Installation Instructions AQ-5100, AQ-5200 & AQ-5300 Under Counter Water Filter Single Stage (5100), Two Stage (5200) and Three Stage (5300) systems

Transcription

1 Live Healthy s ' p V iv Installatin Instructins AQ-5100, AQ-5200 & AQ-5300 Under Cunter Water Filter Single Stage (5100), Tw Stage (5200) and Three Stage (5300) systems Welcme t the Aquasana experience. Yu are abut t enjy clean, healthy water and the peace f mind that cmes frm knwing award-winning filter technlgy is wrking fr yu. Installatin must cmply with state and lcal laws.

2 AQ e * * 0 - *' e. O AQ-5300 filter unit O Faucet (1) 0 Filter Cartridges (3) O Screws with anchrs (2) O Faucet Rubber Washer (1) Q Faucet Spacer (1) 0 Faucet Washer (1) Faucet Nut (1) O 3 x!4 Ply tubing (1) O Chrme nut (1) Plastic cllar (2) 0 Plastic tube insert (1) 0 3 X3/8M Ply tubing (1) Brass nut (1) 0Brass tube insert (1) O 3/8" Brass Tee (1) AQ-5200 O - e «!. W jqua am AQ-5i i* i* A 4 i. 0 tp e t# - -., X» O AQ-5200 filter unit O Faucet (1) 0 Filter Cartridges (2) O Screws with anchrs (2) 0 Faucet Rubber Washer (1) 0 Faucet Spacer (1) 0 Faucet Washer (1) O Faucet Nut (1) O 3 x!4 Ply tubing (1) O Chrme nut (1) Plastic cllar (2) 0 Plastic tube insert (l) 03 x!4 Ply tubing (1) Brass nut (1) 0Brass tube insert (1) Q'/A" Brass Tee (1) O AQ-5100 filter unit O Faucet (i) 0 Filter Cartridge (1) 0Screws with anchrs (2) 0 Faucet Rubber Washer (1) 0 Faucet Spacer (1) 0 Faucet Washer (1) Faucet Nut (1) O 3 x!4 Ply tubing (1) 0Chrme nut (1) Plastic cllar (2) 0 Plastic tube insert (1) 03 x!4 Ply tubing (1) Brass nut (1) 0Brass tube insert (1) O!4" Brass Tee (1) Preparing fr Installatin Please read entire installatin guide befre installing thefilter system. Tls Recmmended fr Installatin Variable speed drill w/ 7/32 bit Adjustable wrench Measuring tape Bucket Phillips head screwdriver Hammer Befre beginning installatin, please ensure all parts listed are present. If any part is missing r damaged, d nt attempt t install the filter. Please cntact Custmer Service fr replacement parts at (866) Estimated Installatin Time: 45 minutes

3 ft I Chrme Brushed Nickel Oil-Rubbed Brnze The AQ-5200 & 5300 cmes in three designer finishes, Chrme, Brushed Nickel and Oil-Rubbed Brnze. The AQ-5100 is nly available with the Chrme finish. The faucet may be munted n the sink using an existing hle fr a sprayer nzzle r sap dispenser, r by drilling a hle at least 1/2 in diameter. Be sure the lcatin f the faucet allws the sput t extend slightly past the edge f the sink. Nte: we recmmend enlisting the services f an apprved r certified prfessinal if drilling is required.

4 wc Unit Installatin: Select a f RI j mk m 6 Use a 7/32 drill bit t drill 7 space under yur sink fr the 8 filter unit that is at least 12 inches prvided. Carefully tap the frm the bttm f yur cabinet anchrs int the drilled hle with and allws fr easy access t yur a hammer. Munt unit t the wall cld water supply and fr filter with the screws. replacements. Use the munting Fr the AQ-5200 and AQ-5300 hles lcated at the back f the unit Pull the prtective plastic strip t mark the wall screw placements frm the battery cmpartment. with a pencil. The red LED shuld flash and beep Center t center hle distances: five (5) times t indicate that the AQ-5100: 41mm battery is installed crrectly. AQ-5200: 65mm AQ-5300: 98mm *. j Cnnect the supply lines: push the tubing int the inlet side and utlet side f the husing. The tee fitting tube ges t the inlet and the faucet tube ges t the utlet. t-r- Attach each sump t the bttm f the unit husing. Align cnnectin pints, push the sump up and turn t the right. Ensure that the sump is lcked in. 4# Turn the cld water n. Check fr leaks and prper installatin: place a twel under the filter unit and check fr leaks. Allw water t run fr 10 minutes t flush carbn fines. Nte: Never use ils t lubricate the O-rings; O-rings cme pre-lubricated. j i h Enjy yur filtered water!

5 Easy t install! V 1 Unpack and unwrap cntents. Turn ff and discnnect the cld water supply. A V Attach threaded ends f supplied brass tee 2 t the cld water supply line and shut-ff valve; tighten using an adjustable wrench. \ / 3 v V V V V V Attach white tube t the brass tee: Slide the cmpressin nut nt the white tubing (with threads f the nut facing the end f the white tube). Next, slide the plastic sleeve nt the white tube. Place brass insert int the pening f white tube. Push the tip f the white tubing int the pening f the brass tee. While hlding the white tube in place inside the brass tee, tighten the cmpressin nut t cmpress the plastic sleeve and create a seal. NOTE: Use a wrench t ensure cmplete seal. Avid ver tightening. Faucet 4 Installatin: Faucet Cnnectin: cnnect the utlet hse t the Install as shwn. 5 base f the faucet by sliding the chrme nut nt the Tighten nut t secure tube fllwed by the white cllar. Place the white insert int faucet t sink. «the end f the tube. Press the tube against the faucet base and slide the nut and cllar up t the threads. Use wrench t ensure seal is sufficiently tight. Nte: Avid ver tightening. h t

6 Precautins: Filter is nly t be used with cld water. If yu experience a leak at the hse cnnectin, discnnect and re-seat the hse. Aquasana is nt liable fr cnsequential r incidental damages due t imprper installatin. AQ-5IOO AQ-52OO AQ-53OO Replacement cartridge: AQ-5100R Rated service flw: 0.5 gpm Max capacity: 200 gal Min wrking pressure: 20 psi (1.40 kg/cm2) Replacement cartridge: AQ-5200R Rated service flw: 0.5 gpm Max capacity: 500 gal Min wrking pressure: 20 psi (1.40 kg/cm2) Replacement cartridge: AQ-5300R Rated service flw: 0.5 gpm Max capacity: 600 gal Min wrking pressure: 20 psi (1.40 kg/cm2) Max wrking pressure: 80 psi (5.62 kg/cm2) Min perating temperature: 40 F (4.440 C) Max perating temperature: 90 F (32.22 C) Max wrking pressure: 80 psi (5.62 kg/cm2) Min perating temperature: 40 F (4.440 C) Max perating temperature: 90 F (32.22 C) Max wrking pressure: 80 psi (5.62 kg/cm2) Min perating temperature: 40 F (4.44 C) Max perating temperature: 90 F (32.22 C) D nt use with water that is micrbilgically unsafe r f unknwn water quality withut adequate disinfectin befre r after the system. Systems certified fr cyst reductin may be used n disinfected waters that may cntain filterable cysts. aq5x_install_20i40307

7 Care and Maintenance T clean yur filter unit, wipe dwn the exterir with a damp clth. Fr the AQ-5200 and AQ-5300 nly: Once filters are at 95% capacity (abut every 6 mnths), the battery alarm will sund and flash red when water is flwing and will cntinue fr 15 secnds nce water is turned ff. Change the battery every time yu replace yur filters. The battery is included with the filter replacement cartridges. Pure Satisfactin All Aquasana prducts ffer a 90-day 100% satisfactin guarantee. (A i-year warranty is included, which cvers defects in materials and wrkmanship.) If fr any reasn yu are nt satisfied with yur purchase, simply call us r the dealer yu purchased frm. A Return Authrizatin Cde and a full refund will be prmptly issued upn return. Thank yu fr chsing Aquasana! This filter system is designed and tested fr use with genuine Aquasana parts, including replacement filters and all hardware except fr the actual faucet. Use f parts frm ther manufacturers may result in lss f cntaminant reductin perfrmance, system damage r failure. Use f parts frm ther manufacturers (besides the faucet) will als vid yur warranty. Please visit fr all replacement parts. Fr cnditins f use, health claims certified by the Califrnia Department f Public Health, and replacement parts see prduct data sheet. Califrnia Department f Public Health Certificatin Number

8 aquasana Live Healthy: Aquasana, Inc Midway Rad Haltm City, Texas USA Canada Fr exclusive deals f facebk.cm/aquasana fe 1 twitter.cm/aquasana System tested and certified by NSF Internatinal against NSF/ANSI Standard 42 and 53 fr the reductin f the claims specified n the Perfrmance Data Sheet and at