP valve spool.5 dia.; replaces OE -dot or no-dot boost sleeve K & K: Requires F-9774-TL6 & V-FIX. oost ssembly Delayed Forward or Reverse Soft shifts Low pressure K* 0 5. T ontrol Valve & Plunger ssembly T apply & release concerns T codes Overheated fluid urnt converter 974-0K Lower Valve ody Type, EP Style Shown Here 4. Secondary Regulator Valve T apply & release concerns urnt T apply components Overheated transmission ushing wear K Requires F-974-TL8 & V-FIX 5. Lockup Relay Valve & Plunger ssembly T apply & release concerns T codes RPM fluctuation Inadequate lubrication ushing failure Overheated fluid K* Lockup Relay ontrol Valve Kit K Oversized Lockup Relay Valve Kit K: Requires F-9774-TL0 & V-FIX Secondary Modulator Valve Shift concerns codes *Part numbers with an asterisk (*) are included in this Zip Kit LTE-ZIP-ooklet 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany Page F:
7 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Installation & Testing ooklet VUUM TEST 5 For specific vacuum test information, refer to individual part instructions included in kits and available at 7. ccumulator ontrol Valve Shift concerns codes Loss of throttle/line pressure Upper Valve ody Type 4, EP Style Shown Here utback Valve No kickdown Loss of throttle pressure 9. Low oast Modulator Valve urnt st/reverse brake () Loss of manual low 0. nd oast Modulator Valve urnt nd brake () Loss of manual nd. 4 Shift Valve 4 oncerns. Shift Valve oncerns 0 Lower Valve ody Type 4, EP Style Shown Here 5. Shift Valve oncerns 4. Reverse ontrol Valve Delayed Reverse No Reverse 5. End Plugs Soft shifts Low line rise Slips & flares K* NOTE: Several Locations = Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany 40-LTE-ZIP-ooklet F: Page 5
8 OE Exploded View Upper & Lower Valve ody Type, EP Style Shown Here NOTE: Depending upon vehicle application, the OE springs shown may not be present. heckball autions & Notes Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Installation & Testing ooklet Upper Valve ody - Type 0 are should be taken during disassembly. Note location of checkballs as usage varies greatly! 06 When determining when a checkball is required, the circuit orifice in the separator plate over that location will be about.090" dia. When no ball is required, the orifice will be about.50" dia..50" dia. 0 ll checkballs are.8" dia. except where noted (.50" dia.). 05 Upper Valve ody Descriptions I.D. No. 0 Description Lockup Relay Valve & Plunger ssembly 0 4 Shift Valve 0 nd oast Modulator Valve 04 Low oast Modulator Valve 05 Shift Valve 06 Secondary Regulator Valve Lower Valve ody - Type.50" dia. Orifice 0 Separator Plate.090" dia. Orifice Lower Valve ody Descriptions I.D. No. Description 0 ccumulator ontrol Valve 0 Secondary Modulator Valve 0 utback Valve 04 Primary Regulator Valve & oost ssembly 05 onverter Limit Valve 06 Manual Valve 07 Shift Valve NOTE: Filters should be installed into the separator plate during assembly. The open end of the filter snaps into the plate opening LTE-ZIP-ooklet 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany Page F:
9 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Installation & Testing ooklet Upper & Lower Valve ody Type 4, EP Style Shown Here NOTES: Depending upon vehicle application, the OE springs shown may not be present. Slight wormtrack difference and valve components will vary in throttle cable style valve bodies. Upper Valve ody - Type Upper Valve ody Descriptions I.D. No. Description 0 Lockup Relay Valve & Plunger ssembly.50" dia Shift Valve 0 nd oast Modulator Valve 07 04* heck Valve 06 05* 0 05* heck Valve 06 Reverse ontrol Valve 07 Shift Valve 08 Secondary Regulator Valve 04* *Not in throttle cable style..090" dia. Orifice Please review heckball autions & Notes as well as Filter Note on page 6 as they apply to both Type & Type 4 valve bodies. Lower Valve ody - Type 4 Separator Plate.50" dia. Orifice Lower Valve ody Descriptions Large Filter I.D. No. Description 09 0 ccumulator ontrol Valve 0 Secondary Modulator Valve 08 0 utback Valve 04** T ontrol Valve & Plunger ssembly Teardrop Filter Primary Regulator Valve & oost ssembly 06 onverter Limit Valve 07 Manual Valve 08 Shift Valve 04** 09 Low oast Modulator Valve **Not in all applications 07 Small Filter Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany 40-LTE-ZIP-ooklet F: Page 7
10 Toyota/Lexus 40E, 40F 00-LTER, V6 & V8 ZIP KIT Installation & Testing ooklet Detailed Instructions for s 6 to 8 from Quick Guide For Replacing a No Dot OE oost Valve ssembly Figure 5 dd Sonnax Shims Under OE Washer hoose Sonnax EP oost Valve with Flat on Large Diameter Primary Regulator Valve & oost ssembly ore For Replacing a Dot OE oost Valve ssembly Figure 6 Do NOT add Sonnax Shims Here hoose Sonnax EP oost Valve with Flat on Small Diameter Primary Regulator Valve & oost ssembly ore For Replacing a Dot OE oost Valve ssembly Figure 7 Do NOT add Sonnax Shims Here hoose Sonnax EP oost Valve with Flat on Large Diameter Primary Regulator Valve & oost ssembly ore LTE-ZIP-ooklet 08 Sonnax Transmission ompany, Inc. Marmon / erkshire Hathaway ompany Page F:
GM 6T40 (Gen. 1), 6T45 (Gen.1), 6T50 (Gen. 1) ZIP KIT
GM 6T40 (Gen. ), 6T45 (Gen.), 6T50 (Gen. ) PART NUMER 6T40-ZIP QUIK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on kit contents. Main ontrol Valve ody installation
More informationToyota/Lexus U760E, U760F ZIP KIT. Valve Body Identification Guide
Toyota/Lexus U760E, U760F ZIP KIT PRT NUMBER U760E-ZIP IDENTIFITION UIDE Valve Body Identification uide U760E Upper Valve Body asting Small Exhaust roove U660E, U660F Upper Valve Body asting Extended Exhaust
More informationTOYOTA/LEXUS U760E, U760F ZIP KIT. Valve Body Identification Guide
TOYOT/LEXUS U760E, U760F ZIP KIT PRT NUMBER U760E-ZIP IDENTIFITION UIDE Valve Body Identification uide U760E Upper Valve Body asting Small Exhaust roove U660E, U660F Upper Valve Body asting Extended Exhaust
More informationTOYOTA U151E-U250E ZIP KIT
TOYOTA U5E-U50E ZIP KIT PART NUMBER U5E-U50E-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram Upper Valve Body
More informationTOYOTA/LEXUS U151E, U151F, U250E Zip Kit
TOYOTA/LEXUS U5E, U5F, U50E Zip Kit PART NUMBER U5E-U50E-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram Upper
More informationGM 6T70 (Gen. 1), 6T75 (Gen. 1) ZIP KIT
GM 6T70 (Gen. ), 6T75 (Gen. ) ZIP KIT PART NUMBER 6T70-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on kit contents. installation Diagram CAUTION!:
More information46RE, 46RH, 47RE, 47RH ZIP KIT
46RE, 46RH, 47RE, 47RH ZIP KIT PART NUMBER 46-47RHE-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram 7 1 Separator
More informationTOYOTA/LEXUS U660E, U660F ZIP KIT. Valve Body Identification Guide
TOYOTA/LEXUS U660E, U660F ZIP KIT PART NUMBER U660E-ZIP IENTIFICATION GUIE Valve Body Identification Guide U760E Upper Valve Body Casting Small Exhaust Groove U660E, U660F Upper Valve Body Casting Extended
More informationElectronic Cautions. Resetting Shift Adapts. Post-Adapt Road Test. Solenoids. 5th Off Off ON ON ON ON
Toyota u5e-u250e zip Kit PaRT NUMBER u5e-u250e-zip Installation & TESTING BOOKLET Torque Specifications Pan Filter to Valve Body 8 ft-lb Oil Pan to Transaxle 9 in-lb Component Pack Clearance Forward (C)
More informationAISIN AW 60-41SN (AF-17)
AISIN AW 60-41SN (AF-17) zip Kit PaRT NUMBER AW60-41SN-ZIP Installation & TESTING BOOKLET Torque Specifications Manual Shaft Detent Spring Bolt 89 in-lb Manual Shift Shaft Retaining Nut 61 in-lb Transmission
More informationParts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram
FORD 6R140 ZIP KIT PART NUMBER 6R140-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram WARNING: If ridge and
More informationFORD 6F50, 6F55 ZIP KIT
FORD 6F0, 6F ZIP KIT PART NUMBER 6F0-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on kit contents. CAUTION: Ensure shuttle valve is installed with
More informationParts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram
FORD 6R140 ZIP KIT PART NUMBER 6R140-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram WARNING WARNING: If ridge
More informationGM 6L45, 6L50, 6L80, 6L90
Identification Guide GM 6L45, 6L50, 6L80, 6L90 Valve Body Casting Identification Look for the machined-down boss on the upper valve body (Figure 1). Generally, if the A boss is machined down, this indicates
More informationFORD 6F50, 6F55 ZIP KIT
FORD 6F0, 6F ZIP KIT PART NUMBER 6F0-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. CAUTION: Ensure shuttle valve is installed
More informationZF6HP19/26/32 (Generation 1), Ford 6R60, 6R75, 6R80, ZF6HP21/28/34 (Generation 2)
Valve Body Identification ZF6HP19/26/32 (Generation 1), Ford 6R60, 6R7, 6R80, ZF6HP21/28/34 (Generation 2) IDENTIFICATION GUIDE Valve components differ between Generation 1 (ZF6HP19/26/32), Ford 6R60,
More informationValve Body Rebuild Tips & Techniques
Ford 4r44e, 4r55e, 5r44e, 5r55e zip Kit PaRT NUMBER 4r44e-5r55e-zip Installation & TESTING BOOKLET Torque Specifications Band Adjuster Lock Nut 35 to 45 ft-lb Transmission Oil Pan Bolt 115 to 133 in-lb
More informationZF6HP19, ZF6HP26, ZF6HP32, Ford 6R60, 6R75, 6R80, ZF6HP21, ZF6HP28, ZF6HP identify! 2. VERify! .804" .629" dia..629" dia. .629" dia.
Valve Body Identification ZF6HP19, ZF6HP26, ZF6HP32, Ford 6R60, 6R75, 6R80, ZF6HP21, ZF6HP28, ZF6HP34 IDENTIFICATION GUIDE Valve components differ between Generation 1 (ZF6HP19, ZF6HP26, ZF6HP32), Ford
More informationGM 4L80-E, 4L85-E SURE CURE KIT
GM 4L80-E, 4L85-E SURE CURE KIT PART NUMBER SC-4L80E INSTRUCTION BOOKLET Parts are labeled here in order of installation. See page 2 for details on Sure Cure kit contents. See Sure Cure instruction booklet
More informationZF6HP19/26/32 (Generation 1), Ford 6R60, 6R75, 6R80, ZF6HP21/28/34 (Generation 2)
Valve Body Identification ZF6HP19/26/32 (Generation 1), Ford 6R60, 6R75, 6R80, ZF6HP21/28/34 (Generation 2) 1. identify! IDENTIFICATION GUIDE Valve components differ between Generation 1 (ZF6HP19/26/32),
More informationZF6HP19/26/32 (Gen. 1); FORD 6R60, 6R80 Vacuum Test Plate Kit
ZF6HP19/26/32 (Gen. 1); FORD 6R60, 6R80 Kit PART NUMBER 95740-VTP1 INSTRUCTIONS Alignment Hole Key Red = Alignment Pins / Black = Push Pin Locations / Blue = Optional Bolt Locations NOTES: Cannot be used
More informationGM 4L80-E, 4L85-E SURE CURE KIT
GM 4L80-E, 4L85-E SURE CURE KIT PART NUMBER SC-4L80E INSTALLATION GUIDE Parts are labeled here in order of installation. See page 2 for details on Sure Cure kit contents. See Sure Cure instruction booklet
More informationGM 4L60-E, 4L65-E, 4L70-E Vacuum Test Plate Kit
Vacuum Test Plate Kit PART NUMBER 77754-VTP INSTRUCTION BOOKLET Alignment Hole Key Red = Alignment Pins Black = Push Pin Locations Blue = Optional Bolt Locations 2017 Sonnax Industries, Inc. 77754-VTP-IN
More informationFord 6F35 (Gen. 1 & Gen. 2); GM 6T40/45/50 (Gen. 1) Vacuum Test Plate Kit
Ford 6F35 (Gen. 1 & Gen. 2); GM 6T40/45/50 (Gen. 1) Kit PART NUMBER 144740-VTP INSTRUCTIONS Alignment Hole Key Red = Alignment Pins Black = Push Pin Locations Blue = Dowel Pin Location 2018 Sonnax Transmission
More informationZF6HP19/26/32 (Gen. 1), 6R60, 6R80 Vacuum Test Plate Kit
TIME TESTED INDUSTRY TRUSTED ZF6HP19/26/32 (Gen. 1), 6R60, 6R80 Vacuum Test Plate Kit INSTRUCTION BOOKLET Alignment Hole Key Red = Alignment Pins / Black = Push Pin Locations / Blue = Optional Bolt Locations
More informationTRANSMISSION PARTS Instructions
TRANSMISSION PARTS Instructions Sure Cure Kit Part No. SC-4T65E GM 4T65-E Valve Body Parts Boost Valve Kit 84754-30K Patent No. 6,832,632 TCC Apply Valve Kit 84754-43K Patent No. 7,100,753 TCC Regulated
More informationChrysler 46RE, 46RH, 47RE, 47RH SURE CURE KIT
Chrysler 46RE, 46RH, 47RE, 47RH SURE CURE KIT PART NUMBER SC-46-47RHE-OS INSTALLATION GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Sure Cure kit contents.
More informationTechnical Service Information
Technical Service Information VOLVO/SAAB AW0-4LE VALVE BODY EXPLODED VIEWS AND IDENTIFICATION OF COMPONENTS Refer to Figure 1 for Solenoid identification and locations on the valve body. Refer to Figure
More informationTRANSMISSION PARTS Instructions. Solenoid Regulator Valve Retainer Shim. Main Pressure Regulator Valve
TRANSMISSION PARTS Instructions Sure Cure Kit Part No. SC-AODE NOTE: This kit is fully compatible with '91 '95 only. Identified by alignment pins 13mm heads. This kit will not work on '96 Later units.
More informationAODE ( 96 & LATER) SC-AODE-1. Transmission Reconditioning Kit FULL COMPATIBILITY IMPORTANT VALVE BODY PARTS REASSEMBLY PARTS
AODE ( 96 & LATER) Transmission Reconditioning Kit FULL COMPATIBILITY SC-AODE-1 Full compatibility with 1996 and later units. Identified by alignment pins with 10mm head and.173" pin diameter. IMPORTANT
More informationContents: This booklet contains instructions for all series kits. Individual Part Number Reaming & Installation Instructions:
Instruction Data Sheet 37947 Series Instructions 4R44E/55E, 5R44E/55E PART NUMBERS 37947-01K, -03K, -05K, -07K, -09K, -11K, -13K, -33K, -TL5, -TL9, -TL11, -TL33 Contents: This booklet contains instructions
More informationChrysler 48RE SURE CURE KIT
Chrysler 48RE SURE CURE KIT PART NUMBER SC-48RE INSTALLATION GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Sure Cure kit contents. See Sure Cure instruction
More informationHIGH PERFORMANCE TRANSMISSION PARTS Instructions. Line Pressure Booster Kit. TCC Control Plunger Valve Kit. Line Pressure Modulator Plunger Valve Kit
Performance Pack Ford 4R100 Part No. HP-4R100-01 Line Pressure Booster Kit Line-to-Lube Pressure Regulator Valve Line Pressure Booster Kit Valve Sleeve O-Rings (2) TCC Control Plunger Valve Kit Front Lube/Drainback
More information2005 Toyota RAV AUTOMATIC TRANSMISSIONS U240E & U241E Overhaul
2001-05 AUTOMATIC TRANSMISSIONS U240E & U241E Overhaul APPLICATION CAUTION: Flush oil cooler and oil cooler lines prior to transaxle installation. Oil cooling system contamination may cause premature transaxle
More informationHIGH PERFORMANCE TRANSMISSION PARTS Instructions. Line Pressure Booster Kit. TCC Control Plunger Valve Kit. Line Pressure Modulator Plunger Valve Kit
Performance Pack Ford 4R100 Part No. HP-4R100-01 Line Pressure Booster Kit Line-to-Lube Pressure Regulator Valve Line Pressure Booster Kit Valve Sleeve O-Rings (2) TCC Control Plunger Valve Kit Front Lube/Drainback
More informationTH325. FWD 3 Speed. FWD 3 Speed. COPYRIGHT 2009 DACCO Incorporated. COPYRIGHT 2009 DACCO Incorporated. 373 Conv. Reactor
TH325 TH325 W 3 Speed 325 036 043 89 279 898 529 30 700 705 77 W 3 Speed 778 7 497 373 onv. Reactor 323 037 79 73 044 895 28 899 rive 706 760 50 070 034 30 544 324 755 530 riven Support 229 878 46 06 26
More informationToyota U140 / U240. FWD 4 Speed. D B-1 Accumulator. Pinion. Differential 120. Bell Housing. Forward Drum. Pump Body Stator. Case
Toyota U140 / U240 FWD 4 Speed Pinion 11 12 A 40 3 118 Differential 120 Bell Housing 10 B 85 Pump Body Stator 29 30 Forward Drum C Case 1st / Reverse Clutch 79 D B-1 Accumulator C-2 Accumulator 150 SLT
More informationby David Skora These pressure readings are based on the computer reacting to the load conditions of the vehicle. Pressures may vary
Looking inside the Volkswagen 09G 6-Speed; Part 3 Looking inside the Volkswagen 09G 6-Speed; by David Skora PART 3 I n past issues we looked at the design and operation of the VW 6-speed transmission.
More informationMercedes
Mercedes 7.3 7.4 3 4 5 6 7 8 - Clutch K - Brake Band B 3 - Disc Brake B 3 4 - Wide Planet Pinion 5 - One-Way Clutch F 6 - Clutch K 7 - Brake Band B 8 - Narrow Planet Pinion Int. Band Fwd. Band Rev. Clutch
More informationTechnical Service Information
TOYOTA/LEXUS U/U0 PRELIMINARY INFORMATI Starting at the beginning of production for the 00 model year for Lexus and 00 for Toyota, a spin-off of the U10/U0 Four speed transaxle, designated as the U/U0
More information4 L E. Part No. SC-4L80E. Transmission Reconditioning Kit FULL COMPAT I B I L I T Y PUMP PA RT S VA LVE BODY PA RT S R E A S S E M B LY PA RT S
4 L 8 0 - E Transmission Reconditioning Kit Part No. SC-4L80E FULL COMPAT I B I L I T Y Full compatibility with 1991 and up. PUMP PA RT S Boost valve kit (34200-01K) Wide stator bushing (34016-W) End plugs
More informationTCI E4OD/4R100 Valve Body Performance Improver Kit
151 INDUSTRIAL DRIVE ASHLAND, MISSISSIPPI 38603 http://www.tciauto.com TCI 496500 E4OD/4R100 Valve Body Performance Improver Kit TELEPHONE: 662-224-8972 FAX LINE: 662-224-8255 E-MAIL: tech@tciauto.com
More informationReturn to Instruction Sheet index TCI Installation Instructions for Turbo Hydramatic 350C & 250C
Page 1 of 6 Return to Instruction Sheet index TCI 326300 Installation Instructions for Turbo Hydramatic 350C & 250C NOTE: This kit was not intended for installation in transmissions that are in poor general
More informationGM 4L60 (700-R4) SURE CURE KIT
REQUIRED REQUIRED GM 4L60 (700-R4) SURE CURE KIT PART NUMBER SC-4L60 We need to decide if we're going to tell people to test before they install parts, after, or both. Why are we wiggle/bore inspecting?
More informationF4A41 / 42 / 51 / A / B / F5A51/A
F4A41 / 42 / 51 / A / B / F5A51/A FWD 4 & 5 Speed 5 Speed Only A Pinion Driven Transfer Direct Planet B 50 Bell Housing. 11 Pinion Driven Transfer 11 66 Drive C Filter Differential 51 TISS 67 68 TOSS 24
More information1 Green Pressure Regulator Spring Automatic transmissions operate at temperatures between 150ºF and
Installation Instructions for 603107 Valve Body Kit C-4 1970 & Later Tools Required Speed Handle or Ratchet 3/8 Drive 1/2 Socket 3/8 Drive 7/16 Socket 3/8 Drive 5/16 Socket 3/8 Drive Small Screwdriver
More informationToyota A750 E/F A760 E/F A761 Introduction. Sponsored By: Presented by: Steve Garrett ATRA
Toyota A750 E/F A760 E/F A761 Introduction Sponsored By: Presented by: Steve Garrett ATRA Today s Presentation Sponsored By: Lwiggins@ATRA.com Connections Handout Questions Survey Toyota A750 E/F Common
More information16.Control Valve Body
ONTROL VLVE OY UTOMTI TRNSMISSION 16.ontrol Valve ody : REMOVL 1) Lift-up the vehicle. 2) lean the transmission exterior. 3) rain the TF completely. Tighten the TF drain plug after draining the TF. Replace
More informationMercedes Clutch KS 5 - Brake BS 6 - Clutch K2
965 Mercedes 7.5 1 9 8 6 3 7 5 1 - Brand Band B1 - Brake Band B 3 - Sprag Clutch F - Clutch KS 5 - Brake BS 6 - Clutch K 7 - Sprag Clutch F1 8 - Multi-Disc Clutch B3 9 - Clutch K1 Application Chart Lever
More informationReturn to Instruction Sheet index. Installation Instructions For C-4 70 and Later, Except 70 Falcon
Page 1 of 8 Return to Instruction Sheet index TCI 260100 Trans-Scat Automatic Transmission Installation Instructions For C-4 70 and Later, Except 70 Falcon TCI 260100 Kit Contains: Qty. Description One
More informationTCI TRANS-SCAT
Page 1 of 9 Return to Instruction Sheet index TCI 360000 TRANS-SCAT Installation Instructions for FORD C-6 Transmissions TCI s TRANS-SCAT kit will allow you to calibrate the performance of your transmission.
More informationGeo Prizm ( LSi) Toyota Celica 1.8L (1994)
Page 1 of 140 ARTICLE BEGINNING APPLICATION TRANSMISSION APPLICATIONS Application Geo Prizm (1993-94 LSi) Toyota Celica 1.6L (1993) Celica 1.8L (1994) Celica 2.2L (1993) Corolla 1.8L MR2 Paseo Transaxle
More informationDIAGNOSIS AND TESTING
307-01B-1 DIAGNOSIS AND TESTING Special Testing Procedures The special tests are designed to aid the technician in diagnosing the hydraulic and mechanical portion of the transmission. Engine Idle speed
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Special Testing Procedures Special Tool(s) Air Test Plate, Transmission 307-405 Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A)
More informationTranspak. Torqueflite Part No (1978½-1996) Part No ( ) 2008, 2002 by B&M Racing and Performance Products
Installation Instructions Transpak for Torqueflite Part No. 10227 (1978½-1996) Part No. 10228 (1962-1978) 2008, 2002 by B&M Racing and Performance Products Congratulations. You have just purchased the
More informationStep 3: Remove the six 8mm retaining bolts for the pressure manifold switch assembly. The manifold switch will not be re-installed.
1 INSTRUCTIONS TCI 274500/274501 4L80E Trans Brake Valve Body Thank you for choosing TCI products. We are proud to be your manufacturer of choice. Please read this instruction sheet carefully before beginning
More informationAW55-50SN / AF23/33-5 / RE5-F22A
AW55-50SN / AF23/33-5 / RE5-F22A FWD 5 Speed 11 10 51 A Pump Assembly 65 B Filter C 12 Case D 84 SLT SLU 82 83 116 SLS Differential 150 Valve Body 115 81 1 80 Shift Solenoids Band Servo Linkage Assembly
More informationLX AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION TABLE OF CONTENTS
LX AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION 21-495 AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION TABLE OF CONTENTS page AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION DESCRIPTION...496
More informationThe following tool kit is required to install this Sure Cure Kit: Note: Instructions are provided with this tool kit.
REQUIRED REQUIRED Transmission Parts Instructions Sure Cure Kit Part No. SC-4L60 TOOL TOOL REQUIRED REQUIRED GM 4L60 (700-R4) Valve Body Parts TV Cable Corrector Kit AS1-01K Shortened TV Link 77872-01
More informationMANUAL TRANS OVERHAUL - BORG-WARNER - T56 6-SPEED MANUAL TRANSMISSIONS Borg-Warner T56 (MM6) 6-Speed
IDENTIFICATION MANUAL TRANS OVERHAUL - BORG-WARNER - T56 6-SPEED 1998 MANUAL TRANSMISSIONS Borg-Warner T56 (MM6) 6-Speed Transmission has 2 identification labels, located on lower left side of case. One
More informationIn the last issue of GEARS we went
A Look Inside the 6-Speed Volkswagen Automatic; Part 2 A Look Inside the 6-Speed Volkswagen Automatic; Part 2 by David Skora In the last issue of GEARS we went over the theory of VW s 09G and 09M 6-speed
More informationINDEX BACK AUTOMATIC TRANSMISSION SERVICE GROUP SW 107TH AVENUE MIAMI, FLORIDA (305) Copyright ATSG 2005
BACK INDEX MITSUBISHI F4A4, F4A42, F4A5 IDENTIFICATION CODE STAMPING LOCATION... GEAR RATIO IDENTIFICATION... INTERNAL COMPONENT AND SOLENOID APPLICATION CHART... FLUID REQUIREMENTS... CASE CONNECTOR TERMINAL
More information2000 Jeep Truck Cherokee 4WD L6-4.0L VIN S
2000 Jeep Truck Cherokee 4WD L6-4.0L VIN S Vehicle» Transmission and Drivetrain» Automatic Transmission/Transaxle» Service and Repair» 30-40LE (AW4) 4 Speed» Overhaul (Transmission)» Disassembly DISASSEMBLY
More informationPROBLEM SYMPTOMS TABLE
Last Modified: 4262007 Service Category: Drivetrain 1.6 T Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W7304AX Title: A750E AUTOMATIC TRANSMISSION: AUTOMATIC
More informationThe Toyota A750E was first
A Closer Look at the Toyota A750E Valve Body by Mike Brown members.atra.com Figure 1 The Toyota A750E was first introduced in the 2003 4-Runner and Land Cruiser, and the Lexus LX400 and GX470. Since then
More informationTH200/C, TH200-4R (Pictured)
TH200/C, TH200-4R (Pictured) RWD 4 Speed 63 68 134 100 2 135 138 101 136 137 101 69 140 5 6 A 7 Pump Body 122 121 3 4 Stator 130 50 51 71 84 85 86 B Overdrive Roller Clutch Overrun Clutch O.D. Sun Overdrive
More informationAUTOMATIC TRANSMISSIONS. General Motors Corp. Hydra-Matic 4L60-E Overhaul
1997-98 AUTOMATIC TRANSMISSIONS General Motors Corp. Hydra-Matic 4L60-E Overhaul APPLICATION TRANSMISSION APPLICATIONS Application Corvette Transaxle 4L60-E IDENTIFICATION The 4L60-E transmission can be
More informationPROBLEM SYMPTOMS TABLE
A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Last Modified: 4262007 Service Category: Drivetrain 1.6 T Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner
More informationItems Vehicles with 4G63 engine Vehicles with 4D56 engine. Type 4-speed full automatic 4-speed full automatic. 2nd rd
23-2 AUTOMATIC TRANSMISSION General Information/ Service Specifications GENERAL INFORMATION 23100010141 Items Vehicles with 4G63 engine Vehicles with 4D56 engine Transmission model R4AW2-6 V4AW2-6 Type
More informationBRAKE SYSTEM Return To Main Table of Contents
BRAKE SYSTEM Return To Main Table of Contents GENERAL... 2 BRAKE PEDAL... 10 MASTER CYLINDER... 13 BRAKE BOOSTER... 16 BRAKE LINE... 18 PROPORTIONING VALVE... 19 FRONT DISC BRAKE... 20 REAR DRUM BRAKE...
More informationTransmission Converter Driveshaft
WORK SPORT Transmission Converter Driveshaft Whether put to the test in a daily use workhorse or plow truck, or ensuring worry-free trips with a trailered truck pulling heavy loads, Sonnax components for
More informationTCI Turbo 400 Full Manual Valve Body. Shift Pattern: Park Reverse Neutral First Second Third. NOTE: You must reuse stock manual control valve.
TCI 221100 Turbo 400 Full Manual Valve Body Shift Pattern: Park Reverse Neutral First Second Third This Kit Contains: (1) Turbo 400 Full Manual Valve Body (1) Separator Plate & Gaskets (1) Pressure Regulator
More informationAisin Warner LE 1998-Up Nissan UD Isuzu RNJ Mitsubishi FUSO
Aisin Warner 450-43LE 1998-Up Nissan UD Isuzu RNJ Mitsubishi FUSO AISIN SEIKI CO., LTD. SERIAL NO. 9A0001 Year: 1999 Month: January Ex. B: February C: March D: April * * L: December Serial Numbers Component
More informationE4OD/4R100. Check Ball Identification and Symptom Chart. Early 1989 E4ODs The first E4OD had 16 checkballs.
110 FORD Check Ball Identification and Symptom Chart Repeated failures are caused by only two types of problems: parts or technique. If a part is causing the failure, it should be no surprise that using
More informationTech. Services: (800) Fax: (800) Order Entry: (800) Fax: (800) MODEL C ELECTRIC HYDRAULIC PUMP
SPX Corporation 5885 11th Street Rockford, IL 61109-3699 USA Internet Address: http://www.powerteam.com Tech. Services: (800) 477-8326 Fax: (800) 765-8326 Order Entry: (800) 541-1418 Fax: (800) 288-7031
More informationAutomatic Transmission/Transaxle: All Technical Service Bulletins A/T - AOD Diagnostic Information Article No
1991 Ford Mustang V8-302 5.0L HO Copyright 2004, ALLDATA 8.30 Page 1 Automatic Transmission/Transaxle: All Technical Service Bulletins A/T - AOD Diagnostic Information Article No. 93-23-18 11/10/93 TRANSMISSION
More informationVolkswagen 095/096/01M, 097/01N, 098/01P
Volkswagen 095/096/01M, 097/01N, 098/01P FWD 4 Speed 50 20 21 30 31 45 10 A Pump Body Stator 2-4 Brake Clutch (B2) 37 67 36 46 82 B Forward Clutch (K1) Forward Hub 65 69 42 43 C Drive Sun Gear Shell Center
More informationAUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series TRANSMISSION APPLICATION TABLE
Article Text ARTICLE BEGINNING AUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series APPLICATION TRANSMISSION APPLICATION TABLE Vehicle Application Transmission Model Colt 3-Speed (1990-94)... F3A21 Colt Vista
More informationTCI Trans-Scat
Page 1 of 5 Return to Instruction Sheet index TCI 350000 Trans-Scat Installation Instructions For TURBO HYDRAMATIC 350 This kit will allow you to reprogram your transmission to meet your driving needs
More informationInstallation Instruction for B&M Transpak for THM200-4R Transmission
Installation Instruction for B&M Transpak for 1981-90 THM200-4R Transmission Part No. 35229 B&M Racing & Performance Products 1999 ongratulations! You have just purchased the most complete and versatile
More informationDISASSEMBLY AND ASSEMBLY
307-01-1 Automatic Transaxle/Transmission 4R70E/4R75E 307-01-1 DISASSEMBLY AND ASSEMBLY Main Control Valve Body Disassembly Main Control Valve Body Disassembled View Item Part Number Description Item Part
More informationAWTF80SC / 81SC (AF21/AF40-6)
AWTF80SC / 81SC (AF21/AF40-6) FWD 6 Speed 15 35 11 10 40 41 65 50 66 A Pump Assembly 2-6 (B1) Brake Band 3-5 Reverse (C3) Drum 75 Filter 80 20 21 51 52 57 16 17 58 B 24 3-5 Reverse (C3) Clutch 25 81 Front
More informationPart No amatic 350
Watch our installation video on YouTube Installation Instructions Shift Improver Kit Part No. 30262 1968-1981 TurboHy urbohydr drama amatic 350 B&M Racing and Performance Products 2002 Congratulations!
More informationParking brake Mechanical brake acting on rear wheels
11 Brake System 11.1 General SPECIFICATIONS EJTC0010 Master cylinder Type Tandem type I.D. mm(in.) 20.64 mm (0.813 in.) Fluid level warning sensor Provided Brake booster Type Vacuum Boosting ratio 4.0
More informationInstallation Instructions Shift Improver Kit for THM200-4R Transmission
Installation Instructions Shift Improver Kit for 1981-90 THM200-4R Transmission ongratulations! You have just purchased the most complete and versatile recalibration kit available for the TH- 200-4R transmission.
More informationCheck Valves Check Valves are the simplest form of directional control valves, but they can also be used as pressure controls.
Check Valves Check Valves are the simplest form of directional control valves, but they can also be used as pressure controls. Standard Check Valve The standard check valve permits free flow in one direction
More informationP R N D2 D1 L. FM3 Cast Iron Fordomatic No Vacuum Modulator. D2 Starts in 2nd. Shifts to 3rd Will kickdown to 2nd but not to first.
No No Hole Here No Vent here Has FM3 Cast Iron Fordomatic 1951-54 No Vacuum Modulator P R N D2 D1 L D2 Starts in 2nd. Shifts to 3rd Will kickdown to 2nd but not to first. D1 Starts in 1st and shifts 1-2
More informationHow to Order Manifold FD2. Manifold mounting. D DIN rail mount style Note) E Direct mount style. Note) C kit of SQ2000 only. Cable specifications
For details about certified products conforming to international standards, visit us at www.smcworld.com. Series SQ000 Plug Lead Unit How to Order Manifold SSQ 0 FD D Electrical entry F kit D-sub Connector
More informationPROBLEM SYMPTOMS TABLE
DI476 PROBLEM SYMPTOMS TABLE HINT: If a normal code is displayed during the DTC check but the trouble still occurs, check the circuits for each symptom in the order given in the charts on the following
More informationThe AW55-50SN transmission
TECHNICAL TRAINING Shift Pointers Author: Jesse Zacarias Subject: Drive and Reverse engagement problems Unit: AW55-50SN (Nissan RE5F22A, GM AF33-5) Vehicle Applications: 2005 Nissan Altima Essential Reading:
More informationJatco 5 Speed ATRA. All Rights Reserved. Printed in U.S.A.
1 2 3 Table Of Contents Transmission Diassembly... 4 Front Pump... 16 Reverse/High Clutch Drum... 18 Direct Clutch Drum... 22 Low Clutch Drum... 26 Planetary Gearsets... 29 Transfer Gear/Reduction Gear...
More informationCAUTION: Ensure battery Is fully charged prior to testing. Low battery voltage will cause faulty diagnostic system operation.
AUTO TRANS DIAGNOSIS - A-340E/F/H & A-341E Selected Block 1990 Lexus LS 400 For Lextreme Powertrain 2020 S. Hacienda Blvd. # D Hacienda Heights California 91745 Copyright 1998 Mitchell Repair Information
More informationAre Transmission Problems Causing Your Converter to Fail? By Ed Lee and Maura Stafford
Are Transmission Problems Causing Your Converter to Fail? By Ed Lee and Maura Stafford There are many transmission-related problems that can directly affect the functioning and longevity of the torque
More informationCAUTION: The possible problems and causes are listed in order of likelihood and ease of checking.
The information contained herein is for use by skilled hydraulic elevator professionals. Before disassembly of the valve, make sure the power is off by turning the main disconnect switch off and that the
More informationMODEL B ELECTRIC HYDRAULIC PUMP
DIVISION UNEX CORPORATION 333 STATE ROUTE 7 NORTH MAHWAH, N.J. 07430- Tel: (0) -00 Fax: (0) -030 Parts List for: Form No. 0 HYTORCQAS- MODEL B ELECTRIC HYDRAULIC PUMP "A" "A", 4 7 3, 4 Motor Control Assemblies
More information2002 F-Super Duty /Excursion Workshop Manual
Page 1 of 25 SECTION 307-01: Automatic Transaxle/Transmission 2002 F-Super Duty 250-550/Excursion Workshop Manual ASSEMBLY Procedure revision date: 05/23/2001 Transmission Special Tool(s) Remover, O-Ring
More informationTurbo 400 Trans Brake Valve Body Shift Pattern: Park Reverse Neutral 1st 2nd 3rd
TCI 221500 Turbo 400 Trans Brake Valve Body Shift Pattern: Park Reverse Neutral 1st 2nd 3rd This Valve Body will neutralize at shut-down by putting shifter In 2nd gear position This Kit Contains: (1) Turbo
More informationAUTO TRANS OVERHAUL - V.A.G. 01V Article Text 1998 Volkswagen Passat This file passed thru Volkswagen Technical Site -
AUTO TRANS OVERHAUL - V.A.G. 01V Article Text 1998 Volkswagen Passat This file passed thru Volkswagen Technical Site - http://volkswagen.msk.ru ARTICLE BEGINNING 1997-98 AUTOMATIC TRANSMISSIONS Volkswagen/Audi
More informationPrincipals of Operation... 1 Rotary Vane Priming Pump VPE and VPES... 2 Rotary Vane Priming Pump VPO and VPOS Priming Valve...
Priming Systems Installation Priming Systems Operation & Maintenance Form No. F 1031 Section 2312 Issue Date 10/07/94 Rev. Date 02/27/06 Table of Contents Illustrations Principals of Operation...........................
More informationMODEL mm Hinges Included. MODEL 1432 Hinges Purchased Separately Anti-Rak Cable System Flipper Door Slide Up to 75 lb.
MODEL 1332 35 mm Hinges Included MODEL 1432 Hinges Purchased Separately nti-rak System Flipper Slide Up to 75 lb. [34 kg] apacity pplications: Vertically mounted concealed doors for office/residential
More information