WIDETRAK LX Model #S03SU4BS Rev. 01. E 2002 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /03

Transcription

1 WIDETRAK LX Model #S0SUBS Rev. 0 E 00 Polaris Sales Inc. PARTS MANUAL PN and MICROFICHE PN /0

2 TABLE OF CONTENTS WIDETRAK LX S0SUBS Parts Manual AIR BOX A... B C BATTERY BOX... B BRAKE... B CARBURETOR... C0 CONSOLE... A COOLING SYSTEM... C CRANKCASE... C CRANKSHAFT... C CYLINDER... C DECALS... A0 DRIVE CLUTCH... B DRIVEN CLUTCH... B DRIVESHAFT... B ENGINE MOUNTING... C EXHAUST SYSTEM... C FUEL PUMP... C GAS TANK... A GEARCASE... B-0 HANDLEBAR... B HOOD... A- HOOD - FOAM/FOIL... A C D E F G H M MAGNETO... C N NOSEPAN... A- OIL PUMP... C OIL TANK... C PISTON O P... R C RACK... A RECOIL STARTER... C SEAT... A SHIFT LINKAGE... C SKI... A STARTING MOTOR... C STEERING... B- SUSPENSION... B- SUSPENSION COUPLER, REAR... B SUSPENSION, FRONT... A TOOL KIT... D TORQUE ARM, FRONT... B TORQUE ARM, REAR... B TUNNEL... A TUNNEL EXTENSION... A WATER PUMP S T W... C The illustrations used in this Parts Manual are for reference to replacement parts only. This manual is not to be used for assembly.

3 E 00 Polaris Sales Inc. TUNNEL WIDETRAK LX S0SUBS Rivet, Pop 0 Cover, Tool Box 0 Foam, Tool Box 0 Box, Tool 0 Seal, Riser, Seat 0 Seal, Riser, Seat, Short 00 Clip, Half 0-0 Riser, Seat Rivet 0 0 Strip, Wear Pad, Suspension, Heavy Duty, LH Pad, Suspension, Heavy Duty, RH Rivet Rivet Extrusion, Clutch Guard 0 0 Asm.,Footrest,LH Asm.,Footrest,RH Support, Trailing Arm, LH Support, Trailing Arm, RH 0-0 Plate, Tunnel, Carrier A -0 Bracket, Suspension, Front 0 Bulkhead 0 Guard, Drive Adaptor 00 Plug, Hole 00 Plug, Hole 00 Bushing, Open/Close 0 Screw Support, Muffler (See Exhaust System Pg. C, Ref. ) 0 Rivet Nut, Flange -0 Bracket, Gas Tank 0 Rivet 0 00 Asm., Tunnel (Incl. -,) 00 Bushing, Open/Close 0 Protector, Riser 000 Hinge, Flat 0 Grommet /0

4 SEAT and GAS TANK WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Cap w/gauge, Gas Gasket, Gas Cap 0 Asm.,Seat,-Up(Incl.) Cover, Seat Screw 0 Washer, Wrought 0 Pull, Seat 0 Nut, Tee Hinge, Flat (See Tunnel Pg. A, Ref. ) 0 Screw Pad, Bottom, Seat 0 Tank, Fuel 00 Belt, Seat (Incl. ) Rivet Footman Loop (Supplied w/strap)(see Ref. ) Rivet 0 Pick-Up w/filter, Fuel 000 Ring, Compression 00- AR Line, Fuel AR Line, Fuel 00 Fitting, 0 Degree 0 00 Fitting, Outlet, Double 000 Clamp, Hose, Large Green AR Line, Fuel 000 Spring, Tank Front /0 A

5 NOSEPAN WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Brace, Hinge Foil, Tape 0 Washer, Spring Lock Screw 0 Rivet 0 Nut Spacer Guide, Hood, LH Guide, Hood, RH Rivet 0 0 Rivet 00 Strap, Hood Latch Brace, Pan, LH Brace, Pan, RH Cap, Bumper, LH Cap, Bumper, RH A 0 Screw 00 Plug, Hole -0-0 Extrusion, Bumper, Formed, LH Extrusion, Bumper, Formed, RH Rivet Bracket, Hose Protector Shield, Shock Tower 0 Bolt, Carriage -0 Brace, Pan, Lower Rivet -00 Bumper, Front Nut, Nylok 0 Brace, Pan, Upper 0 Washer, Flat Screw 0/0

6 NOSEPAN WIDETRAK LX S0SUBS 0 E 00 Polaris Sales Inc. 0 0 Tape, Foil Tape, Foil 0 Tape, Foil 0 Tape, Foil 0 Tape, Foil 0 Tape, Foil Tape, Foil 0 Tape, Foil 0 Tape, Foil 0 0 Tape, Foil 0 Foil, Battery Box Clip, Belt Retainer 00 Pin, Clutch Guard 0 Asm., Clutch Guard 0 Rivet 00 Decal, Engine and Clutch Rivet Plate, Backer 00 Clip, Rosebud 0 Rivet 000 Nut, Push On 0-00 Grill, Louvered 0 Plug, Hole 00 Plug, Hole Nosepan Rivet /00 A

7 HOOD WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Mount, Headlight 0 Screw 00 Nut, U-Type Speed 0 Asm., Headlamp (Incl. Bulbs) 00 Bulb, High Beam 0 Bulb, Halogen Lens/Reflector, LH Lens/Reflector, RH - Asm., Hood, Sonic Blue (Incl. Foam/Foil) Screw 0 00 Knob, Headlight Adjust 00 0 Hinge, Upper, LH Hinge, Upper, RH Plate, Bolt Screw Bolt, Carriage Nut, Nylok Plate, Hinge, Lower Brace, Hood, Upper Brace, Hood, Lower Rivet 0 0 Spring, Extension 00 Ring, Spring Attachment 00 Clamp, Retainer Screw Screen, Front 00 Spring, Headlight Adjust Bolt, Tee, Adjuster 000 Clip, U-Type /0 A

8 HOOD WIDETRAK LX S0SUBS 0 E 00 Polaris Sales Inc. 0 0 Windshield, Flared, Clear, 0 Inch 0 Rivet 0 Nut 0 Washer, Lock 0 Washer, Flat 00 Bracket, Speedo/Tach Housing, Instrument (Incl. Warning Decals) 0 Harness, Jumper, Temp/Rev 000 Indicator, Temp Warning 000 Indicator, Reverse 0 Knob, Trip Meter Asm., Speedometer, MPH Bulb, Replacement 00 Cushion, Rubber 0 Cable, Speedometer Foam, Pre-Filter 00 Cable Tie 00 Harness, Headlight Foil, Connector, Wire Harness Foam, Seal, Headlight 00 Clip, Rosebud, Gray Screw Rivet 0 0 Cup, Hood Latch 00 Retainer 0 Washer Clip, Pigtail 0 Rivet 00 Cable, Hood 0 Rivet 0 Screw Deflector, Air Rivet 0 00 Clamp /0 A

9 HOOD - FOAM/FOIL WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Screen, Hood, RH Screw 000 Clip, U-Type Screen, Hood, Front, Upper, LH Screen, Hood, Front, Upper, RH Screen, Hood, Front, Lower, LH Screen, Hood, Front, Lower, RH Foil, Hood, RH Foil, Hood, RH 0 Foam, Hood, Center 0 Foil, Hood Tab, Reinforcement 0 0 Foil, Heat Shield, Hood, RH A Foil, Tape, Upper Louver, RH 0 Foil, Louver Edge, Front Rivet, Bulbex -0 Screen, Hood, LH Foil, Hinge Mount, RH Foil, Tape Foil, Tape, Lower, LH Foil, Hinge Mount, LH Foil, Tape, Upper, LH 0 0 Foam, Hood, LH /00

10 DECALS WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Kit, Hood Decal, 0 WideTrak LX (Incl.,,,,,) 0 Decal, Warning, Electric Reverse 0 Decal, Warning, English 0 Decal, Warning, French 00 Decal, Warning, One Passenger 0 Decal, Shift Pattern 00 Decal, Hood Center, POLARIS 0 Decal, Hood Center, LX 00 Decal, Choke 0 Logo, Polaris Star 0 0 Decal, Electric Start 0 Decal, Max. lbs. ( kg) 00 Decal, Track/Seat, English/French 0 Decal, POLARIS, Riser 0 0 Decal, 00 Liquid Cooled Twin, LH Decal, Liquid Cooled Twin 00, RH 0 0 Decal, Hood Side, LH Decal, Hood Side, RH 0 0 Decal, Hood Side, Front, LH Decal, Hood Side, Front, RH 0 0 Decal, Trailing Arm, INDY IFS, LH Decal, Trailing Arm, INDY IFS, RH /0 A0

11 CONSOLE WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. Footrest 0 0 Screw 00 Regulator, AC/DC..V Washer Nut, Nylok 00 Cable Tie 000 Terminal, Ring 000 Housing 00 Harness, Wire, Main Foil, Connector, Wire Harness Screw 0 00 Kit, Ignition Switch 000 Cable, Choke (Incl.,0) Lever, Choke (Incl. Pin) 000 Cable Tie, Releasable Washer, Nylon 0 Rivet 0 Guide, Recoil 00 Cable Tie Boot, Handlebar 0 Washer, Lock 0 Nut, Choke 0 Cap w/key NOTE: When ordering ignition key PN 0 be sure to specify if for an A,B,C,D, or E switch. Letter code will be labeled on underside of switch body behind console. Key dot code found on key cap (i.e. one dot = A, two dots= B, etc.). 0 Nut, Ignition 0 Switch, Heater, Hi/Lo Console /0 A

12 RACK and TUNNEL EXTENSION WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Asm.,Backrest(Incl.) Cover, Backrest -0 Shield, Taillight Rivet 00-0 Rack Rivet 0-0 Bracket, Snow Flap Flap, Snow, Side 0 Asm., Taillight (Incl. -) 00 Backing, Taillight 0 00 Gasket, Taillight 00 Lens, Taillight 00 Screw, Taillight 000 Bulb, Taillight, Extreme Duty Kit, Hitch (Incl. -) Hitch 0 Pin, Clevis 0-0 Hitch 0 Pin, Cotter 0 Washer, Spring Lock 0 Screw Extension, Tunnel 0 Reflector, Red 00-0 Panel, Tunnel Back 0 Flap, Snow 0 Washer Rivet Strip, Wear, Extension Rivet Bracket, Harness Protector 00 Protector, Bed 0 Rivet 00 Nut, Speed, Washer 0 Washer, Flat Nut, Nylok Screw Bolt Nut, Acorn 0 Plug, Tube Bolt 0 Washer, Spring Lock 0 Washer, Flat Nut, Nylok 0/0 A

13 E 00 Polaris Sales Inc. FRONT SUSPENSION WIDETRAK LX S0SUBS Brace, Bulkhead Rivet Strap, Spacer, Bottom Strap, Spacer, Top Screw Bolt Nut, Nylok Screw 0 Retainer, Spring Coil Spring, Compression 0 Retainer, Spring 0 Shock Screw Washer 0-0 Arm, Steering Stop, Steering, LH Stop, Steering, RH 0 Rivet 0 Pivot, Rubber Screw 0 Washer 000 Bushing A 0 Bushing, Flange Asm., Trailing Arm, LH (Incl.,) Asm., Trailing Arm, RH (Incl.,) 0 Bushing, Machinery 0 Bushing, Flanged 00-0 Shaft, Spindle 000 Fitting, Lubrication 00 Bushing 00 Fitting, Lubrication 0 00 Bushing, Pivot, Radius Rod Bushing, Pivot, Radius Rod, Outer -0 Rod, Radius, Lower 0 Bushing, Pivot, / Inch 0-0 Asm., Rod, Radius, Upper, Fixed (Incl.,) 0 Bushing, Pivot, / Inch 0 Nut, FLEXLOC Bracket, Radius Rod, Bottom 0 Nut, FLEXLOC 00 Rod End, RH 0 Nut, Jam /0

14 SKI WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 Nut, Flange -00 Toe, Ski, Plastic, Black Nut, Nylok Washer 0 Pin, Cotter Nut 0 Washer Bushing 0 Stop, Rubber 0 Nut, Nylok Washer Ski, LH (Incl. ) Ski, RH (Incl. ) Screw Kit, Skag, -Inch, 0 Degree Screw 00 Screw /0 A

15 STEERING WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Cable Tie, Releasable 0-0 Hoop, Steering 0 Nut, FLEXLOC 0 Nut, FLEXLOC 00 Rod End, RH 0 Nut, LH Nut, RH -0 Rod, Drag Link 00 Rod End, LH 0 Rivet 0-0 Plate, Boot Seal 0 Boot, Tie Rod Screw 00 Bushing 0 Bushing Washer B 0 Nut, FLEXLOC 0 Pin, Cotter Rivet 0 Nut, FLEXLOC 0 Bolt 00 Rod End, RH 00 Tie Rod 00 Clip, Rosebud 0 Screw 0 Block, Steering Screw Washer, Wave 00 Fitting, Lubrication Asm., Center Steering Arm (Incl.,) 0 Bolt /0

16 STEERING - HANDLEBAR WIDETRAK LX S0SUBS 0 0 E 00 Polaris Sales Inc. Grip, Handlebar Pin, Retaining 0 Washer 00 Ring, Retaining 00 0 Asm., Heater Lever, Hi/Lo Lever, Throttle Block, Throttle/Brake 00 Adaptor, Block 0 Plug -0 Handlebar 0 0 Asm., Handlebar Cover Foam, Handlebar Pad 0 Grip Heater, Hi/Lo 00 Switch, Brake Light 00 Switch, Dimmer Rivet 00 Lever, Brake 00 Clip, Speed, U-Type Screw Screw Block, Handlebar Screw 0 Nut, FLEXLOC Nut, Nylok -0 Post, Steering Holder, Wire 00 Ring, Retaining Screw, Set Washer 00 Switch, Auxiliary Shut-Off /0 B

17 FRONT TORQUE ARM WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Shaft, Spanner 0 Spacer 0 Bushing 0 Asm., Bogie Wheel 0-0 Arm, Torque, Front 00 Fitting, Lubrication Washer, Flat Shaft, Pivot 00 Retainer, Spring, Slotted 0 Nut, FLEXLOC Screw Screw 0 Washer, Spring Lock Washer, Flat 000 Shaft, Mounting 0 Shock, Suspension, Center 0 Retainer, Spring 0-0 Spring, Front Track 0 Shield, Spring 0 Nut, Nylok Screw /0 B

18 REAR TORQUE ARM WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Screw 0 Washer, Spring Lock Washer, Flat 000 Shaft, Mounting 00-0 Spring, Suspension, Rear, RH Spacer, Spring 0 Nut, FLEXLOC Screw 0-0 Arm, Torque, Rear Tube, Spacer, Rear Torque Arm Bolt Nut, Shoulder 0 Nut, Lock 0-0 Spring, Suspension, Rear, LH B 00 Bolt, Eye Washer, Flat Shaft, Pivot 0-0 Arm, Pivot, Rear 00 Fitting, Lubrication 0 Bolt 0 Retainer, Spring 0-0 Spring, Compression 0 Sleeve, Spring Protector 0 Cam, Adjusting, Spring 0 Shock, Rear Track 0 Bushing Nut, Nylok /0

19 SUSPENSION WIDETRAK LX S0SUBS E 00 Polaris Sales Inc B

20 SUSPENSION WIDETRAK LX S0SUBS 0 Asm., Wheel, Carrier (Incl.,,) 0 Insert, Wheel 0 0 Bearing, Roller ( per Wheel) 0 0 Ring, Retaining ( per Wheel) 0-0 Spacer Washer, Flat 00 Shaft, Mounting, Carrier 00-0 Spacer Bolt 0 0 Washer, Spring Lock Screw Washer, Flat 0 Washer, Belle 0- Asm., Idler Wheel, Scrolled Spacer, Idler Bushing 0 Asm., Wheel 00 Shaft, Idler 00 Block, Idler Bolt Adjust 0 0 Rivet Screw Asm., Rail, Swing Arm, Riveted (Incl.,0) Hi-Fax, White 0-0 Spacer 0 Bushing 0- Asm., Idler Wheel, Scrolled 0 Rivet Screw 0 Washer, Flat 0 Spacer, Bogie Wheel 0 Nut, Nylok Washer, Flat 0- Asm., Wheel, Scroll Spacer 0 Washer, Spring Lock Bolt 0 Asm., Wheel w/insert (Incl.,,) Insert, Wheel ( per Wheel) 0 Ring, Retaining 0 Bearing 0 0 Bolt Roller, Spring Rivet Angle, Bumper Reinforcement Track Clip, Slide Screw 0 Asm., Rail, LH (Incl.,,) Hi-Fax, White 0 Cover, Rail Tip Rivet Shaft, Pivot 0 Washer, Flat 0 Asm., Rail, RH (Incl.,,) Hi-Fax, White 000 Shaft, Spanner Nut, Nylok 0 Bumper, Suspension Spacer 00 Shaft, Rear Shock Screw 0 Washer, Split Lock 0 Washer 0 Spacer 00 Bracket, Bogie Wheel 0-0 Spring, Extension, Rear 00 Shaft, Idler 0-0 Spacer 00 Shaft, Pivot Arm Screw 0 Nut Spacer, Idler /0 B

21 REAR SUSPENSION COUPLER WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Arm, Adjustment, Inner, RH 0 Adjuster Shaft, Adjuster Nut, Nylok 0 Washer, Lock Bolt 0-0 Knob, Backrest 0 Washer Arm, Adjustment, Inner, LH 0 0 Washer, Spring Lock Screw Bolt Bushing B 00 Fitting, Lubrication 0 Bar, Coupler 0 Bushing 0 Bolt 0 Coupler, Outside Sleeve, Pivot Shaft 0 Shaft, Pivot 00 Clevis Nut, Flange Lock Bolt 0 LInk, Coupler, Inside 000 Fitting, 0 Degree /0

22 BRAKE WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Asm., Caliper (Incl.,-,-,,) 0 Nut, FLEXLOC 00 Clevis 0 Bolt -0 Bracket, Brake Clip, Spring Washer, Flat Screw 0 Screw 00 Kit, Mount Bushing Bearings, Ball Spacer, Ball 00 Kit, Caliper, Casting 00 Kit, Ball Bearing (Incl. 0,) 00 Kit, CW Rotor (Incl. 0,) 000 Kit, Pad Spring and Clip (Incl. ) 0 Kit, Brake Pad, Type (Set of ) (Incl.,,0) 00 Cable, Brake 00 Kit, Lever and Spring (Incl.,0,,) Screw Anti-Rotation Clip Lever Bushing Lever, Spring /0 B

23 GEARCASE WIDETRAK LX S0SUBS 0 0 E 00 Polaris Sales Inc B

24 GEARCASE WIDETRAK LX S0SUBS Asm., Gearcase (Incl. -) 0 Index, Shift Spring, Torsion 0 Fork, Shift, Low Pin, Dowel 0 Drum, Shift 0 Fork,Shift,High 0 Shaft, Shift 00 O-Ring Key 0 Bellcrank 0 Screw 0 Switch 0 O-Ring Dipstick 0 Bearing, Ball 0 Ring, Retainer Washer, Thrust Bearing, Needle 0 Sprocket, T NOTE: Must order with Ref. 0 Key 0 Dog, Engagement, High NOTE: Must order with Ref. 0 Chain, Silent (.W 0P) Ring, Retainer 0 Sprocket, T 0 Input, Shaft Gear, T Spacer 0 Bearing, Ball Screw, Set 0 0 Extension, Detent 0 Spring, Detent, Shifter 000 Ball, Detent Seal 0 Plug 0 Deflector, Oil 0 Screw 0 Gearcase, RH 0 Pipe, Knock 0 Washer 0 0 Bearing, Needle Gear, T 0 Washer Dog, Engagement, L/R Ring, Retaining Washer, Thrust Bearing, Needle Sprocket, T Shaft, Reverse Gear, T 0 Spacer Ring, Retaining 0 Gearcase, LH Spacer Shaft, Output 0 Chain, Silent (.W P) Sprocket, T, T Spline Gear, T Spacer /00 B0

25 DRIVESHAFT WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Ring, Retaining Bushing 0 Asm., Brake Disc Asm., Gearcase (See Gearcase Pg. B0 for Details) Bolt, Carriage 00 O-Ring Screw 00 Asm., Coupler w/grease (Incl. Fitting & Screw) Fitting, Lubrication Asm., Jackshaft (Incl. 0) 0 Bearing, Greaseable, Inch Nut, Nylok 0 Washer, Flat Flangette, Bolt 0 Gasket, Jackshaft, -Bolt Flangette w/grease Groove, -Bolt Bolt, Carriage 0 Bushing, Machinery Key Asm., Driven Clutch (See Driven Clutch Pg. B, Ref. ) B 0 Spacer, Inlet Shaft 0 Washer, Flat Washer, Spring 0 Screw 00 Belt, Drive 0 Adaptor w/fitting, Drive 00 Gasket, Drive Adaptor 00 Key, Square, Speedometer Flangette 00 Bushing, Speedometer, Metal 0 0 Asm., Flangette w/screws 0 Asm., Drive Shaft (Incl.-) 0 00 Asm., Coupler w/grease Zerk Fitting, Lubrication Bolt, Carriage Bolt, Carriage AR AR AR AR Nut, Flange Shim, Chaincase (.00) Shim, Chaincase (.0) Shim, Chaincase (.00) Shim, Chaincase (.00) /0

26 DRIVE CLUTCH WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Kit, Clutch Rebuild (Incl. -,,,) Bolt 0 Washer, Spring Lock Bearing, Cover, Garmax 0 Ring, Retaining, Cover 00 Spring, Clutch, Brown 00 Nut, Jam 0 Washer, Multilube Asm., Roller and Bushing 0 Button, Guide AR AR AR AR Spacer (.00) Spacer (.0) Spacer (.0) Spacer (.00) B Asm., Weight/Bushing (0) 0 Pin, Weight 0 Bearing, Sleeve 00 Insert, Moveable 0 Gear, Ring Screw 0 Nut, FLEXLOC 00 Pin, Roller 00 Kit, Drive Clutch Shim 0 Asm., Drive Clutch, Basic (Incl.,,,-,-) /00

27 DRIVEN CLUTCH WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Ring, Retaining 0 Washer 0 Ramp, Driven, Degree Key 0 Spring, Clutch, Silver 0 Screw 0 Bushing, Driven, Large DU 0 0 AR AR AR Washer (.0) Washer (.0) Washer (.0) Washer, Flat 0 00 Pin, Driven Cam, Driven Bolt 0 Button, Ramp 0 Asm., Driven Clutch, Adjustable, Degree (Incl. -) /0 B

28 BATTERY BOX WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Pad, Battery 00-0 Box, Battery Foil, Battery Box Nut, Flange 0 Insulator, Cable 0 Asm., Cable, Battery, Inch 000 Battery 000 Kit, Battery Bolt 0 Washer, External Tooth Cable, Starter, Black, Inch 0 AR Line, Vent B D-Hook 0 Strap, Rubber 00 Breaker, Circuit Nut, Nylok 0 Washer, Flat 000 Cable, Starter 0 Washer 0 Screw 0 0 Screw Screw /0

29 EXHAUST SYSTEM WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Muffler Shield, Muffler Bolt Washer, Flat 0 Washer, Spring Lock 00 Spring, Exhaust 0 Spring, Exhaust 00-0 Manifold Gasket, Exhaust (See Cylinder Pg. C, Ref. ) 0 Rivet Dampener, Vibration 00 AR Washer -0 Bracket, Muffler, Rear Hat, Exhaust 00 Boot, Exhaust Washer, Flat Rivet 00-0 Support, Muffler /00 C

30 OIL TANK / AIR BOX WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Sensor w/connectors, Oil Level 0 Cap, Oil Tank 0 Gasket, Oil Cap 0 Washer Bolt, Lock 000- AR Line, Fuel 000 Filter 000 Clamp, Hose, Green, Large 00 Fitting, Outlet, Single 0 Screw Rivet Bracket, Oil Tank, Coined -0 Bracket, Silencer/Remote Filler Nut, Well 0 Decal, Fuel Shut-Off 0 Washer, External Tooth Screw Nut, Nylok 0 Oil Tank w/sending Unit Hole C 0 00 Nut, Chimney 00 Fitting, 0 Degree AR Line, Vent 00 Plate, Air, Silencer 0 Cover, Silencer 0 Decal, Cooling System 00 Clip, Rosebud Screw Foam, Air Box 0 Decal, Air Box Caution 0 00 Decal, Adjustable Driven Clutch 0 Decal, Greasing 0 Decal, Caution, Burn Hazard 0 Asm., Baffle (Incl. ) 00 0 Clip, Silencer Bracket, Intake Silencer Silencer, Intake 00 Boot, Air Silencer Washer, Flat /00

31 E 00 Polaris Sales Inc. COOLING SYSTEM WIDETRAK LX S0SUBS Bolt 0 Washer 0 Cap, Overflow 0 Plug, Overflow 0 Gasket, Overflow Cap 00 Nut, Chimney Bottle w/fittings, Overflow Rivet Asm., Cooling Extrusion, Center 0 00 Clamp, Hose, mm 00 Clamp, Hose, mm Cooler, Side, LH Cooler, Side, RH 0 Guard, Cooling Extrusion Tubing, Convoluted C 0 Hose, Crossover, Short 0 Hose, Crossover Hose, Engine/Center Extrusion Bracket Tubing, Convoluted 0 00 Clamp, Hose, mm Hose, Filler Out, Extrusion, RH 00 Hose, Engine Out/Filler Filler, Remote Coolant Cap, Pressure 000 Clamp, Hose, Large Green 000- AR Line, Fuel 00 Valve, Check 00 Filter, Coolant 00 Clip, Rosebud /0

32 SHIFT LINKAGE WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Decal, Shift Pattern Foam, Indicator Plate Rivet 0 Plate, Indicator Support, Indicator Plate, RH 0 Nut 0 Washer, Flat Nut, Nylok 0 Washer, Flat Washer, Flat Rivet C 0 0 Pin, Cotter 0 Plate, Pivot, Lower 0 Rod, Linkage, Lower Bolt, Carriage Support, Indicator Plate, LH Rod, Linkage, Upper 0 Rod, Shift Lever 00 Handle, Shift 0 Nut, Nylok Washer, Wave 0 Support, Shift Lever Rod /0

33 ENGINE MOUNTING WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Screw 0 Washer, Lock 00 Washer, Clutch Retainer 00 O-Ring, Clutch Bolt 00 Spacer, Clutch Bolt 00 Spark Plug, RNC Champion -0 Tubing, Convoluted 00 Engine, Short Block EC0PL0 NOTE: The Short Block assembly contains a crankcase assembly, cylinder and cylinder head assembly, and a piston & crankshaft assembly. Prior authorization required for warranty consideration. -00 Recoil Handle 0 0 Screw Mount, Engine, Rubber, Top Nut Mount, Engine, Rubber, Bottom Plate, Mount, Motor 0 Washer, Spring Lock Screw C 00 Mount, Engine, Stud Washer, Flat Nut, Nylok Limiter, Torque Rivet Nut, Hex Asm., Water Pump/Fuel Pump (See Fuel Pump Pg. C, Ref. 0) 00 Stop, Torque Washer, Flat 00 Nut, FLEXLOC AR Line, Fuel AR Line, Fuel, Vent 00 Cable Tie 0 00 Cable w/oil, Throttle Control 000 Clamp 000- Tubing, Convoluted 0 Valve, Fuel 0000 Clamp, Hose, Red AR Line, Impulse /0

34 CRANKCASE WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Stud 0 Grommet 0 Asm., Crankcase (Incl.,,-0,) 000 Pin, Dowel 0 Bolt, Flange 0 Gasket, Aluminum 0 Seal, Oil (MAG Side) 00 Bolt and Washer 00 Bolt and Washer 0 00 Bolt and Washer 000 Seal, Oil (PTO Shaft) 0 Pipe, Pulse (mm) /00 C

35 CYLINDER WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Bolt, Flange 0 Head, Cylinder (Incl. ) 0 Plug 0 Gasket, Aluminum 0 Gasket, Exhaust 000 Pin, Dowel 0 Stud 0 Cylinder (Incl. ) 0 Nut, Flange 0 0 Gasket, Cylinder 0 Valve, Check 0 Asm., Band, Adaptor (Incl. ) 0 Screw 00 Adaptor (Incl. ) 0 O-Ring 00 Bolt 0 Switch, Thermo (0 Degree C) 0 Pipe, Water 0 Gasket, Head /0 C

36 PISTON and CRANKSHAFT WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Clip, Piston Pin 0 0 Ring, Piston (Standard) Ring, Piston (0.mm/.00 Inch O/S) 0 Ring, Piston (0.0mm/.00 Inch O/S) Piston (Standard) Piston (0.mm/.00 Inch O/S) Piston (0.0mm/.00 Inch O/S) 0 Pin, Piston 0 Spacer, Crank Pin 0 Crank Pin 0 Bearing, End, Large 0 Rod, Connecting 0 Bearing, End, Small 0 0 Crank Pin 0 C 00 Bearing, Ball 00 Spacer 00 Bearing, Ball 0 Crankshaft (PTO Side) 00 0 Asm., Crankshaft (Incl. -,0-,,0) Crankshaft (Mag Side) 000 Key 00 Bearing, Ball 00 Washer, Spring 00 Nut 0 0 Crankshaft (Center)(Incl.,0) 0 Bearing, Ball /0

37 WATER PUMP / FUEL PUMP WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Screw and Washer 0 O-Ring 0 Pump Casing 00 Bolt and Washer 0 Gasket, Water Pump 0 Asm., Water Pump (Incl. -,) C 0 Belt 0 Pulley, Drive 0 Screw and Washer 0 00 Asm., Fuel Pump (Incl. -) 00 Diaphragm, Gasket Set /00

38 CARBURETOR WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Top, Mixing Chamber 0 Spring, Throttle 00 Plate, Throttle 00 E-Ring 0 Needle, Jet (EJ-) 0 Valve, Throttle (.0) 00 Jet, Needle, P- () 0 Cap 0 Asm., Carburetor (Incl. -0,-) 0 0 Pin, Float 00 Arm, Float 00 Packing, Needle Valve Valve, Needle (.) 000 Gasket, Float Chamber 0 Cap 00 Float C0 00 Washer 0 Jet, Main (#) 0 O-Ring 0 00 Nipple Line, Fuel Plug, Trap 0000 Clamp, Hose 00 Screw and Washer 00 Jet, Pilot (#) 00 Spring, Air Adjuster 00 Screw, Air 000 Screw, Throttle Stop 000 Spring, Throttle Adjuster 0 0 Plunger 000 Spring, Plunger 0 Cap, Plunger /00

39 OIL PUMP WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Vinyl Pipe 0 Clamp, Hose 0 Screw, Air Vent 0 Packing 00 Asm., Oil Pump (Incl. -0,) 0 Spring, Return 0 Collar, Cam Shaft 00 Lever, Control 0 Washer, Spring C 0 00 Nut 0 Screw and Washer 0 Gear, Small 00 Spacer 0 Bushing AR AR AR 0 O-Ring Spacer (.mm) Spacer (.mm) Spacer (.mm) /00

40 MAGNETO WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Coupler, P 0 Grommet 000 Harness, Wire (Incl. ) 00 Screw and Washer 0 Clamp Asm., Plate (Incl. -,0,,) Plate 0 Stator 0 Screw and Washer 000 Flywheel C 0 0 Screw and Washer 0 Coil, Exciter 0 Screw and Washer 0 Coupler, P, Male 00 Cap, Resistor Plug 000 Coil, Ignition 0 Screw and Washer 00 Nut, Rubber 000 Washer /00

41 RECOIL STARTER WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 0 Pulley, Starting 0 Bolt and Washer 0 Nut, Flange 0 Plate, Friction 0 Spring, Friction Starter, Recoil (Incl. -,-) Case, Starter 0 Clamp 0 Bolt and Washer 00 Guide, Rope 0 0 Spring, Spiral 0 AR Rope, Starter 0 Reel 0 Spring, Return 0 Ratchet /00 C

42 STARTING MOTOR WIDETRAK LX S0SUBS E 00 Polaris Sales Inc Kit, Brush and Spring Brush and Screw Brush Bushing, Insulation Washer, Insulation Nut 0 Nut, FLEXLOC 00 Kit, Asm., Commutator Cap (Incl. ) Nut, Nylok Screw 0 Bracket, Starter, Rear 00 Armature Kit, Drive Hardware Washer, Curved Spring Washer, Thrust Spacer Spring, Antidrift Pinion, Stop Ring, Lock Cover, Dust C 00 Kit, Drive Cap Motor, Starter, Domestic Kit, Drive Plate, Drive Pinion Bracket, Starter, Front 0 Washer, Spring Lock Screw 0 Screw Kit, Screw Through Bolt 0 Nut 000 Washer, Spring 0 Switch, Magnetic (Incl.,) /00

43 TOOL KIT WIDETRAK LX S0SUBS E 00 Polaris Sales Inc. 0 Kit - Tool (Incl. -) Screwdriver Wrench, - Spanner Box Wrench, Special Wrench, 0- Spanner 00 Strap, Starter, Emergency Manual, Owners, 0 Snowmobile Supplement, Owner s Manual, 0 WideTrak LX /0 D

44 PRINTED IN THE USA PARTS MANUAL PN and MICROFICHE PN /0

45 Changed pages in 0 A cover toc x x x B x C D E F G 0